042749 SDS EVSCHEM550.pdf

FLOOR STRIPPER

Product number: EVSCHEM550

SAFETY DATA SHEET

1. Identification

Product identifier FLOOR STRIPPER

Other means of identification

Product number EVSCHEM550

Recommended use Floor polish remover

Recommended restrictions None known.

Manufacturer/Importer/Supplier/Distributor information

Manufacturer

Medline Industries, Inc.

Address One Medline Place

Company name

Telephone Phone: 800 633-5463

Emergency phone number CHEMTREC 800-424-9300

Mundelein, IL 60060

2. Hazard(s) identification

Category 4Flammable liquidsPhysical hazards

Category 4Acute toxicity, oralHealth hazards

Category 3Acute toxicity, dermal

Category 2Acute toxicity, inhalation

Category 1Skin corrosion/irritation

Category 1Serious eye damage/eye irritation

Category 1Sensitization, skin

Category 3 respiratory tract irritationSpecific target organ toxicity, single exposure

Category 3Hazardous to the aquatic environment, acute hazard

Environmental hazards

Category 3Hazardous to the aquatic environment, long-term hazard

Not classified.OSHA defined hazards

GHS label elements

Hazard statement Combustible liquid. Harmful if swallowed. Toxic in contact with skin. Causes severe skin burns and eye damage. May cause an allergic skin reaction. Causes serious eye damage. May cause respiratory irritation. Toxic to aquatic life.

Label elements

Signal word Danger

Prevention Avoid breathing vapors. In case of inadequate ventilation wear respiratory protection. Wash hands thoroughly after handling. Do not eat, drink or smoke when using this product. Avoid release to the environment. Wear chemical goggles. Chemical resistant gloves. Do not get this material on clothing.

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

SDS US

1 / 7

Item# 042749

Response IF IN EYES: Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses if present and safe to do so. Continue rinsing. Get medical attention if irritation develops or persists. IF ON SKIN: Wash off immediately with plenty of soap and water. Remove and wash contaminated clothing before reuse. Get medical attention if irritation develops or persists. IF SWALLOWED: Rinse mouth thoroughly with water. Drink plenty water to dilute contents of stomach. If large amount is ingested, contact a poison control center immediately. If a person feels unwell, consult a physician. IF INHALED: Move to fresh air. If a person feels unwell, contact a physician or medical personnel.

Storage Store in a well-ventilated place. Keep container tightly closed. Keep out of the reach of children.

Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.

Hazard(s) not otherwise classified (HNOC)

None known.

Supplemental information 49.9% of the mixture consists of component(s) of unknown acute oral toxicity. 50.4% of the mixture consists of component(s) of unknown acute dermal toxicity. 50.4% of the mixture consists of component(s) of unknown acute inhalation toxicity. % of the mixture consists of component(s) of unknown acute hazards to the aquatic environment. % of the mixture consists of component(s) of unknown long-term hazards to the aquatic environment.

3. Composition/information on ingredients

Mixtures

CAS number %Chemical name Common name and synonyms

111-76-22-Butoxyethanol 25 - <30

141-43-5Ethanolamine 20 - <25

9016-45-9Nonylphenol Ethoxylate 1 - <5

Composition comments For the full text of the R phrases mentioned in this Section, see Section 16. The manufacturer has claimed the percentage of one or more ingredients as trade secret.

4. First-aid measures

Eye contact Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses if present and safe to do so. Continue rinsing. Get medical attention if irritation develops or persists.

Skin contact Wash off immediately with plenty of soap and water. Remove and wash contaminated clothing before reuse. Get medical attention if irritation develops or persists.

Ingestion Rinse mouth thoroughly with water. Drink plenty water to dilute contents of stomach. If large amount is ingested, contact a poison control center immediately. If a person feels unwell, consult a physician.

Inhalation Move to fresh air. If a person feels unwell, contact a physician or medical personnel.

Most important symptoms/effects, acute and delayed

Not available.

General information Keep victim warm. Take off contaminated clothing and shoes immediately. In case of shortness of breath, give oxygen. In the case of accident or if you feel unwell, seek medical advice immediately (show the label where possible).

5. Fire-fighting measures

Suitable extinguishing media Carbon dioxide (CO2). Foam. Dry chemical.

Unsuitable extinguishing media

Do not use water jet as an extinguisher, as this will spread the fire.

Specific hazards arising from the chemical

Combustible.

Special protective equipment and precautions for firefighters

Self-contained breathing apparatus and full protective clothing must be worn in case of fire.

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

SDS US

2 / 7

6. Accidental release measures

Personal precautions, protective equipment and emergency procedures

Ensure adequate ventilation. Use personal protective equipment. Do not touch or walk through spilled material. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Surfaces may become slippery after spillage.

Methods and materials for containment and cleaning up

Stop the flow of material, if this is without risk. Dike the spilled material, where this is possible.

Absorb with inert absorbent such as dry clay, sand or diatomaceous earth, commercial sorbents, or recover using pumps. Dike far ahead of liquid spill for later disposal.

Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean contaminated surface thoroughly. Prevent product from entering drains. Do not allow material to contaminate ground water system. Soak up with inert absorbent material and dispose of as hazardous waste. After removal flush contaminated area thoroughly with water.

7. Handling and storage

Precautions for safe handling When using do not eat or drink. Avoid contact with skin and eyes.

Conditions for safe storage, including any incompatibilities

Keep this material away from food, drink and animal feed. Keep at temperatures between andC.

Keep tightly closed. Keep out of the reach of children.

8. Exposure controls/personal protection

Occupational exposure limits

US. ACGIH Threshold Limit Values

ValueComponents Type

TWA 20 ppm2-Butoxyethanol (CAS 111-76-2)

STEL 6 ppmEthanolamine (CAS 141-43-5)

TWA 3 ppm

US. NIOSH: Pocket Guide to Chemical Hazards

ValueComponents Type

TWA 24 mg/m32-Butoxyethanol (CAS 111-76-2)

5 ppm

STEL 15 mg/m3Ethanolamine (CAS 141-43-5)

6 ppm

TWA 8 mg/m3

3 ppm

Control parameters

US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)

ValueComponents Type

PEL 240 mg/m32-Butoxyethanol (CAS 111-76-2)

50 ppm

PEL 6 mg/m3Ethanolamine (CAS 141-43-5)

3 ppm

Biological limit values

ACGIH Biological Exposure Indices

ValueComponents Determinant Specimen Sampling Time

200 mg/g Butoxyacetic acid (BAA), with hydrolysis

Creatinine in urine

*2-Butoxyethanol (CAS 111-76-2)

* - For sampling details, please see the source document.

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

3 / 7

Appropriate engineering controls

Provide eyewash station. Ensure adequate ventilation, especially in confined areas. Ventilation is normally required when handling or using this product to keep exposure to airborne contaminants below the exposure limit. Ventilation should be sufficient to effectively remove and prevent buildup of any dusts or fumes that may be generated during handling or thermal processing. Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level.

Individual protection measures, such as personal protective equipment

Eye/face protection Wear chemical goggles.

Skin protection

Hand protection Chemical resistant gloves.

Respiratory protection None required where adequate ventilation conditions exist. If ventilation is insufficient, suitable respiratory protection must be provided.

General hygiene considerations

When using do not eat or drink. Avoid contact with skin. Avoid contact with eyes.

9. Physical and chemical properties

Appearance liquid

Color clear, red

Odor amine

Odor threshold Not available.

pH 11.7

Melting point/freezing point 30 °F (-1.11 °C) / -102.64 °F (-74.8 °C) estimated

Boiling point Not available.

Flash point 175.0 °F (79.4 °C) