Attachment 8.826-926 Complete Report - Honolulu VAMC Final-4.pdf

ACC

Emergency Generator

Test

9/1 1/1 9

7/ 1 /

/0?

Date:

Tech Signature:

WL or Supv. Signature:

fr

Date: r

Ambulatory Care Clinic Attachment (D)

Model # 3508 Serial # 23207184 Start Time: e'Stop Time: (_,D7/ e.„ Pre checklist:

Satisfactory Unsatisfactory Comments Check fuel & fuel tank /

Check oil level /

Check coolant level 1i

Check air filter /

Check batteries & terminals /

Running check list: Comments Quarter:

1) Simulate power outage /

2) Transfer life safety & critical equipment

3) Take reading every 15 minutes

Engine Speed (rpm)

Lube Oil pressure (psi)

C, Lube Oil Temperature (F)

1 c, Hour Meter (hours) i 'Si. 3

Engine Temperature (F)

/ 9 0

Frequency (Hz)

Operating Voltage (v) 1 480

2 480 3 480 Operating Amperage (amps) 1

/42_ 2 1 I- 4 3 1 3ei

ir. I (rpm)

/ /P-7

I .

Operating Voltage (v) 1 480 2 480 3 480

Orating Amperage (amps) 1 1z-r1 2 / 3! 3 j 1r6

Shutdown check list: comments

1) Return normal power .

2) Check oil, fuel and coolant level

3) Log all checks & corresponding reading a

4) Summarize test & list any problems & corrective actiqp r). Signature: Date:

Ambulatory Care Clinic Attachment (A)

Model #3508 Serial #23207184

Hours eS i . `7

Monthly Check list: satisfactory Unsatisfactory

Comments

Check for moisture, dust, oils, greases, & debris on main stator, exciter, & PMG windings, Check oil & coolant levels.

Drain fuel system to remove H20 & sediment.

Check for leaks: cooling, lube oil, & fuel system.

Check for loose/damaged clamps, filters, brackets, fittings, hoses, & other components.

Check belts. .

Check for restrictions of intake/exhaust system.

Check for any loose electrical connections., .Tnspea'contacts for pits, burns, evidence Of arcing.

r

InSpect progiann:nable logic control adjustments bbserve.& vent/ AT.S. .

Certify that equipment has received MOnthly service:, ,• : . .

'Check batters, Cahles.,-, • . - ' / - •

Check coating on terminals, lugs;

shunts, koable connections.

Check & record Voltage:readings of each cell & total Celtbank., :' , • .. .•

CS, 14,,, i 3,i'r, Check &record battery load w/ cells on . . _ float charge.. .

e -s-

Check.electrolyte levels. .

Check output ammeter & voltmeter.

Check rate of charge for float & 'trickle . ehai-ging. . . •

Check AC power. . . _ .

Check for cleanliness of system. & area..

Start generator 4. Epn on building load-. - , [Refer to attachMent MA . ...• .

Check engine & bearingi for 'oit&II.20 leaks,•unusual noise, excessive • • ... .. . . • I . • •

& overheating.

_Vibration, -After lbadtest, ebserVe transfer & Shadow-a se 'quenie

A.fler shuttloWb_,\*Ilie .ridwengitte, Clean buy sill k update log

,CgrifirM'W'it,la Security that audible _.

alarm from panel -arr be heard.. .

Tech Sign. ato.r:. • Date:

V' II a a

Voltage and Current. From 9/11/2019 6:35:08 AM To 9/11/2019 7:18:28 AM

• 210

• 150

▪ 90

RepodDaternme 9/11/2019 7:49:12 AM Page 1 Filename HalfHourGenTestG190911..fpq

---- 200ms Period Min ---- 200ms Period Max ---- 200ms Period Avg

• 150

▪ 90

• 150 csi

• 150

- 90

• 20

-4

MUiLkJ dulj

LLd LLhLhnJItA

'LAU

LLLLIJLJL

06 40 06 45 06 50 06 55 07 Or 07 05 07 10 07 15

Generator

Load Bank Test 8/13/19

Tech Signature:

WL or Supv. Signature:

Ambulatory Care Clinic Attachment (D)

SA3

Model # 3508 Serial # 23207184 Start Time: Stop Time: N ' 2.a v i-t 'Pre check list: •

Satisfactory Unsatisfactory u..,eck fuel & fuel tank

1..."... 4" i•-• st don !edit ael iN• h iv.

Check coolant level /

Check air filter in.e Speed (rpm) _

.L.oe Oil pressure (psi)

6st. 1

Shutdown check list:

1) Return normal power corresponding reading problems & corrective action , / a ...'

F's. Signature:

Date: .cj /24/19

Date: (7/74(11

Date:

Amb latory Care Clinic Attachme t (A)

Model #3508 Serial # 23207184 Hours 4 -3 1. /

Monthly Check list: Satisfactory Unsatisfactory Comments

PMG windings.

Check oil & coolant levels. /

1 components. / connections, .Thspeet.coptacts fox. pits, bums, evidence Of arcing.

S.

InSpect progratnniable logic control adjustments. " / bbserve.& verify AT,S. . ' , inbnthly service:, :. : . .. : • .

:Check battery Cables..••5 • . • - • / '

Check coating on terminals, lugs; /

. shunts, &seal* connections.

Check & record Voltage,readings of

-each cell & total Cell-bank., : , Check &record battery load w/ cells on _ float charge.: • . .. . -

Check.elect.rolyte levels. /

Check rate of charge for float &trickle •charging • •

Check Ad power

Check for cleanliness of system. & area.

Start generator & run on building load-. - 5 IRefer to attachMent 0)1 ,L.' , , .. . . .. . . ,. ..

Check engine & bearings. for oil& 1120 , . .

lealss,•unusual noise, e*cessive :". : . .

vibration, & overheating. .

After lbadtest, observe transfer & ShUtdown- seiluenc'e. . •,..

After shutdoWn,' Wilie rldwn.engthe, Clean 'my snillk update log. .

.cop.nrul. -i:iii,th Security that Audible 55 alarm from panel (..an• be heard.., Tech Sign. ainre:. Date:

Attachment (D)

Model # 3508 Serial # 23207184

Running check list: Comments Quarter: ATS#1 Time to transfer power ATS#2 Time to transfer power Passed

Failed

2) Log all checks &

3) Summarize test & list any problems & corrective action , , /

/ i

WL or Supv. Signature: Date:

Eng. Signature: Date:

Date: 7r/zi /1 5

Generator

7/10/19

7 --to --/fr

Attachment (19)

# 3508 Serial # 23207184 jo•-? 'p'Model Start TimeeSr Stop Time:

Pre checklist:

( Satisfactory Unsatisfactory

—Check fuel & fuel tank ..-

Check oil level e'

Check coolant level ,--

Check batteries & terminals ...'"

3) Take reading every 15 minutes /

Engine Speed (rpm) 1800

Lube Oil pressure (psi) 8' 0 •

Lube Oil Temperature (F) I /a

Hour Meter (hours) 1r2-4. • 5

Engine Temperature (F) I (11(.7

Frequency (Hz) 60

Operating Amperage (amps) 1 / 1-1 1— 2 i 2_1! 3 i f 2_

Ine Speed (rpm) — 1800

Lube Oil pressure (psi) 4-e:3•• 5-17-0 f c, Hour Meter (hours) .6•;•(4. • laP

Engine Temperature (F) teg7

Operating Amperage (amps) 1 / q 2— 2 / 2 y 3 i Y /

Shutdown check list: .v Comments 1)Return normal power

4) Summarize test & list any / problems & corrective action /%11/ / / 4—/ #2

Tech Signature: Date:

WL or Supv. Signa Date:

Signature: Date:

Attaehme i t (A)

Model #3508 Serial # 23207184

Hours

Monthly Check list: Satisfactory Unsatisfactory sediment. /

Check for loose/damaged clamps, filters, brackets, fittings, hoses, & other

Check belts. , ../

•Check for any loose electrical connections., .linspeof contaets for pits, burns, evidence. cif arcing.

InSpbct progrm-rnable logic control adjustments, .. . _.

'Observe* verify AT,S. . ..r inbrithly service., .,• -• . • • . .

..,V

*Check batten', Cables,. • . . • ' .V shunts, kcable connections.

