RFP Attachment J.C-1 J-1502000-00 Attachments
688 KB Posted
- Solicitation number
- N6247013R3011
About this file
J.C-1 J-1502000-00
Text of this file
N62470-13-R-3011
SECTION J
DOCUMENTS, EXHIBITS, AND OTHER ATTACHMENTS
TABLE OF CONTENTS
| ATTACHMENT NUMBER |
| ATTACHMENT TITLE |
| J-1502000-01 |
| DEFINITIONS AND ACRONYMS |
| J-1502000-02 |
| REFERENCES AND TECHNICAL DOCUMENTS |
| J-1502000-03 |
| FACILITIES INVENTORY |
| J-1502000-04 |
| HISTORICAL SERVICE REQUEST WORKLOAD |
| J-1502000-05 |
| METER GROUP DESCRIPTIONS |
| J-1502000-06 |
| GENERAL DIRECT CONDITION RATING GUIDANCE |
| J-1502000-07 |
| METER GROUP CONDITION RATING GUIDANCE |
| J-1502000-08 |
| PM PROGRAM INVENTORIES |
Attachment J-1502000-01
DEFINITIONS AND ACRONYMS
| DEFINITION |
| DESCRIPTION |
Category III
Construction Services Category III construction services are primarily composed of minor renovation or repair. No permits are required unless specifically requested in the Task Order; however, the Contractor shall comply with all applicable local laws. Building and/or site approvals are not required. There are no plans and specifications; work is developed from a scope of work supplemented by professional engineering staff as needed with sketches, catalog cuts, and/or narrative descriptions. Examples of typical Category III work include: fire protection alarm relocation; pre-engineering buildings (>120 sf) with no utilities; installation of pre-fabricated carports; replacement of conveyors; non-structural demolition; overhead door repair/replacement (>100 sf); replacement of non-load bearing wall; exterior insulation finish system; HVAC package units (<5 tons, ground level); paving, asphalt overlay, large repair; sprinkler head, fire protection relocation/replacement (<21); roof replacement, structural repair in-kind; stairs, interior or exterior, single flight pre-engineering; utilities – connecting to existing with provider consultation; walls partition, no ingress/egress issues, no utilities; and window installation on non-load bearing walls.
Category IV Construction Services Category IV construction services includes work without permits and is built from client requirements. There is no structural, electrical (primary distribution system), mechanical (HVAC), fire protection, intrusion detection, anti-terrorism force protection, or hazardous abatement. It may include replacement or repair of fixtures, hardware, and finishes. Examples of typical Category IV work include protective bollards (not on piers or for ATFP purposes); pre-engineered buildings (<120 sf) with no utilities; parking lot bumpers; pre-engineered bus stop with no utilities; floor cabinet installation; wall cabinets; cable TV receptacles; floor carpet replacement/installation; laminate countertop installation; solid surface countertop; under sink waste disposer installation; overhead garage door replacement (<100 sf); replacement of personnel doors (non-fire rated doors in non-fire rated walls); asphalt repair or replacement; concrete driveway repair or replacement; dumpster enclosure; ceiling fan replacement; exhaust fan replacement; lighting fixture replacement; plumbing fixture replacement; ceramic floor tile; hardwood and vinyl floor; garage door electric openers; GFCI electrical receptacles; gutters and downspouts; disabled ramps at curbs; handrail/guardrail replacement; replacing door hardware; replacing window hardware; baseboard electric heater replacement; duct installation; pipe installation; wall installation (non-load bearing); landscape sprinkler system; landscaping (<5,000 sf); installing wall mirrors; installing motion detectors; exterior painting (no lead paint removal); interior painting (no lead paint removal); concrete or synthetic parking bumpers; parking lot striping; landscaping pavers; built-up roof repair (no structural); fiberglass roof shingle repair by replacement (no structural); standing seam metal roof repair (no structural); light duty shelving; concrete sidewalk; exterior vinyl siding; architectural signage; clearing and grubbing site preparation (<1 acre); roof skylight; solar lighting; wood exterior stair replacement; roof ventilator replacement; interior wall wainscot; ceramic tile wall; vinyl base wall; vinyl covering wall; film tint windows; window replacement (non-load bearing); storm windows.
