Appendix H - C20_C37AB CMP Codes.pdf

For the best experience, open this PDF portfolio in

Acrobat X or Adobe Reader X, or later.

Get Adobe Reader Now!

http://www.adobe.com/go/reader

Appendix H Depot CLIN Listing for C-37A/B

CLIN No. Firm Fixed Price Depot CLINS for C-37A X700 "4C" Checks (A Models) X701 48 Month Initial/48 Month Recurring Insp (A Models) X702 "8 C" Checks (A Models) X703 72 Month Recurring Insp (A Models) X704 96 Month Initial/96 Month Recurring Insp (A Models) X705 144 Month Initial/96 Month Recurring Insp (A Models) X706 144 Month Initial/144 Month Recurring Insp (A Models) X707 192 Month Initial/192 Month Recurring Aircraft Structural Inspections (A Models) X708 192 Month Initial/144 Month Recurring Aircraft Structural Inspections (A Models) X709 192 Month Initial/various recurring Engine related structural inspections (A Models) X710 Horizontal Stabilizer Restor/Discard (12 yrs) (A Models) X711 Landing Gear Overhaul at 5000 Landings (A Models) X712 Main Landing Gear Sponson Bore Structural Inspection (A Models) X713 8000 Initial Landing Items (A models) X714 12000 Initial Landing Items (A Models) X715 2700 Initial/2300 Recurring Landings (A Models) X716 Flap B&C Track 5300 Initial/2000 Recurring Landings (A Models) X717 Forward Engine Mount at 5000 Initial/2000 Recurring (A Models) X718 FS 465 Frame Stringer 9 and Below at 5400 Initial/2700 Recurring (A Models) X719 FS 465 Frame Stringer 9 and Below at 80000 Initial/8000 Recurring (A Models)

X720 RESERVED

X721 8300 Cycle Initial/2755 Cycle Recurring - Elevator & Rudder Hinge Bolts and Sleeves (A Models)

Firm Fixed Price Depot CLINS for C-37B X725 "4C" Checks (B Models) X726 48 Month Initial/48 Month Recurring Insp (B Models) X727 "8 C" Checks ( B Models) X728 96 Month Initial/96 Month Recurring Insp (B Models) X729 144 Month Initial/96 Month Recurring Insp (B Models) X730 144 Month Initial/144 Month Recurring Insp (B Models) X731 192 Month Initial/Various Recurring Aircraft Structural Inspections (B Models) X732 192 Month Initial/various recurring Engine related structural inspections (B Models) X733 Main Landing Gear Sponson Bore Structural Inspection (B Models) X734 Horizontal Stabilizer Restor/Discard (12 yrs) (B Models) X735 Landing Gear Overhaul at 5000 Landings (B Models) X736 5000 initial/2000 Recurring Landings (Fwd Upper Bulkhead) (B Models) X737 2700 Initial/2300 Recurring Landings (B Models) X738 Flap B&C Track 7200 initial/3400 Recurring Landings ( B Models) X739 8000 Initial Landing Items (B Models) X740 Lwr Sponson Doubler 6000 Cyc Initial/1370 Cyc Recurring Insp (B Models) X741 72 Mo Recurring Insp (B Models) NEW X742 192 Mo Initial /192 Recurring Aircraft Structural Inspections (B Models) NEW X743 FWD Wing to Fuselage Fitting 7500 Cyc Initial/1400 Cyc Recurring Insp (B Models) NEW

Appendix H Depot CLIN Listing for C-37A/B

Firm Fixed Price Depot CLINS Common to C-37A & B X745 APU Life Limited Part Replacement at 10,000 Hours (to include Remove/Replace and Life Limited Parts)

(A & B Models - CMP Codes 492001, 492002, 492003) X746 APU Inspection (to include Remove/Replace) (A & B Models) X747 48 Mo Detailed Corrosion Inspection - NLG & MLG (A & B Models - CMP Codes

321003,321004,321221,321222,321228,321232,321235,321236,321239,321240,321243,321244,32124 7,321248,321251,321252,321255,321256,321259,321260,321263,321264,322003,322220, 321201, 321202, 322202)

X748 Aircraft Complete Strip and Paint to include Wheel Wells - Blue & White (A & B Models) X749 Aircraft Complete Strip and Paint to include Wheel Wells - White Only (A & B Models) X750 Teflon Coating (A & B Models) X751 Remove and Replace Engine (A & B Models - CMP Codes 710001(LH) or 710002(RH))

X752 RESERVED

X753 RESERVED

X754 Weight and Balance (A & B Models) X755 Flight Test/Functional Check Flight (A & B Models)

X756 2900 Cyc Recurring Insp - Side Post Upper Attach NDT Insp (A & B Models - CMP Codes 531715 & 531716)

X757 6300 Cyc Initial/1000 Cyc Recurring Insp - Center Post Lwr Attach NDT Insp (A & B Models - CMP Code 531721)

X758 6100 Cyc Initial/1100 or 1300 Cyc Recurring - Cockpit Side Post & Lwr Side Rail NDT Insp (A & B Models - CMP Codes 531717 & 531718)

X759 144 Mos Recurring Insp - Windshield Rails & Posts (LT & RT) Detailed Insp (A & B Models - CMP Codes

531700 & 531701) NEW

X760 144 Mos Recurring Insp - Side Windows Rails & Posts (LT & RT) Detailed Insp (A & B Models - CMP Codes

531705 & 531706) NEW

X761 12 Mos Recurring - Leading Edge Polishing (A & B Models - CMP Codes 545003, 545004, 551113, 553013, 574013,574014, 711109, 711110) NEW

Appendix H C-37A FFP Depot CLINS CMP CODES

Code Code Description 236001 L Wing Static Wicks / Bonding - Functional

Test

236002 R Wing Static Wicks / Bonding - Functional

236003 L Horizontal Stab Static Wick / Bonding - Functional Test

236004 R Horizontal Stab Static Wick / Bonding -

236005 Vertical Stabilizer Static Wick / Bonding -

236006 Tail Cone Static Wick / Bonding - Functional

251021 Crew Seats Locking Mechanism and Seat Tracks (Pilot) - Detailed Inspection

251022 Crew Seats Locking Mechanism and Seat Tracks (Copilot) - Detailed Inspection

251023 Crew Seats Locking Mechanism and Seat Tracks (Observer) - Detailed Inspection

252101 Passenger Seats Attachments and Locking - Detailed Inspection

261418 Aft Equipment Overheat Thermal Switches -

272303 Standby Rudder System - Operational Test

275302 Flap Tracks - General Visual Inspection

284301 Fuel Tank Temperature Bulb - Functional

491207 APU Inlet Door & Actuator - Detailed Inspection

527201 Internal Baggage Door - Functional Check

535028 Tail Compartment Above Floor Electrical Junction Boxes - Detailed Inspection

560001 Emergency Window Release Mechanism - Operational Test

"4 C" Checks (A Models) CLIN X700

Code Code Description Code Code Description 350002 Crew / Passenger Oxygen System Check