. V .

each cell & total cell-bank.,: , 13.144/

1 5

.14

.24

Check &record battery load w/ cells on . . . . -. float charge.' . .. , ., . • .

• r _ .

.2.4 . '4-

Checkelectrolyte levels. .

Check output ammeter & voltmeter. 7 .

Check rate of charge for float &trickle .cha . . •i-ging.

'Check Ad power. , Check for cleanliness of system & area.. X •

Start generator 4. hm on building loact -f • .

[Refer to attaclMient (D)1

7 '

Check engine 0 , bearings. for oil* H20 leaks •tuiusual noise, excessive •". ' Vibration, & overheating. .

After leanest, obsr.rsie transfer & Shntdown seiiilleDid. • - • ..

Aftei- shutdoWh,Vilie rkwn. engine', Clean any spilli, update log

/ r

.dorifirth.i.,7,ii,th Security that audible alarm from panel bakl: be heard..

Tech Signature:: • Date:

II

Report Date/Time

7/10/2019 7:47:11 AM Page 1

Voltage and Current. From 7/10/2019 6:34:55 AM To 7/10/2019 7:15:50 AM Filename

HalfHourGenTestG190710..fpq

• 210

• 150

▪ 90

411. — 200ms Period Min

— 200ms Period Max

— 200ms Period Avg

WY'

CNI

• 150 cs,

▪ 90

• 210

▪ 90

210 _

16.5 13.5 10.5_

7.5

4.5 '

1.5:

1.5 -

06 ?`

1 6.11t_tfula.

oo 07 05 07 10

.411-112tWL:trualt_t_it...

06 40 06 45 06 50 06 55 07 15

Generator'

6/12/19

Attachnie It (A)

,del #3508 Serial # 23207184 Hours C 2. 5. 1

& debris on main stator, exciter, & PMG windings.

y V

Chock oil & coolant levels. t/

Drain fuel system to remove 1120 &

Check belts.

I/

Check for any loose electrical • connections., .Inspeefoputaets for pits, bums, evidence Of arcing.

Inspect progfan-iMable logic control adjustments. .. . l/V

'Observe* verify AT,S. . 1/''' nionthly service:,;. -.. . : • .

•C' -I batter Y Cables:, • . . -

C.L—ek coating on terminals, lugs;

shunts, kcable connections. LZ

Check & record VoltageJeadings of -each cell & total Cell-bank., : .

Check &record battery load w/ cells on float charge.: . ., : ., . ' •

Cheekelectrolyte levels.

Check output output ammeter & vOltmeter. v y

Check rate of charge for float & triclde . charging.

t/ j

'Check AC power. . .

Check for cleanliness of sYstern & area. +.7. •

Start generator & sun on building load: • .

'Refer to attachinent (D)1 . ‘ '

17 •

Check engine &, bearings for oil* 1120 leaks,•unusual noise, excessive : • 'vibration, & overheating, ' v r .

-After leadtest, ohserVe transfer & Shittclown- sequence. . • .

After shutdoWn,,'Witie 46ml:engine:, Crean any spine,. update log. . . . \.,/

.Coritriiii;jith Seenrity that audible ...

alarm from panel ban be heard. .

Date: 0 2- //, Ambulatory Care Clinic Attachment (D)

Model # 3508 Serial # 23207184 Start Time: 0 C2 2 Stop Time: 0 6 5 2_.

• Pre check list:

Check fuel & fuel tank tZ

Check oil level IV

Check coolant level

Check air filter i/

Check batteries & terminals

Running check list:

1) Simulate power outage V equipment I/ Al s I '. It 5 C c- A-TS ̀ • 2- a 5€

Lube Oil pressure (psi) 14

Lube Oil Temperature (F) I 1-e10

Hour Meter (hams) 425 • II

Engine Temperature (F) I fic 0

Operating Amperage (amps) 1 /0 2 i 2.;2— 3 i V f

Lube Oil pressure (psi) ly

Lube Oil Temperature (F) / `ZiO

Hour Meter (hours) .6 2 S . -7

Engine Temperature (F) i 1(0

Operating Amperage (amps) 1 11 1

2 I q g 3 2c,-1—

Shutdown check list: Comments

1) Return normal power ..."

‘7

CZ

problems & corrective action .-) /

Tech Signature:

jka

RepoaDatenlme

6/12/2019 7:21:42 AM Page 1

Voltage and Current. From 6/12/2019 6:22:42 AM To 6/12/2019 7:02:02 AM

HalfHourGenTestG190612..fpq

— 200ms Period Min

— 200ms Period Avg

- 90

30 -

330_

• 210

• 150 cs,

▪ 90

• 90 -

2.2

1.8

▪ 1.4

• 1

• 0.6_

0.2

0.2

2.75 _ 2.25

1.75

• 1.25

0.75

0.25

-0.25

• 1750

• 1250

▪ 750

165000 135000 105000

=C-- 75000

• 45000

15000:

-15000

- OW i11 A. lir a_ T2-

LL

L

LLiLLALL

06 25 06 30 06 35 06 40 06 06 50 06 55 07 00

MONTHLY'

GENT - ST

5/8/19

WL or Supv. Signature:' Date:

/1

Attachment (D)

Model # 3508 Serial # 23207184 Start Time: 06'30 Stop Time: (...1 -702 Pre check list:

Satisfactory Unsatisfactory

—Check fuel & fuel tank /

Lube Oil Temperature (F) I V

Hour Meter (hours) 6g q 0 4

Engine Temperature (F) 110

Operating Amperage (amps) 1 )2.4 2 I 1 6.. 3 / 5 7

..ae 1. 1. in 1800

Lube Oil pressure (psi) /

Lube Oil Temperature (F) J 0

Hour Meter (hours) A.2 s i I

Operating Voltage (v) 1 480 2 480

3 480 Operating Amperage (amps) 1 /4/ 2 /3 / 3 i 9 q ing reading corresponding

& corrective action /

1 / ,/ I I • •

Model #3508 Serial #23207184 Hours

Monthly Check Check list: Satisfactory Unsatisfactory

' components.

Check belts. / aonnections., .1-nspea.contacts for. pits, burns, evidence cif arcing.

Insp'ect prograrciniable logic control adjustments bbserve& verify ATS. .

Monthly service,,• -.. . • / .

'Check batter Y Cables.... • . ' - ' - -shunts, 4:cable connections.

Check & record 'voltage:readings of each cell & total Cell-bank., :. .

,1 kl,tc.), 2.(,. 2 -s

&record battery load w/ cells on Check . . . _ float charge. . .. - • .

• / _ . . ._ C. A

Checkelectrolyte levels. /

Check output ammeter & vOltmeter.

/ . V

. charging'. •

V• .V V V•

Check Ad power. . . _. . /

_ V-

Check for cloar:diness of system & area:. .i -

Start generator i.% run on building load: • iftlefei to attacinient (D)1 . .. , . .

. / V. •

Check engine& bearing for oit& 1120 . . .

1palp,uUusual p.o.ise, o*cessive : • : . . .

vibration, & oVerheating.

-After lbadtest, obserVe tMnsfer & . ..

ShUtdown sequence. . ... ,.

After shutdoWn,‘Wifve rkvvii engine, Clean ;wiy spill. update lag. . .

1 .

.cOntirM..V.;iith Security that audible _.

alarm from panel ban be herd.. .

Tech Signature:. Date:

5/8/2019 7:52:23 AM

00 6 55 07 05 07:10

Voltage and Current. From 5/8/2019 6:31:17 AM To 5/8/2019 7:10:37 AM Filename

HalfHourGenTestG190508..fpq

....1,-, .- ...- ,,,, ...,.......—.0e- -

U

....... ,.... ..t

1 0

50 _

30 :

.70

!10 _

30, !70:

!10;

90 -

30 -_

'JO

,.10

11111M111111111

11111

1 I.

I I=

...., , MN ill aill i II irmiinwilturoorm mai simr„prausimp.

ril

111111111= 41 11.1

.11. I 111111 111111. 110011. 411 1.1111 'Mlle. "'L.:111

-..MINI IIININIMIS.11.11 MM. hit IIIIM

Mel. 10.1. 11 MI

11111

INI

Mill 30 , 111 11111111

140 , /60.:

)00

DOD',

200ms Period Max

— 200ms Period Avg

Co

Co

-2

MONTHLY

GEN TEST

4/10/19

Date:

Tech Signature:

-. Signature:

Air bulatory Care Clinic Attachment (D)

Model # 3508 Serial # 23207184 Start Time: c‘i/S Stop Time: 0 1.2 1 Pre check list:

Check fuel & fuel tank

Check oil oil level ...----

Check coolant level ,...,-----

Check air filter ..-------

1) Simulate power outage V".