| Equipment, Collateral |
| Encompasses built-in and large substantially affixed equipment/property that is normally acquired and installed as part of a facility project. |
| Equipment, Installed |
| Encompasses building-type equipment, built-in equipment, and large, substantially affixed equipment/property, and is normally acquired and installed as part of a facility project. Installed equipment is normally required to make a facility useful and operable. Removing such equipment would impair the usefulness, safety, or environment of the facility or the facility restoration work required after its removal, is substantial. |
| Facilities Life Cycle |
| A facilities life cycle is divided into four stages, requirements (planning and design), acquisition (construction and acceptance), stewardship (operations, maintenance and repair), and disposal. |
| Facilities Maintenance Management |
| The planning, prioritizing, organizing, controlling, reporting, evaluating, and adjusting of facilities maintenance operations to support the CNO/NAVFAC facilities policy and objectives and satisfy customers’ facility needs. Defined by the International Facility Management Association as “the practice of coordinating the physical workplace with the people and work of the organization.” |
| Life-Cycle Costs |
| A form of economic analysis that considers the total cost of owning, operating, and maintaining a building or system over its useful life. |
| Maintenance, Preventive |
| Maintenance designed to increase the availability of the facilities/equipment by reducing the number of unexpected breakdowns or service interruptions. It is any planned maintenance activity that improves equipment life and avoid any unplanned maintenance requirements. |
| Management Information Systems-Maintenance |
| A computerized system that will provide sufficient information for management to evaluate differences between budgets and actual costs and evaluate performance. |
| Repair |
| Repair is the restoration of facilities or equipment to such a condition that it may be effectively utilized for its designated purposes by overhaul, reconstruction, or replacement of constituent parts or materials which have deteriorated by action of the elements or usage, and which have not been corrected through maintenance. This term also applies to replacement of the entire unit or system if beyond economical repair. The intent of repair is to have the equipment at normal working condition. |
| Replacement |
| Replacement, as a distinct work element, is confined to a program of planned replacement of a facility or its components. It may be further limited to major components such as air conditioning compressors, furnaces or hot water heaters. Replacement is performed when the equipment has reached the end of its useful life; when it no longer can perform due to degradation of its internal components and repair is no longer cost effective. Included under the replacement would be the major rebuilding of any component, since rebuilding also restores performance. |
| Response Time |
| Response time is defined as the time allowed the Contractor, after initial Government notification (either verbal or written) of a service request, to be physically on the premises at the work site with appropriate tools, equipment, and materials, ready to perform the work required. |
| Restoration |
| Restoration of real property to such a condition that it can be used for its intended purpose. Includes repair or replacement work to restore facilities damaged by inadequate sustainment, excessive age, natural disaster, fire, accident or other causes. |
| Sustainment |
| Maintenance and repair activities necessary to keep a typical inventory of facilities in “normal working condition”. Sustainment includes regularly scheduled maintenance as well as cyclical major repairs or replacement of components that occur periodically over the expected service life of the facilities. |
Attachment J-1502000-01
DEFINITIONS AND ACRONYMS
| ACRONYM |
| TITLE |
| FI |
| Facilities Investment |
| HVAC |
| Heating, Ventilation, and Air Conditioning |
| OEM |
| Original Equipment Manufacturer |
| PCB |
| Polychlorinated biphenyls |
| PM |
| Preventive Maintenance |
| SRM |
| Sustainment, Restoration and Modernization |
| UFC |
| Unified Facilities Criteria |
Attachment J-1502000-02
REFERENCES AND TECHNICAL DOCUMENTS
| REFERENCE |
| TITLE |
| UFC 3-430-07 |
| Operations and Maintenance: Inspection and Certification of Boilers and Unfired Pressure Vessels |
| UFC 3-410-06N |
| Central Heating Plants Operation and Maintenance |
| DM 1 March 1974 |
| Norme per l'Abilitazione alla Conduzione di Generatori di Vapore |
| NAVFAC MO-118 |
| Inspection of Vertical Transportation Equipment |
| DPR 162/99 |
| Norme per l’attuazione delle direttive 95/16/CE e 2006/42/CE (Ascensori e Montacarichi) |
| UNI EN 81-1 |
| Safety rules for the construction and installation of lifts – Part 1 : Electric lifts |
| UNI EN 81-2 |
| Safety rules for the construction and installation of lifts – Part 2 : Hydraulic lifts |
| NAVFAC MO-200 |
| Facilities Engineering Electrical Exterior Facilities |
| CEI EN 50110-1 |
| Operation of Electrical Installations |
| CEI 11-27 |
| Lavori su Impianti Elettrici |
| UFC 3-601-02 |
| Operation and Maintenance: Inspection, Testing, and Maintenance of Fire Protection Systems |
Attachment J-1502000-03
FACILITIES INVENTORY
NOTE:
THE FACILITIES LISTED BELOW SHALL BE INTENDED INCLUSIVE OF ALL THEIR ALLIED GROUND STRUCTURES, ANNEXES, EQUIPMENT, SYSTEMS, AND ACCESSORIES.
| Facility # |
| Activity |
| # of |
Floors Approx.
Size/Area
GAETA - Old Mill Inn Area
| 707 |
| MWR Recreational Building-Open Mess |
| 2 |
| 380 m² |
| 753 |
| MWR Warehouse |
| 1 |
| 114 m2 |
GAETA - Fleet Landing Area
| 717 |
| Guard Shack |
| 1 |
| 23 m² |
| 719 |
| Port Operations, NCTS |
| 1 |
| 84 m² |
| 725 |
| Tender Transit Shed |
| 1 |
| 240 m² |
| 752 |
| Fitness/Fleet Recreational Center, NEX, Post Office, Housing |
| 2 |
| 250 m² |
| 752A |
| Laundry, Barber Shop, Beauty Salon |
| 1 |
| 115 m² |
| 754 |
| Running Track - Sport Courts - Parking Lot |
| N/A |
| 1200 m² |
| 755 |
| Ship-to-Shore Wastewater Plant |
| N/A |
| 520 lm |
(trailer)
| NSA Admin, NAVSUPP FISC Sigonella, Port Operations, PWD, Security, MSC |
| 1 |
| 338 m² |
Attachment J-1502000-04
HISTORICAL SERVICE REQUEST WORKLOAD
The historical information provided below refers to Gaeta Department only. FI Service Requests are not required at Support Site.
EMERGENCY SERVICE REQUESTS
| FY 11 |
| FY 12 |
| REGION |
| HOUSING |
| REGION |
| HOUSING |
| Approx. Total Cost (lab + mat’l) |
| Quantity |
| OT (*) |
| Quantity |
| OT (*) |
| Quantity |
| OT (*) |
| Quantity |
| OT (*) |
| up to $200 |
| 30 |
| 3 |
| 1 |
| 0 |
| 34 |
| 4 |
| 2 |
| 0 |
| $201-$1000 |
| 6 |
| 1 |
| 0 |
| 0 |
| 4 |
| 1 |
| 1 |
| 0 |
(*) OT (Overtime) indicates the number of emergency service requests placed outside regular working hours.