Valves - Operational Check 533202 FS 426 Bulkhead - Inspection

351206 Crew Oxygen Low-Pressure Switch -

533335 Longeron 22 at FS 417 - FS 426.5 - Detailed

521012 Main Entrance Door Internal - Detailed

571110 Lower Cover Splice and Coaming Stringers (Left) - NDT Inspection

521016 Main Entrance Door Cables - Tension Check 571112 Lower Cover Splice and Coaming Stringers (Right) -

533620 Pressure Blkd FS 758 Composite Panels -

571201 Rear Spar BL 6 - BL 35 (Left) - NDT Inspection

534202 Flat Pressure Bulkhead Forward And Aft Face Above Floor, Fs 758 - Special Detailed

571202 Rear Spar BL 6 - BL 35 (Right) - NDT Inspection

539004 Lower Antenna & Penetration Interface -

571709 External Rear Beam Web at BL 49 - NDT Inspection

539005 Upper Antenna & Penetration Interface -

575220 Flap Rear Spar at B, C and D Track Cutouts (Left) -

551025 Horizontal Stabilizer Leading Edge Upper and Lower Surfaces (Left) - GVI

575222 Flap Rear Spar at B, C and D Track Cutouts (Right) -

551026 Horizontal Stabilizer Leading Edge Upper and Lower Surfaces (Right) - GVI

783111 Primary Door Actuator Rod End (Left) -

783112 Primary Door Actuator Rod End (Right) -

12000 Initial Landing Items (A Models) CLIN X714

72 Mo Recurring Insp (A Models) CLIN X703

242001 Tail Compartment AC Feeder Cables - Detailed

282604 Engine Feed Dual Wall Fuel Line Shroud (Right) -

243020 Tail Compartment DC Feeder Cables - Detailed

282605 APU Feed Dual Wall Fuel Line Shroud -

271008 Aileron Trim Tab Actuator / Linkage - General Visual

282611 Engine Heated Return Feed Dual Wall Fuel Line Shroud (Left) - Functional Test

271010 Aileron Control and Trim Cables in Pressurized Areas of Fuselage and Overwing to Aft Wing Links - Detailed

282612 Engine Heated Return Feed Dual Wall Fuel Line Shroud (Right) - Functional Test

272012 Rudder Torque Tube - Inspection 301121 Wing Hot / Wing Temp Low Message (Left) -

272107 Rudder Control and Trim Cables in Pressurized Areas of Fuselage / Overwing to Aft Wing Links - Detailed

301122 Wing Hot / Wing Temp Low Message (Right) -

273019 Elevator Drive Rod - Lubrication

273099 Elevator Control and Trim Cables in Pressurized Areas of Fuselage and Overwing to Aft Wing Links - Detailed

276104 Speedbrake Cable Assemblies in Fuselage and Overwing Area to Aft Links - Detailed Inspection

281409 Flapper Check Valve (Left) - Inspection

281410 Flapper Check Valve (Right) - Inspection

281515 L Wing Vent Float Drain Valve - Detailed Inspection

281516 R Wing Vent Float Drain Valve - Detailed Inspection

281527 L Overboard Vent / Ram Air Inlet Mast - Inspection

281528 R Overboard Vent / Ram Air Inlet Mast - Inspection

282603 Engine Feed Dual Wall Fuel Line Shroud (Left) -

"8 C" Checks (A Models)

CLIN X702

533205 FS 465 Frame Stringer 9 and Below (Left) - NDT

552012 Elevator Hinge Bolts and Sleeves - Detailed

533206 FS 465 Frame Stringer 9 and Below (Right) - NDT

554020 Rudder Hinge Fittings Bolts and Sleeves -

FS 465 Frame Stringer 9 & Below at 8000 Initial/8000 Recurring Landing (A Models - Eff 625 & Higher) CLIN X719

8300 Cycle Initial/2755 Cycle Recurring Elevator and Rudder - Hinge Bolts & Sleeves (A Models)

CLIN X721

520005 Exterior Cabin Doors and Exits - Zonal

533300 Longeron 24 Left and Right FS 632 - FS

758 - Detailed Inspection

521011 Main Entrance Door - Zonal Inspection 533415 Drag Beam Overwing Installation -

523006 Baggage Compartment Door - Zonal

533600 Auxiliary Pressure Bulkhead Installation Below Floor FS 684 - Detailed I ti531010 Radome FS -4 thru FS 63 - Zonal Inspection 533615 Pressure Bulkhead Installation Below Floor FS 758 - Detailed Inspection

531013 (If Installed)

EVS Fairing and Rain Diverter Fairing -

534000 Aft Engine Mount Frame Structure -

531020 Cockpit Below Floor FS 119 - FS 145 - Zonal

551015 Horizontal Stabilizer Trailing Edge (Left)

- Zonal Inspection

531025 Lower Fuselage FS 85 - FS 119 Cheek Panel (Left) - Zonal Inspection

551016 Horizontal Stabilizer Trailing Edge (Right) - Zonal Inspection

531026 Lower Fuselage FS 85 - FS 119 Cheek Panel

553010 Vertical Cap, SATCOM and Bullet Fairing - Zonal Inspection

531030 Internal Cockpit Below Floor FS 63 - FS 85, WL 81 - WL 71 - Zonal Inspection

553016 Vertical Stabilizer Box Section Internal Flight Controls - Zonal Inspection

531035 Cabin Below Floor FS 229 - FS 426 - Zonal

553020 Vertical Stabilizer Rear Beam Aft Face - Zonal Inspection

531041 Upper Surface of Center Wing FS 426 - FS 576 From Cabin - Zonal Inspection

562015 Overwing Emergency Exits - Zonal

531050 Overwing Area FS 354 - FS 736 Between Drag Beam and Wing to Body Fairing (Left) - Zonal

570017 Wing Rear Beam at Aileron (Left) - Zonal

531051 Overwing Area FS 354 - FS 736 Between Drag Beam and Wing to Body Fairing (Right) -

570018 Wing Rear Beam at Aileron (Right) -

531066 External Upper Fuselage FS 63 - 758 - Zonal

570200 Wing Box Structure Forward Spar Through Gap Bands (Left) - Detailed

531090 External Aft Fuselage and Empennage FS 758

- FS 1123 - Zonal Inspection

570201 Wing Box Structure Forward Spar Through Gap Bands (Right) - Detailed

531105 Aft Fuselage Below Floor FS 797 - FS 974 -

570205 Fuel Tank Internal (Left) - Detailed

532120 Cabin Internal Below Floor and Below Stringer 19 Left / Right - Detailed Inspection

570206 Fuel Tank Internal (Right) - Detailed

532300 Longeron 22 Installation Under Galley / Lavatory (Wet Areas) FS 145 - FS 426 -

571601 Wing to Fuselage Attach Corrosion Resistant Steel / Titanium Fitting -

532500 Floor Structure Under Galleys, Lavatories FS 139 - FS 758 (Wet Areas) - Detailed Inspection

574017 Wing Leading Edge With Gap Bands Removed (Left) - Zonal Inspection

532520 Floor Beam and Wing Link FS 465 - FS 576 -

574018 Wing Leading Edge With Gap Bands Removed (Right) - Zonal Inspection

532525 Floorboards FS 426 - FS 632 Areas Below Galleys, Lavatory (Wet Areas) - Detailed

711305 Powerplant and Pylon External (96 Month) (Left) - Zonal Inspection

711306 Powerplant and Pylon External (96 Month) (Right) - Zonal Inspection

96 Mo Initial/96 Mo Recurring Insp (A Models) CLIN X704

240111 L Emergency Battery Pack - Discard 570005 Wing Upper Surface View from on Wing

240112 R Emergency Battery Pack - Discard 570006 Wing Upper Surface View from on Wing

240113 Fwd Emergency Battery Pack - Discard 570013 Upper Wing Extension BL 542 - BL 545 (View from on Wing) (Left) - Zonal

240114 Aft Emergency Battery Pack - Discard 570014 Upper Wing Extension BL 542 - BL 545 (View from on Wing) (Right) - Zonal

