2016-11-30_MAFB_TitleVRenewal_Part2_SIGNED_Part1.pdf

Ll l l l

U.S. Air Force Title V Permit Renewal Application

Appendix F PSD Lookback and GHG Emission Summary

EN0728161132BOI

c n r;

c c D c c c

MAFB

PSD Lookback (CY 2004 to Present) Facility-Wide Stationary Emergency Cl ICE and Miscellaneous Natural

Criteria Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg Bldg -- "J 165 200 219 Bldg407 429 500 530 780 1836 1879 18902 82110 1840 1012 1180 !"!A] B\To1i Pollutants (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy) (tpy)l

PMlO as PM 0.003 0.13 0.002 0.02 0.0005 0.02 0.01 0.01 0.005 0.01 0.01 0.03 0.0013 0.45 0.22 ~ . (O~ PM2.5 as PM 0.003 0.02 0.002 0.02 0.0005 0.02 0.01 0.01 0.005 0.01 0.01 0.03 0.0013 0.45 0.22 . @~81 co 0.02 0.40 0.01 0.05 0.001 0.10 0.02 0.02 0.03 0.02 0.04 0.17 0.0013 2.46 2.46 f : ;:.,r~ri1i NOx 0.06 0.64 0.06 0.25 0.02 0.83 0.09 0.28 0.10 0.11 0.17 1.03 0.0194 3.13 1.56 I •8~ 502 0.005 0.13 0.004 0.02 0.004 0.02 0.01 0.03 0.02 0.01 0.01 0.03 0.0002 0.04 0.02 ~ {~~3~ HCas voe 0.003 0.15 0.001 0.02 0.0004 0.02 0.001 0.01 0.01 0.001 0.01 0.02 0.0002 0.18 0.09 0!51

-: .:.. "l Total HAPs 3.6E-04 5.9E-04 2.4E-04 2.0E-04 5.8E-05 9.2E-04 8.0E-05 2.4E-04 2.2E-04 9.7E-05 1.3E-04 1.2E-03 0.0004 8.0E-02 4.0E-02 ~ 0~13 Note:

NA= Not Applicable

NOx potential emissions for the Heating Plant Boilers are based on the fuel consumption permit limit of 999,000 MM Btu/yr amd emission factor limit of 0.5 lb/MMBtu.

NOx PTE for the Heating Plant Boilers was documented in the Montana Air Quality Permit (MAQP) Analysis for Malmstrom Air Force Base, MAQP #1427-09.

NOx PTE = (0.5 lb/MMBtu)x(999,000 MMBtu/yr)x(0.0005 ton/lb)= 249.75 tpy

In a memorandum dated January 16, 2004, MDEQ determined that MAFB is a major source as defined under the NSR permitting program.

-lji---l lfi>"Yft _ . ~

'"ltd.ad .. · iV-i

~ . ocqo!Oo . ' ' - io'im

"·"!""I . "'· @foo - ~ • - .;. ~roo fi ~ l ~ 6~

In 2004, MDEQ determined that potential emissions from MAFB and any modifications were below the NSR/PSD significance threhold for all pollutants and the permit action was not subject to NSR/PSD review.

The emission units presented in this table are ONLY those that are new since the 2004 MDEQ determination.

This table establishes a PSD lookback to document that the potential emissions from the above modifications since 2004 were below the NSR/PSD significance threshold for all regulated pollutants.

F-1

J

Greenhouse Gas Emissions Summary

Stationary Emergency Cl ICE and Natural Gas Boilers I I I I

Building I Source Type I

165iE Gen I

200!E Gen I

219!E Gen I

4071E Gen I

429!E Gen I

500!E Gen I

53DIE Gen I

780!E Gen I

1836!E Gen I

18791E Gen I

18902!E Gen I

82110jE Gen I

1012!Boiler 1

1012!Boiler 2 I

1180jBoiler I

Central Heat Plant1!Boilers 1 and 3

Central Heat Plant lsoiler 2

Total Metric Tons

Iotil1Slior.t'irons1'

Note:

1 metric ton = 1.10231 short tons

Short tons are use in PSD applicability

I I I I I I I I I Fuel Type I Emission Unit I

!Diesel iTBDOOl ' I I

I I

!Diesel !TBD002 I I

!Diesel !TBD003

!Diesel I

ITBD004

I I

!Diesel !TBD005 I I

!Diesel !EUOlO I I

I Diesel ITBD006 I I

!Diesel !EU009 I I

!Diesel !TBD007 I I

!Diesel ITBD008 I I I

!Diesel !IEU034 I I

!Diesel jEU004 I I

ING

I jlEU035

!NG !IEU035

I I

!NG !IEU036

I I

!coal !EUOOl, EU003

ING lrnoo2 I ' ' I I I I I I I

F-2

GHG Emissions (metric tons per year) I I I

C02 I N20 I CH4 I C02e ! I I

14! 1.E-04 6.E-04i 14 I I

59! 5.E-04 2.E-03 ! 59 I I

I

8.E-05 4.E-04! 9 I I

81 6.E-05 3.E-041 8 I I

2! 2.E-05 9.E-05! 2 I I

92! 7.E-04 4.E-03 ! 92 I I

31 3.E-05 1.E-041 3 I I

24! 2.E-04 1.E-03! 24 I I

I

7.E-05 3.E-04! 9 I I

41 3.E-05 2.E-041 4 I I

5! 4.E-05 2.E-04! 5 I I

118! 1.E-03 5.E-03 ! 118 I I o:

I

4.E-09 4.E-08! 0 o! 4.E-09 4.E-08! 0 I I o:

I 4.E-09 4.E-08! 0 I I

75,056! 1 8! 75,600

15,896 0 0 15,913

91,299 1 8 91,861

;1;mJ.64D '1 ~ 1.;·~ :101,~ r1 r1 rI r r \ j

L r I r

I [ I I L:

r

MAFB

Centeral Heat Plant Boilers GHG Emissions Annual hours operation

Boiler 1

Boiler2

Boiler3

Boiler Limit

Boiler 1 (coal)

Boiler 3 (coal)

Key Assumption:

Boiler 1 and 3 (coal) Btu/lb coal lb coa I/year ton coal/yr

Boiler 2 (NG)

Boiler 2 (NG)

Boiler 2 ft3/yr NG

Variable

8760 Variable

Variable

999,000,000,000 Btu/yr

106,250,000 Btu/hr

106,250,000 Btu/hr

692,400,000,000 Btu/yr based on maximum usage of NG on Boiler #2 subtracting out from total b 12,000 AP 42 Section 1.2 Paragraph 1.2.1 provides range of 12,000 to 14,000 Btu/lb

57,700,000 assume boilers 1 and 3 operating solely on coal

28,850

35,000,000 Btu/hr

306,600,000,000 Btu/yr

292,000,000 assume HHV of 1050 Btu/ft

NG from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Greenhouse Gas Emissions (Boilers 1 and 3 on coal)

C02/N20/CH4 = 0.001 x ton fuel x HHV x EF (40 CFR 98 Equation C-2a)

HHV 25.09 MM Btu/short ton 40 CFR 98 Table C-1

EF C02 103.69 kg C02/MMBtu 40 CFR 98 Table C-1

EF N20 1.60E-03 kg C02/MMBtu 40 CFR 98 Table C-2

EF CH4 l.lOE-02 kg C02/MMBtu 40 CFR 98 Table C-2

Global Warming Potential C02 = 75056 metric tons 1 40 CFR 98 Table A-1

N20= 1 metric tons 298 40 CFR 98 Table A-1

CH4= 8 metric tons 25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 75,600 metric tons

Greenhouse Gas Emissions (Boiler 2 on NG)

[ C02/N20/CH4 = 0.001 x ft

NG x HHV x EF (40 CFR 98 Equation C-1)