URGENT SERVICE REQUESTS
| FY 11 |
| FY 12 |
| REGION |
| HOUSING |
| REGION |
| HOUSING |
| Approx. Total Cost (lab + mat’l) |
| Quantity |
| Quantity |
| Quantity |
| Quantity |
| up to $200 |
| 160 |
| 8 |
| 157 |
| 7 |
| $201-$1000 |
| 99 |
| 0 |
| 132 |
| 0 |
ROUTINE SERVICE REQUESTS
| FY 11 |
| FY 12 |
| REGION |
| HOUSING |
| REGION |
| HOUSING |
| Approx. Total Cost (lab + mat’l) |
| Quantity |
| Quantity |
| Quantity |
| Quantity |
| up to $200 |
| 0 |
| Not Required |
| 0 |
| Not Required |
| $201-$1000 |
| 0 |
| Not Required |
| 0 |
| Not Required |
| $1001-$3500 |
| 12 |
| Not Required |
| 12 |
| Not Required |
Attachment J-1502000-05
METER GROUP DESCRIPTIONS
Note: The Contractor shall use the following meter group descriptions as applicable for the type of equipment/systems being maintained under this contract.
| Uniformat Classification & Description |
| Meter & Description |
B2030410 - Overhead Doors
CR-5200 - Record the condition of the Controls
CR-5250 - Record the condition of the Door
CR-5415 - Record the condition of the Guides
CR-5505 - Record the condition of the Motor
B2030901 - Hangar Doors
CR-5050 - Record the condition of the Brakes
CR-5200 - Record the condition of the Controls
CR-5250 - Record the condition of the Door
CR-5415 - Record the condition of the Guides
CR-5505 - Record the condition of the Motor
D1010110 - Hydraulic Elevators
CR-5090 - Record the condition of the Car Assembly
CR-5095 - Record the condition of the Car Operating Panel (COP)
CR-5255 - Record the condition of the Door Assembly
CR-5285 - Record the condition of the Elevator Control
CR-5490 - Record the condition of the Lifting Assembly/Machine
D1010140 - Traction Geared Elevators
CR-5090 - Record the condition of the Car Assembly
CR-5095 - Record the condition of the Car Operating Panel (COP)
CR-5100 - Record the condition of the Car Safeties
CR-5255 - Record the condition of the Door Assembly
CR-5285 - Record the condition of the Elevator Control
CR-5435 - Record the condition of the Hoisting Machine
CR-5620 - Record the condition of the Suspension Means
D1010150 - Traction Gearless Elevators
CR-5090 - Record the condition of the Car Assembly
CR-5095 - Record the condition of the Car Operating Panel (COP)
CR-5100 - Record the condition of the Car Safeties
CR-5255 - Record the condition of the Door Assembly
CR-5285 - Record the condition of the Elevator Control
CR-5435 - Record the condition of the Hoisting Machine
CR-5620 - Record the condition of the Suspension Means
D1010901 - Lifts
CR-5200 - Record the condition of the Controls
CR-5265 - Record the condition of the Drive Assembly
CR-5485 - Record the condition of the Lift Frame
D1020110 - Escalators
CR-5135 - Record the condition of the Comb Plates
CR-5200 - Record the condition of the Controls
CR-5265 - Record the condition of the Drive Assembly
CR-5420 - Record the condition of the Handrails
CR-5485 - Record the condition of the Lift Frame
CR-5600 - Record the condition of the Step Risers/Tread
D1090902 - Cranes and Hoists
CR-5050 - Record the condition of the Brakes
CR-5115 - Record the condition of the Chains/Hooks
CR-5200 - Record the condition of the Controls
CR-5225 - Record the condition of the Crane Unit
CR-5410 - Record the condition of the Guide Wheels
CR-5445 - Record the condition of the Hooklift Motor
CR-5610 - Record the condition of the Structure
CR-5660 - Record the condition of the Trolley Drive
D3020130 - Boiler, Cast Iron, Hot Water, Gas
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5370 - Record the condition of the Flue
CR-5380 - Record the condition of the Fuel System
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
CR-5690 - Record the condition of the Wiring/Connections
D3020134 - Boiler, Cast Iron, Steam, Gas
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5520 - Record the condition of the Pipes/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
D3020136 - Boiler, Cast Iron, Hot Water, Gas/Oil
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5380 - Record the condition of the Fuel System
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
CR-5690 - Record the condition of the Wiring/Connections
D3020138 - Boiler, Cast Iron, Steam, Gas/Oil
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5345 - Record the condition of the Feed Water System
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5370 - Record the condition of the Flue
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
D3020901 - Boiler, Cast Iron, HW, Oil
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5370 - Record the condition of the Flue
CR-5380 - Record the condition of the Fuel System
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
CR-5690 - Record the condition of the Wiring/Connections
D3020902 - Boiler, Cast Iron, Steam, Oil
CR-5060 - Record the condition of the Burner Assembly
CR-5200 - Record the condition of the Controls
CR-5365 - Record the condition of the Firebox/Fire Tubes
CR-5520 - Record the condition of the Pipes/Fittings/Valves
CR-5540 - Record the condition of the Pressure Vessel
D3030130 - Chiller, Reciprocating, Water Cooled
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5200 - Record the condition of the Controls
CR-5295 - Record the condition of the Enclosure
CR-5305 - Record the condition of the Evaporator
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5565 - Record the condition of the Receiver Tank
D3030135 - Chiller, Reciprocating, Air Cooled
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5295 - Record the condition of the Enclosure
CR-5305 - Record the condition of the Evaporator
CR-5520 - Record the condition of the Pipes/Fittings/Valves
CR-5565 - Record the condition of the Receiver Tank
CR-5690 - Record the condition of the Wiring/Connections