384003 FILTER, #1 AIR PUMP - CLEANING 573010 Winglet Blade (View From Ground)

531036 Cabin Below Floor FS 145 - FS 229 - Zonal

573011 Winglet Blade (View From Ground)

531040 Upper Surface of Center Wing FS 426 - FS 576 From Wheel Well - Zonal Inspection

575300 Flap Upper Skins - Detailed Inspection

531100 Aft Fuselage Below Floor FS 758 - FS 797 -

541005 Pylons External (Left) - Zonal Inspection

541006 Pylons External (Right) - Zonal Inspection

541010 Pylons Internal (Left) - Zonal Inspection

541011 Pylons Internal (Right) - Zonal Inspection

551027 HSTAB TRAILING EDGE AREA (ELEVATOR

CURTAINS REMOVED, Left) - DETAILED

INSPECTION

551028 HSTAB TRAILING EDGE AREA (ELEVATOR

CURTAINS REMOVED, Right) - DETAILED

INSPECTION

551111 Elevator Upper Surface - Detailed inspection

551201 HSTAB INTERNAL CORROSION INHIBITING

COMPOUND (LEFT) - RESTORE

551202 HSTAB INTERNAL CORROSION INHIBITING

COMPOUND (RIGHT) - RESTORE

48 Month Initial/48 Month Recurring Insp (A Models) CLIN X701

523201 Baggage Compartment Door Internal Structure -

524001 Tail Compartment Door - Zonal Inspection

532110 Below Emergency Exits - Detailed Inspection 525002 Auxiliary Pressure Bulkhead Door - Zonal

532115 Baggage Door Surround Structure - Detailed

531300 Longeron Installation L / R BL 12 FS 119 - 145 (Left) - Detailed Inspection

552001 Elevator External for Delamination (Left) -

531305 Longeron Installation L / R BL 12 FS 119 - 145 (Right) - Detailed Inspection

552002 Elevator External for Delamination (Right) -

532105 Cabin Internal Structure Headliner Removed All Penetrations - Detailed

552005 Elevator Hinge (Left) - Detailed Inspection 533410 Torque Box Installation / Connections -

552006 Elevator Hinge (Right) - Detailed Inspection 533610 Forward Engine Mounts Installation FS

554005 Rudder External for Delamination - Detailed

551014 Horizontal Stabilizer Hinge and Actuator Fitting - Detailed Inspection

575601 Trailing Edge Flight Control Attach Hinge / Support Fittings (Left) - Detailed Inspection

554010 Rudder Assembly Front Beam Internal -

575602 Trailing Edge Flight Control Attach Hinge / Support Fittings (Right) - Detailed Inspection

711310 Powerplant Nose Cowls Internal (Left) -

576005 Aileron Ballast Weights (Left) - Detailed

711311 Powerplant Nose Cowls Internal (Right) -

576006 Aileron Ballast Weights (Right) - Detailed

576010 Aileron Tab / Spoilers External for Delamination -

551012 Horizontal Stabilizer Assembly (Interior) {Left} -

551013 Horizontal Stabilizer Assembly (Interior) {Right} -

144 Mo Initial/ 96 Mo Recurring Insp (A Models) CLIN X705

144 Mo Initial /144 Mo Recurring Inspection (A Models) CLIN X706

531070 Cockpit Above Floor FS 63 - FS 145 - Zonal

531019 Cockpit Internal Structure Headliner Removed -

531074 Cabin Above Floor FS 145 - FS 758 - Zonal

531200 Bulkhead Installation FS 44 - Detailed

531076 Cabin Above Floor FS 145 - FS 758 - (Enhanced)

531205 Bulkhead Installation FS 63 - Detailed

531110 Tail Cone FS 974 - FS 1026 - Zonal Inspection 531210 Bulkhead Installation FS 85 - Detailed

532305 Longeron 22 Installation Not Under Galleys and Lavatories (Dry Areas), FS 145 - FS 426 - Detailed

531215 Bulkhead Installation FS 119 - Detailed

551005 Horizontal Leading Edge (Left) - Zonal Inspection 531220 Bulkhead Installation FS 133 - Detailed

551006 Horizontal Leading Edge (Right) - Zonal Inspection 531700 Windshield Rails and Posts Internal (Left) -

551010 Horizontal Stabilizer Box (Left) - Zonal Inspection 531701 Windshield Rails and Posts Internal (Right) -

551011 Horizontal Stabilizer Box (Right) - Zonal Inspection 531705 Side Window Rails and Posts Internal (Left) -

553005 Vertical Stabilizer Leading Edge Lower Section -

531706 Side Window Rails and Posts Internal (Right) -

553015 Vertical Stabilizer Box Section Internal Structure -

532505 Floor Structure Not Under Galleys, Lavatories FS 139 - FS 758 (Dry Areas) - Detailed Inspection

573005 Wing Extension BL 542 - BL 545 (Left) - Zonal

532510 Floorboards FS 426 - FS 632 Between Left / Right BL 30 - Detailed Inspection

573006 Wing Extension BL 542 - BL 545 (Right) - Zonal

532515 Floorboards FS 426 - FS 632 Outboard Left / Right BL 30 - Detailed Inspection

574019 Wing Leading Edges Removed (Left) - Zonal

532600 Electronic Equipment Rack to Fuselage Upper Attachment Structure (Left) - Detailed

574020 Wing Leading Edges Removed (Right) - Zonal

532601 Electronic Equipment Rack to Fuselage Upper Attachment Structure (Right) - Detailed

551031 Horizontal Stab Leading Edge Internal Structure (LE Removed, Left) - Detailed Inspection

533400 Bulkhead Installation FS 426 Aft Face - Detailed

551032 Horizontal Stab Leading Edge Internal Structure (LE Removed, Right) - Detailed Inspection

533405 Lower Bulkhead Stiffeners and Angles at FS 632

- Detailed Inspection

301117 Wing Anti-ice Thermal Switch (Left Wing) -

533605 Auxiliary Pressure Bulkhead Installation Above Floor FS 684 - Detailed Inspection

301118 Wing Anti-ice Thermal Switch (Right Wing) -

553025 Vertical Stabilizer Assembly Internal - Detailed

553030 Vertical Stabilizer Rudder Support Structure -

553035 Vertical Stabilizer Upper Boomerang Fittings -

554015 Rudder Assembly Hinges, Bushing and Brackets - Detailed Inspection

192 Mo Initial /192 Mo Recurring Aircraft Struct Insp (A Models) CLIN X707

192 Mo Initial /144 Mo Recurring Aircraft Struct Insp (A Models) CLIN X708

712103 Forward Engine Mount (Left) - Detailed Inspection 274204 Horizontal Stabilizer Actuator - Restore

712104 Forward Engine Mount (Right) - Detailed

712109 Link Assemblies (Engine Removed) (Left) -

712110 Link Assemblies (Engine Removed) (Right) -

712209 Rear Suspension - Engine Mounted (Left) - Inspection / Check

712210 Rear Suspension - Engine Mounted (Right) -

712249 Aft Engine Mount Upper / Lower Strut Assemblies (Internal) - Special Detailed Inspection

712250 Aft Engine Mount Upper / Lower Strut Assemblies

712303 Thrust and Alignment Strut Assemblies External (Left) - Detailed Inspection

712304 Thrust and Alignment Strut Assemblies External (Right) - Detailed Inspection

712307 Aft Engine Mount Strut Attach Fittings (Left) -

712308 Aft Engine Mount Strut Attach Fittings (Right) -

712403 Engine Jury Strut (Left) - Detailed Inspection

712404 Engine Jury Strut (Right) - Detailed Inspection

712503 Forward Engine Mount Thrust Pin (NDT) - Special

712504 Forward Engine Mount Thrust Pin (NDT) - Special

712160 Forward Engine Mount Spherical Bearings & Bearing Inner & Outer Housings (Left) - Detailed

712162 Forward Engine Mount Spherical Bearings & Bearing Inner & Outer Housings (Right) - Detailed

192 Mo Initial /Various Recurring Engine Related Struct Insp (A Models) CLIN X709