Engine Speed Speed (rpm) 1800

Lube Oil pressure (psi) Icf

Lube Oil Temperature (F) — N it-

Hour Meter (hours) 6ac I . 7--

Engine Temperature (F) i 4K-7--

Operating Amperage (amps) 1 1 ; if 2 / /6 3 1.3 I h_ 52 j2 n a) _ _I 1800

Lube Oil pressure (psi) 1 6r

Lube Oil Temperature (F) l 151—

Hour Meter (hours) c a Al. z(

Engine Temperature (F) 1 q -2--

Frequency (Hz) 60 -

Operating Amperage (amps) 1 I ( 2 1 /10 level / corresponding reading / problems & corrective action/) / /1 /— •

Model #3508 Serial # 23207184 Hours C., ' ..( , C.

Monthly Check list: Satisfactory Unsatisfactory Comments

& debris on main stator, exciter, & /

PMG windings, S filters, brackets, fittings, hoses, & other conttectipils, .linspe6t .contaCts for pits, burns, evidence,df arcing.

InSpect programable logic control adjustments bbserve.& verify ATS. .

7 .-

Monthly servim ,• : . .. :- .

'Check battery Cables:. • . • ' ;/-shunts, kcable cormection.s.

-each cell & total Cell-bank., :

I 1,6 5 II . 6 2- 2.3. 6y . • .

Check Sr record battery load w/ cells on float charge.. . : .. . • -

Check electrolyte levels. ..7

Check rate of charge for float Sr 'trickle •charging. • •

1. _7

. i . • ..

Check Ad power. . . _.

Check for cleriliness of system & area, .7'.

*art generator 4 run on building load-, - -Refer to attacbnient (D)i . ... •

. / S - • • - -

Check engine& bearing4 for .oit& 1120 .

lealss,unusual noise, e*cessive •" Vibration, & oVerheating..

5 - •

-After lOad.test, ob,r,rVe transfer & Shadown- sequence. . .. •,...

After shutdoWh,'Wilie rlOWA engine, Clean :any spilli, update lag. . . . •/ . .

Confirm with Security that Audible ..1 alarm from panel ban: be herd.. • S

Tech Signature.:. • Date:

4/10/2019 7:56:05 AM Page 1

Voltage and Current. From 4/10/2019 6:38:19 AM 10 4/10/2019 7:23:04 AM

Recorded data 2.fpq

— 200ms Period Avg

• 210

— J 90

▪ 90

• 210

0,

• 350

• 250

▪ 150

• 420

66000

54000 42000 30000

• 18000

-6000

--r•r tiolai.1.411„t_tt

. - PC Ir Ito • • V'

LILL JiLiLtkk

-̀ 6 40 06 45 06 50 06 55 07 00 07 10 07 15 07 20

3/22/19

Model # 3508 Serial # 23207184 Start Tim --7 i c Stop Time: oiy —7 c c,"

' pre check list:

Satisfactory Unsatisfactory i

Check oil level /-

7/5

1 $ V t( °

Frequency (Hz) 60t

Operating Amperage (amps) 1 I '16 2 i 2 7 3

1 1--r a-ine Speed (rpm)

—Lube Oil pressure (psi)

.7 .

6. d-3 , 1

60 -

Operating Amperage (amps) 1 • ', t ).% 2 t 32-f 3

1 `i- ...

comments problems & corrective action

1/ 7 i

. 1 / % i

(-/ Tech Signature: .///'

WL or Supv. Signatir‘: . Date:

ttachme t (A)

Model #3508 Serial # 23207184 Hours „ . (2 . 4-4 . 0

Monthly Check list: Satisfactory Unsatisfactory Comments Check for moisture, dust, oils, greases, & debris on main stator, exciter, &

Check for loose/damaged clamps, system, , eonnections., .InspeCt 'eon:tads for pits, bums, evidence.df arcing.

InSpect programinable logic control adjustments

'Observe* verify AT,S. :

inonthly service., ••• -- . ,: :. . .

-Check batterY 661s..... • . •

:shunts, &cable connections.

_Check & record Voltage,readings of each cell & total Cell-bank., :* , 12,c.)3 / 11,99 / 2. 4/.1k, .

float charge... • -. , ., . . • •

. • 57'

Check.electrolyte levels.

Check output ammeter & veltraeter. /

•chai-ging .

*Check Ad power. . . . _. /

Check for clefiliness of system & area.

*art generator & run on building load.: • :

-Refer to attachnient OM . : :. .

: 7 •

Check engine*, bearings for oil* 1120

. lealcs,•unusual noise, eicessive •". -' - .., .. : . . • , . • • Vibration, & overheating.

After leadtest, obserVe transfer & Sshutdown'sePuences. . -. • ..

After shutdoW•h,‘Witie ridt74 engine, Crean any spine,. update log. .

.Conftini..With 8- bilrity. that audible .

alarm from panel ban: be heard.. .

Tech Siinature:. Date: . .

A_ALLILLikuLithJILL

I. II

3/22/2019 10:08:28 AM Page 1

Voltage and Current. From 3/22/2019 7:10:57 AM To 3/22/2019 7:51:02 AM

Recorded data 1

• 150

▪ 90

330 :

270;

210;

• 150;

90;

30 -

• 150

- 90

2 20

• 12

-4

• 28

• 20 cs,

• 12

-4

35 :

• 25 0-)

- 15

3300000 2700000

—2100000 ---1‹ 500000

900000 300000

-300000

Jr • MAIL• .L=4. I - -

— 200ms Period Min

II 41—

..A.ALLILL 1.1.1tuiLiddilLILALLir-A-A

07 15 07 20 07 25 07 30 15 07 40 07 45 07 50

Model # 3508 Serial ti 23207184 Start Time: 6633 Stop Time: 0 40

P"4 check list:

Check fuel & fuel tank 7

Check oil level " /

Check batterieS & terminals /

. Running Check list: Comments Quarter: - Month #1 - ATsta 30 5ed '1 Month #2 - ATS#2 5 5 5.. 'i Month #3 -=1V1aiiiiIi•eaketr

1) Simulate power outage / Note how many seconds takes to transfer )....2_seco vl 0)

- Transfer life safety & critical

7 0

-7

.4-z_ 741)-9

1-'7g

Operating Amperage (amps) 1 g S

2 s c_D 3 S 9

_i: .s_iT_DI in 1800

Lube Oil pressure (psi) 7

Lube Oil Temperature (F) (., 2

Hour Meter (hours) 2.3.

Engine Temperature (F) / St)

Operating Amperage (amps) 1 "2 "-; 2 SO 3 sq

Shutdown check list:

v.Ze 1) Return normal power corresponding reading \.

4) Summarize test & list an/ V -problems & corrective actio

Model # 3508 Serial # 23207184 Hours C2_'3.3

Check oil & coolant levels, Drain fuel fuel system to remove H20 &

Check Check for leaks: cooling, lube oil, & fuel system. CZ

_astern.

connections., hispeet contacts for pits, burns, evidence,df arcing.

Inspect programmable logic control adjustments. I./ bbserve & verify ATS.

Certify that that equipment has received monthly service,,, :

Check battery cables, - t -.

shunts, & cable connections.

..Z

I Check & record Voltage,readings of each cell & total cell bank : , V

I 3.i( 1 i 0 _6, i /3./4 2

Check & record battery load w/ cells on float charge.

Check electrolyte levels. . z -.

Check output ammeter & voltmeter. ../

Check rate of charge for float & trickle •charging

Check AC power.

Check for cleanliness of system & area.

Start generator 4 run on building load [Refer to attachineht (D)1 , Check engine & bearings for oil.& H20

• leaks, unusualnoise, excessive i vibration' , & overheating.

After loadtest, observe transfer & shutdown sequence.

After shutdoWn,'WiPe down engine;

Clean xhy spills,, update log.