D3030140 - Chiller, Centrifugal, Water Cooled
CR-5110 - Record the condition of the Centrifugal Motor
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5210 - Record the condition of the Controls/Sensors
CR-5295 - Record the condition of the Enclosure
CR-5305 - Record the condition of the Evaporator
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5565 - Record the condition of the Receiver Tank
D3030145 - Chiller, Gas Absorption, Water Cooled
CR-5000 - Record the condition of the Absorber
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5200 - Record the condition of the Controls
CR-5295 - Record the condition of the Enclosure
CR-5305 - Record the condition of the Evaporator
CR-5430 - Record the condition of the Heat Generator
CR-5520 - Record the condition of the Pipes/Fittings/Valves
CR-5555 - Record the condition of the Receiver
D3030150 - Chiller, Steam Absorption, Water Cooled
CR-5000 - Record the condition of the Absorber
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5200 - Record the condition of the Controls
CR-5295 - Record the condition of the Enclosure
CR-5305 - Record the condition of the Evaporator
CR-5430 - Record the condition of the Heat Generator
CR-5520 - Record the condition of the Pipes/Fittings/Valves
CR-5555 - Record the condition of the Receiver
| D3030310 - Cooling Tower, Galvanized |
| CR-5025 - Record the condition of the Basin/Sump |
CR-5280 - Record the condition of the Electrodes
CR-5325 - Record the condition of the Fan Assembly
CR-5350 - Record the condition of the Fill Material
CR-5520 - Record the condition of the Pipes/Fittings/Valves
D3030320 - Cooling Tower, Fiberglass
CR-5025 - Record the condition of the Basin/Sump
CR-5280 - Record the condition of the Electrodes
CR-5325 - Record the condition of the Fan Assembly
CR-5350 - Record the condition of the Fill Material
CR-5520 - Record the condition of the Pipes/Fittings/Valves
D3030330 - Cooling Tower, Stainless Steel
CR-5025 - Record the condition of the Basin/Sump
CR-5280 - Record the condition of the Electrodes
CR-5325 - Record the condition of the Fan Assembly
CR-5350 - Record the condition of the Fill Material
CR-5520 - Record the condition of the Pipes/Fittings/Valves
D3030902 - Condenser, DX, Evaporative
CR-5325 - Record the condition of the Fan Assembly
CR-5495 - Record the condition of the Louvers
CR-5515 - Record the condition of the Nozzles
CR-5615 - Record the condition of the Sump Pump
CR-5690 - Record the condition of the Wiring/Connections
D3030903 - Packaged DX Refrigerant System
CR-5140 - Record the condition of the Compressor
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5185 - Record the condition of the Condensing Coils
CR-5200 - Record the condition of the Controls
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3040106 - Air Handling Unit, Field Fabricated
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5145 - Record the condition of the Condensate Piping
CR-5210 - Record the condition of the Controls/Sensors
CR-5235 - Record the condition of the Dampers
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5530 - Record the condition of the Piping/Fittings/Valves
D3040110 - Air Handling Unit, Central Station
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5200 - Record the condition of the Controls
CR-5235 - Record the condition of the Dampers
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5340 - Record the condition of the Fan(s) Assembly
CR-5495 - Record the condition of the Louvers
CR-5530 - Record the condition of the Piping/Fittings/Valves
D3040114 - Air Handling Unit, Rooftop
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5200 - Record the condition of the Controls
CR-5235 - Record the condition of the Dampers
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5340 - Record the condition of the Fan(s) Assembly
CR-5495 - Record the condition of the Louvers
CR-5530 - Record the condition of the Piping/Fittings/Valves
D3040220 - Fan System, Centrifugal In-Line
CR-5200 - Record the condition of the Controls
CR-5235 - Record the condition of the Dampers
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5690 - Record the condition of the Wiring/Connections
D3040230 - Fan System, Utility Set
CR-5330 - Record the condition of the Fan Assy
CR-5630 - Record the condition of the Switches Controls
CR-5690 - Record the condition of the Wiring/Connections
D3040240 - Fan System, Roof Exhaust
CR-5200 - Record the condition of the Controls
CR-5235 - Record the condition of the Dampers
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5690 - Record the condition of the Wiring/Connections
| D3040330 - Circulating Pump, End Suction |
| CR-5045 - Record the condition of the Booster Pump, w/ Oil Reservoir |
| D3040340 - Circulating Pump, Double Suction |
| CR-5045 - Record the condition of the Booster Pump, w/ Oil Reservoir |
D3040610 - Heat Exchanger, Plate Type
CR-5200 - Record the condition of the Controls
CR-5375 - Record the condition of the Frame/Supports
CR-5465 - Record the condition of the Insulation
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5570 - Record the condition of the Relief Valve
CR-5590 - Record the condition of the Steam Modulating Valve
D3040620 - Heat Exchanger, Shell Tube
CR-5200 - Record the condition of the Controls
CR-5375 - Record the condition of the Frame/Supports
CR-5465 - Record the condition of the Insulation
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5570 - Record the condition of the Relief Valve
CR-5590 - Record the condition of the Steam Modulating Valve
D3050170 - Split Systems With Air Cooled Condensing Units
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5460 - Record the condition of the Indoor Fan Motor Assembly