Horizontal Stabilizer Actuator Restore/ Discard (12yrs)(A Models) CLIN X710

321011 Main Landing Gear Structural Post (Left) -

Restore 321406 Main Landing Gear Side Brace Fitting Pin (Right) -

321012 Main Landing Gear Structural Post (Right) -

321409 Main Landing Gear Side Brace (Left) - Restore

321015 Main Landing Gear Forward Trunnion Pin (Left) - Restore

321410 Main Landing Gear Side Brace (Right) - Restore

321016 Main Landing Gear Forward Trunnion Pin (Right) - Restore

322005 Nose Landing Gear - Restore

321023 Main Landing Gear Spindle Pin (Left) -

322205 Nose Landing Gear Shock Strut - Restore

321024 Main Landing Gear Spindle Pin (Right) -

322402 Nose Landing Gear Trunnion - Restore

321031 Main Landing Gear (Left) - Restore 322404 Nose Landing Gear Drag Brace - Restore

321032 Main Landing Gear (Right) - Restore 322406 Nose Landing Gear Trunnion Pin (Left) - Restore

321205 Main Gear Shock Absorber (Left) - Restore 322408 Nose Landing Gear Trunnion Pin (Right) - Restore

321206 Main Gear Shock Absorber (Right) - Restore 322410 Nose Landing Gear Truss Brace Assembly -

321209 Main Gear Shock Strut Attach Pins (Left Upper) - Restore

322411 Nose Landing Gear Upper Drag Brace Pin - Discard

321210 Main Gear Shock Strut Attach Pins (Right Upper) - Restore

322414 Nose Landing Gear Lower Drag Brace Pin -

321213 Main Gear Shock Strut Attach Pins (Left Lower) - Restore

322416 Nose Landing Gear Actuator Attachment Pin -

321214 Main Gear Shock Strut Attach Pins (Right Lower) - Restore

322418 Nose Landing Gear Strut Trunnion Pins - Restore

321303 Main Landing Gear Axle (Left) - Restore 322420 Nose Landing Gear Upper Torque Arm - Restore

321304 Main Landing Gear Axle (Right) - Restore 322422 Nose Landing Gear Lower Torque Arm - Restore

321307 Main Gear Axle Fitting Pin (Left) - Restore

321308 Main Gear Axle Fitting Pin (Right) - Restore

321405 Main Landing Gear Side Brace Fitting Pin

Landing Gear Overhaul at 5000 Landings (A Models) CLIN X711

321039 Main Landing Gear Sponson Bores (Left) -

Structural Inspection 712137 Forward Upper Fuselage Link (Left Engine) - NDT

321040 Main Landing Gear Sponson Bores (Right) -

712138 Forward Upper Fuselage Link (Right Engine) -

575111 Flap B and C Track Lower Flange (Left B Track) -

534005 Forward Engine Mount Upper Bulkhead Fitting (Left) - NDT Inspection

575112 Flap B and C Track Lower Flange (Right B Track) - NDT Inspection

534006 Forward Engine Mount Upper Bulkhead Fitting (Right) - NDT Inspection

575113 Flap B and C Track Lower Flange (Left C Track) -

575114 Flap B and C Track Lower Flange (Right C Track) - NDT Inspection

533206 FS 465 Frame Stringer 9 and Below (Right) -

2700 Initial/2300 Recurring Landings (A Models) CLIN X715

Main Landing Gear Sponson Bore Structural Insp (A Models) CLIN X712

Flap B&C Track 5300 Initial/2000 Recurring Landings (A Models) CLIN X716

Forward Engine Mount at 5000 Initial/2000 Recurring (A Models) CLIN X717

FS 465 Frame Stringer 9 & Below at 5400 Initial/2700 Recurring (A Models - Eff 521 to 624) CLIN X718

531016 Nose Landing Gear Skin Cutout - NDT

532201 FS 193 Frames - NDT Inspection

532540 FS 193 and FS 229 Floor Beams - NDT

533207 FS 576 Frame (Left) - NDT Inspection

533208 FS 576 Frame (Right) - NDT Inspection

533416 Overwing Drag Beam - Inspection

534715 FS 820 Bulkhead - NDT Inspection

553036 Vertical Fin to Fuselage- General Visual

8000 Initial Landing Items - (A Models)

CLIN X713

Appendix H C-37B FFP Depot CLIN CMP CODES

236001 L Wing Static Wicks / Bonding - Functional Test 560001 Emergency Window Release Mechanism - Operational Test

236002 R Wing Static Wicks / Bonding - Functional Test

236003 L Horizontal Stabilizer Static Wick / Bonding -

236004 R Horizontal Stabilizer Static Wick / Bonding -

236005 Vertical Stabilizer Static Wick / Bonding - Functional

236006 Tail Cone Static Wick / Bonding - Functional Test

251021 Crew Seats Locking Mechanism and Seat Tracks (Pilot) - Detailed Inspection

251022 Crew Seats Locking Mechanism and Seat Tracks (Copilot) - Detailed Inspection

251023 Crew Seats Locking Mechanism and Seat Tracks (Observer) - Detailed Inspection

252101 Passenger Seats Attachments and Locking -

256025 Ditching Line - Detailed Inspection

261418 Aft Equipment Overheat Thermal Switches -

272303 Standby Rudder System - Operational Test

275302 FLAP TRACKS - GENERAL VISUAL INSPECTION

284301 Fuel Tank Temperature Bulb - Functional Check

491207

APU Inlet Door & Actuator - Detailed Inspection

527201 Internal Baggage Door - Functional Check

535028 Tail Compartment Above Floor Electrical Junction Boxes - Detailed Inspection

"4 C" Checks (B Models) CLIN X725

531019 Cockpit Internal Structure Headliner Removed -

533405 Lower Bulkhead Stiffeners and Angles at FS 632 - Detailed

531200 Bulkhead Installation FS 44 - Detailed Inspection 533605 Auxiliary Pressure Bulkhead Installation Above Floor FS 684 -

531205 Bulkhead Installation FS 63 - Detailed Inspection 551031 Horizontal Stabilizer Leading Edge Internal Structure (Leading Edge Removed, Left) - Detailed Inspection

531210 Bulkhead Installation FS 85 - Detailed Inspection 551032 Horizontal Stabilizer Leading Edge Internal Structure (Leading Edge Removed, Right) - Detailed Inspection

531215 Bulkhead Installation FS 119 - Detailed Inspection 553025 Vertical Stabilizer Assembly Internal - Detailed Inspection

531220 Bulkhead Installation FS 133 - Detailed Inspection 553030 Vertical Stabilizer Rudder Support Structure - Detailed

532505 Floor Structure Not Under Galleys, Lavatories FS 139 - FS 758 (Dry Areas) - Detailed Inspection

553035 Vertical Stabilizer Upper Boomerang Fittings - Detailed

532510 Floorboards FS 426 - FS 632 Between Left / Right BL 30 - Detailed Inspection

532515 Floorboards FS 426 - FS 632 Outboard Left / Right BL 30 - Detailed Inspection

532600 Electronic Equipment Rack to Fuselage Upper Attachment Structure (Left) - Detailed Inspection

532601 Electronic Equipment Rack to Fuselage Upper Attachment Structure (Right) - Detailed Inspection

533400 Bulkhead Installation FS 426 Aft Face - Detailed

192 Mo Initial /144 Mo Recurring Aircraft Structural Inspections (B Models) CLIN X731

242001 Tail Compartment AC Feeder Cables - Detailed

282611 Engine Heated Return Feed Dual Wall Fuel Line

Shroud (Left) - Functional Test

243020 Tail Compartment DC Feeder Cables - Detailed

282612 Engine Heated Return Feed Dual Wall Fuel Line Shroud (Right) - Functional Test

271008 Aileron Trim Tab Actuator / Linkage - General Visual Inspection

301121 Wing Hot / Wing Temp Low Message (Left) -

271010 Aileron Control and Trim Cables in Pressurized Areas of Fuselage and Overwing to Aft Wing Links - Detailed Inspection

