J_-_2_REVISION_Category_A_Items.xls

XLS spreadsheet 75 KB Posted Dec 4, 2018

Attached to: Repair and Overhaul Dry Docking USNS CARL BRASHEAR
Solicitation number: N3220519R4260
Issued by: Department of the Navy Military Sealift Command

About this file

From the source

Revised J-2

View the file

Other files

File	Type	Posted
BRASHERA_AMENDMENT_0007.doc	DOC document	Jan 30, 2019
J_-_2_Category_A_REV_002.xls	XLS spreadsheet	Dec 27, 2018
J_-_3_REVISION_002_Category_B_Items.xls	XLS spreadsheet	Dec 27, 2018
BRASHERA_AMENDMENT_0006.docx	DOCX document	Dec 27, 2018
611_MSC_Circ_1331Guidlines_for_Embarkation.pdf	PDF	Dec 4, 2018
J_-_3_REVISION_Category_B_Items.xls	XLS spreadsheet	Dec 4, 2018
BRASHEAR_AMENDMENT_0005.doc	DOC document	Dec 4, 2018
0528_B_Food_Waste_Transfer_Pump_Overhaul.docx	DOCX document	Nov 29, 2018
0307_B_MOTOR_CONTROL_CENTER_M05_ALTERNATE_POWER_SOURCE_(T-ALT_370).docx	DOCX document	Nov 29, 2018
BRASHEAR_AMENDMENT_0004.doc	DOC document	Nov 29, 2018
8391502_A.pdf	PDF	Nov 29, 2018
0522_A_Magazine_Drain_Piping_Replacement_Rev_A.doc	DOC document	Nov 29, 2018
8391502_-.pdf	PDF	Nov 29, 2018
0527_B_Grey_Water_Transfer_Pump_Overhaul.docx	DOCX document	Nov 29, 2018
0569_B__SW_Check_Valve_Clean_and_Repair_(VR18-0036-55).docx	DOCX document	Nov 29, 2018
0105_A_DECK_HOUSE_CLEANING_AND_PAINTING_(SPOT_BLAST)_REV_A.docx	DOCX document	Nov 29, 2018
0227_A_MDG_Attached_Lube_Oil_Pump_Rebuilds.doc	DOC document	Nov 29, 2018
0530_A_CARGO_AND_AC_30K_HR_COMPRESSOR_REPLACEMENT_REV_A.docx	DOCX document	Nov 29, 2018
T6225-MS-MMC-010_0_0_(Tech_Manual).pdf	PDF	Nov 29, 2018
0540_A_No1_Mooring_Capstan_Leak_Repair.doc	DOC document	Nov 29, 2018
0104_A_Mechanically_Clean_and_Preserve_Tanks_Rev_A.docx	DOCX document	Nov 29, 2018