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050185 - Computer Room Cooling Units
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5150 - Record the condition of the Condensate Pump
CR-5210 - Record the condition of the Controls/Sensors
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5450 - Record the condition of the Humidifier
CR-5530 - Record the condition of the Piping/Fittings/Valves
D3050201 - Packaged A/C, Air Cooled, Elec Heat
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5275 - Record the condition of the Duct Connectors
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050203 - Packaged A/C, Air Cooled, HW Heat
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5275 - Record the condition of the Duct Connectors
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050210 - Packaged A/C, Water Cooled, Elec Heat
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050220 - Packaged A/C, Water Cooled, HW Heat
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5295 - Record the condition of the Enclosure
CR-5330 - Record the condition of the Fan Assy
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050255 - Thru-Wall A/C Unit
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5460 - Record the condition of the Indoor Fan Motor Assembly
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D3050260 - Thru-Wall Heat Pump
CR-5120 - Record the condition of the Coils (Cooling)
CR-5125 - Record the condition of the Coils (Heating)
CR-5140 - Record the condition of the Compressor
CR-5155 - Record the condition of the Condenser
CR-5175 - Record the condition of the Condenser Fan(s) Assembly
CR-5200 - Record the condition of the Controls
CR-5260 - Record the condition of the Drain Pan
CR-5460 - Record the condition of the Indoor Fan Motor Assembly
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5690 - Record the condition of the Wiring/Connections
D5010240 - Switchgear
CR-5030 - Record the condition of the Batteries
CR-5055 - Record the condition of the Breakers/Fuses
CR-5475 - Record the condition of the Interlock
CR-5500 - Record the condition of the Meters
D5010901 - Transfer Switch
CR-5245 - Record the condition of the Disconnect/Safety Switch
CR-5295 - Record the condition of the Enclosure
CR-5405 - Record the condition of the Ground System
D5010902 - Transformer
CR-5070 - Record the condition of the Bushings/Insulators
CR-5335 - Record the condition of the Fan(s)
CR-5390 - Record the condition of the Gaskets/Seals
CR-5405 - Record the condition of the Ground System
CR-5510 - Record the condition of the Motor Rotor
CR-5535 - Record the condition of the Pressure Relief Valve
D5010905 - Capacitor Bank
CR-5295 - Record the condition of the Enclosure
CR-5335 - Record the condition of the Fan(s)
CR-5405 - Record the condition of the Ground System
CR-5650 - Record the condition of the Transformer
CR-5690 - Record the condition of the Wiring/Connections
D5010906 - Panelboards
CR-5055 - Record the condition of the Breakers/Fuses
CR-5245 - Record the condition of the Disconnect/Safety Switch
CR-5295 - Record the condition of the Enclosure
CR-5690 - Record the condition of the Wiring/Connections
D5030910 - Communication/Alarm Systems
CR-5015 - Record the condition of the Annunciator/Control Panel
CR-5020 - Record the condition of the Audible/Visual Alarm Device
CR-5030 - Record the condition of the Batteries
CR-5240 - Record the condition of the Detectors
CR-5625 - Record the condition of the Switches
CR-5690 - Record the condition of the Wiring/Connections
D5090210 - Generators
CR-5030 - Record the condition of the Batteries
CR-5200 - Record the condition of the Controls
CR-5220 - Record the condition of the Cooling System/Radiator
CR-5300 - Record the condition of the Engine
CR-5315 - Record the condition of the Exhaust System
CR-5385 - Record the condition of the Fuel Tank and Pump
CR-5400 - Record the condition of the Generator
CR-5530 - Record the condition of the Piping/Fittings/Valves
CR-5585 - Record the condition of the Silencer/Muffler
CR-5690 - Record the condition of the Wiring/Connections
D5090901 - Emergency Lighting
CR-5075 - Record the condition of the Cabinet
CR-5290 - Record the condition of the Encasement/Deflector
CR-5480 - Record the condition of the Lamps/Lamp Heads
CR-5690 - Record the condition of the Wiring/Connections
D5090904 - Uninteruptible Power Supply
CR-5030 - Record the condition of the Batteries
CR-5035 - Record the condition of the Battery Rack
CR-5195 - Record the condition of the Control Panel
CR-5295 - Record the condition of the Enclosure
CR-5680 - Record the condition of the UPS Alarm System
Attachment J-1502000-06
GENERAL DIRECT CONDITION RATING GUIDANCE
Attachment J-1502000-07
METER GROUP CONDITION RATING GUIDANCE
| Meter |
| Direct Condition Rating Guidance |
| CR-5000 |
| GREEN: Absorber has minimal damage and corrosion, but no leaks |
AMBER: Absorber has noticeable damage and corrosion, but minimal leaks and is still operational RED: Absorber has significant damage and corrosion, and noticeable leaks, operationally impaired
| CR-5015 |
| GREEN: Annunciator/Control Panel has minimal damage, alarm component fully operational |
AMBER: Annunciator/Control Panel has minimal signs of wear, but alarm component functions properly RED: Annunciator/Control Panel has noticeable damage, and/or alarm component does not function properly
| CR-5020 |
| GREEN: Alarms function properly |
AMBER: None RED: Alarms do not function properly
| CR-5025 |
| GREEN: Sump has minimal damage or corrosion, no leaking |
AMBER: Sump has noticeable damage or corrosion, but no leaking RED: Sump has significant damage or corrosion, and noticeable leaking, operationally impaired
| CR-5030 |
| GREEN: Batteries provide adequate power to the device. |
AMBER: None.