301122 Wing Hot / Wing Temp Low Message (Right) -

272012 Rudder Torque Tube - Inspection

272107 Rudder Control and Trim Cables in Pressurized Areas of Fuselage / Overwing to Aft Wing Links -

273019 Elevator Drive Rod - Lubrication

273099 Elevator Control and Trim Cables in Pressurized Areas of Fuselage and Overwing to Aft Wing Links - Detailed Inspection

276104 Speedbrake Cable Assemblies in Fuselage and Overwing Area to Aft Links - Detailed Inspection

281409 Flapper Check Valve (Left) - Inspection

281410 Flapper Check Valve (Right) - Inspection

281515 L Wing Vent Float Drain Valve - Detailed

281516 R Wing Vent Float Drain Valve - Detailed

281527 L Overboard Vent / Ram Air Inlet Mast -

281528 R Overboard Vent / Ram Air Inlet Mast -

282603 Engine Feed Dual Wall Fuel Line Shroud (Left) -

282604 Engine Feed Dual Wall Fuel Line Shroud (Right) -

282605 APU Feed Dual Wall Fuel Line Shroud -

"8 C" Checks (B Models) CLIN X727

531070 Cockpit Above Floor FS 63 - FS 145 - Zonal

712103 Forward Engine Mount (Left) - Detailed Inspection

531074 Cabin Above Floor FS 145 - FS 758 - Zonal

712104 Forward Engine Mount (Right) - Detailed Inspection

531076 Cabin Above Floor FS 145 - FS 758 - (Enhanced)

712109 Link Assemblies (Engine Removed) (Left) - Detailed

531110 Tail Cone FS 974 - FS 1026 - Zonal Inspection 712110 Link Assemblies (Engine Removed) (Right) -

532305 Longeron 22 Installation Not Under Galleys and Lavatories (Dry Areas), FS 145 - FS 426 - Detailed

712160 Forward Engine Mount Spherical Bearings And Bearing Inner And Outer Housings (Left) - Detailed

551005 Horizontal Leading Edge (Left) - Zonal Inspection 712162 Forward Engine Mount Spherical Bearings And Bearing Inner And Outer Housings (Right) -

551006 Horizontal Leading Edge (Right) - Zonal

712209 Rear Suspension - Engine Mounted (Left) -

551010 Horizontal Stabilizer Box (Left) - Zonal

712210 Rear Suspension - Engine Mounted (Right) -

551011 Horizontal Stabilizer Box (Right) - Zonal

712249 Aft Engine Mount Upper / Lower Strut Assemblies

553005 Vertical Stabilizer Leading Edge Lower Section -

712250 Aft Engine Mount Upper / Lower Strut Assemblies

553015 Vertical Stabilizer Box Section Internal Structure -

712303 Thrust and Alignment Strut Assemblies External

554015 Rudder Assembly Hinges, Bushing and Brackets

- Detailed Inspection

712304 Thrust and Alignment Strut Assemblies External

573005 Wing Extension BL 542 - BL 545 (Left) - Zonal

712307 Aft Engine Mount Strut Attach Fittings (Left) -

573006 Wing Extension BL 542 - BL 545 (Right) - Zonal

712308 Aft Engine Mount Strut Attach Fittings (Right) -

574019 Wing Leading Edges Removed (Left) - Zonal

712403 Engine Jury Strut (Left) - Detailed Inspection

574020 Wing Leading Edges Removed (Right) - Zonal

712404 Engine Jury Strut (Right) - Detailed Inspection

301117 Wing Anti-ice Thermal Switch (Left Wing) -

712503 Forward Engine Mount Thrust Pin (NDT) - Special

301118 Wing Anti-ice Thermal Switch (Right Wing) -

712504 Forward Engine Mount Thrust Pin (NDT) - Special

192 Mo Initial /Various Recurring Engine Related Struct Insp (B Models) CLIN X732

192 Mo Initial /192 Recurring Aircraft Structural Inspections (B Models) CLIN X742

(NEW)

520005 Exterior Cabin Doors and Exits - Zonal

533300 Longeron 24 Left and Right FS 632 - FS 758 -

521011 Main Entrance Door - Zonal Inspection 533415 Drag Beam Overwing Installation - Detailed

523006 Baggage Compartment Door - Zonal

533600 Auxiliary Pressure Bulkhead Installation Below Floor FS 684 - Detailed Inspection

531010 Radome FS -4 thru FS 63 - Zonal Inspection 533615 Pressure Bulkhead Installation Below Floor FS

531013 EVS Fairing and Rain Diverter Fairing - Detailed Insp

534000 Aft Engine Mount Frame Structure - Detailed

531020 Cockpit Below Floor FS 119 - FS 145 - Zonal

551015 Horizontal Stabilizer Trailing Edge (Left) - Zonal

531025 Lower Fuselage FS 85 - FS 119 Cheek Panel

551016 Horizontal Stabilizer Trailing Edge (Right) - Zonal

531026 Lower Fuselage FS 85 - FS 119 Cheek Panel

553010 Vertical Cap, SATCOM and Bullet Fairing - Zonal

531030 Internal Cockpit Below Floor FS 63 - FS 85, WL 81 - WL 71 - Zonal Inspection

553016 Vertical Stabilizer Box Section Internal Flight Controls - Zonal Inspection

531035 Cabin Below Floor FS 229 - FS 426 - Zonal

553020 Vertical Stabilizer Rear Beam Aft Face - Zonal

531041 Upper Surface of Center Wing FS 426 - FS 576 From Cabin - Zonal Inspection

562015 Overwing Emergency Exits - Zonal Inspection

531050 Overwing Area FS 354 - FS 736 Between Drag Beam and Wing to Body Fairing (Left) - Zonal

570017 Wing Rear Beam at Aileron (Left) - Zonal

531051 Overwing Area FS 354 - FS 736 Between Drag Beam and Wing to Body Fairing (Right) -

570018 Rear Beam at Aileron (Right) - Zonal Inspection

531066 External Upper Fuselage FS 63 - FS 758 -

570200 Wing Box Structure Forward Spar Through Gap Bands (Left) - Detailed Inspection

531090 External Aft Fuselage and Empennage FS 758

- FS 1123 - Zonal Inspection

570201 Wing Box Structure Forward Spar Through Gap Bands (Right) - Detailed Inspection

531105 Aft Fuselage Below Floor FS 797 - FS 974 -

570205 Fuel Tank Internal (Left) - Detailed Inspection

532120 Cabin Internal Below Floor and Below Stringer 19 Left / Right - Detailed Inspection

570206 Fuel Tank Internal (Right) - Detailed Inspection

532300 Longeron 22 Installation Under Galley / Lavatory (Wet Areas) FS 145 - FS 426 -

571601 Wing to Fuselage Attach Corrosion Resistant Steel / Titanium Fitting - Detailed Inspection

96 Month Initial/96 Month Recurring Insp (B Models) CLIN X728

Appendix H C-37B FFP Depot CLIN CMP CODES532500 Floor Structure Under Galleys, Lavatories FS 139 - FS 758 (Wet Areas) - Detailed Inspection

574017 Wing Leading Edge With Gap Bands Removed

532520 Floor Beam and Wing Link FS 465 - FS 576 -

574018 Wing Leading Edge With Gap Bands Removed

532525 Floorboards FS 426 - FS 632 Areas Below Galleys, Lavatory (Wet Areas) - Detailed

711305 Powerplant / Nacelle External (View from Platform)

711305 (711306) Powerplant / Nacelle External (View from Platform)