L

HHV

EF C02

EF N20

EF CH4

C02=

N20=

CH4=

1.03E-03 MMBtu/gal

53.06 kg C02/MMBtu

1.00E-04 kg C02/MMBtu

1.00E-03 kg C02/MMBtu

15896 metric tons

0 metric tons

0 metric tons

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential 1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 15,913 metric tons

GHG Boiler Summary GHG Boller Summal'Y

91,513 C02e metric tons per year 100,875 C02e short tons i>er year conversion to short tons: 1 metric ton= 1.10231 short tons

F-3

Central Heat Plant Boilers GHG Emissions (Calculation Check)

Permit limit

Boiler 1 (coal)

Boiler 3 (coal)

Btu/lb coal lb coal/year ton coal/yr

Boiler 2 (NG)

Boiler 2 ft3 /yr NG

999,000,000,000 Btu/yr

333,000,000,000 Btu/yr

333,000,000,000 Btu/yr

(assume 1/3 Btu/yr goes through each of the three boilers)

AP 42 Section 1.2 Paragraph 1.2.1 provides range of

12,000 12,000 to 14,000 Btu/lb

55,500,000 assume boilers 1 and 3 operating solely on coal

27,750

333,000,000,000 Btu/yr

317,142,857 assume HHV of 1050 Btu/ft3 NG from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Greenhouse Gas Emissions (Boilers 1 and 3 on coal)

C02/N20/CH4 = 0.001 x ton fuel x HHV x EF (40 CFR 98 Equation C-2a)

HHV 25.09 MM Btu/short ton 40 CFR 98 Table C-1

EF C02 103.69 kg C02/MMBtu 40 CFR 98 Table C-1

EF N20 1.60E-03 kg C02/MMBtu 40 CFR 98 Table C-2

EF CH4 1.lOE-02 kg C02/MMBtu 40 CFR 98 Table C-2

Global Warming Potential

C02 = 72194 metric tons 1 40 CFR 98 Table A-1

N20= 1 metric tons 298 40 CFR 98 Table A-1

CH4= 8 metric tons 25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 72717.34 metric tons

Greenhouse Gas Emissions (Boller 2 on NG)

C02/N20/CH4 = 0.001 x ft 3 NG x HHV x EF (40 CFR 98 Equation C-1)

HHV 1.03E-03 MMBtu/gal

EF C02 53.06 kg C02/MMBtu

EF N20 1.00E-04 kg C02/MMBtu

EF CH4 1.00E-03 kg C02/MMBtu

C02=

N20 =

CH4=

17265 metric tons

0 metric tons

0 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

17,283 metric tons

GHG Boller Summary

GHG Boller Summary

90,000 C02e metric tons per year

99,208 C02e short tons per year ..=------conversion to short tons: 1 metric ton= 1.10231 short tons

F-4

MAFB

Emergency Diesel Generator

Emission Unit TBD001

Building

Engine manufacturer Cummins

Engine HP rating

Hours of Operation

Model No. DSGAA-1423168

162 hp

160 hr/yr proposed PTE

Maximum fuel 8. 70 gal/hr Reference: Cummins DSGAA. Refer to App F emissions data sheet.

MM Btu/hr 1.19 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Manufacturer MDEQ De Minimus Above or Below

Criteria Pollutants EF

Emissions Emissions Emissions Threshold MDEQ De Minimus

(g/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr) Threshold

PMlO as PM 0.10 0.04 5.71 0 5 Below

PM2.5 as PM 0.10 0.04 5.71 0 5 Below co 0.83 0.30 47.43 0 5 Below

N02 1.94 0.69 110.86 0 5 Below

502 0.16 0.06 9.14 0 5 Below

HCasVOC 0.12 0.04 6.86 0 5 Below

HAPs AP42 EF

Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr)

Benzene 9.33E-04 1.llE-03 1.78E-01 9.E-05

Toluene 4.09E·04 4.87E-04 7.80E-02 4.E-05

Xylenes 2.85E-04 3.40E-04 5.44E-02 3.E-05

1,3-Butadiene 3.91E·OS 4.66E-05 7.46E-03 4.E-06

Formaldehyde 1.18E-03 1.41E-03 2.25E·Ol 1.E-04

Acetaldehyde 7.67E-04 9.14E-04 1.46E-01 7.E-05

Acrolein 9.25E-05 1.lOE-04 1.76E-02 9.E-06

Naphthalene 8.48E-05 1.0lE-04 1.62E-02 8.E-06

Total HAPS 4.E-04

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs =(lb/MM Btu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EF C02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EF CH4 3.00E-03 kg C02/MMBtu

C02 = 14 metric tons

N20= 1.E-04 metric tons

CH4= 6.E-04 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A·l

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

14 metric tons

F-5

Emergency Diesel Generator

Emission Unit TBD002

Building 200

Cummins Model No. QSX15-G9

755 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 35.9 gal/hr Reference: Cummins QSX15-G9. Refer to App F emissions data sheet.

MM Btu/hr 4.9 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Montana

Criteria Pollutants AP 42 EF1

DEQ

2 Emissions Emissions Emissions

(lb/hp-hr) (lb/hp-hr) (lb/hr) (lb/yr) (ton/yr) PMlO as PM 0.0007 0.0022 1.66 265.76 PM2.5 as PM 0.0007 0.000331 0.25 39.98 co 0.0055 0.0067 5.06 809.36 N02 0.024 0.0106 8.00 1280.48

S02 1.21E-05 2.lOE-03 1.59 253.68 HC as voe 7.05E-04 2.50E-03 1.89 302.00

HAPs AP 42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

Benzene 7.76E-04 3.82E-03 6.llE-01 3.E-04

Toluene 2.81E-04 1.38E-03 2.21E-01 1.E-04

Xyienes 1.93E-04 9.49E-04 l.52E-01 8.E-05

Formaldehyde 7.89E-05 3.88E-04 6.21E-02 3.E-05

Acetaldehyde 2.52E-05 1.24E-04 1.98E-02 1.E-05 Acrolein 7.88E-06 3.88E-05 6.20E-03 3.E-06

Naphthalene l.30E-04 6.39E-04 1.02E-01 5.E-05

Total HAPS 6.E-04

Notes:

1 Criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.4, Table 3.4-1.

2 Montana DEQ emission factors used in place of AP-42 emission factors for PTE 3 HAP emission factors based on AP-42, Fifth Edition, Section 3.4, Tables 3.4-3 and 3.4-4.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb) = tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb) = tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel = Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal EFC02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu EF CH4 3.00E-03 kg C02/MMBtu

C02= 59 metric tons

N20= 5.E-04 metric tons

CH4= 2.E-03 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

6.E+Ol metric tons

F-6

MDEQ De Mini mus Above or Below

Threshold MDEQ De Minimus

(ton/yr) Threshold

0 5 Below

0 5 Below

0 5 Below

1 5 Below

0 5 Below

0 5 Below l

MAFB

Emergency Diesel Generator

Emission Unit TBD003

Building

Engine manufacturer Cummins

HP rating

Model No. DSFAD-10096807

145 hp

160 proposed PTE Hours of Operation

Maximum fuel 5.7 gal/hr Reference: Cummins DSFAD. Refer to App F emissions data sheet.