RED: Batteries do not provide adequate power to the device.
| CR-5035 |
| GREEN: Battery Rack shows little to no signs of corrosion or damage. |
AMBER: Battery Rack shows minimal to noticeable corrosion or damage, but rack is structurally sound RED: Battery Rack shows significant signs of corrosion and/or the rack is significantly damaged, rack is structurally unsound.
| CR-5045 |
| GREEN: Pump has minimal damage or corrosion, no unusual noise/vibration, no leaks, and is fully operational |
AMBER: Pump has noticeable damage or corrosion, slight leaking, unusual noise/vibration, but still operational RED: Pump has significant damage or corrosion, excessive noise/vibration, noticeable leaking, and/or is operationally impaired
| CR-5050 |
| GREEN: Brakes have minimal wear |
AMBER: Brakes have noticeable wear, may exhibit unusual noise, but are still operational RED: Brakes have significant wear, excessive noise, or may not function properly
| CR-5055 |
| GREEN: Breaker successfully trips when circuit is overloaded/shorted out. Fuse is not burnt out. |
AMBER: Breaker has been tripped RED: Breaker does not successfully trip when circuit is overloaded/shorted out. Fuse is burnt out.
| CR-5060 |
| GREEN: Burners have minimal damage or corrosion, but is fully operational |
AMBER: Burners have noticeable damage or corrosion, flame quality may need adjustment, but still operationally sound RED: Burners have significant damage or corrosion, may be loose or displaced, improper flame, and is not operationally sound
| CR-5070 |
| GREEN: Busings/Insulators show little to no signs of damage or wear, fully operational |
AMBER: Bushings/Insulators have noticeable damage or wear, but still operational RED: Busings/Insulators have significant damage or wear, operationally impaired
| CR-5075 |
| GREEN: Minimal damage or corrosion on enclosure, fully secured |
AMBER: Noticeable damage/corrosion to enclosure, may be slightly detached, loose or displaced RED: Significant damage/corrosion to enclosure, loose, displaced, or missing
| CR-5085 |
| GREEN: Cable/Chain has minimal wear, no damage, functions properly |
AMBER: Cable/Chain has noticeable wear, minimal damage, may need adjustment but still functions RED: Cable/Chain has significant wear, excessive damage, and does not function properly
| CR-5090 |
| GREEN: Car Supporting Platform/Frame has no damage, is structurally sound |
AMBER: Car Supporting Platform/Frame has noticeable damage or corrosion, but no loss of structural integrity RED: Car Supporting Platform/Frame has significant damage and corrosion, structural integrity significantly impaired
| CR-5095 |
| GREEN: Car Operating Panel/Indicator has minimal damage and corrosion, fully operational |
AMBER: Car Operating Panel/Indicator has noticeable damage and corrosion, still operational RED: Car Operating Panel/Indicator has significant damage and corrosion, operationally impaired
| CR-5100 |
| GREEN: Safety Buffers have minimal deterioration or damage, fully operational |
AMBER: Safety Buffers have noticeable deterioration or damage, still operational RED: Safety Buffers have significant deterioration or damage, operationally impaired
| CR-5110 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5115 |
| GREEN: Hook has minimal damage or wear, and is fully secured |
AMBER: Hook has noticeable damage or wear, but is still securely fastened RED: Hook has significant damage, connections not secure
| CR-5120 |
| GREEN: Coils have minimal scaling and free of debris. |
AMBER: Coils are clogged, or show significant scaling and deterioration, but minimal damage.
RED: Coils are clogged, show some signs of damage, or significant scaling and deterioration.
| CR-5125 |
| GREEN: Coils have minimal scaling and free of debris. |
AMBER: Coils are clogged, or show significant scaling and deterioration, but minimal damage.
RED: Coils are clogged, show some signs of damage, or significant scaling and deterioration.
| CR-5135 |
| GREEN: Comb Plates have minimal deterioration and damage, and are not loose or displaced |
AMBER: Comb Plates have noticeable deterioration and damage, but are not loose or displaced RED: Comb Plates have significant deterioration and damage, may be noticeably loose, displaced, or misaligned
| CR-5140 |
| GREEN: No excessive noise, vibration, or overheating from compressor, little to no damage and fully operational |
AMBER: Excessive Noise, Vibration, or overheating noticeable from compressor, but compressor is still functional RED: Unacceptable Noise, Vibration, or overheating from compressor, significant damage, and/or operationally impaired
| CR-5145 |
| GREEN: Piping/fittings free of leaks, all connections are tight, valves operate properly, insulation is in place, minimal corrosion |
AMBER: Piping/Fittings show noticeable signs of corrosion, missing or damaged insulation, but connections are tight and no leaking RED: Piping/Fittings are damaged and leaking, valves are not functioning, significant internal scale and corrosion may lead to clogs
| CR-5150 |
| GREEN: Pump has minimal damage or corrosion, no unusual noise/vibration, no leaks, and is fully operational |
AMBER: Pump has noticeable damage or corrosion, slight leaking, unusual noise/vibration, but still operational RED: Pump has significant damage or corrosion, excessive noise/vibration, noticeable leaking, and/or is operationally impaired
| CR-5155 |
| GREEN: Minimal corrosion or fouling of the condenser/coils, no damage |
AMBER: Minimal to noticeable signs of corrosion on coils, or coils are clogged, still operational RED: Significant damage, corrosion or fouling of the condenser/coils, no damage, operationally impaired
| CR-5175 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5185 |
| GREEN: Coils have minimal scaling and free of debris. |
AMBER: Coils are clogged, or show significant scaling and deterioration, but minimal damage.