Confirm with Security that audible alarm frorn_panel Can be heard. •

Tech Signature:. - Date:

du_

— 200ms Period Max

— 200ms Period Avg

War Pr'

-t

[AUL

Voltage and Current. From 2/20/2019 6:41:33 AM To 2/20/2019 7:24:28 AM

Report Date/Time

2/20/2019 7:55:04 AM

Filename

HalfHourGenTestG190220..fpq

I Page 1

06 45 06 50 06!55 07 00

5: 210

• 90

• 150_ co —J 90

1.1 _

0.9

0.7 2 0.5

0.3

0.1

0.1

• 1050

CO

--1 450

88000 72000 56000 40000

• 24000

-8000 uHi ana

1 11 kr, LU

07 05 07 10 07 15 07 20

1/23/19

Model # 3508 Serial # 23207184 Start Time:06;31 Stop Time: c, -1 I 2.-r '; check list:

Check fuel & fuel tank • /

Check oil level • i

Check coolant level . /

Check batteries & terminals '•

Running check list: `---4v-*/ w -N-- Comments Quarter: Month #1- ATS#1 rl 5,-4:s Month #2 - ATS#2 '--1 6 5, Month #3 - Main Breaker

1) Simulate power outage 7/ Note how many seconds takes to transfer /1. L-i 0

2) Transfer life safety & critical

-1 4 l 1 1 ')

& 2-2 • :).-

1 V I c

Operating Amperage (amps) 1 t tc- 2 lOt( 3 k I q

,me Speed (rpm)

72.

\ `g 2-6

(c, Z2.-

Engine Temperature Temperature (F)

5 )2'

Operating Amperage (amps) 1 t 2. '5 2 k \ -S 3

1 3 I

1) Return normal power 7 / level ( .

3) Log all checks & ( corresponding reading , A

4) Summarize test & list any/, // problems & corrective actioA // / / 7.1 i . - I - . il

Model # 3508 Serial # 23207184

Hours 6 22 , Monthly Check Check list: Satisfactory Unsatisfactory

& debris on main stator, exciter, & PMG windings.

I system. .

connections.. 'lisped contaCts for pits, bums, evidence of arcing.

Inspect programmable logic control adjustments.

Observe & verify ATS. • / --

Monthly -service:, ,- . • -

Check battery cables,. - 1 shunts, &cable connections. /

Check & record Voltagel'eadings of each cell & total cell-bank, ; .

0 .11-1 / t-1 .07i 2-6.2-4/ float charge. . -

,2 C. , +

Check electrolyte levels. /

Check output ammeter & voltmeter. /

Check rate of charge for float & 'trickle charging'

Check AC power. . . _ .

Check for cleanliness of system & area. /

Start generator 4 run on building load- - ,. -.

[Refer to attachinent (D)1

Check engine .& bearings for oii-& H20

- leaks, -unusual noise, excessive ' vibration, & overheating.

-After loads-test, observe transfer & shutdown' sequence.

After shutdoh,‘Vitie -awn engine', Clean any spillS,. update log. _ /

Confirm with sp'cUrity that audible alarm from panel Can: be heard.., /.

Tech Signature: Date:

LL1.1.L11.1.211,2L11_1_1_1.L_ r-- -1

Voltage and Current. From 1/23/2019 6:51:10 AM To 1/23/2019 7:31:45 AM a- • *S.

aa• T • - • a•--f

Report Date/Mme

1/23/2019 7:46:17 AM Page 1 Filename

HalfHourGenTestG190123..fpq

— 200ms Period Min

— 200ms Period Max

— 200ms Period Avg

• 150

• 150

• 210

• 150 -m

4.4

3.6

- 2.8 2 2

• 1.2

0.4

0.4

4.4

3.6

2.8 2 2

▪ 1.2

0.4

0.4

330000 270000

210000 150000 z 90000

30000 -30000 aa -

1.

06 55 07 00 07 05 07 10 07 - 07 20 07 25 07 30

Parking Structure

Emergency Generator Load Bank

8/21/19

Running check list:

1) SirOulate power outage

Comments Note how many seconds takes to transfer

2) Transfer life safety & critical equipment

3) Take reading everytc minutes

P riding Structure Attachment (I))

Model # 2000FAA . Serial # F960608681 •

Start Time: Stop Time:

Pre check Hsi:

check fuel & fuel tank /

G-4, rte roa..4-0 tr ti 1-.6 4- v- ..# pi 41%* ,„„cs .

Check oil level _I

Kilowatt (Kw) 1 gine Speed (rpm) _Fn e Oil pressure (psi)

C C 0.2

Operating Voltage (v) 1 480 2 480 3 . 480 check list:

tevel

' 3g all checks & ' orresponding reading

Summarize test & list any / , / blems & corrective action , /

13. Signature: / I Date:

Date; Signature:

P gt dare

Attaeltpl.FAt\k(A)

Mode/ # 2.06DFAA Serial # F960608681 Hours 66 O . 2, \

Monthly Cheek list: Satisfactory

Unsatisfactory _ Comments •

Thecic for moisture, dust, oils, grease, k debris on main stator, exciter, & )A40- windings.

:Ilea( oil & coolant levels. /

)rairt fuel system to remove H20 & edirrlent

-;heck for leaks: cooling, lube oil, & uel system-leak for loose/damaged clamps, liters, brackets, fittings, hoses, & other amp orients.

'heck belts.

heck for restrictions of intake/exhaust ?stem.

heck for any loose electrical mnections. Inspect contacts for pits, ims, evidence of arcing.

spect programmable logic control justrnents.

bserve &.venfy ATS.

;rtify that equipment has received prithly service.

leek battery cables.

ieck coating on terminals, Jugs, its, & cable connections.

eck & record voltage readings of ;h cell & total cell bank.

eck &record battery load WI cells on at charge.

eck electrolyte levels.

eck output ammeter & voltmeter.

eck rate of charge for float & trickle rging.

;ck AC power.

;ck for cleanliness of system & area.

rt generator & run on building load fer to attachment'(D)] :ck engine &bearings for oil & H20 s, unusual noise, excessive ation, & overheating.

u- load test, observe transfer & down sequence.

T shutdown, wipe down engine, n any spills, update log.

PARKING

STRUCTURE

7/1/19

Centcr for Agi Attachment

Model # 3508 Serial # 514'02819 Start Time: /W ig— Stop Time: A/M—

Pre check list:

uneck fuel & fuel tank

Check oil level

Check batteries & terminals /...

I Quarter:

, 1) Simulate power outage equipment fAl 1

3) Take reading every 15 minutes KAN.

ti c

W Pc

15 Minutes , Hour Meter (hum.)

Engine Temperature (F) * Ps ik

Operating Amperage (amps) 1 IV /A 2

'die Speed (rpm) 1800

—Lube Oil pressure (psi) WA-

15 Minutes

Hour Meter (hours) AVAA

4/1/4—

Operating Amperage (amps) 1 2

1) Return noimal power

2) Check Check oil, fuel and coolant level AVA corresponding reading reading problems & corrective action, 7,4/F?

WL or Supv. Signatur :

h1

1 Date: /?

F • Signature:

Model # 3508 Serial # 23207184 HOUTS 6_60 2—, Check for moisture, dust, oils, greases, & debris on main stator, exciter, & PNIG windings.

Check oil & coolant levels. /.

sediment. ---''' fuel-system. e----

7"

Check belts. • ./.

Connections., ,Inspeet 'contacts for pits, burns, evidence of arcing.

InSpecf progranunable logic control adjustments. ..

bbeive & verify ATS. .

Monthly servico:,,• : . . t

-Check battery eahles.:. - . -

Check coating on terminals, lugs,' .shunts, kcable connections.

Check & record Voltageq:eadings of -each cell & total Cell-bank.- , ' Check &record battery load w/ cells on 7 .

float : -. : charge. .. • c:,—; \).

Che &electrolyte levels.

Check output ammeter & WA:Meter. .

Check rate of charge for float &trickle 7 •

• charging • • . •

'Check AC power. . ---- • .

Check for cleanliness of system & area /--

Start generator & inn on buildi,.ng load-. - . ....„.._ . . . ,. .

[Refer to attacl4ent (b)1 . .. . .,.

Check engine .& bearings for oit& 1120

• lealcs,.unusual noise., excessive : • ....---. , . .. , vibration, & overheating..