MM Btu/hr 0.78 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85 1v1anuracturer MDEQ De Minimus Above or Below MDEQ

Criteria Pollutants EF1 Emissions Emissions Emissions Threshold De Minimus

(g/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr) Threshold PMlO as PM 0.06 0.02 3.07 0.002 5 Below

PM2.5 as PM 0.06 0.02 3.07 0.002 5 Below co 0.50 0.16 25.57 0.01 5 Below

N02 2.37 0.76 121.22 0.06 5 Below

502 0.14 0.04 7.16 0.004 5 Below

HC as VOC 0.04 0.01 2.05 0.001 5 Below

HAPS AP42 EF2

Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr)

Benzene 9.33E-04 7.29E-04 1.17E-01 6.E-05

Toluene 4.09E-04 3.19E-04 5.llE-02 3.E-05

Xylenes 2.85E-04 2.23E-04 3.56E-02 2.E-05

1,3-Butadiene 3.91E-05 3.05E-05 4.89E-03 2.E-06

Formaldehyde l.18E-03 9.21E-04 l.47E-01 7.E-05

Acetaldehyde 7.67E-04 5.99E-04 9.58E-02 5.E-05

Acrolein 9.25E-05 7.22E-05 1.16E-02 6.E-06

Naphthalene 8.48E-05 6.62E-05 l.06E-02 5.E-06

Total HAPS 2.E-04

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs =(lb/MM Btu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal 90 CFR 98 Table C-1

EF C02 73.96 kg C02/MMBtu 90 CFR 98 Table C-1

EF N20 6.00E-04 kg C02/MMBtu 90 CFR 98 Table C-2

EF CH4 3.00E-03 kg C02/MMBtu 90 CFR 98 Table C-2

Global Warming Potential

C02= 9.31 metric tons 1 40 CFR 98 Table A-1

N20= 7.55E-05 metric tons 298 40 CFR 98 Table A-1

CH4= 3. 78E-04 metric tons 25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 9.34E+OO metric tons

F-7

Emission Unit TBD004

Building 407

Engine manufacturer Cummins Model No. DGCB

Engine HP rating 99 hp

Hours of Operation 160 hr/yr proposed PTE

Maximum fuel 4. 7 gal/hr Reference: Cummins DGCB. Refer to App F emissions data sheet.

MM Btu/hr 0.6 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Montana

Criteria Pollutants AP 42 EF

DEQ

Emissions Emissions Emissions (lb/hp-hr) (lb/hp-hr) (lb/hr) (lb/yr) (ton/yr)

PM10 as PM 2.20E-03 2.20E-03 0.22 34.85

PM2.5 as PM 2.20E-03 2.20E-03 0.22 34.85 co 6.68E-03 6.68E-03 0.66 105.81

N02 0.031 0.031 3.07 491.04

502 2.05E-03 2.05E-03 0.20 32.47

HCasVOC 2.47E-03 2.47E-03 0.24 39.12

HAPs AP42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

Benzene 9.33E-04 6.0lE-04 9.61E-02 5.E-05

Toluene 4.09E-04 2.63E-04 4.21E-02 2.E-05

Xyienes 2.85E-04 1.84E-04 2.94E-02 1.E-05

1,3-Butadiene 3.91E-05 2.52E-05 4.03E-03 2.E-06

Formaldehyde 1.18E-03 7.60E-04 1.22E-01 6.E-05

Acetaldehyde 7.67E-04 4.94E-04 7.90E-02 4.E-05

Acrolein 9.25E-05 5.96E-05 9.53E-03 5.E-06

Naphthalene 8.48E-05 5.46E-05 8.74E-03 4.E-06

Total HAPS 2.E-04

Notes:

1 Criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

2 Montana DEQ emission factors are the same as AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

3 HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant = (g/hp-hr) x (hp) x PTE (hr/yr) x (ib/453.6 g) x (ton/2000 lb) = tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF {40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV

EF C02

EF N20

EF CH4

0.138 MMBtu/gal

73.96 kg C02/MMBtu

6.00E-04 kg C02/MMBtu

3.00E-03 kg C02/MMBtu

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

C02 =

N20 =

CH4=

8 metric tons

6. E-05 metric tons

3.E-04 metric tons

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 8.E+OO metric tons

F-8

MDEQ De Minimus

Threshold (ton/yr) r

Above or

BelowMDEQ 0 DeMinimus Threshold

5 Below

5 Below

5 Below

5 Below

5 Below

5 Below 0

D r l l

MAFB

Emergency Diesel Generator

Emission Unit TBD005

Building 429

Engine manufacturer Cummins Model No. DSKAB-1856029

Engine HP rating 25 hp

Hours of Operation 160 hr/yr proposed PTE

Maximum fuel 1.4 gal/hr Reference: Cummins DSKAB. Refer to App F emissions doto sheet.

MMBtu/hr 0.19 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85 1 Manufacturer MDEQ De Minimus

Criteria Pollutants AP 42 EF

EF

Emissions Emissions Emissions Threshold

(lb/hp-hr) (g/hr-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr)

PMlO as PM 0.11 0.01 0.97 0

PM2.5 as PM 0.11 0.01 0.97 0 co 0.30 0.02 2.65 0

N02 3.50 0.19 30.86 0

502 2.05E-03 0.05 8.20 0

HC as voe 0.10 0.01 0.88 0

HAPs AP42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

Benzene 9.33E-04 1.79E-04 2.86E-02 1.E-05

Toluene 4.09E-04 7.84E-05 1.26E-02 6.E-06

Xylenes 2.85E-04 5.47E-05 8.75E-03 4.E-06

1,3-Butadiene 3.91E-05 7.50E-06 1.20E-03 6.E-07

Formaldehyde 1.18E-03 2.26E-04 3.62E-02 2.E-05

Acetaldehyde 7.67E-04 1.47E-04 2.35E-02 1.E-05

Acrolein 9.25E-05 1.77E-05 2.84E-03 1.E-06

Naphthalene 8.48E-05 1.63E-05 2.60E-03 1.E-06

Total HAPS 6.E-05

Notes:

1 502 criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

2Criteria pollutant emission factors based on Caterpillar manufacturer supplied emissions data sheet.

3HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPS= (lb/MMBtu) x (MM Btu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EFC02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EFCH4 3.00E-03 kg C02/MMBtu

C02 = 2 metric tons

N20= 2. E-05 metric tons

CH4= 9.E-05 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential 1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

2.E+OO metric tons

F-9

Above or Below

MDEQ De Minimus

Threshold

5 Below

5 Below

5 Below

5 Below

5 Below

Emission Unit EU010

Building

Engine manufacturer Cummins

Engine HP rating

Hours of Operation

Maximum fuel

MM Btu/hr

Model No. DQFAB-7621697

1175 hp

160 hr/yr proposed PTE

56.4 gal/hr Reference: Cummins DQFAB. Refer to App F emissions data she1

7.7 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Manufacturer MDEQ De Minimus Above or Below

Criteria Pollutants EF1 Emissions Emissions Emissions Threshold MDEQ De Minimus

(g/hp·hr) (lb/hr) {lb/yr) (ton/yr) (ton/yr) Threshold

PMlO as PM 0.12 0.31 49.74 0 5 Below

PM2.5 as PM 0.12 0.31 49.74 0 5 Below co 0.50 1.30 207.23 0 5 Below

N02 4.00 10.36 1657.85 1 5 Below

502 0.10 0.26 41.45 0 5 Below

HCasVOC 0.08 0.21 33.16 0 5 Below

HAPs AP42 EF2 Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr)

Benzene 7.76E-04 6.00E-03 9.59E-01 5.E-04

Toluene 2.81E-04 2.17E-03 3.47E-01 2.E-04

Xylenes 1.93E-04 l.49E-03 2.39E-01 l.E-04

Formaldehyde 7.89E-05 6.lOE-04 9.75E-02 5.E-05

Acetaldehyde 2.52E-05 1.95E-04 3.12E-02 2.E-05

Acrolein 7.88E-06 6.09E-05 9.74E-03 5.E-06

Naphthalene 1.30E-04 l.OOE-03 l.61E-01 8.E-05

Total HAPs 9.E-04

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.4, Tables 3.4-3 and 3.4-4.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs = (lb/MMBtu) x (MM Btu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal 40 CFR 98 Table C-1

EF C02 73.96 kg C02/MMBtu 40 CFR 98 Table C-1

EFN20 6.00E-04 kg C02/MMBtu 40 CFR 98 Table C-2

EF CH4 3.00E-03 kg C02/MMBtu 40 CFR 98 Table C-2

Global Warming Potential

C02= 92 metric tons 1 40 CFR 98 Table A-1

N20= 7.E-04 metric tons 298 40 CFR 98 Table A-1

CH4= 4.E-03 metric tons 25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 9.24E+01 metric tons

F-10

D c l

L r

MAFB

Emergency Diesel Generator

Emission Unit TBD006

Building 530

Cummins Model No. DSKBA-1854029

37.1 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 1.93 gal/hr Reference: Cummins DSKBA. Refer to App F emissions data sheet.