350002 Crew / Passenger Oxygen System Check

Valves - Operational Check 533421 Forward Wing to Fuselage Fitting (Left) -

351206 Crew Oxygen Low-Pressure Switch -

533422 Forward Wing to Fuselage Fitting (Right) -

521012 Main Entrance Door Internal - Detailed

521016 Main Entrance Door Cables - Tension Check

533620 Pressure Blkd FS 758 Composite Panels -

534202 Flat Pressure Bulkhead Forward And Aft Face Above Floor, Fs 758 - Special Detailed

539004 Lower Antenna & Penetration Interface -

539005 Upper Antenna & Penetration Interface -

551025 Horizontal Stabilizer Leading Edge Upper and Lower Surfaces (Left) - GVI

551026 Horizontal Stabilizer Leading Edge Upper and Lower Surfaces (Right) - GVI

783111 Primary Door Actuator Rod End (Left) -

783112 Primary Door Actuator Rod End (Right) -

FWD Wing to Fuselage Fitting 7500 Cyc Initial/1400 Cyc Recurring Insp (B Models) CLIN X743 (NEW)

72 Mo Recurring Insp (B Models) CLIN X741 (NEW)

523201 Baggage Compartment Door Internal Structure -

524001 Tail Compartment Door - Zonal Inspection

532110 Below Emergency Exits - Detailed Inspection 525002 Auxiliary Pressure Bulkhead Door - Zonal

532115 Baggage Door Surround Structure - Detailed

531300 Longeron Installation L / R BL 12 FS 119 - 145 (Left) - Detailed Inspection

552001 Elevator External for Delamination (Left) -

531305 Longeron Installation L / R BL 12 FS 119 - 145 (Right) - Detailed Inspection

552002 Elevator External for Delamination (Right) -

532105 Cabin Internal Structure Headliner Removed All Penetrations - Detailed Inspection

552005 Elevator Hinge (Left) - Detailed Inspection 532610 Traffic Alert and Collision Avoidance System Antenna Spacer - Detailed Inspection

552006 Elevator Hinge (Right) - Detailed Inspection 533410 Torque Box Installation / Connections -

554005 Rudder External for Delamination - Detailed

533610 Forward Engine Mounts Installation FS 758 -

575601 Trailing Edge Flight Control Attach Hinge / Support Fittings (Left) - Detailed Inspection

551014 Horizontal Stabilizer Hinge and Actuator Fitting - Detailed Inspection

575602 Trailing Edge Flight Control Attach Hinge / Support Fittings (Right) - Detailed Inspection

554010 Rudder Assembly Front Beam Internal -

576005 Aileron Ballast Weights (Left) - Detailed

711310 Powerplant Nose Cowls Internal (Left) - Zonal

576006 Aileron Ballast Weights (Right) - Detailed

711311 Powerplant Nose Cowls Internal (Right) -

576010 Aileron Tab / Spoilers External for Delamination -

551012 Horizontal Stabilizer Assembly (Interior) {Left} -

551013 Horizontal Stabilizer Assembly (Interior) {Right} -

551029 Horizontal Stabilizer Ultrasound / Mobile Automated Scanner (Left) - NDT Inspection

551030 Horizontal Stabilizer Ultrasound / Mobile Automated Scanner (Right) - NDT Inspection

551033 Horizontal Stabilizer Internal Structure (Left) - Special Detailed Inspection

144 Mo Initial/ 96 Mo Recurring Insp (B Models) CLIN X729

144 Mo Initial /144 Mo Recurring Insp (B Models) CLIN X730

551034 Horizontal Stabilizer Internal Structure (Right) - Special Detailed Inspection

551035 Horizontal Stabilizer Internal Skin / Bond Lines

551036 Horizontal Stabilizer Internal Skin / Bond Lines

530025 Fuselage Penetrations Production and

Outfitting Installations - Detailed Inspection 533817 Wing Link Cutout FS 465 (Left) - NDT

531016 Nose Landing Gear Skin Cutout - NDT

533819 Wing Link Cutout FS 465 (Right) - NDT

531115 Cockpit Window Skins (Left) - NDT Inspection 534715 FS 820 Bulkhead - NDT Inspection

531116 Cockpit Window Skins (Right) - NDT Inspection 534920 Aft Fuselage Covered Cutouts (Left) -

531715 Side Post Upper Attach (Left) - NDT Inspection 534922 Aft Fuselage Covered Cutouts (Right) -

531716 Side Post Upper Attach (Right) - NDT Inspection 551018 Horizontal Stabilizer Access Cutouts - NDT

532201 FS 193 Frames - NDT Inspection 553036 Vertical Fin to Fuselage- General Visual

533120 Fuselage Skins at Wing Pressure Box Cutout (Left) - NDT Inspection

553048 Vertical Stabilizer Access Cutouts - NDT

533122 Fuselage Skins at Wing Pressure Box Cutout (Right) - NDT Inspection

571301 Rear Spar at Spoiler Actuator Tension Fittings (Left) - NDT Inspection

571302 Rear Spar at Spoiler Actuator Tension Fittings (Right) - NDT Inspection

533206 FS 465 Frame Stringer 9 and Below (Right) -

571403 RBS 109.5 Sponson Rib (Left) - NDT

533207 FS 576 Frame (Left) - NDT Inspection 571404 RBS 109.5 Sponson Rib (Right) - NDT

533208 FS 576 Frame (Right) - NDT Inspection 575215 Flap Front Spar At Spoiler Doors (Left) - NDT

533211 Window Surround Frame Splice - NDT

575217 Flap Front Spar At Spoiler Doors (Right) -

533315 Longeron 7 and Longeron 15 at FS 576 (Left No.

7) - Detailed Inspection

533316 Longeron 7 and Longeron 15 at FS 576 (Right No. 7) - Detailed Inspection

533321 Longeron 7 and Longeron 15 at FS 576 (Left No.

15) - Detailed Inspection

533322 Longeron 7 and Longeron 15 at FS 576 (Right No. 15) - Detailed Inspection

533416 Overwing Drag Beam - Inspection

533435 BL 6 Forward Wing to Fuselage Attachment Link - Detailed Inspection

8000 Initial Landing Items - (B Models)

CLIN X739

321011 Main Landing Gear Structural Post (Left) -

321409 Main Landing Gear Side Brace (Left) - Restore

321012 Main Landing Gear Structural Post (Right) -

321410 Main Landing Gear Side Brace (Right) - Restore

321015 Main Landing Gear Forward Trunnion Pin

322005 Nose Landing Gear - Restore

321016 Main Landing Gear Forward Trunnion Pin

322205 Nose Landing Gear Shock Strut - Restore

321023 Main Landing Gear Spindle Pin (Left) -

322402 Nose Landing Gear Trunnion - Restore

321024 Main Landing Gear Spindle Pin (Right) -

322404 Nose Landing Gear Drag Brace - Restore

321031 Main Landing Gear (Left) - Restore 322406 Nose Landing Gear Trunnion Pin (Left) - Restore

321032 Main Landing Gear (Right) - Restore 322408 Nose Landing Gear Trunnion Pin (Right) -

322410 Nose Landing Gear Truss Brace Assembly -

322411 Nose Landing Gear Upper Drag Brace Pin - Discard

321205 Main Gear Shock Absorber (Left) - Restore 322414 Nose Landing Gear Drag Brace (Lower Pin) -

321206 Main Gear Shock Absorber (Right) - Restore 322416 Nose Landing Gear Actuator Attach Pins -

321209 Main Landing Gear Shock Strut Attach Pin (Left Upper) - Restore

322418 Nose Landing Gear Strut Trunnion Pins -

321210 Main Landing Gear Shock Strut Attach Pin (Right Upper) - Restore

322420 Nose Landing Gear Upper Torque Arm - Restore

321213 Main Landing Gear Shock Strut Attach Pin (Left Lower) - Restore

322422 Nose Landing Gear Lower Torque Arm - Restore

321214 Main Landing Gear Shock Strut Attach Pin (Right Lower) - Restore

321303 Main Landing Gear Axle (Left) - Restore

321304 Main Landing Gear Axle (Right) - Restore

Landing Gear Overhaul at 5000 Landings (B Models) CLIN X735

Appendix H C-37B FFP Depot CLIN CMP CODES321307 Main Landing Gear Axle (Left Fitting Pin) -