-After liradtest, Qbs.erve transfer & 7 . shshutdown'sequence'. . , , After shutdoWn, ' Wipe ikwii. engine', Clean any spillk. update lag. .

ge'cUrity that Audible alarm from panel Can be heard.. .

Center for Aging

Model # 3508 Serial # 5YF02819

Running check list: Comments

Failed X a"--

OVet ilAAA i (..._ A-1-5) er problems & con-ective action A.4 /

Date: 77171/

Parking Stiucture

Emergency Generator

6/20/19

Parking Structure

Model # 200DFAA Serial # F960608681 Start Time: Stop Time:

atAtt eA14-0 r IS -pee ttse....54.1 e, a 4-i.--,e 6w-fs i x.),....;-P rP di - ri)ekir- .

1,--v ri. "'; -zs,,,, 0 A

1) Simulate power outage

Note how many seconds takes to transfer

3) Take reading every IS minutes

'-c,rine Speed (rpm)

Je Oil pressure (psi)

Operating Voltage (v) 1 480 2 480 3 480 .

1-- rel

Log all checks & orrespondi-ng reading

\ Summarize test & list any h A Oblems & corrective actioik /1 / ,/

Paridim Sttcture AttackprieAt (A) *

• t

Moclel # 2.00DFAA ' Serial # F960608681 Hours

Vlorithly Cheek list: Satisfactory Unsatisfactory Comments • :heck for moisture, dust, oils, greases, k debris on main stator, exciter, & wia windings.

heck oil & coolant levels.

)rairi fuel system to remove 1120 8c edinaent.

:heck for leaks: cooling, lube oil, 8c Liel system.

:heck for loose/damaged clamps, er , ojaelcers, nttmgs, noses, o er amp onents.

'heck belts.

heck for restrictions of intake/exhaust (stem.

heck for any loose electrical mnections. Inspect contacts for pits, ims, evidence of arcing.

spect programmable logic control ijust-rnents.

bserve 8z verify ATS.

:rtify that equipment has received DnthIy service.

leek battery cables.

ieck coating on terminals, Jugs, zits, & cable connections.

:eck & record voltage readings of ;h. cell & total cell bank.

eck &record battery load w/ cells on at charge, eck electrolyte levels.

eck output ammeter & voltmeter.

eck rate of charge for float & trickle rging.

eck AC power.

!•,ck for cleanliness of system & area.

rt generator 8c run on building load fer to attachment (D)] :ck engine &bearings for oil & I-120 -is, unusual noise, excessive ation, & overheating.

x load test, observe transfer & down sequence.

3- shutdown, wipe down engine, n any spills, update log.

i Signature: Date:

PARKING

kging 11)

Serial # 5VF02819 Start Time: 1,4- Stop Time: fil/Ak ... list:

( fuel & fuel tank /

C oil level A, c coolant level ../ c air filter / c batteries & terminals s sing check list: Comments 'I ter: ,v--nulate power outage to:•1 , msfer life safety & critical nent feal I ie reading every 15 minutes N/A

Speed (rpm) 1800

)il pressure (psi) ,,,,, )il Temperature (F)

',Teter (hours)

; Temperature (F) 4PC ncy (Hz) 60 lug Voltage (v) 1 40 2 480 ing AniRerage (amps) 1 A/A. 2

Speed (rpm) 1800

fl. pressure (psi) APC il Temperature (F) AI ,A-leter (hours)

Temperature (F) 10Ar icy (Hz) 60 ag Voltage (v) 1 480 2 480 ig Amperage (amps) 1 W/A. 2 down check list: Comments 'n normal power k oil, fuel and coolant

OS

II checks & riding reading WM-larize test & list any & corrective action

Date: (II gnature:

:upv. Signature:

nature:

Model # 3508 Serial # 23207184 Hours 4 6O. Z.

Check for moisture, dust, oils, greases, & debris on main stator, exciter, &

V---fuel-system. /".

Check belts.- .----connections., .Inspedfoontacts for pits, burns, evidence.df arcing.

InSp*ect programa. ' able logic control adjustments bberve & verify ATS. . (-- • . _ intinthly service- : . ,. s • * ..

/7

Check battery cables..-. - .

Check coating on terminals, lugs,* " V

.shunts, 4 cable connections.

Check & record Voltage%readings of each cell & total Cell-bank, : . - • float charge. .

Checkelectrolyte levels.

Check output ammeter & vOltmeter. / i

Check rate of charge for float &b.it,kle . char in : •

7-

Check AC power. /<

Check for cleanliness of sYstem & area. / 7 •

Start generator & i-un on buflding load- • .

tRefei to attachinent On : .. .

t " • • • - •

Check engine .&. bearingS for oit& 1120

• lealcs,unusualnoise, eXcessive ."

Vibration, & overheating.

-After kradtest„ observe transfer & shirtclown sequence. .. :.

After shutdoWn,IWilie rfirWri.engitte;

Crean :any spillS, update lag. . . 7 -- .

.Confirin.i0h g .ciartty that audible alarm from panel CALI: be heard.. . ../

Model # 3508 Serial # 5YF02819

Running check list: Comments

Failed X

1) Return normal power ,, Al- 5 corresponding reading ,,'

3) Summarize test & list problems & corrective ac any

G N TEST

PARKING

4/1/19 ttachment (ID)

Model # 3508 Serial # 5YF02819 Start Time: it Sto Time:

Pre cheek list:

uneck fuel & fuel tank ./

Check coolant level .--

Check batteries & terminals ,..-.

Quarter: &me veato\e- ari 4" _,L r-i L equipment T-C6 \

3) Take reading every 15 minutes WA .

Lube Oil pressure (psi) iV IA

Lube Oil Temperature (F) Ai /A

Engine Temperature (F) /1//h ne Speed (rpm) 1800

Lube Oil Oil Temperature (F) A/ /Pc

Hour Meter (hours) /V PC

Engine Temperature (F) /1/4//k

1) Return nowial power itY/A level IviA, problems & corrective action ----- , 7 tl,:, V64 -01 vvoseV- .6A-rAY-HP9 s

Tech Signature: Date:

WL or Supv. Signature: . Date:

F Signature: Date:

Model #3508 Serial # 23207184 Hours 660

Check oil & coolant levels. 7 fuel-system. 7

Check belts. • ..----''

Check fer restrictions of intake/exhaust system. /-

Connections., ohispeCt gontacts for pits, burns, evidence cif arcing.

InSpiectprograminable logic control bb§erve & verify ATS. .

Ceitify that equipment has received inonthly service:, .,- : .

'Check battery. Cables..., • . • ' / shunts, &cable connections.

Check & record Voltagel'eadings of each cell & total Celtbanic, ; .

al-6 V float charge. : - .

Check output output ammeter & voltmeter.

•charging • •

'Check AC power. . . _.

Check for cleanliness of system & area. "--

Start generator & run on building load-. •

' .. . ' '. ". . [Refer to attaclinnt (D)1. ie ; . . •, Check engine .4 bearings for (AY& H20 - — .

*lealss,*unusualneis!e, excessive Vibration, & overheating.

-After jaadtest, observe transfer & Shinclown seCruence. . . :..

After shutdoWb, ' Wilie dalmi.engine;

elean any spillg, update lag. . .

.cenfinnWith Security that audible alarm from panel eau: be heard'.. .

Eng. Signature:

Center for Aging Attachment (D)

Model # 3508 Serial # 5YF02819

Running check list: Comments

Failed )‹

1) Return normal power tv7

Pselm5 WV- Q-A-VOA (1 corresponding reading Z

..."7 i

Date: 44/

PARKING

3/13/19 h Signature:

Parking Structure Attachment (ID)

Model # 200DFAA Serial # F960608681 Start Time: 66 TOStop Time:

check list: .

—Check fuel & fuel tank / a ---em er -40 v" t...Jac_i (ci v, , -1 4, --.(--, Note how many seconds takes to transfer

2) Transfer life safety & critical .

equipment

3) Take reading every 45- minutes

Engine Speed (rpm) •

— 9,ine Speed (rpm)

Je Oil pressure (psi)

Operating Voltage (v) 1 480 2 480 3 480 .

Log all checks & .

rresponding reading

Summarize test & list any

//://; blems & corrective action , heck belts.

rz, 2_ ' • / hers , brackets, fittings, hoses, & other impcnients.

'neck for restrictions of intake/exhaust stem.

leek for any loose electrical nnoctions. Inspect contacts for pits, ms, evidence of arcing.

ipect programmable logic control justrnents, iserve & verify ATS.

rtify that equipment has received ,nthly service.

eck battery cables.

eck coating on terminals, lugs, nts, & cable connections.

;ck & record voltage readings of 4 cell & total cell bank.

Date: Signature:

Paridim gt eture AttachlnapAtifA) t

Wociel # 2.06DFAA ' Serial # F960608631 Hours

Vloutthly Cheek list: Satisfactory Unsatisfactory Comments • :heck for moisture, dust, oils, greases, debris on main stator, exciter, & MG windings.

:heck oil & coolant levels. i

)rairt fuel system to remove H20 & cdirri.ent.

'heck for leaks: cooling, lube oil, & lel system.

heck for loose/damaged clamps.

;ck &,.record battery load w/ cells on o t charge.

;ck electrolyte levels.

ek output ammeter & voltmeter.

ck rate of charge for float & trickle ak AC power.

ek for cleanliness of system & area.

: generator & run on building load er to attachment (1))) :lc engine &bearings for oil & H20 ;, unusual noise, excessive don, & overheating.

- load test, observe transfer & lown sequence.

• shutdown, wipe down engine, any spills, update log.

PARKING

2/13/19

) Return normal power ) Check oil, fuel and coolant wel ) all checics &

.......ponding reading

) Summarize test & list any :oblems & corrective actio

,ch Signature: Date:

Parking Structure

Model # 200DFAA Serial # F960608681 ' i Start Time: `s -'s Stop Time: Ci---idc —

_deck fuel & fuel tank /

Grs_ —............6 ----

4+1, Check batteries & terminals ,/

1) Simulate power outage / Note how many seconds takes to transfer i 5- 5„

.2) Transfer life safety & critical equipment

3) Take reading every if minutes /

Engine Speed (rpm) • t Cc'

Operating Amperage (amps) 1 / L 2

1 cl 3 ci

I 1 Oil pressure (psi)

Lu.—e Oil Temperature (F)

VW

( lc .c'.

Kilo-watt (Kw) 1

3 ' 480 .

Operating Amperage (amps) 1 / (..e, 2 i cl 3 cf ithutdown check list:

heaE Delis.

heck for restrictions of intake/exhaust (stern.

heck for any loose electrical amections. Inspect contacts for pits, ims, evidence of arcing.

lack battery cables.

leek coating on terminals, lugs, wits, & cable connections.

VS 1,3 1 2C

spect programmable logic control jus-trnents.

bserve & verify ATS.

:rtify that equipment has received withly service.

teck & record voltage readings of cell & total cell bank.

2(0 Lek &Jecord battery load w/ cells on at charge.

eck electrolyte levels.

eck output ammeter & voltmeter.

eck rate of charge for float & trickle aging.

eck AC power.

3ck for cleanliness of system & area.

rt generator & rim on building load far to attachment (D)] ;ck engine &bearings for oil & H20

is. unusual noise, excessive ation, & overheating.

:1- load test, observe transfer & tdown sequence.

:i- shutdown, wipe down engine, n any spills, update log.

h Signature: Date:

Parithm gt cture Att.achla-eAt IA) •

VlocieJ # AUU.D.FAA Serial # F96060868I HQurs C. 0 wouithly Cheek list: Satisfactory Unsatisfactory Comments • -...leok for moisture, dust, oils, greases, k debris on main stator, exciter, & )A4G- -windings.

:heck oil & coolant levels. .

}rjn. fuel system to remove 1120 & edko.ent. /

;heck for leaks: cooling, lube oil, & uel s ystem.

lea( for loose/damaged clamps, lter, brackets, fittings, hoses, & other DMponents.

Voltage and Current. From 2/13/2019 6:32:58 AM To 2/13/2019 7:13:53 AM

2/13/2019 7:28:57 AM Page 1 Filename

HalfHourGenTestG190213..fpq

• 150

• 150

• 210

• 150 co

- 90

2.2

1.8

1.4 2 1

0.6

0.2

0.2

2.2

1.8

<7 1.4 2 1

0.6

0.2

0.2

1400 Ze.

co

- 600

165000 135000

105000 :!-C- 75000

45000 15000

-15000

9 r4 if fir r

— 200ms Period Min

— 200ms Period Max

— 200ms Period Avg r r r r . r

b. ff I -r- r r r

LI 1

Ii Ii LU

06 35 06 40 06 45 06 50 06 55 07 00 07 05 07 10

PARKING

1/16/19

) Return normal power

Check oil, fuel and coolant vel

; all checks & npsponding reading Simamarize test & list any oblerna & corrective actio ch Signature: Date:

Parking Structure Attachment (1))

114o del # 200DFAA Serial # F960608681 Start Time:4-6'5,C, Stop Time:

Pre check list: '

—heck fuel & fuel tank /

Rimini' g check list: Comments

1) SiMulate power outage

Note how many seconds takes to transfer i .2) Transfer life safety & critical equipment ' ' / .

3) Take reading every t5 minutes /

C.5" : ( t -1

Operating Voltage (v) 1 480 . 2 480

I `1

3 - 7

Engine Speed (wm) a Oil pressure (psi)

3 6

Luoe Oil Temperature (F)

61`I'

6.cal

11 Ce

.2 hutdown checklist:

Date: Signature:

Paridim StPictore Attochlyi0t fik) godel #2.00DFAA Serial # F960608681

VlorAthly Check list:

:helc for MOiStUre, dust, oils, greases, delpris on main stator, exciter, & qvIG- windings.

3hea( oil & coolant levels.

Satisfactory Unsatisfactory Comments

)rairt. fuel system to remove 1120 & edirowat ;heck for leaks: cooling, lube oil, & uel s ystem.

;heck for loose/damaged clamps, ,her., brackets, fittings, hosts, & other ompOTIents.

heck belts.

heck for restrictions of intakdexhaust rstern.

heck for any loose electrical amections. Inspect contacts for pits, mcs, evidence of arcing.

spect programmable logie control justrnents, nerve & verify ATS.

atify that equipment has received niftily service.

teck battery cables.

teck coating on terminals, Jugs, vats, ic cable connections.

eck & record voltage readings of cell & total cell bank.

eck &yecord battery load w/ cells on it charge sek electrolyte levels.

:ck output ammeter & voltmeter.

ick rate of charge for float & trickle

:ck AC power.

a for cleanliness of system & area.

t generator & run on building load Fer to attachment (D)) ck engine &bearings fru oil &H20 s, unusual noise, excessive ation, & overheating.

r load test, observe transfer & iown sequence.

r shutdown, wipe down engine, 1 any spills, update log.

lb

1/16/2019 7:38:50 AM Page 1

Voltage and Current. From 1/16/2019 6:38:59 AM To 1/16/2019 7:20:24 AM

HalfHourGenTestG190116..fpq

• 210

• 150 w".

• B r n a ao 9

— 200ms Period Mn

Ir• r B.

• 150 0.1

• 150

2.2

1.8

▪ 1.4 2 1

• 0.6

0.2

0.2

2.2

1.8

▪ 1.4

• 1

0.6

0.2

0.2

• 1400

165000 135000 105000

S 75000 45000 j

Uk

Uu

• rr tjLj 'F

LULl

15000 -15000

00 ^0 06 45 06 50 06 55 07 00 07 05 07 10 07 15 07 20

GEN TES

CFA

12/4/19

Date: zAt

. Date:

Tech Signature:

WL or Supv. Signa

CerAer ,for Aging Attachment (D)

Model # 3508 Serial # 517F02819 Start Time: ObA Stop Time: 6 (-,- c'S' Pre check list:

_ Satisfactory Unsatisfactory Comments

(-neck fuel & fuel tank /

Check oil level 7

Check air filter 7

Running check list: Comments .

equipment /

' Engine Speed (rpm) 1800

Lube Oil pressure (psi) 75

1 Lube Oil Temperature (F) i k 2

Hour Meter (hours) Li z... If

Engine Temperature (F) /‘ 0

Operating Amperage (amps) 1 3 i, 2

5 C

3 /...7

*lie Speed (rpm)

—Luoe Oil pressure (psi)

1 t i 6, C°

S'-1.:2 i G

1 6 r'

Operating Amperage (amps) 1 L.( 6 2

1)Return normal power level .