MM Btu/hr 0.26 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85 IADove or Below

Montana MDEQ De Minimus MDEQDe

Criteria Pollutants AP42 EF1 DEQ

Emissions Emissions Emissions Threshold

(lb/hp-hr) (lb/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr)

PMlO as PM 2.20E-03 0.0022 0.08 13.06 0

PM2.5 as PM 2.20E-03 0.0022 0.08 13.06 0 co 6.68E-03 0.00668 0.25 39.65 0

N02 0.031 0.031 1.15 184.02 0

502 2.05E-03 0.00205 0.08 12.17 0

HC as voe 2.47E-03 0.000247 0.01 1.47 0

HAPS AP42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

Benzene 9.33E-04 2.47E-04 3.95E-02 2.E-05

Toluene 4.09E-04 1.08E-04 1.73E-02 9.E-06

Xylenes 2.85E-04 7.54E-05 1.21E-02 6.E-06

1,3-Butadiene 3.91E-05 1.03E-05 1.65E-03 8.E-07

Formaldehyde 1.18E-03 3.12E-04 4.99E-02 2.E-05

Acetaldehyde 7.67E-04 2.03E-04 3.24E-02 2.E-05

Acroiein 9.25E-05 2.45E-05 3.91E-03 2.E-06

Naphthalene 8.48E-05 2.24E-05 3.59E-03 2.E-06

Total HAPs 8.E-05

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2 Montana DEQ emission factors are the same as AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

3 HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb) = tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EFC02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EF CH4 3.00E-03 kg C02/MMBtu

C02= 3 metric tons

N20= 3.E-05 metric tons

CH4= 1.E-04 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

3.E+OO metric tons

F-11

Minim us

Threshold

5 Below

5 Below

5 Below

5 Below

Emission Unit EU009

Building 780

Cummins Onan Model No. DGFC

317 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 14.9 gal/hr Reference: Cummins DGFC. Refer to App F emissions data sheet.

MM Btu/hr 2.0 assume HHVof 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Manufacturer MDEQ De Minimus Above or Below

Criteria Pollutants EF 1 Emissions Emissions Emissions Threshold MDEQ De Minimus

(g/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr) Threshold

PMlO as PM 0.17 0.12 19.01 0 5 Below

PM2.5 as PM 0.17 0.12 19.01 0 5 Below co 0.37 0.26 41.37 0 5 Below

NOx 4.98 3.48 556.85 0 5 Below

502 0.58 0.41 64.85 0 5 Below

HC as VOC 0.23 0.16 25.72 0 5 Below

HAPs AP 42 EF

Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr)

Benzene 7.76E-04 l.58E-03 2.53E-01 l.E-04

Toluene 2.81E-04 5.74E-04 9.18E-02 5.E-05

Xylenes l.93E-04 3.94E-04 6.30E-02 3.E-05

Formaldehyde 7.89E-05 l.61E-04 2.58E-02 l.E-05

Acetaldehyde 2.52E-05 5.14E-05 8.23E-03 4.E-06

Acrolein 7.88E-06 l.61E-05 2.57E-03 1.E-06

Naphthalene 1.30E-04 2.65E-04 4.25E-02 2.E-05

Total HAPs 2.E-04

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.4, Tables 3.4-3 and 3.4-4.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs = (lb/MMBtu) x (MM Btu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1) Note: Gal fuel = Maximum fuel x 160 hr/yr

HHV

EF C02

EF N20

EFCH4

C02 =

N20=

CH4=

0.138 MMBtu/gal

73.96 kg C02/MMBtu

6.00E-04 kg C02/MMBtu

3.00E-03 kg C02/MMBtu

24 metric tons

2.E-04 metric tons l.E-03 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

2.E+Ol metric tons

F-12 n

D c

MAFB

Emergency Diesel Generator

Emission Unit TBD007

Building 1836 caterpillar Model No. C4.4

99.9 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 5.2 gal/hr Reference: Caterpillar C4.4. Refer to App F emissions data sheet.

MM Btu/hr 0.71 assume HHVof 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85 1Manuracturer

Criteria Pollutants AP 42 EF1 EF2 Emissions Emissions Emissions

(lb/hp-hr) (g/hr-hr) (lb/hr) (lb/yr) (ton/yr)

PMlO as PM 0.28 0.06 9.87

PM2.5 as PM 0.28 0.06 9.87 co 1.69 0.37 59.55

N02 5.40 1.19 190.29

S02 2.05E-03 0.20 32.77

HC as voe 0.32 0.07 11.28

HAPs AP 42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr) Benzene 9.33E-04 6.65E-04 1.06E-01 5.E-05

Toluene 4.09E-04 2.91E-04 4.66E-02 2.E-05

Xylenes 2.85E-04 2.03E-04 3.25E-02 2.E-05

1,3-Butadiene 3.91E-05 2.79E-05 4.46E-03 2.E-06

Formaldehyde 1.18E-03 8.41E-04 1.35E-01 7.E-05

Acetaldehyde 7.67E-04 5.46E-04 8.74E-02 4.E-05

Acrolein 9.25E-05 6.59E-05 1.05E-02 5.E-06

Naphthalene 8.48E-05 6.04E-05 9.67E-03 5.E-06

Total HAPS 2.E-04

Notes:

S02 criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

2Criteria pollutant emission factors based on Caterpillar manufacturer supplied emissions data sheet.

3HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EFC02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EF CH4 3.00E-03 kg C02/MMBtu

C02= 8 metric tons

N20 = 7. E-05 metric tons

CH4= 3.E-04 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

9.E+OO metric tons

F-13

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

MDEQ De Minim us Above or Below

Threshold MDEQ De Minimus

(ton/yr) Threshold

0 5 Below

0 5 Below

0 5 Below

0 5 Below

0 5 Below

0 5 Below

Emission Unit TBD008

Building 1879

Engine manufacturer Cummins Model No. DKAF-5938404

Engine HP rating 44.8 hp

Hours of Operation 160 hr/yr proposed PTE

Maximum fuel 2.33 gal/hr Reference: Cummins DKAF. Refer to App F emissions data sheet.

MMBtu/hr 0.32 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Criteria Pollutants AP 42 EF1 Montana DEQ2 Emissions Emissions Emissions

(lb/hp-hr) (lb/hp-hr) (lb/hr) (lb/yr) (ton/yr) PMlO as PM 2.20E-03 0.0022 0.10 15.77

PM2.5 as PM 2.20E-03 0.0022 0.10 15.77 co 6.68E-03 0.00668 0.30 47.88

N02 0.031 0.031 1.39 222.21

502 2.05E-03 0.00205 0.09 14.69

HC as voe 2.47E-03 0.000247 0.01 1.77

HAPS AP 42 EF3 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr) Benzene 9.33E-04 2.98E-04 4.77E-02 2.E-05

Toluene 4.09E-04 1.31E-04 2.09E-02 1.E-05

Xylenes 2.85E-04 9.lOE-05 1.46E-02 7.E-06

1,3-Butadiene 3.91E-05 1.2SE-05 2.00E-03 1.E-06

Formaldehyde 1.18E-03 3.77E-04 6.03E-02 3.E-05

Acetaldehyde 7.67E-04 2.45E-04 3.92E-02 2.E-05

Acrolein 9.25E-05 2.95E-05 4.72E-03 2.E-06

Naphthalene 8.48E-05 2.71E-05 4.33E-03 2.E-06 Total HAPs l.E-04

Notes:

1 Criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

2 Montana DEQ emission factors are the same as AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

3 HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (ib/453.6 g) x (ton/2000 lb)= tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EFC02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EF CH4 3.00E-03 kg C02/MMBtu

C02 = 4 metric tons

N20 = 3.E-05 metric tons

CH4= 2.E-04 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

4.E+OO metric tons

F-14

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

MDEQ De Minimus Above or Below

Threshold MDEQ De Minimus

(ton/yr) Threshold

5 Below

5 Below

5 Below

5 Below

5 Below

5 Below r r l c c l

MAFB

Emergency Diesel Generator

Emission Unit IEU034

Building 18902

Cummins Model No. C35 D6

69 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 3.16 gal/hr Reference: Cummins C35 D6. Refer to App F emissions data sheet.