0627_B_04_Lounge_Stratica_Deck_Covering_and_Removals_(VR_18-0049).doc	DOC document	Nov 29, 2018
0507_A_DISTILLER_CLEANING_INSPECTION_AND_MAINTENANCE.doc	DOC document	Nov 29, 2018
0517_A_Cargo_Defrost_Brine_Heater_Replacement_(VR16-0069)_Rev_A.doc	DOC document	Nov 29, 2018
0217_A_9_CYLINDER_MAIN_DIESEL_ENGINE_30,000_HOUR_SCHEDULED_MAINTENANCE_R....docx	DOCX document	Nov 16, 2018
0904_A_STERN_TUBE_SEAL_INSPECTION_(SW_SYS)_REV_-_(CSI).docx	DOCX document	Nov 16, 2018
AMENDMENT_BRASHEAR_0003.doc	DOC document	Nov 16, 2018
0216_A_8_CYLINDER_MAIN_DIESEL_ENGINE_30,000_HOUR_SCHEDULED_MAINTENANCE_R....docx	DOCX document	Nov 16, 2018
BRASHEAR_AMENDMENT_0001.doc	DOC document	Nov 14, 2018
BRASHEAR_AMENDMENT_0002.doc	DOC document	Nov 14, 2018
J-4__BRASHEAR_GFP_Module_AttachmentTemplate_-_Rev_3_5_Mar_(3)_1.xlsx	XLSX spreadsheet	Oct 26, 2018
J_-_4_CARL_BRASHEAR_MAR_2019_ROH_GFM_REPORT_10-05-18.xlsx	XLSX spreadsheet	Oct 25, 2018
J_-_6_BRASHEAR.pdf	PDF	Oct 25, 2018
J_-_7_MSC_Ship_Repair_Facility_Survey.docx	DOCX document	Oct 25, 2018
J_-_2_Category_A_Items.xls	XLS spreadsheet	Oct 25, 2018
J_-_9_Disclosure_of_Lobbying_Activities_SF-LLL.doc	DOC document	Oct 25, 2018
J_-_13__PAST_PERFORMANCE_QUESTIONNAIRE.docx	DOCX document	Oct 25, 2018
J_-_11_Dry_Dock_Evaluation_Form.docx	DOCX document	Oct 25, 2018
J_-_3_Category_B_Items.xls	XLS spreadsheet	Oct 25, 2018
J_-_12_Past_Performance_Data.doc	DOC document	Oct 25, 2018
J_-_8_Request_for_Spec_Clarification.doc	DOC document	Oct 25, 2018
J_-_14_Technical_Non-Disclosure_Agreement.docx	DOCX document	Oct 25, 2018
J_-_15_Non-Mariner_Maintenance_Contractor_Vetting_Sheet_(Rev_8_(v4)_20_Sep_2017)_(002).xlsx	XLSX spreadsheet	Oct 25, 2018
N3220519R4260_BRASHEAR.doc	DOC document	Oct 25, 2018

