66_M-502 - MECHANICAL DETAILS.pdf

AIR FLOW

MV

MV

MV

MV

NOTES:

1. INSTALL CONTROL VALVE BETWEEN UNIONS OR FLANGES.

2. PROVIDE CONCENTRIC REDUCERS BOTH SIDES OF CONTROL VALVE AS REQUIRED.

3. REPLACE UNION/FLANGE SET WITH A FLEXIBLE PIPE CONNECTOR WHERE EQUIPMENT IS

SUPPORTED OR SUSPENDED BY SPRING ISOLATORS.

4. ARRANGEMENT SHOWN FOR FULL FLOW THROUGH COIL ON FAILURE.

COMBINATION UNION

AND PT PORT (TYP)

COIL

COIL DRAIN WITH CAP AT

LOWEST POINT OF COIL (TYP)

PRESSURE

GAUGE (TYP)

THERMOMETER

(TYP)

MANUAL AIR VENT

(TYP)

2-WAY PRESSURE

INDEPENDENT CONTROL

VALVE

SEE NOTE 2

UNION (TYP)

ISOLATION VALVE (TYP)

INSTALL MANUAL AIR VENT AT HIGH

POINT WHEN TAPPED INTO TO OF

MAINS. USE A PIPE STUB WITH MIN

HEIGHT OF 4 PIPE DIAMETERS (TYP)

CONNECT TO SUPPLY AND RETURN

MAINS AS SHOWN ON PLAN

RETURN PIPING MAIN

SUPPLY PIPING MAIN

SEE PLAN FOR PIPE SIZES

DRAW THRU

BLOW THRU

X

2X

UNIT TYPE A B

WHERE X = STATIC PRESSURE IN PAN

CLEAN OUT

FLOOR SINK

NOTES:

1. CPVC PIPE MAY BE USED ONLY IF APPROVED BY LOCAL VA AND IS INDOORS

AND DOES NOT PASS THROUGH RATED BARRIERS.

2. DIELECTRIC FITTING TO BE USED WHEN TWO DISSIMILAR METALS ARE TO BE

CONNECTED.

PITCH DOWN

TOWARD DRAIN

DRAIN LINE SHALL BE AT LEAST THE SAME SIZE

AS THE NIPPLE ON THE DRAIN PAN PIPING

SHALL BE RIGID COPPER TYPE L OR TYPE M

UNLESS NOTE BELOW IS MET

DRAIN

PAN

DIELECTRIC

FITTING

1" MINIMUM

2" PLUS X

B A

1"

AIR FLOW

MV

MV

PRESSURE INDEPENDENT

CONTROL VALVE

COMBINATION UNION/BALL

VALVE WITH TEST PLUG AND

UNION END

INSTALL MANUAL AIR VENT AT HIGH

POINT WHEN TAPPED INTO TOP OF

MAINS. USE A PIPE STUB WITH MIN.

HEIGHT OF 4 PIPE DIAMETERS (TYP).

CONNECT TO SUPPLY AND RETURN

MAIN AS SHOWN ON PLANS.

RETURN PIPING MAIN

SUPPLY PIPING MAIN

SEE PLAN FOR PIPE SIZESSTAINLESS STEEL

BRAIDED HOSE

COMBINATION BALL VALVE

ISOLATION/STRAINER WITH P/T TEST

PLUG, BLOW DOWN DRAIN VALVE,

MANUAL AIR VENT, AND UNION END.

COIL

HHS

HHR

DP

OPTION "A"

OPTION "B"

ROOF DECK

ABS CURB CAP

EPDM RUBBER CAP

INSULATION

1" CLEAR OPENING AROUND

PIPE TO ALLOW FOR PIPE

MOVEMENT

INSULATED ROOF CURB

WITH 26 GA. GALVANIZED

COUNTER FLASHING

ACRYLIC COATED ABS

RUB REINFORCED

PLASTIC CURB COVER

EPDM PROTECTIVE

RUBBER CAP

STAINLESS STEEL

CLAMP

SINGLE OR MULTIPLE

PENETRATIONS

PIPE PENETRATION(S)

PER PLAN

PIPE

INSULATION

SCREW CAP

PIGTAIL OR VIBRATION

ISOLATOR

1/4" PIPE, GUAGE COCK

AND PIPEFITINGS

CONTINOUS

WELD

WELD-O-LET

NOT TO SCALE

TYPICAL AHU COIL PIPING - 2-WAY (PIC) VALVE1NOT TO SCALE

AIR HANDLING UNIT DRAIN TRAP3 NOT TO SCALE

TYPICAL HYDRONIC COIL PIPING - 2-WAY (PIC) VALVE2NOT TO SCALE

PIPE ROOF PENETRATION CURB4

NOT TO SCALE

TYPICAL GAUGE OUTLET DETAIL5

th re e in c h e s o n e fo o t o n e a n d o n e h a lf in c h e s o n e fo o t o n e in c h o n e fo o t th re e q u a rt e rs in c h o n e fo o t o n e h a lf in c h o n e fo o t th re e e ig h th s in c h o n e fo o t o n e q u a rt e r in c h o n e fo o t o n e e ig h th in c h o n e fo o t

A

B

C

D

E

F

Veterans Health

Administration

VA FORM 08-6231

Drawing Title Project Title

Location

Date Checked Drawn

Project Number

Building Number

Drawing Number

CONSULTANTS:

Drawing #

VA Office Of Construction & Facilities Management Approval:

ARCHITECT:

SPUR DESIGN, LLC

312 SW 25TH STREET

Oklahoma City, OK 73109

(405) 842-6100

OK ARCH REG. NO. CA02295, EXP. 06/30/2023

OK ENGR REG. NO. CA7127, EXP. 06/30/2023

The information on this document is preliminary or incomplete, not for construction, recording purposes, or implementation.

FULLY SPRINKLERED

1 2 3 4 5 6 7 8 9

1 2 3 4 5 6 7 8 9

A

B

C

D

E

F

STAMP:

STRUCTURAL ENGINEER

H2B, INC.

1225 N. LOOP WEST, SUITE 800

HOUSTON, TX 77008

(713) 864-2900

MECH / ELEC / PLUMB / TECH ENGINEER

FIRE PROTECTION ENGINEER

POOLE FIRE PROTECTION, INC.

19910 WEST 161ST STREET

OLATHE, KANSAS 66062

(913) 829-8690

HEALTHCARE PLANNER

OCULUS INC.

1 S. MEMORIAL DR., SUITE 1500

ST. LOUIS, MO 63102

(314) 367-6100

SPUR PROJECT NUMBER: 1791.08

SPUR DESIGN

11020 KING STREET, SUITE 350

OVERLAND PARK, KS 66210

(913) 369-7200

SEE FRONT COVER SHEET

FOR APPROVAL SIGNATURE

VERTICAL TRANSPORTATION

ENVIRONMENTAL HYGIENIST

TEC-AN, INC.

2517 S. PURDUE AVE.

OKLAHOMA CITY, OK 73128

(405) 681-7076

LERCH BATES

2001 BRYAN ST., SUITE 1930

DALLAS, TX 75201

(972) 294-5221

/2

/2

:2 :0

P

M

M-502

MECHANICAL DETAILS

JLF

66 OF 92JRM

100% RFP DOCUMENTS

CONSTRUCT SURGICAL INTENSIVE

CARE UNIT & RENOVATE

OPERATING ROOMS

08/02/2021

635-436

OKLAHOMA CITY VA HEALTHCARE SYSTEM

921 NE 13TH ST, OKLAHOMA CITY, OK 73104

No. REVISION DESCRIPTION DATE