MM Btu/hr 0.43 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85 MDEQ De Minimus

Criteria Pollutants AP 42 EF1 Emissions Emissions Emissions Threshold

(lb/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr)

PMlOas PM 2.20E-03 0.15 24.29 0

PM2.5 as PM 2.20E-03 0.15 24.29 0 co 6.68E-03 0.46 73.75 0

N02 0.031 2.14 342.24 0

502 2.05E-03 0.14 22.63 0

HC as voe 2.47E-03 0.17 27.27 0

HAPs AP42 EF2 Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr) Benzene 9.33E-04 4.04E-04 6.46E-02 3.E-05

Toluene 4.09E-04 l.77E-04 2.83E-02 l.E-05

Xylenes 2.85E-04 l.23E-04 l.97E-02 l.E-05

1,3-Butadiene 3.91E-05 l.69E-05 2.71E-03 l.E-06

Formaldehyde l.18E-03 5.llE-04 8.17E-02 4.E-05

Acetaldehyde 7.67E-04 3.32E-04 5.31E-02 3.E-05

Acrolein 9.25E-05 4.00E-05 6.41E-03 3.E-06

Naphthalene 8.48E-05 3.67E-05 5.87E-03 3.E-06

Total HAPS l.E-04

Notes:

1 Criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.3, Table 3.3-2.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs =(lb/MM Btu) x (MM Btu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal

EF C02 73.96 kg C02/MMBtu

EF N20 6.00E-04 kg C02/MMBtu

EF CH4 3.00E-03 kg C02/MMBtu

C02= 5 metric tons

N20= 4.E-05 metric tons

CH4= 2.E-04 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

S.E+OO metric tons

F-15

Above or Below

MDEQ De Minimus

Threshold

5 Below

5 Below

5 Below

5 Below

Unit EU004

Building 82110

Cummins Model No. DQFAD

1482 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel 72.2 gal/hr Reference: Cummins DQFAD-7631045. Refer to App F emissions c

MM Btu/hr 9.9 assume HHV of 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A - Misc. Data & Conversion Factors, 9/85

Manufacturer MDEQ De Minimus Above or Below

Criteria Pollutants EF

Emissions Emissions Emissions Threshold MDEQ De Minimus

(g/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr) Threshold

PMlO as PM 0.11 0.36 57.50 0 5 Below

PM2.5 as PM 0.11 0.36 57.50 0 5 Below co 0.66 2.16 345.02 0 5 Below

N02 3.95 12.91 2064.87 1 5 Below

502 0.11 0.36 57.50 0 5 Below

HCasVOC 0.07 0.23 36.59 0 5 Below

HAPs AP 42 EF2 Emissions Emissions Emissions

(lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

Benzene 7.76E-04 7.68E-03 1.23E+OO 6.E-04

Toluene 2.81E-04 2.78E-03 4.45E-01 2.E-04

Xylenes 1.93E-04 1.91E-03 3.05E-01 2.E-04

Formaldehyde 7.89E-05 7.80E-04 l.25E-01 6.E-05

Acetaldehyde 2.52E-05 2.49E-04 3.99E-02 2.E-05

Acrolein 7.88E-06 7.79E-05 1.25E-02 6.E-06

Naphthalene l.30E-04 1.29E-03 2.06E-01 1.E-04

Total HAPs 1.E-03

Notes:

1Criteria pollutant emission factors based on Cummins manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.4, Tables 3.4-3 and 3.4-4.

Example Calculations:

Criteria Pollutant= (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb)= tpy

HAPs = (lb/MMBtu) x (MM Btu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse Gas Emissions

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel= Maximum fuel x 160 hr/yr

HHV 0.138 MMBtu/gal 40 CFR 98 Table C-1

EF C02 73.96 kg C02/MMBtu 40 CFR 98 Table C-1

EF N20 6.00E-04 kg C02/MMBtu 40 CFR 98 Table C-2

EF CH4 3.00E-03 kg C02/MMBtu 40 CFR 98 Table C-2

Global Warming Potential

C02= 118 metric tons 1 40 CFR 98 Table A-1

N20= 1.E-03 metric tons 298 40 CFR 98 Table A-1

CH4= 5.E-03 metric tons 25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 1.E+02 metric tons

F-16 r l

MAFB

Natural Gas Boilers

Unit IEU035 Reference: 2011 Title V Permit Renewal Package, Attachment 6

Manufacturer Input (Btu/hr) MMBtu/hr

Hrs/yr

Cleaver Brooks 5,102,000

5.1

Fuel Usage (sci/yr) 42.55 assume HHV of 1050 Btu/ft

NG from AP-42, Fifth Edition, Appendix A - Misc Data & Conversion Factors 9/85

Emission

Fector 1 Potential Emissions Pollutant (lb/MM Btu) MM Btu/hr hrs/vr #Boilers (ton/yr) co' 0.04 5.10 8760 2 1.79 co' 0.11 2.55 8760 2 2.46

NOx 0.07 5.10 8760 2 3.13

SOx 0.001 5.10 8760 2 0.04

HC/VOC 0.004 5.10 8760 2 0.18

PM 0.01 5.10 8760 2 0.45

c111l:io:iolun Potentla1 eotentla1

Factor' Emissions Emissions

HAP (lb/MMscf) (lb/yr) (tpy)

Trace Metals Arsenic 2.00E-04 8.SlE-03 4.2SE-06

Beryllium 1.20E-05 5.llE-04 2.SSE-07

Cadmium l.lOE-03 4.68E-02 2.34E·OS

Chromium 1.40E-03 5.96E-02 2.98E-05

Cobalt 8.40E-05 3.57E-03 l.79E-06

Lead S.OOE-04 2.13E-02 1.06E-OS

Manganese 3.80E-04 l.62E-02 8.08E-06 Mercury 2.60E-04 l.llE-02 S.53E-06

Nickel 2.lOE-03 8.94E-02 4.47E-05

Selenium 2.40E-OS 1.02E-03 5.llE-07 Various Organic Compounds

Acetaldehyde 2.09E-05 8.89E-04 4.45E-07

Acrolein l.80E-05 7.66E-04 3.83E-07

Benzene 2.lOE-03 8.94E-02 4.47E·OS

Dichlorobenzene l.20E-03 5.llE-02 2.SSE-05

Formaldehyde 7.SOE-02 3.19E+OO l.60E-03

Hexane 1.80E+OO 7.66E+Ol 3.83E-02

Toluene 3.40E-03 1.45E-01 7.23E-05

Polynuclear Aromatic Hydrocarbons Methylnaphthalene 2.40E-05 1.02E-03 S.llE-07 3-Methylchloranthrene l.80E-06 7.66E-OS 3.83E-08