3) Log all checks & /

4) Summarize test & list any j/ j / problems & corrective actioVI / .cl / A

Hours

Month! Check list: Satisfactory

Unsatisfactory

PMG -windirt,:s.

fuel-s stem.

cora • onents.

Check belts..

s !stem.

burns, evidence cif arcin:.

connectioAs., .Inspea.contacts for pits, In'spectprogramniable logic control adjustments. .. _.

bbserve & verify ATS. .

Certi—fy that equipment has received babrithl service-,., :. . Ina

Check battery cables,. • . MEI

Check coating on terminals, lugs; l' shunts, &cable connections.

Check & record Voltageleadings of -each cell & total Cell:bank., : .

0--'1'd 7

12 . '7 2

., C-

Check &record battery load w/ cells on . , float char:e. . . -

;26. ̀ -f

Checkelectrolyte levels. IMMIIII

Check output ammeter & vOltnIeter. MEI

.ehat: 11 :, Check AC power. =MI

Check for cleanliness of system& area.

Start generator & run on building load, - : • ..

[Refer to attachinent (D)

Check engine &bearin:gs for oir& 1120 leaks -unusual noise, eXcessive --.

Vibration, & overheatin•

.After lhadtest, observe transfer 8c §hadown: seuen.c:d. .. •,..

Alter shuldoWWilie &WA:engine, 61ean an Sii11.6„. u• date lo• .

c:(2 .:VAttl. Security that audible alarm from panel t an:be heard..

Tech Signablre.:. Date:

12/4/2019 7:43:36 AM Page 1

Voltage and Current. From 12/4/2019 6:25:43 AM To 12/4/2019 7:02:03 AM

HalfHourGenTestG191204..fpq

.7'

.7

— 200ms Period Avg

1.65

1.35

1.05

3.

r., 2 0.75

0.45

"0

0.15

1.65

1.35

1.05

2 E.

0.75

.11

0.45

0.15

55000

45000

35000

25000

15000

-5000

06 30 06 35 06 40 06 45 06 50 06 55 07 00

1 1/6/1 9

Tech Signature:

WL or Supv. Si ature:

Centei for Aging Attachment (D)

Model # 3508 Serial # 5YF02819 Start Time: a 4. VT Stop Time: 0 -1_ I 2_ Pre check list:

-Lueck fuel & fuel tank /

1 1) Simulate power outage v

--1 (..

/--.-( c, I L..i d s-/ .c..---- , s'" 7 ( . 1(

A-10 - f- Ci0 47'b,-) <

Operating Amperage (amps) 1 ;Z 4 2

02 6 3 j ‘ '13§..pe_L(ail m

Luoe Oil pressure (psi)

7 6

IC C.- 4 a ,...) 'ff-Lku a e k Cb, ---.7 cJ • k , I (., C )(.1

Operating Amperage (amps) 1 J c.- 2

"5 problems & corrective acti i i i / 1 / n /2

7. Signature: Date:

Hours 5 7 2

, Monthly Check list: Satisfactory Unsatisfactory

PMG windings. / fuel-system.

components.

Check belts. / system, conneetions.„Inspedfcontaets for pits, InSpiect prograrnin— able logic control adjustments.

Observe & verify A,T,S. " intuathly serviccs,,,- -• . • - .

Check battery cables,. -shunts, 4:cable co-nnections. /

Check & record Voltage•feadings of each cell & total Cell-bank.,;

vs

IS'

' 't-

0_,L,,, ...._ci

Check &record battery load Iv/ cells on float charge. • . , _ .. . *V-6,1- .

Check.electrolyte levels. /

Check output ammeter & vOltineter.

•cha:rging.

Check AC power. , Check for cleanliness of system& area. .

Start generator 4 run on building load-. • : , [Refer to attachnient (D)1

Check engiric e,6 bearings for oil I-120 • . .

leaks -miusual noise excessive vibration, & overheating.

After lbadtest, observe transfer & shadow:I sOuence. .

After shutdoWn,'WiPe ridwri.eng,ffie, 61'eart 'any spillS,• update log. . . . . - . • ..

Confirm with Security that audible alarm from panel Can be heard. .

0 .

Tech Signature. Date:

— 200ms Period Avg

.7

0645 06 50 06 55 07 00 07 05 07 10 07 15

11/6/2019 7:50:23 AM Page 1

Voltage and Current. From 11/6/2019 6:39:36 AM To 11/6/2019 7:17:56 AM

HalfHourGenTestG191106..fpq

• 210

• 150

• 150

• 150

▪ 90

▪ 500 csi

▪ 300

r. 500

▪ 300

33000 27000 21000

• 15000

• 9000

-3000

OF 4r)

E.

E.

fr

Generator

10/2/19 t b - Tech Signature:

Attachment (D)

Model # 3508 Serial # 5YF02819 Start Timeq lio Stop Time: 0 7 1 Pe check list:

Satisfactory Unsatisfactory Comments ___, Check fuel & fuel tank --/

Check oil level ../

Check coolant level

Check batteries batteries & terminals

1) Simulate power outage i .

Engine Speed Speed (rpm) 1800

Lube Oil pressure (psi) hiol Vli c)1, k:i L/n

Lube Oil Temperature (F) nat I.A..).)y- le..\‘'

Hour Meter (hours) 5.7 / • 1—*

Engine Temperature (F) Ac9"\- Itiovv....`oi

Frequency (Hz) 60 .

Operating Amperage (amps) 1 21 2 Xi_h

3 1 /0 me Speed 2021. 1800

—Lube Oil pressure (psi) vix.er JO 'f

Lube Oil Temperature (F) Oval. Lvov Wt./

Hour Meter (hours) 5 1 1 AS

Engine Temperature (F) Ptil. k.00v ke-A

Operating Amperage an__ 2,6 2

3) Log all checics &

4 l

WL or Supv. Signature: . Date: AO

-. Signature:

Model # 3508 Serial #23207184 Hours 51 / .;

PlVIG windings.

Check oil & coolant levels. ,---fuel-system. ../.

filters, brackets, fittings, hoses, & other

Check belts. - ..".

connections, °hasped contacts for pits, InSriectprograrnMable logic control adjustments, .. ... V bbserve & verify AS. .

MOnthly service:, ., : . ,. :- *

- 0 ----.)

'Check battert Cibles.-:. . . ' -

;shunts, keable connections.

Check & record Voltage-readings of -each cell & total Cell-bank, ; .

.. . . 13. "IV) 13- i ti1, ,--C, w 01.1 V . . V V . .

Check &record battery load w/ cells on float charge. . . .. . • v - .,..--

Checkelectrolyte levels.

Check output output ammeter & vOltmeter. t' charging VVVVVVV

V ' V V

V V . .

Check Ad power. . . ,...----

Check for cleanliness of SSt11 & area L'''''.

_Start generator 4 i-pi: on building load-. v .

[Refer to attachinent (D)-I, . : .. .

17 - . v

Check engin..9 V& bearing for oily& 1120 • . .

leaks,.unusual poise, excessive :".

V Vi7VVVV

Vibration, & overheating..

V V V . -

-After lbadtest, ebsenie transfer & V Vt/ shadown- se *quelled. . ; .

After shutdoWh, \WiPe rioWn engine;

Clean 'any sPilli„. update lag. . .

i -

. VVV V .

cOrifinn.With Security that audible alarm from panel 6an: be heard-. . .

re-tmwte..( 1300.4.91

Report DateMme

10/2/2019 7:37:16 AM Page 1

Voltage and Current. From 10/2/2019 6:43:11 AM To 10/2/2019 7:21:01 AM Rename

HalfHourGenTestG191002..fpq

— 200ms Period Min

— 200ms Period Max

360 =

200 :

280:

120 =

40:

40 -

- 200

120 =

200 =

- 120

40 _

105 =

75:

45:

15 -

. ' 15 -

135 =

105:

75:

45;

180 =

140:

- 100

60 =

- 20

6.6 =

,,,,..____IL..,,,--.—•

r

3:

.-, .I—'

0.6

0.6 =

Ut lb 07 Ob '6:45 06 50

Emeigency Generator

9/4/19

Ceni.er for Aging Attachment OD)

Model # 3508 Serial # 5YF02819 . Start Time: At 2S—Stop Time: 0-7 o 6 Pre check list: -uneck fuel & fuel tank /

Lube Oil pressure (psi) 1 S

Lube Oil Temperature (F) IV D1 worlAbn

Hour Meter (hours) S. 75, Co.