Show all 44

On GovTribe

Work with this file

Download the original file
Contacts named in this file
Similar government files
Ask GovTribe AI about this file

Try for free Login

Text version

The file's text, extracted by GovTribe without its formatting.

Cat A Items

	CATEGORY “A” ITEMS
	GENERAL REQUIREMENT	PRIME Contractor			SUB Contractor			Govt Mandated Tech Rep / Sub	OTHER COSTS			TOTAL PRICE
ITEM NO.	TITLE CAT A ITEM	PRIME L/H	LABOR PRICE	MATERIAL PRICE	SUB L/H	LABOR PRICE	MATERIAL PRICE	Price		TOTAL LABOR HOURS	TOTAL MATERIAL
	CATEGORY "A"
000	GENERAL REQUIREMENTS
001	Intent, Scope, General Condition, and Definitions									- 0	$ - 0	$0
002	Technical and Manufacturer's Representative									- 0	$ - 0	$0
003	Approach, Berth, and Mooring Requirements									- 0	$ - 0	$0
004	Testing and Quality Assurance									- 0	$ - 0	$0
005	Electrical Safety Procedure Requirements									- 0	$ - 0	$0
006	Heavy Weather Plan									- 0	$ - 0	$0
007	Cold Weather Plan									- 0	$ - 0	$0
010	Furnish Office for Overhaul Management Team (OMT)									- 0	$ - 0	$0
011	Furnish General Services									- 0	$ - 0	$0
012	Telephone Services									- 0	$ - 0	$0
013	Project Planning and Production Status Monitoring Reports									- 0	$ - 0	$0
014	Preparation of Weight and Moment Report									- 0	$ - 0	$0
015	Integrated Logistics and GFM Support Requirements									- 0	$ - 0	$0
016	Fire Protection and Ship's Safety Program									- 0	$ - 0	$0
017	Handling Ship's Stores									- 0	$ - 0	$0
018	Delivery and Redelivery of the Vessel									- 0	$ - 0	$0
019	Shipboard Access and Security									- 0	$ - 0	$0
020	Gas Free Certificates									- 0	$ - 0	$0
021	Clean and Gas Free Tanks, Voids, Cofferdams, and Spaces									- 0	$ - 0	$0
022	Dock Trails and Sea Trials									- 0	$ - 0	$0
023	Hazardous Waste Disposal									- 0	$ - 0	$0
100	HULL STRUCTURE
0101	Ballast Tank Zinc Inspection									- 0	$ - 0	$0
0102	Open Clean Inspect Tank Goosene										$ - 0	$0
0103	Tank Coating Gray WTR and FD Waste										$ - 0	$0
0104	Mechanically Clean and Preserve Tanks										$ - 0	$0
0105	Deck House Cleaning and Painting (Spot Blast)										$ - 0	$0
0106	Joiner Door Replacement										$ - 0	$0
0107	Wasted Penetrations Replacements										$ - 0	$0
200	MACHINERY, PROPULSION
0201	Propulsion Motor and Cooler Cleaning, Insp & Maint									- 0	$ - 0	$0
0202	Main Engine Flexible Connection Replacement (10-YR)										$ - 0	$0
0204	MDE Automation Annuals										$ - 0	$0
0205	Automation and Propulsion Control Inspection and Test										$ - 0	$0
0206	Vulkan Coupling Annual Inspection										$ - 0	$0
0207	Propulsion Motor Pedestal Bearing Inspection (RENK)										$ - 0	$0
0208	Propulsion Motor Delamination Inspection
0216	8 Cylinder Main Diesel Engine 30K Hr Sch Maintenance
0217	9 Cylinder Main Diesel Engine 30K Hr Sch Maintenance
0224	MDE 1 through 4 Governor Service
0225	MDE Charge Air Cooler Inpsection and Regasket
0227	MDG Attached Lube Oil Pump Rebuilds										$ - 0	$0
300	ELECTRICAL
0301	Cleaning Main Generator and Propulsion Control System									- 0	$ - 0	$0
0303	HV-SS-Emergency Switchboard Cleaning									- 0	$ - 0	$0
400	COMMUNICATION AND NAVIGATIONAL AIDS
0401	Bridge Equipment Annual Service									- 0	$ - 0	$0
0402	Antenna Preventative Maintenance									- 0	$ - 0	$0
0403	Communications Center Preventative Maintenance									- 0	$ - 0	$0
0404	OE-570 Antenna System Preventative Maintenance									- 0	$ - 0	$0
0405	Atenna Rigging Photos
0406	AIS/DGPS Renewal (T-ALT 437)
0414	Hydra Radio Upgrade (T-ALT 472)									- 0	$ - 0	$0
500	AUXILIARY MACHINERY