7,12-Dimethylbenz(a)ai 1.60E-OS 6.81E-04 3.40E-07

Acenaphthene 1.80E-06 7.66E-05 3.83E-08

Acenaphthylene 1.80E-06 7.66E-05 3.83E-08

Anthracene 2.40E-06 1.02E-04 5.llE-08

Benz(a)anthracene 1.80E-06 7.66E-05 3.83E-08

Benzo(a)pyrene 1.20E-06 5.llE-05 2.SSE-08 Benzo(b)flouranthene 1.80E-06 7.66E-OS 3.83E-08

Benzo(g,h,i)perylene l.20E-06 S.llE-05 2.SSE-08

Benzo(k)fluoranthene 1.80E-06 7.66E-05 3.83E-08 Chrysene l.80E-06 7.66E-05 3.83E-08

Dibenzo(a,h)anthracen 1.20E-06 S.llE-05 2.SSE-08

Flouranthene 3.00E-06 1.28E-04 6.38E-08 Flourene 2.80E-06 1.19E-04 S.96E-08 lndeno(l,2,3-cd)pyrene 1.80E-06 7.66E-05 3.83E-08

Naphthalene 6.lOE-04 2.60E-02 1.30E-05

Phenanathrene 1.70E-05 7.23E-04 3.62E-07 Pyrene 5.00E-06 2.13E-04 1.06E-07

Total Potential.HAP Emissions 160.71 8;04E--02 1 Criteria pollutant emission factors obtained from Table A2-14, pg. A2-16 of Cleaver Brooks specificat£on sheets 2 CO emission is 0.04 lb/MMBtu when boiler is operating above 50% of rated capacity. CO emiss on ls 0.11 lb/ MMBtu when boiler is operating below 50% of rated capacity.

1 HAP emission factors obtained from AP-42, Fifth Edition, Chapter 1, Section 1.4, July 1998, Table 1.4-3.

Greenhouse Gas Emissions

Calculated for each 5.1 MMBtu/hr unit

C02/N20/CH4 = 0.001 x ft' NG x HHV x EF (40 CFR 98 Equation C-1)

HHV 1.03E-03 MMBtu/gal

EFC02 53.06 kg C02/MMBtu

EF N20 1.00E-04 kg C02/MMBtu

EF CH4 1.00E-03 kg C02/MM8tu

C02= O metric tons N20= 4.37E-09 metric tons CH4= 4.37E-08 metric tons

C02e = C02 x GWP + N20 x GWP + CH4 x GWP

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

2.E-03 metric tons one unit

F-17

Natural Gas Boller Unit IEU036

Referenu: 2011 Title V Permit Renewal Package. Attachment 7 Building Number 1180 User

Boiler Make Boiler Model Max Operating Hours Rated MMBtu

Services Cleaver Brooks Promethean 4WI

S.l

Fuel Usoge (sci/yr) 42.55 assume HHV of 1050 Btu/ft1 NG from AP-42, Fifth Edition, Appendix A - Misc Data & Conversion Factors, 9/85

Emission Factor Emissions Pollutantt.l (lb/MMBtu) (lb/hr) (lb/yr) (ton/yr)

NOX 0.07 0.36 3127.32 l.S6 co 0.11 O.S6 4914.36 2.46

S02 0.001 0.01 44.68 0.02

PMlO 0.01 o.os 446.76 0.22 voe 0.004 0.02 178.70 0.09

Below S Ton/yr tot•l (ARM 17.B.74S)

Individual criteria below 5 ton/yr (ARM 17.8.12011

Potential Potential Emission Factor!I Emissions Emissions

HAP (lb/MM5cf) (lb/yr) (tpy)

Trace Metals

Arsenic 2.00E-04 8.SlE-03 4.2SE-06

Beryllium 1.20E-OS S.llE-04 2.SSE-07 Cadmium l.lOE-03 4 .68E-02 2.34E-OS

Chromium l .40E-03 S.96E-02 2.9BE-OS

Cobalt 8.40E-OS 3.S7E-03 !.79E-OE lead S.OOE-04 2.13E-02 1.06E-OS

Manganese 3.80E-04 l.62E-02 B.OBE-06

Mercury 2.60E-04 1.11E·02 S.S3E-06 Nickel 2.lOE-03 8.94E-02 4 .47E-OS Selenium 2.40E·OS l .02E-03 S.11E·07

Various Organic Compounds Acetaldehyde 2.09E-OS B.B9E-04 4.4SE-07

Acrolein I .BOE-OS 7.66E-04 3.B3E-07

Benzene 2.IOE-03 B.94E-02 4 .47E-OS

Dichlorobenzene l .20E-03 S.llE-02 2.SSE·OS

Formaldehyde 7.SOE-02 3 .19E+OO l.60E-03

Hexane l.80E+OO 7 .66E+Ol 3.83E-02

Toluene 3.40E-03 l.4SE-Ol 7.23E-OS

Polynuclear Aromatic Hydrocarbons Methylnaphthalene 2.40E-OS ! .02E-03 S.llE-07 3-Methylchloranthrer l.80E-06 7.66E·OS 3.B3E-08

7,12-Dimethylbenz(•) l .60E-OS 6.BIE-04 3.40E-07

Acenaphthene l .BOE-06 7.66E-OS 3.83E-08 Acenaphthylene l.SOE-06 7.66E-OS 3.83E ·OB Anthracene 2.40E-06 l.02E·04 S llE-08

Benz(a)anthracene l.80E-06 7.66E-OS 3 B3E-08 Benzo(a)pyrene l .20E-06 S.llE-OS 2 SSE-08

Benzo(b)flouranthem l .80E-06 7.66E-OS 3 ,83E-o8

Benzo(g,h,i)perylene l.20E-06 S.llE-OS 2.SSE·08 Benzo(k)fluoranthene l.SOE-06 7.66E-OS 3.83E·08

Chrysene l .80E-06 7.66E-OS 3 .83E-08

Dlbenzofa,h)anthrace l .20E-06 S.ll E·OS 2 SSE-OB Flouranthene 3.00E-06 l.28E-04 6.3BE-08 Flourene 2.BOE·06 l.19E-04 S.96E-08 lndeno(l,2,3-cd)pyre l.80E-06 7.66E-OS 3 B3E-08 Naphthalene 6.IOE-04 2.60E-02 l.30E ·OS Phenanathrene l.70E-OS 7.23E-04 3 62E-07 Pyrene S.OOE-06 2.13E-04 I 06E-07

Total.~ HAP Emissions IC);J5 Lllll;m 1 Criteria pollutant emission factors obtained from Table A2·14, PB· A2-16 of Cleaver Brooks specification sheets 2 CO emission Is 0.04 lb/MMBtu when boiler is operatins above 50% of rated capacity. CO emission ls OU lb/MMBtu when boiler is operating below 50% of rated capacity.

1 HAP emission factors obtained from AP-42, Fifth Edition, Chapter 1, Section 14, Juty 1998, Table 1.4 ·3.

Grwenhouse Gas Emissions

C02/N20/CH4 = 0.001 x tt' NG x HHV x EF (40 CFR 98 Equ•tion C-1)

HHV

EF C02

EF N20

EF CH4

C02 =

N20 =

CH4=

l .03E-03 MMBtu/g•I

S3.06 kg C02/MMBtu l.OOE-04 kg C02/MMBtu l.OOE-03 kg C02/MMBtu

O metric tons 4.E-09 metric tons

4.E-08 metric tons

C02e = C02 x GWP + N20 JC GWP + CH4 x GWP

40 CFR 9B Table C-1

40 CFR 98 T•ble C-1

40 CFR 98 T•ble C-2

40 CFR 9B Table C-2

Global Warming Potent11I

I 40 CFR 9B Table A-I

29B 40 CFR 9B T•ble A-I

2S 40 CFR 9B T•ble A-I

2.E·03 metric tons one unit

F-18 r l

D

MAFB

Emergency Diesel Generator

Unit TBD028

Building 1840 Hipower / lveco Model No. HFW350T6U

497 hp

160 hr/yr proposed PTE

Engine manufacturer

Engine HP rating

Hours of Operation

Maximum fuel

MMBtu/hr

26.9 gal/hr Reference: Hipower HFW 360 T6U specification data sheet

3.7 assume HHVof 137,000 Btu/gal diesel from AP-42, Fifth Edition, Appendix A • Misc. Data & Conversion Factors, 9/85