321308 Main Landing Gear Axle (Right Fitting Pin) -

321405 Main Landing Gear Side Brace Fitting Pin

321406 Main Landing Gear Side Brace Fitting Pin

240111 L Emergency Battery Pack - Discard 570005 Wing Upper Surface View from on Wing (Left) -

240112 R Emergency Battery Pack - Discard 570006 Wing Upper Surface View from on Wing (Right) -

240113 Fwd Emergency Battery Pack - Discard 570013 Upper Wing Extension BL 542 - BL 545 (View from on Wing) {Left} - Zonal Inspection

240114 Aft Emergency Battery Pack - Discard 570014 Upper Wing Extension BL 542 - BL 545 (View from on Wing) {Right} - Zonal Inspection

531036 Cabin Below Floor FS 145 - FS 229 - Zonal

573010 Winglet Blade (View From Ground) {Left} - Zonal

531040 Upper Surface of Center Wing FS 426 - FS 576 From Wheel Well - Zonal Inspection

573011 Winglet Blade (View From Ground) {Right} -

531100 Aft Fuselage Below Floor FS 758 - FS 797 -

534001 Baggage Compartment Electronic Equipment Rack FS 689 - FS 698 - Zonal Inspection

541005 Pylons External (Left) - Zonal Inspection

541006 Pylons External (Right) - Zonal Inspection

541010 Pylons Internal (Left) - Zonal Inspection

541011 Pylons Internal (Right) - Zonal Inspection

551027 Hstab Trailing Edge Area (Elevator Curtains Removed, Left) - Detailed Inspection

551028 Hstab Trailing Edge Area (Elevator Curtains Removed, Right) - Detailed Inspection

551111 Elevator Upper Surface - Detailed inspection

551201 Hstab Internal Corrosion Inhibiting Compound (Left) - Restore

551202 Hstab Internal Corrosion Inhibiting Compound (Right) - Restore

48 Month Initial/48 Month Recurring Inspection (B Models) CLIN X726

534005 Forward Upper Bulkhead Fitting (Left) - NDT

534006 Forward Upper Bulkhead Fitting (Right) - NDT

712137 Forward Upper Fueselage Link (Left) - NDT

575111 Flap B and C Track Lower Flange (Left B Track) -

712138 Forward Upper Fueselage Link (Right) - NDT

575112 Flap B and C Track Lower Flange (Right B Track) -

575113 Flap B and C Track Lower Flange (Left C Track) -

575114 Flap B and C Track Lower Flange (Right C Track) -

274204 Horizontal Stabilizer Actuator - Restore 571401 Lower Sponson Doubler (Left) - NDT Inspection

571402 Lower Sponson Doubler (Right) - NDT Inspection

Lwr Sponson Doubler 6000 Cyc Initial/1370 Cyc Recurring Insp (B Models)

CLIN X740

Flap B&C Track 7200 Initial/3400 Recurring Landings (B Models) CLIN X738

5000 initial/2000 Recurring Landings (Fwd Upper Bulkhead) (B Models) CLIN X736

2700 Initial/2300 Recurring Landings (B Models) CLIN X737

Main Landing Gear Sponson Bore Structural Insp (B Models) CLIN X733

Horizontal Stabilizer Restore/ Discard (12yrs)(B Models) CLIN X734

C-37 A & B Depot CLINS

CMP Codes for C-37As

CMP Codes for C-37Bs

Appendix H: C-20 CMP Codes

C-20 CMP Codes X600 48 MOS Gear Inspections X601 8C Depot Level Inspection X602 48 MOS Depot Level Inspection X603 96 MOS Depot Level Inspection X604 192 MOS Depot Level Inspection X605 3100/3300 HRS Depot Level Inspection X606 2300 AFL Depot Level Inspection X607 3300/3500 AFL Depot Level Inspection X608 4250/4000 AFL Depot Level Inspection X609 Reserved X610 4000 HRS Depot Level Inspection X611 5000 HRS Depot Level Inspection X612 6800/6500 HRS Depot Level Inspection X613 Reserved X614 7100/7000 HRS Depot Level Inspection X615 Reserved X616 7700 HRS Depot Level Inspection X617 10,000 HRS Depot Level Inspection X618-X628 Reserved X629 RVSM Re-Certification X630 Reserved X631-X635 Reserved

X636 Aircraft Strip & Paint--Gray only X637 Aircraft Strip & Paint- White only with Black wings X638 Teflon Coating X639 Reserved X640 APU (Model -150) Inspection to include remove/replace labor only no parts X641 Remove and Replace Engine C-20 (GIV) X642 Reserved X643 MK-611 Engine Midlife Inspection to include remove/replace FFP labor only no parts X644 MK-611 Engine Overhaul Inspection to include remove/replace FFP labor only no parts X645-X646 Reserved X647 Weight and Balance X655 4K Thrust Reverser Inspection X657 5K Landing Gear Overhaul

48 MOS Landing Gear Inspections

CLIN X600

CMP Code Code Description

320011 Nose Landing Gear and Components – Detailed Inspection 320013 Main Landing Gear and Components (Left) – Detailed Inspection 320014 Main Landing Gear and Components (Right) – Detailed Inspection

8C Depot Level Inspection

CLIN X601

223009 Autothrottle Servo Assembly - Detailed Inspection 242011 Tail Compartment AC Power Feeder Cables – Detailed Inspection 243003 Tail Compartment DC Power Feeder Cables – Detailed Inspection 271012 Aileron Trim Tab Actuator / Linkage - General Visual Inspection 271047 Aileron Control and Trim Cables in Pressurized Areas - Detailed Inspection 272028 Rudder Control and Trim Cables (Except Wheel Well) - Detailed Inspection 273037 Elevator Control and Trim Cables (Except Wheel Well) - Detailed Inspection 273401 Elevator AFT Push Rods - Lubrication 276089 Speed Break Cable Assemblies in Fuselage and Over- Wing Area - Detailed Inspection 282007 Ejection Pump Flapper Check Valve - General Visual Inspection 282025 Fuel Inlet Screen (Main, Left Wing) - Detailed Inspection 282026 Fuel Inlet Screen (Alternate, Left Wing) – Detailed Inspection 282027 Fuel Inlet Screen (Main, Right Wing) – Detailed Inspection 282028 Fuel Inlet Screen (Alternate, Right Wing) – Detailed Inspection 282086 Engine / APU Double Wall Tubing (left) – Functional Test 282087 Engine / APU Double Wall Tubing (Right) – Functional Test 284010 Fuel Tank Temperature Probe - Functional Test 284025 Fuel Low Level Warning Sensor (Left) - Functional Test 284026 Fuel Low Level Warning Sensor (Right) – Functional Test 762007 Throttle/Fuel SOV Control Cables (Baggage Compartment/Pylon Left) Detailed Inspection 762008 Throttle/Fuel SOV Control Cables (Baggage Compartment/Pylon Right) Detailed Inspection

48 MOS Depot Level Inspection

CLIN X602

532004 Cabin Below Floor FS 133 - FS 193 - Zonal Inspection 535015 Aft Fuselage Below Floor FS 596 - FS 812 Internal - Zonal Inspection 541023 Pylon Boards (Left) - Detailed Inspection 541024 Pylon Boards (Right) - Detailed Inspection