0501	Firefighting Inspection and Testing (10-YR)									- 0	$ - 0	$0
0502	SCBA Annual Inspection									- 0	$ - 0	$0
0503	SCBA Air Compressor and Filling Station Inspection/Maint									- 0	$ - 0	$0
0504	Cargo Crane Maintenance and Retesting (10-YR)
0506	Emergency Diesel Generator Annual Testing and Inspection
0507	Distilling Plant Maintenance (5-YR)
0513	MDG Pre-Heat Sys Mods (T-ALT 186)
0514	Relief Valve Testing
0515	Open and Inspect Air Receiver and HP Flasks
0516	Sewage System Piping and Cleaning
0517	Cargo Brine Defrost Brine Heater Replacement
0518	Brine System Flush
0519	Flush HT LT Freshwater and Chill WTR Systems
0520	Overhaul CLA VALs
0521	Vane Axial Fan Motor Overhauls
0522	Magazine Drain Piping Replacement
0523	MSD Tank and Piping Repairs
0530	Cargo and SC 20 Hour Compressor Overhaul Replacement
0540	No 1 Mooring Capstan Leak Repair
0541	Planetary Gear Replace
0542	MMR AFFF Foam System Piping Replacement (T-ALT 394)
0543	FWD AFFF Foam System Piping Replacement (T-ALT 394)
0546	Incinerator Inspection and Maintenance
0556	Steering Gear Preventative Maintenance
0557	Charging Pump and Motor Overhaul
0558	Salt Water Pump and Motor Repair 1, 2, and 3
0564	1 2 and 3 Lube Oil Cooler Cleaning and Gasket Replacement
0583	Overhaul Chatco Valves and Tune
600	HABITABILITY
0601	LB, RHIB, Davits and ACCOM Ladders Annuals
0602	Accom Ladder Insp and Load Testing
0604	RHIB Maintenanace and Falls Renewal
0605	Liferaft Annual Certification
0606	Flight deck Non-Skid Renewal
0607	Replace Cargo Hold Grating Near Elevators
0609	Fall Protection Anchors (T-ALT 350)
0610	Galley Equipement Calibration									- 0	$ - 0	$0
0611	Roller Curtain Door Assembly Replacement									- 0	$ - 0	$0
0624	MSD Tank and VCHT Holding Tanks Coating									- 0	$ - 0	$0
0626	Flight Deck Hatch Wire Rope Replacement (T-ALT 450)									- 0	$ - 0	$0
800	HEATING, VENTILATION, AND AIR CONDITIONING
0801	Galley and Laundry Exhaust Duct Cleaning
0804	Install Fan Coils in Engine Room
0806	Replace of Cooling Coil Fasteners and Inspection
0807	Air Handler and Fan Coil Units Cleaning									- 0	$ - 0	$0
0809	Galley HVAC Modifications (T-ALT 330)
0810	House Accomidation HVAC Duct Cleaning
0811	EOS Air Conditioning Units Install										$ - 0	$0
0812	Cargo Reefer and AC Plants Expansion Joints Replacement									- 0	$ - 0	$0
900	DRY-DOCKING AND UNDOCKING
0901	Dry-Docking and Undocking Vessel									- 0	$ - 0	$0
0903	Propeller Shaft and Stern Tube Inspection									- 0	$ - 0	$0
0904	Stern Tube Seal Inspection									- 0	$ - 0	$0
0905	Bow Thruster Maintenance									- 0	$ - 0	$0
0907	Polish Bow Thruster Propeller									- 0	$ - 0	$0
0908	Renewal Seachest Rope Guard and BT Zincs									- 0	$ - 0	$0
0909	Anchor and Anchor Chain Ranging										$ - 0	$0
0910	Overhaul Sea Valves										$ - 0	$0
0911	Inspect and Repair Cathodic Protection
0912	Shaft Grounding Maintenance
0913	Renew Waster Pieces
0914	Bilge Keel Repair										$ - 0	$0
0915	Seachest Attachment System Upgrade Installation (T-ALT 296)									- 0	$ - 0	$0
0616	Underwater Hull Cleaing and Painting (Sport Blast)
0917	Freeboard Cleaning and Painting (Near White Blast)
0919	Rudder Gland Seal Lower Bearing Inspection									- 0	$ - 0	$0
0931	Fresh Water (Closed Loop) Stern Tube Lubrication (T-ALT 403)									- 0	$ - 0	$0
1000	UNREP EQUIPEMENT
1001	Ram Tensioners Remove and Replace									- 0	$ - 0	$0
1002	HP Air Flask Inspection
1003	HP Air Gauge Calibration
1006	Winch Control (Controles) Riser									- 0	$ - 0	$0
1007	Hauling Winch Band Brake Refurbishment									- 0	$ - 0	$0
											TOTAL CAT "A"	$0.00