Manufacturer MDEQ De Minimus Above or Below

Criteria Pollutants EF1 Emissions Emissions Emissions Threshold MDEQ De Minlmus

(g/hp-hr) (lb/hr) (lb/yr) (ton/yr) (ton/yr) Threshold

PMlO as PM 0.015 0.02 2.63 0.0013 5 Below

PM2.5 as PM 0.015 0.02 2.63 0.0013 5 Below co 0.015 0.02 2.63 0.0013 5 Below

N02 0.221 0.24 38.74 0.0194 5 Below

S023 2.05E-03 0.0022 0.36 0.0002 5 Below

HCasVOC 0.002 0.0022 0.35 0.0002 5 Below

HAPs AP42 EF2 Emissions Emissions Emissions

(lb/MM Btu) (lb/hr) (lb/yr) (ton/yr)

Benzene 7.76E-04 2.86E-03 4.58E-01 2.E-04

Toluene 2.81E-04 1.04E-03 1.66E-01 8.E-05

Xylenes 1.93E-04 7.llE-04 1.14E-01 6.E-05

Formaldehyde 7.89E-05 2.91E-04 4.65E-02 2.E-05

Acetaldehyde 2.52E-05 9.29E-05 l.49E-02 7.E-06

Acrolein 7.88E-06 2.90E-05 4.65E-03 2.E-06

Naphthalene l.30E-04 4.79E-04 7.67E-02 4.E-05

Total HAPs 4.E-04

Notes:

1Criteria pollutant emission factors based on Hipower manufacturer supplied emissions data sheet.

2HAP emission factors based on AP-42, Fifth Edition, Section 3.4, Tables 3.4-3 and 3.4-4.

3 Criteria pollutant emission factor based on AP-42, Fifth Edition, Section 3.3, Table 3.3-1.

Example Calculations:

Criteria Pollutant = (g/hp-hr) x (hp) x PTE (hr/yr) x (lb/453.6 g) x (ton/2000 lb) = tpy

HAPs = (lb/MMBtu) x (MMBtu/hr) x PTE(hr/yr) x (ton/2000 lb)= tpy

Greenhouse G11s Emissions • _J

C02/N20/CH4 = 0.001 x Gal fuel x HHV x EF (40 CFR 98 Equation C-1)

Note: Gal fuel =Maximum fuel x 160 hr/yr

HHV

EFC02

EFN20

EFCH4

0.138 MMBtu/gal

73.96 kg C02/MMBtu

6.00E-04 kg C02/MMBtu

3.00E-03 kg C02/MMBtu

40 CFR 98 Table C-1

40 CFR 98 Table C-1

40 CFR 98 Table C-2

40 CFR 98 Table C-2

Global Warming Potential

C02 =

N20=

CH4=

44 metric tons

4.E-04 metric tons

2.E-03 metric tons

1 40 CFR 98 Table A-1

298 40 CFR 98 Table A-1

25 40 CFR 98 Table A-1

C02e = C02 x GWP + N20 x GWP + CH4 x GWP 4.E+Ol metric tons

F-19 r~ c

G c

C

L

C n l

U.S. Air Force Title V Permit Renewal Application

Emergency Engine Emissions Data Sheets

EN0728161132BOI

r~ c c b c c c C C u

L

Attachment Emergency Generator Emissions Specifications c Power Generation

Engine Information:

Model: Cummins Inc. QSB7-G5 NR3 Type: 4 Cycle, In-line, 6 Cylinder Diesel Aspiration: Turbocharged and CAC Compression Ratio: 17.2:1 Emission Control Device: Turbochamed and CAC

11•

PERFORMANCE DATA - ..

BHP (ij) 1800 RPM (60 Hz) 51 Fuel Consumotion fnal/Hrl 3.4 Exhaust Gas Flow (CFM) 457 Exhaust Gas Temoeralwe 1°Fl 544 l!XHAU:n EM15!ilDN DATA

HC (Total Unburned H ns) 0.71 NOx IOxides of Nitroaen as N02) 2.28 co <carbon Monoxide) 2.93 PM (Particular Matter) 0.16 S02 (g/Hp-hr) 0.18 Smoke <Bosch) 0.41

8/l_j II~ Exhaust Emission Data Sheet

100DSGAA

60 Hz Diesel Generator Set

EPA Emission: Tier 3

Standbv

4.9

0.29 1.85 1.80 0.16 0.17 0.73

F-21

Bore:

Stroke:

Displacement

;v4

Standbv 7.0

0.20 1.89 1.32 0.13 0.17 0.89

4.21 in. (107 mm)

4.88 In. (124 mm)

408 cu. In .(6.7 liters)

FUii Full Standhv Prim•

162 147

8.7 8.1

1108 1022 807 788

0.12 0.15

1.94 1.92

0.83 1.03

0.10 0.11

0.16 D.17

0.65 0.67

All values are Grams oer HP-Hour

QSX15-G9

Emissions Compliance@ 60Hz:

EPA NSPS Stationary Emergency Tier 2

13 t jj zoo

Description The OSX 15-Series Is the first heavy-duty diesel with 24· valve dual overhead camshaft lechnology. Yet it has an impressive 30% fewer parts than comparable diesels and a utilised design, which eftminales external lube, coolant and fuel lines leading to higher reliability for such a high power output.

The 15 litre, six-cylinder CSX 15 engine Is Ideally suited to both open and containerised applications in static or portable genset equipment. II can be matched to meet specific duty cycle and operating conditions or any genset.

•!l!Aii"•

This engine has been built to comply with CE certification.

This engine has been designed In faciltles certified to 1509001 and manufadured In facilities certified to 1509001 ot 1509002.

1500 rpm (50 Hz Ratings)

Groa Engine Output Net Englna Output

Standby I Prime I Base Standby I Prime I Base kWmlBHP kWmlBHP

NIA I NIA I NIA NIA I NIA I NIA

1800 rpm (60 Hz Ratings)

Groa Engine Output

Standby I Prima I Base kWmlBHP

5631755 I so11Seo I 3541475

Our energy working for you."' www cumminsgdrive com

Nat Engine Output

Standby I Prime I Base kWmlBHP

526/705 I 47B/63e I 3231433

Features HolNt HX82 Turbocharglng • Wastegated deSign optimizes operation across the torque a.irve with improved response.

Integrated Block Da1lgn • Integrated Ouid circuits replace hoses and eliminate potential leaks.

High.Pressure Fuel Injection • Capable of over 1,900 bar (28,000 psi) for cleaner, more fuel-efficient combustion.

24-Valve Cylinder Haad - Four valves per cylinder for increased power with faster response at every rpm.

Coolpac lntagrated De1lgn • Products are supplied complele wilh cooling package and air cleaner kH for a complete power package. Each component has been specifically developed and rigorously tested for G·Drive products, ensuring high performance, durability and reliability.

Service and Support· G-Drive products are backed by an uncompromising level of technical support and after sales service, delivered through a world dass service network.

Typical Generator Set Output

Standby (ESP) Prtme(PRP) Base(COP) kWa I kVA kW• I kVA kWe I kVA

NIA I NIA NIA I NIA NIA I NIA

TyplCll G.....tor Set Output

Standby (ESPI Prtme(PRP) Base(COP) kWe I kVA kW• I kVA kWa I kVA

500 I s2s 450 I 563 303 I 379

<i2011 I Cummn1 o-onwe Engine• I SpocdicllloM 6'dlj9cl 111 Che1Qe Wlllloul - I Cummins 1s •,....... lradtmft d c""'"*" Inc.