RED: Coils are clogged, show some signs of damage, or significant scaling and deterioration.
| CR-5195 |
| GREEN: Controls function properly |
AMBER: Controls need calibrating RED: Controls are damaged and/or not operational
| CR-5200 |
| GREEN: Controls function properly |
AMBER: Controls need calibrating RED: Controls are damaged and/or not operational
| CR-5210 |
| GREEN: Controls function properly |
AMBER: Controls need calibrating RED: Controls are damaged and/or not operational
| CR-5220 |
| GREEN: Radiator has minimal damage and corrosion, Fins are straight allowing good airflow, Flow rate is adequate |
AMBER: Radiator has noticeable damage and corrosion, some Fins are bent but still allow good airflow though system, Flow rate is less than usual, but still functional RED: Radiator has significant damage and corrosion, many fins are bent and preventing air flow, Flow is blocked or slowed, operationally impaired
| CR-5225 |
| GREEN: Crane Unit shows minimal signs of wear, no loose components, structurally sound, fully operational |
AMBER: Crane Unit shows noticeable signs of damage or wear, but no loose or missing components, and still operational RED: Crane Unit shows significant signs of damage or wear, may have missing or loose components, comprised structural integrity, or is operationally impaired
| CR-5230 |
| GREEN: Crank Case Heater fully functional |
AMBER: None RED: Crank Case Heater is operationally impaired
| CR-5235 |
| GREEN: Damper has minimal damage, is secured and aligned properly, and fully operational |
AMBER: Damper has noticeable damage and corrosion, may be slightly loose or misaligned, but still operational RED: Damper has significant damage and corrosion, noticeably loose, misaligned, or missing, and/or operationally impaired
| CR-5240 |
| GREEN: Detectors function properly |
AMBER: None RED: Detectors do not function properly
| CR-5245 |
| GREEN: Disconnect/Safety Switch is present and works properly |
AMBER: None RED: Disconnect/Safety Switch is missing or not functional
| CR-5250 |
| GREEN: Door has minimal damage and corrosion, is square and securely fastened |
AMBER: Door has noticeable damage and corrosion, may be slightly displaced, but does not affect door operation or safety RED: Door has significant damage and/or corrosion, noticeably displaced, and may be structurally unsound or affect door operation
| CR-5255 |
| GREEN: Car Doors have minimal damage or wear, door operation is smooth |
AMBER: Car Doors have noticeable damage or wear, doors are operational but may need adjustments RED: Car Doors have significant damage or corrosion, doors are operationally impaired
| CR-5260 |
| GREEN: Drain Pan has minimal damage or corrosion |
AMBER: Drain Pan has noticeable damage or corrosion, but no leaks RED: Drain Pan has significant damage or corrosion, and noticeable leaks
| CR-5265 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5275 |
| GREEN: Ductwork has little to no damage or corrosion, insulation is intact and there are no holes, leaks, or blockages |
AMBER: Ductwork has noticeable damage or corrosion, but minimal leaks or blockages RED: Ductwork has significant damage or corrosion, holes, punctures, leaks, or blockages. Operation is severely impaired
| CR-5280 |
| GREEN: Conductivity Electrodes have minimal damage and corrosion, secure connections and fully functional |
AMBER: Conductivity Electrodes have noticeable damage and corrosion, some loose connections but still functional RED: Conductivity Electrodes have significant damage and corrosion, loose or missing connections, operationally impaired
| CR-5285 |
| GREEN: Controls function properly |
AMBER: Controls need calibrating RED: Controls are damaged and/or not operational
| CR-5290 |
| GREEN: Encasement/Deflector has minimal damage or deterioration, and is fully secured |
AMBER: Encasement/Deflector has noticeable damage or deterioration, some panels may be loose or displaced RED: Encasement/Deflector has significant damage, panels are displaced or missing
| CR-5295 |
| GREEN: Minimal damage and corrosion on Enclosure, fully secured |
AMBER: Noticeable damage/corrosion to Enclosure, Panels may be slightly detached, loose or displaced RED: Significant damage/corrosion to Enclosure, a number of panels are loose, displaced, or missing
| CR-5300 |
| GREEN: Engine operates properly, free of excessive noise/vibration, no fluid leaks or overheating |
AMBER: Engine exhibits unusual noise/vibration, minor fluid leaks but still operational, may require maintenance RED: Engine exhibits excessive noise/vibration, overheating, noticeable fluid leaks, and/or operation is significantly impaired
| CR-5305 |
| GREEN: Minimal corrosion or fouling of the evaporator/coils, no damage |
AMBER: Minimal to noticeable signs of corrosion on coils, or coils are clogged, still operational RED: Significant damage, corrosion or fouling of the evaporator/coils, operationally impaired
| CR-5315 |
| GREEN: Exhaust has minimal damage and corrosion, suppresses engine noise |
AMBER: Exhaust has noticeable damage and corrosion, engine noise is louder than usual RED: Exhaust has significant damage and corrosion, engine noise not being surprised
| CR-5325 |
| GREEN: Fan blades are in balance and free of damage or corrosion |
AMBER: Excessive Noise/Vibration, but blades not bent or corroded, fully operational RED: Fans blades are out of balance, significantly bent or corroded, or fan is operationally impaired
| CR-5330 |
| GREEN: Fan blades are in balance and free of damage or corrosion |
AMBER: Excessive Noise/Vibration, but blades not bent or corroded, fully operational RED: Fans blades are out of balance, significantly bent or corroded, or fan is operationally impaired
| CR-5335 |
| GREEN: Fan blades are in balance and free of damage or corrosion |
AMBER: Excessive Noise/Vibration, but blades not bent or corroded, fully operational RED: Fans blades are out of balance, significantly bent or corroded, or fan is operationally impaired
| CR-5340 |
| GREEN: Fan blades are in balance and free of damage or corrosion |
AMBER: Excessive Noise/Vibration, but blades not bent or corroded, fully operational RED: Fans blades are out of balance, significantly bent or corroded, or fan is operationally impaired