96 MOS Depot Level Inspection

CLIN X603

272034 Rudder Torque Tube - Detailed Inspection 531000 Thrust Strut Fitting - Detailed Inspection 531003 Forward Engine Mounts (Left) - (Aircraft 1180 and Subsequent) - Detailed Inspection 531005 Aft Engine Mounts (Left) - (Aircraft 1180 and Subsequent) - Detailed Inspection 531010 Forward Engine Mounts (Right) - (Aircraft 1180 and Subsequent) - Detailed Inspection 531012 Aft Engine Mounts (Left) - (Aircraft 1180 and Subsequent) - Detailed Inspection 531021 Cockpit Entrance Below Floor FS 63 - FS 133 - Enhanced Zonal Inspection 532001 Cabin Interior Below Floor - Detailed Inspection 532010 Cabin Below Floor FS 193 - FS 321 - Zonal Inspection 532012 Cockpit Below Floor FS 63 - FS 133 - Zonal Inspection 532013 Cockpit Below Floor FS 63 - FS 85 WL 81 - WL 71 - Zonal Inspection 532046 Pressure Bulkhead Structure Below Floor (FS 596) - Detailed Inspection 532072 Upper Surface of Center Wing FS 321 - FS 452 – Zonal Inspection 532079 Floor Structure Under Galleys, Lavatories FS 133 – FS 596 (Wet Areas) - Detailed Inspection 532081 Wing Links - Detailed Inspection 532082 Wing Attach Fittings - Detailed Inspection 532083 Secondary Bulkhead Structure Below Floor (FS 539) - Detailed Inspection 532084 Secondary Bulkhead Structure Above Floor (FS 539) - Detailed Inspection 532085 Left and Right Overwing Area Between Drag Beam and Wing to Body Fairing FS 257.5 - FS 512 Internal

– Zonal Inspection 535016 Aft Fuselage Below Floor FS 596 - FS 812 – Zonal Inspection 539501 Emergency Exit Window Interior Skin and Substructure - Detailed Inspection 551004 Horizontal Stabilizer Trailing Edge - Zonal Inspection 551006 Horizontal Stabilizer Assembly (Internal) – Detailed Inspection 552002 Elevator Ballast Weights (Aircraft Having ASC 263 and Aircraft 1234 and Subsequent) - Detailed

552087 Vertical Cap, SATCOM Antenna and Bullet Fairing Internal - Zonal Inspection 553003 Vertical Stabilizer Rear Beam Aft Face – Zonal Inspection 554002 Rudder Assembly Ballast Weight - Detailed Inspection 571013 Wing Leading Edge Gap Bands Removed (Left) – Zonal Inspection 571014 Wing Leading Edge Gap Bands Removed (Right) - Zonal Inspection 571025 Fuel Tank Internal (Left) - Detailed Inspection 571026 Fuel Tank Internal (Right) - Detailed Inspection 571037 Wing Box Section (Left) - Zonal Inspection 571038 Wing Box Section (Right) - Zonal Inspection 571039 Wing Box Forward Spar (Through Gap Bands) (Left) - Detailed Inspection 571040 Wing Box Forward Spar (Through Gap Bands) (Right) - Detailed Inspection 571064 Wing to Fuselage Attach Fitting CRES / Titanium Fitting (Left) - Detailed Inspection 571065 Wing to Fuselage Attach Fitting CRES / Titanium Fitting (Right) - Detailed Inspection 575109 Trailing Edge Flight Control Attach Hinge / Support Fittings (Left) - Detailed Inspection 575110 Trailing Edge Flight Control Attach Hinge / Support Fittings (Right) - Detailed Inspection 576017 Aileron Tab / Spoilers (Left) - Special Detailed Inspection 576018 Aileron Tab / Spoilers (Right) - Special Detailed Inspection 576023 Aileron Ballast Weights (Left) - Detailed Inspection 576024 Aileron Ballast Weights (Right) - Detailed Inspection

192 MOS Depot Level Inspection

CLIN X604

532014 Cockpit Above Floor FS 63 - FS 133 - Zonal Inspection

551002 Horizontal Stabilizer Box - Zonal Inspection

552086 Vertical Stabilizer Leading Edge Lower Section Saddle Internal - Zonal Inspection 574013 Wing Leading Edge Leading Edges Removed (Left) - Zonal Inspection 574014 Wing Leading Edge Leading Edges Removed (Right) - Zonal Inspection

3100/3300 HRS Depot Level Inspection

CLIN X605

571105 Upper Cover Stringers (Left) - General Visual Inspection (3100 HRS Requirement) 571106 Upper Cover Stringers (Right) - General Visual Inspection (3100 HRS Requirement) 571107 Lower Cover Stringers (Left) - General Visual Inspection (3300 HRS Requirement) 571108 Lower Cover Stringers (Right) - General Visual Inspection (3300 HRS Requirement) 533304 Dorsal Longeron Splice at FS 287 - NDT Inspection (1800 AFL/3600HRS Requirement)

2300 AFL Depot Level Inspection

CLIN X606

539502 Cockpit Side Windshield Post - NDT Inspection 575111 Flap Track Support Fittings - NDT Inspection

3300/3500 AFL Depot Level Inspection

CLIN X607

523162 Cargo Door Upper Hinge Backup Structure – Detailed Inspection 575301 Flap A and D Track Roller Fittings (Left) – NDT Inspection 575302 Flap A and D Track Roller Fittings (Right) – NDT Inspection 575303 Flap B and C Track Roller Fittings (Left) – NDT Inspection 575304 Flap B and C Track Roller Fittings (Right) – NDT Inspection 575501 Flap Track Beam (Left) - Inspection 575502 Flap Track Beam (Right) – Inspection

4000/4250 AFL Depot Level Inspection

CLIN X608

537003 Wing Attach Frames - Inspection 571601 Forward Inboard and Outboard Attach Fittings FS 345 - NDT Inspection (4000 AFL Requirement) 535018 BL 6 Breather Beam FS 321 - FS 498 – Inspection (4000 AFL Requirement) 533001 Drag Beam - Detailed Inspection (4000 AFL Requirement) 533305 Pressure Floor Beams - NDT Inspection (4250 AFL Requirement) 539515 Fuselage Penetration – Inspection (3961 AFL Requirement)

Reserved

CLIN X609

4000 HRS Depot Level Inspection

CLIN X610

537003 Wing Attach Frames - Inspection (4000 HRS/400 AFL Requirement) 551101 Horizontal Stabilizer General Skins - General Visual Inspection (4300 HRS/ 2100 AFL Requirement) 553050 Vertical Stabilizer General Skins - General Visual Inspection (4300 HRS/2100 AFL Requirement)

5000 HRS Depot Level Inspection

CLIN X611

522020 Skin at Aft EER Door External Doubler - NDT Inspection 523163 Cargo Door Longitudinal Skin Splice at Stringer No. 6 - NDT Inspection 523165 Cargo Door Forward External Doubler Skin at FS 306 - NDT Inspection 523168 Cargo Door Dorsal Fin Crack, FS 297 - FS 442 – NDT Inspection 523170 Cargo Door Stringer No. 5 Upper Longeron at FS 193D - NDT Inspection 523501 Cargo Door Longeron Upper Inner Cap at FS 265 – NDT Inspection 539051 Pressure Bulkhead Composite Panels - General Visual Inspection 539053 Aft Pressure Bulkhead Beam Bulkhead Support - General Visual Inspection

6500/6800 HRS Depot Level Inspection

CLIN X612

523164 Cargo Door Longeron Lower Inner Cap at FS 265 – NDT Inspection (6500 HRS) 577201 Spoiler Structural…