(117111) C.

F-22 l r r

General Engine Data

Tl/Cle 4 Cyde, ln ~ine. Turbo Charaed. Air Cooled Bare mm 137 mm (5 391n l Stroke mm 169mm (665in l Displacement Litre 15 lltre (912 In., Cvllnder Block Cast iron, 6 c:vt:nder Battery Charging AltemalDr 35amcs Starting Voltage 24 volt FuelSvstem Direct tn1edlon Fuel Filllf spn-on fuel filters with water separator Lube Oil Filer Tvpe(s) spn-on full flow filter Lube Oil C=>ftRl'itv Ill 91.0 Flywheel Dimensions SAE1

Coolpac Performance Data

Air Cluner Type an

Weight & Dimensions

L!!!S!h mm mm

2269 1332

Air·Air C e Cooled 50% ethylene glycol. 50% water 11 8 Light duly dry replaceable element with restriction Indicator

Height mm

Ratings Definitions

Emergency Standby Power IESP):

Applicable for supplying power to varying electrical load for the duration of power lntenuptlon of a reliable utlUty source.

Emergency Standby Power (ESP) Is In accordance with ISO 8528. Fuel Stop power In accordance with ISO 3046, AS 2789, DIN 6271 and BS 5514.

Umltad-Tlme Running Power (L TP):

Applicable for supplying power to a constant electrical load for limited hou11. Llmited·Tlme Running Power (L TP) Is In ac:cordance with

IS08528.

Prim• Power (PRP):

Appllcable for supplying power to varying eledrlcal load for untimlled hours. Prime Power (PRP) 11 In accordance with ISO 8528.

Ten percent overload capablHty Is available In accordance with ISO 3046, AS 2789, DIN 6271andBS5514.

Base Load (Continuous) Power (COP):

Applicable for supplying power contlnuou1ly to a constant electrical load for unlimited hours.

Continuous Power (COP) In accordance with ISO 8528, ISO 3046, AS 2789, DIN6271 and

BS5514.

Fuel Consumption 1500 (50 Hz} Fuel Consumption 1800 (60 Hz}

% kWm BHP Uph Standbv Power .

100 NIA NIA NIA

Prime Power

100 NIA NIA NIA

75 NIA NIA NIA

llO NIA NIA NIA

25 NIA NIA NIA

Continuous Power

100 NIA NIA NIA

Cummins G-Drlve Englnn

Asia P1clllc 10 Toh Gumi Road #07.01 TI lnlema1Janal Tradtparll Singapore 608833 Phone es 11417 2348 Fu858417 2399

Europe, CIS, Middle Ellt 1nd Alrlcll M11111to" P11111 Columbus Ave Manston Rlllllglle Kenl CTl2 SBF. UK Phone 44 11143 255000 Fu 44 1843 255902

Our energy working for you. 111 www cumminsgdrive com

USaaUDh % kWm I BHP Standbv POWllr

NIA 100 563 755

PrlmePOW8r

NIA 100 507 680

NIA 75 380 510

NIA 50 254 340

NIA 25 127 170

Contlnuout Power

NIA

Ladn Amtrlc1 Rua Jatl, 310, Cumblca GuaM!los, SP 07180.900 Brazil Phone 1151121884652 Fax 55 11 21184729

100 354 475

Mexico Cummkll S. de R.L. di C.V.

Eje 122 No. 200 Zo1111 lndu1lrill Sm1 Lull Potosi, S L.P. 78090 Mexlcll Piion• 52 444 870 8700 Fu 52 444 870 1811

02011ICllMllnlG-DnvlEngonH16-flcllians Bulojecl IDClllngeW'lllOul N-1 Cunwllilll ltelWOi-tr8d11111111DI CIMM1IM Ille.

107111)

F-23

Uph US 111Uph

135.9 35.9

117.8 31.1

90.5 23.9

85.3 17.2

37.4 9.9

85 3 I 22.5

Nonh America 1400 73rd Avenue N .E.

Mlnne11110H1, MN 55432

USA

Phone I 783 57 4 5000 USA ToU..frff 1 877 789 78811 Fu 1 783 574 5298

C.

Attachment 1 Emergency Generator Specifications (exerpt) c Power Generation

Compn•nce Information:

& !ly, z.17 EPA Tier 3 Exhaust Emission

Compliance Statement

60DSFAD

60 Hz Dlesal Generator Set

Tll• engine &11ed In thla generator •l complies wHh U.B. EPA snd c1111arni. •ml•lan r11uJallons under the provlllom ol 40 CFA It, Nonroad (Moblle Off Highway) TI1r 3 1mlulOM Hmll9 when tasted par ISO 1171 D2.

Engine Manufacbnr.

EPA Cettlllcate Number.

Blecllv• Dale:

Dldlt luued:

EPA Nonniad Dlasll Engine Famly;

CARB ExlCUllve Ode:

1:11glne Information:

CUmmi111nc.

CEX-NRCH>l-31 12JD4/20fR 11J04/20a1 llCEXL.1127&AAG U.R-OaZ-0442

Model: Cummins Inc. OS85-03 NR3 Englm Nmnaplale HP: 145 Type: 4 CJt:le, l~lne,4 c,tlnd• Dieul Alp(ndlon: Tudlochalgad and CAC Campnmlon Allio: 17.2:1 Emlalon Conlnll Devier. Turbochlrgld IUl:t CAC

Boiw: 4.21 In. (107 mm)

8'lohe: 4.88 In. (124 mm) Dllpliatnenl: 275 m. rn. < u..,. >

U.S. Environmental Protection Nonroad Tier 3 Umlts

CQMPPNINI

NOX + HC (OlidH of Nitrogen aa N02 +Total Unburned HydrocaltlonsJ co (Calban Monoxide) PM (Particulate Malter)

CUmmlne Pows Glnlfr8llon

(Al valun are Gram• par HP-Hour)

3.0

3.7 0.22

To Dater and Assura

F-24 apa·1123b c

Attachment 1 Emergency Generator Specifications (exerpt)

C. Power Generation

Enalne lnfonnatlan:

Mod8I: Cwnmlnl Inc. OS85-G3 NFl3 Tp: 4 Cycle, In-lint, 4 c~ Dluel Aspiration: Tulbocharged and CAC Campnlllion Ratio: 17 .2:1

Exhaust Emission Data Sheet

60DSFAD

60 Hz Dlesel Generator Set EPA Emission: Tier 3

Bore:

Sltoke;

Dlsplac:emtnl:

4.21 In. (107 mmJ

4.88 In. (124 mm)

275 cu. in. I 4.5 lilcn. )

Emlulon Conlral o.vice: T ed with ctwna ,. Cooled

11• 1/!l 31& - l't.lll Ill •T !iUlllBSV :sunanv Sun111111 ,,. ........... -· BHP Iii 1800 60 1Z1 26 51 77 103 92 ... ~ n t.B 3.0 4.8 5.7 5.3

Exhaust lilA flow 308 433 598 665 646 ExhaUllGul 191"F1 500 624 m 7711 785

" n&TA

1'11,,j(I- . ,,., D.24 0.11 0.07 0.04 0.05 NllW 11,.~al ~ u Nl.r..JI 2.76 2.15 2Jl9 2.37 2.20 CO cmbof'I M01111llde) 2.27 1.18 D.83 0.60 0.51 PU Pmtieular Ma-. D.28 0.14 0.05 0.06 0.06 SC ,,,,....... l1111111111111 0.19 0.11 0.15 0.14 0.15 .... ... .....,.,. D.76 0.60 0.31 0.311 D.37

.4' VlllllllS 1118 GIMll nm HP-Hour

TEST CONDmONS

Data II reprM1111tallv• of alelllf1-lllle engine apeed (:t 25 RPM) It daslgnated genut loads.