| CR-5345 |
| GREEN: Feed Water System has no damage or leaks, fully operational |
AMBER: Feed Water System has noticeable damage or corrosion, may have slight leaks but still operational RED: Feed Water System has significant damage or corrosion, noticeable leaks, and does not function properly
| CR-5350 |
| GREEN: Filter has minimal to no dirt and debris, free of damage |
AMBER: Filter shows noticeable signs of debris, but little to no damage allowing unobstructed flow RED: Air Filter clogged with dirt and debris, or shows signs of damage such as, punctures, tears, rips
| CR-5365 |
| GREEN: Firebox has minimal damage or corrosion |
AMBER: Firebox has noticeable damage or corrosion, but no cracks or holes RED: Firebox has significant damage or corrosion, cracks or holes may be present
| CR-5370 |
| GREEN: Flue has minimal damage, is secured and aligned properly, and fully operational |
AMBER: Flue has noticeable damage and corrosion, may be slightly loose or misaligned, but still operational RED: Flue has significant damage and corrosion, noticeably loose, misaligned, or missing, and/or operationally impaired
| CR-5375 |
| GREEN: Supports have minimal damage and corrosion, are fully stable and secure |
AMBER: Supports have noticeable damage and corrosion, but still structurally stable and secure RED: Supports have significant damage and corrosion, and/or unstable or not secured
| CR-5380 |
| GREEN: Little to no damage or corrosion, secure connections, no leaks, fully operational |
AMBER: Fuel System has noticeable damage or corrosion, but free of leaks, fully operational RED: Fuel System has significant damage or corrosion, significant leaking, and/or is operationally impaired
| CR-5385 |
| GREEN: Fuel Tank and Pump has little to no damage, no leaks, fully operational |
AMBER: Fuel Tank and Pump has some noticeable damage, but no leaks and fully operational RED: Fuel Tank and Pump has significant damage and corrosion, may have leaks, or is operationally impaired
| CR-5390 |
| GREEN: Gaskets/Seals are fully intact, no leaks |
AMBER: Gaskets/Seals experience slight leaking RED: Gaskets/Seals show noticeable signs of leaks
| CR-5400 |
| GREEN: Generator is fully operational, no excess noise, vibration, or overheating |
AMBER: Generator exhibits excess noise or vibration, but no overheating and is still operational RED: Generator exhibits excess noise, vibration, or overheating, and/or is operationally impaired
| CR-5405 |
| GREEN: No damage to grounding system, all connections are secure, fully operational |
AMBER: Slight damage or corrosion, but connections are secure and Grounding System is operational RED: Significant damage or corrosion, loose or missing connections, inadequately grounded
| CR-5410 |
| GREEN: Guide Wheels show little to no wear or damage, are securely fastened, and fully functional |
AMBER: Guide Wheels have noticeable wear, may have slight damage, but are secure and still operational RED: Guide Wheels have significant damage, may be loose, displaced, missing, or operationally impaired
| CR-5415 |
| GREEN: Guides/Stops/Rollers/Pulleys show no signs of wear or damage, and are properly secured and aligned |
AMBER: Guides/Stops/Rollers/Pulleys show slight wear, and/or may be slightly loose or misaligned RED: Guides/Stops/Rollers/Pulleys have noticeable damage or wear, and are insecurely fastened and/or misaligned
| CR-5420 |
| GREEN: Handrails have minimal damage or corrosion, and are fully secured |
AMBER: Handrails have noticeable damage or corrosion, slightly loose but still operational RED: Handrails have significant damage or corrosion, noticeable loose or missing
| CR-5430 |
| GREEN: Heating Element has little to no damage or corrosion, and is fully operational |
AMBER: Heating Element has noticeable damage or corrosion, but still operational RED: Heating Element has significant damage or corrosion, operationally impaired
| CR-5435 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5440 |
| GREEN: Hook has minimal damage or wear, and is fully secured |
AMBER: Hook has noticeable damage or wear, but is still securely fastened RED: Hook has significant damage, connections not secure
| CR-5445 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5450 |
| GREEN: Pan has minimal damage or corrosion |
AMBER: Pan has noticeable damage or corrosion, but no leaks RED: Pan has significant damage or corrosion, and noticeable leaks
| CR-5455 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5460 |
| GREEN: Motor operates properly, free of excessive noise/vibration, or overheating |
AMBER: Motor exhibits unusual noise/vibration, but still operational, may require maintenance RED: Motor exhibits excessive noise/vibration, overheating, and/or operation is significantly impaired
| CR-5465 |
| GREEN: Insulation has minimal deterioration, and is mostly in place where necessary |
AMBER: Insulation has noticeable deterioration, portions may be loose or displaced, but mostly intact RED: Insulation is significantly damaged, or large portions are displaced or missing
| CR-5475 |
| GREEN: Interlocks have no damage, none are loose or missing |
AMBER: A small number of interlocks are damaged, loose, or missing RED: Significant number of interlocks are damaged, loose or missing
| CR-5480 |
| GREEN: Lamps/Lamp Heads have minimal damage or deterioration, are secure, and fully operational |
AMBER: Lamps/Lamp Heads have noticeable damage or deterioration, some may be loose, but still operational RED: Lamps/Lamp Heads have significant damage or deterioration, a significant number may be loose or missing, and/or operationally impaired
| CR-5485 |
| GREEN: Platform has little to no damage or deterioration, and is structurally sound |
AMBER: Platform has noticeable damage or deterioration, but still structurally sound RED: Platform has significant damage or deterioration, may be loose or…
This is the start of the file's text. The full file is on GovTribe.
Other files
Show all 46
On GovTribe
Work with this file
- Download the original file
- Contacts named in this file
- Similar government files
- Ask GovTribe AI about this file
File details come from the government source that posted it. Updated .