&LUSNS CARL BRASHEAR (T-AKE 7)&CCONTRACTOR PRICE BREAKDOWN

&"Arial,Bold"CATEGORY "A" ITEMS&RN32205-19-R-4260

&CATTACHMENT J-2

Sheet1

001	Intent, Scope, General Conditions and Definitions
002	Technical and Manufacturer's Representative
003	Approach, Berth, and Mooring Requirements
004	Testing and Quality Assurance
005	Electrical Safety Procedure Requirements
006	Heavy Weather Plan
007	Cold Weather Plan
010	Furnish Office For Overhaul Management Team (OMT)
011	Furnish General Services
012	Telephone Services
013	Project Planning and Production Status Monitoring Report
014	Preparation of Weight and Moment Report
015	Integrated Logistics and GFM Support Requirements
016	Fire Protection and Ship's Safety Program
017	Handling Ship's Stores
018	Delivery and Redelivery of Vessel
019	Shipboard Access and Security
020	Gas Free Certificate
021	Clean and Gas Free Tanks, Voids, Cofferdams and Spaces
022	Dock Trials and Sea Trials
023	Hazardous Waste Disposal at a Contractor's Facility
0101	Ballast Tank Zinc Inspection
0102	OPEN CLEAN INSPECT TANK VENT GOOSENECKS
0103	Tank Coating Gray WTR and FD Waste
0104	Mechanically Clean and Preserve Tanks
0105	DECK HOUSE CLEANING AND PAINTING (NEAR WHITE BLAST)
0106	Joiner Door Replacement
0107	Wasted Penetrations Replacements
0201	Propulsion Motor and Cooler Cleaning, Insp & Maint
0202	Main Engine Flexible Connection Replacement (10-YR)
0204	MDE Automation Annuals
0205	Automation and Propulsion Control Inspection and Test
0206	Vulkan Coupling Annual Inspection
0207	Propulsion Motor Pedestal Bearing Inspection (RENK)
0208	Propulsion Motor Delamination Inspection
0216	8 Cylinder Main Diesel Engine 30K Hr Sch Maintenance
0217	9 Cylinder Main Diesel Engine 30K Hr Sch Maintenance
0224	MDE 1 through 4 Governor Service
0225	MDE Charge Air Cooler Inpsection and Regasket
0226	MDG Crank Case Demister Installation
0301	Cleaning Main Generator and Propulsion Control System
0303	HV-SS-EMERGENCY SWITCHBOARD CLEANING
0304	THERMOGRAPHIC SURVEY
0305	PLC SURVEY
0307	MOTOR CONTROL CENTER M05 ALTERNATE POWER SOURCE (T-ALT 370)
0401	BRIDGE EQUIPMENT ANNUAL SERVICE
0402	ANTENNA PM
0403	COMMS SYS PM
0404	OE-570 ANTENNA SYSTEM MAINTENANCE
0405	ANTENNA RIGGING PHOTOS
0406	AIS/DGPS Renewal (T-ALT 437)
0414	HYDRA Radio Upgrade (T-ALT 472)
0435	TV-DTS SAT SYS UPGRADES (T-ALT 452)
0501	Firefighting Inspection and Testing (10-YR)
0502	SCBA Annual Inspection
0503	SCBA Air Compressor and Filling Station Inspection/Maint
0504	Cargo Crane Maintenance and Retesting (10-YR)
0506	Emergency Diesel Generator Annual Testing and Inspection
0507	Distilling Plant Maintenance (5-YR)
0513	MDG Pre-Heat Sys Mods (T-ALT 186)
0514	RELIEF VALVE TESTING
0515	Open and Inspect Air Receiver and HP Flasks
0516	SEWAGE SYSTEM PIPING AND CLEANING
0517	Cargo Brine Defrost Brine Heater Replacement
0518	Brine System Flush
0519	Flush HT LT Freshwater and Chill WTR Systems
0520	Overhaul CLA VALs
0521	Vane Axial Fan Motor Overhauls
0522	Magazine Drain Piping Replacement
0523	MSD Tank and Piping Repairs
0527	Grey Water Transfer Pump Overhaul
0528	Food Waste Transfer Pump Overhaul
0530	CARGO AND AC 20 HOUR COMPRESSOR OVERHAUL REPLACEMENT
0541	PLANETARY GEAR REPLACE
0542	MMR AFFF Foam System Piping Replacement (T-ALT 394)
0543	FWD AFFF Foam System Piping Replacement (T-ALT 394)
0545	Countermeasure Wash-down System Misc CuNi Pipe (Zone 4)(T-ALT 420)
0546	Incinerator Inspection and Maintenance
0556	Steering Gear Preventative Maintenance
0557	Charging Pump and Motor Overhaul
0558	SALT WATER PUMP AND MOTOR REPAIR 1, 2, and 3
0564	1 2 and 3 Lube Oil Cooler Cleaning and Gasket Replacement
0569	SW FM Check and Isolation Valve Replacement
0583	OVERHAUL CHATCO VALVES AND TUNE
0601	LB, RHIB, Davits and ACCOM Ladders Annuals
0602	ACCOM LADDER INSP AND LOAD TESTING
0603	LIFEBOAT CERTIFICATION AND FALLS RENEWAL
0604	RHIB MAINTENANCE AND FALLS RENEWAL
0605	LIFERAFT ANNUAL CERTIFICATION
0606	FLIGHT DECK NON-SKID RENEWAL
0607	Replace Cargo Hold Grating Near Elevators
0608	ACCOMIDATION LADDER OUTRIGGERS INSTALL
0609	Fall Protection Anchors (T-ALT 350)
0610	GALLEY EQUIPMENT CALIBRATION
0611	ROLLER CURTAIN DOOR HOOD ASSEMBLY REPLACEMENT
0624	MSD Tank and VCHT Holding Tanks Coating
0626	Flight Deck Hatch Wire Rope Replacement (T-ALT 450)
0627	Lounge 07 and Bridge Stratica Deck Covering
0673	Cargo Hold No 6 Bulk Stowage and Cabinet Space Mods (T-ALT 364)
0801	GALLEY AND LAUNDRY EXHAUST DUCT CLEANING
0804	INSTALL FAN COILS IN ENGINE ROOM
0806	Replace of Cooling Coil Fasteners and Inspection
0807	Air Handler and Fan Coil Units Cleaning
0809	Galley HVAC Modifications (T-ALT 330)
0810	House Accomidation HVAC Duct Cleaning
0811	EOS Air Conditioning Units Install
0812	Cargo Reefer and AC Plants Expansion Joints Replacement
0901	Docking and Undocking
0903	Propeller Shaft and Stern Tube Inspection
0905	BOW THRUSTER MAINTENANCE
0907	Polish Bow Thruster Propeller
0908	RENEW SEACHEST ROPE GUARD AND BT ZINCS
0909	ANCHOR AND ANCHOR CHAIN RANGING
0910	OVERHAUL SEA VALVES
0911	INSPECT AND REPAIR CATHODIC PROTECTION
0912	SHAFT GROUNDING MAINTENANCE
0913	Renew Waster Pieces
0914	BILGE KEEL REPAIRS
0915	Seachest Attachment System Upgrade Installation (T-ALT 296)
0916	UNDERWATER HULL CLEANING AND PAINTING (SPOT BLAST)
0917	FREEBOARD CLEANING AND PAINTING (NEAR WHITE BLAST)
0919	Rudder Gland Seal Lower Bearing Inspection
0931	Fresh Water (Closed Loop) Stern Tube Lubrication (T-ALT 403)
1001	RAM TENSIONERS REMOVE AND REPLACE
1002	HP AIR FLASK INSPECTION
1003	HP Air Gauge Calibration
1004	ARC REFURBISHMENT
1005	Winch Heat Exchanger Frame
1006	WINCH CONTROL (CONTROLEX) RISER
1007	HAULING WINCH BAND BRAKE REFURBISHMENT

File details come from the government source that posted it.