Engine Temperature (F) Vat (A.XV let

Frequency (Hz) 60 .

Operating Amperage (amps) 1 -2, 2.... 2 1 47

3 9 2.., ..

,ine Speed (rpm) _ 1800

Lube Oil pressure (psi) V4,01- touv V2L tA\

Lube Oil Temperature (F) 1010 - L,ODY14-;‘,5-) .

Hour Meter (hours) 5 70 .1

Engine Temperature (F) OVNICTI (A.) -in

Operating Amperage (amps) 1 **2—C7 2 --3 5

3 9 7 level .

3) Log all checics & problems & corrective action , ; / , i ,\

,---7

WL or Supv. Signature:

Date:

Date:

Hours $.---t 1. 0

—Drain fuel system to remove 1120 & fuel -system.

Check belts. • / system, con-n.ections., .Inspedtcontacts for, pits, bums, evidence Of 4cing.

InSpiectprograininable logic control adjustments

Observe & verify AT,S. .

Certify that equipment has received / inbrithly service.,:- : . . . :. _

'Check batter Y Cahles.:, • . /

Check coating on terminals, lugs,' .shunts, kcable connections. /

Check & record Voltagetreadings of each cell & total cell-bank..: ,

13.13 /

1 ./ 4,r`C. 1:1 -float charge. • . .. . •

/1 . '

Chec.kelectrolyte levels. /

Check rate of charge for float Ktiiukle •charging .

'Check Ad power

Check for cleanliness of system- & area. : / "

Start generator k rim on building load-. - , : • , [Refer to attachinent (D)1 . . . . ., . . , Check engine & bearings- for oil & 1120 lea,Issoniusual noise, excessive :".

After leadtest, obrzlie tr & ansfer s hadown sequence. . . ... , After shutdoWh,‘Phie'Tidlvii engine, Clean 'any 8j3i114 update log

Confirm with gebiaritin that audible alarm from panel 6am:be heard. .

Z. . 1 ..• 1 •

'tech Signature.: Date:

1-1 1"—m—ft

• 105

• 45

06 30 06 35 06 40 06 45 ".̀9 50 06 55 07 00 07 05 I I

.k iota .Mi TPlimPuk u. I J.• PrOTROPP0.01.4. IL 1PFAV IPPEW 110.491*IN .Juia2L14=2 ' Lr!1.32:4.:%*

• 100 co

5.5 4.5 3.5

• 2.5 1.5 0.5

9/4/2019 8:32:57 AM Page 1

Voltage and Current. From 9/4/2019 6:25:38 AM To 9/4/2019 7:05:13 AM gHalfHourGenTestG190904.fpq

• 210

▪ 90

270 .

• 210 cNi

.1

270 a.

• 210

• 75

▪ 45

Etin_ergency Generator

. Test

8/7/19

Date: *gt 1/ 11

Tech Signature':

WL or Supv. Signa

(:ent,-)r for Aging Attachment (ID) .

Model # 3508 Serial # 5YF02819 Start Time: 4(.'31 Stop Time: 07 0 t P.re check list: ' T, ( Satisfactory Unsatisfactory Comments _

1)Simulate power outage / • equipment /

3) Take reading every 15 minutes / \

Lube Oil pressure (psi) 1.1.4- worki, Lube Oil Temperature (F) lloPA L4) OVV2i1dA

Hour Meter (hours) '

Engine Temperature (F) IN, ok c.4) Dv' V:tion

Operating Amperage (amps) 1 a_

3__c,_____ 3_0.—.6 ne Speed (rpm) 1800

Lube Oil pressure (psi) lio-i- %.)-ov

Lube Oil Temperature (F) Ko+-2. 1410v .V. %.6 •

Hour Meter (hours) s*G5'. 1 '

Engine Temperature (F) n o + k....frov- te._ i , • , 2 480

Operating Amperage (amps) 1 ,9 S"

3 3 c

1)Return normal power / problems & corrective actni/ /'

Model #3508 Serial #23207184 Hours 5-C.C. ct)

Monthly Cheek list: Satisfactory Unsatisfactory Comments fuel-system.

s 'stem. / con-rtections.„InspeCt contacts for pits, InSpecfprograniniable logic control adjustments. _.

bberve & verify ATS.

inonthly service:, ,- : .

I -Check battery Cables...-. • -

Check coating on terminals, lugs,' / shunts, &.cable connections.

Check & record Voltageleadings of -each cell k total Cell.bank. - •

11.14 l%. 12/1 .4#X1 i float charge. ' :

2. C • 4

.chatging • -

'Check Ad power.

Check for cleanliness of stn & area. / -

Start generator & run on buil.ding load-. - 1-Riefei to attachnient 0)1 , " •

Check engine& bearingS for oil. & H20 ' lealcs,•miusualnoise., eXcessive :".

Vibration, & ov. erheating.

--After lbadtest, observe transfer & shUtdown-sequen.ce. . _

After shutdoWn:ViPelftrwit engiflo;

MI Clean an s sill6 sate a.. .

.cOnifum With Security that audible 1. / ..

alarm from panel On be heard..

Tech Signature:. Date:

330 _ if

R.

1.

E.

0-- '

5.5

4.5

3.5

2.5

1.5

Pk it

L a ea .1.11,41 •••• 1

14,4

4-1

41, fig maim 4, a

'6 35 061.40 06 45

06 50

06 55

07 00

— 200ms Period Max

— 200ms Period Avg

07 05 07 10

Voltage and Current. From 8/7/2019 6:33:37 AM To 8/7/2019 7:11:32 AM

Report Date/Time

8/7/2019 7:39:11 AM Page 1

HalfHourGenTestG190807..fpq

G N TEST

LOAD BANK

8/12/19

Attachaient (D) g/tz.

Model # 3508 Serial # 5YF02819 Start Time: Stop Time: ( .%'S T rri Pre check lisf:, Satisfactory Unsatisfactory Comments ___ Cneck fuel & fuel tank /

Check batteries & tem inals /

1 Running check list: Comments I Quarter:

' equipment

3) Take reading every 15 minutes i ne Speed (rpm)

5-1 d •

Engine Temperature Temperature (F) problems & corrective action , ,'/ , / n /9

Date: avfl

WL or Supv. Signature: . Date:

Model #3508 Serial # 23207184 Hours S-70.4/

Check for moisture, dust, oils, greases, & debris on main stator, exciter, &

Drain fuel system to remove IMO & fuel-system. /

I •

Check belts. • connectiorts., .Inspeet contacts for pits, InSpectprogramniable logic control bbgerve & verify 17',',TS.

inbnthly service:, .,- :.

Cheek battery cables,. . •

Cheek coating on terminals, lugs; / shunts, &..eable connections.

Check & record Voltage:readings of • /.

each cell & total Cellhank., : -, ' float charge. * • . . .. * •

Check output ammeter & vOltmeter.

Check rate of charge for float &trickle / .chatging: -

*Check AC power.

Check for cleanliness of system- & area.

Start generator 4. inn on buil.ding load-.

[Refer to attaehMent (D)1, . • •

Check engine & bearingS for oif& 1120

• l9alcs,•uriusualnoise, .4cessive ".

--After ltracrtest, observe transfer & ShUtclown sequence. . . • .

After shutdo-4,‘Wilie.; ritilNii.engthe, Clean any spfflk. update lag.

.c.Onfirin*With Security that audible alarm from panel Can be heard.. .

-Tech Signature: Date:

Model # 3508 Serial # 5YF02819

Running check list: Comments Quarter: Time to transfer power ATS#2 Time to transfer power z

,,ATS#1

Failed

1) Return normal power 7 -problems & corrective action, „

, 1 4 _...?

Date: 372

Generator

7/3/19

Model # 3508 Serial # 5YF02819 . Start TimerArl Stop Time: crtz 7 Pre check list:

IQuarter:

1 1) Simulate power…