Pmt_SOB.PDF

STATEMENT OF BASIS

U. S. Air Force Cape Canaveral Air Station Facility ID No.: 0090005

Brevard County

Renewal Title V Air Operation Permit FINAL Permit No.: 0090005-010-AV

This Title V air operation permit is issued under the provisions of Chapter 403, Florida Statutes (F.S.), and Florida Administrative Code (F.A.C.) Chapters 62-4, 62-210, and 62-213. The above named permittee is hereby authorized to perform the work or operate the facility shown on the application and approved drawing(s), plans, and other documents, attached hereto or on file with the permitting authority, in accordance with the terms and conditions of this permit.

This is a military facility that contains the following emission units:

a) Eight Steam Boilers as follows: CCAFS Boiler #1, #2, #7, and #8 (Donlee Technology), CCAFS Boilers #3 and #4 (Cleaver Brooks) CCAFS Boilers #5 and #6 (Portable)

b) - CCAFS Solvent Sinks Set #1 and Five Paint Spray Booths as follows: CCAFS Solvent Sink Set #1, used for cleaning and preparation of small parts and tools equipped with a single hood, and CCAFS Paint Spray Booths #1,#3, #4, and #5 equipped with dry paint filters and CCAFS Paint Spray Booth #2 equipped with water fall

c) Abrasive Blasting Yards #1, #2, #3, #4, and CCAFS Abrasive Blasting Booth #1

d) CCAFS Engine Driven Chiller #1, fueled by natural gas. This unit constructed was under air construction permit number 0090005-005-AC, issued February 15, 2000, and incorporated into the Title V permit by revision 0090005-006-AV, issued November 13, 2000.

Also included in this permit are miscellaneous insignificant and unregulated emission units and/or activities Based on the initial Title V permit application received June 3, 1996, this facility is a major source of hazardous air pollutants (HAPs).

The applicable emission limitations are as follows:

a) Eight Steam Boilers - VE limit per Rule 62-296.406(1), F.A.C.; BACT per Rule 62- 296.406(2)&(3), F.A.C.

b) Three Solvent Sinks and Five Paint Spray Booths - general VOC standard per Rule 62- 296.320(1)(a), F.A.C.; annual VOC limit per construction permits; VE limit per Rule 62- 296.320(4)(b), F.A.C

c) No. 2 Fuel Oil Storage Tanks #81900 (12,000 gal. AST) and #60533A (16,000 gal. AST) - 40 CFR Part 60, NSPS Subpart Kb

d) Abrasive Blasting - VE limit per Rule 62-296.320(4)(b), F.A.C.

e) Engine Driven Chiller #1 - VE limit per Rule 62-296.406(1), F.A.C.

Construction permit 0090005-008-AC was issued to make the facility a minor for HAP emissions (remains a major facility for other pollutants) and therefore avoid being subject to NESHAP 40 CFR 63, Subpart ZZZZ. HAP emission are limited to less than 9.5/24.5 tons/yr. The permit also sets a limit of 352,000 gals/yr of diesel fuel fired for the IC engines and generators (reclassified as permitted but previously listed as insignificant units); adds a 28,000 gal. kerosene storage tank subject to NSPS Subpart Kb recordkeeping only (24 lb/yr VOC emissions); and allows the firing of bio-diesel fuel in the boilers.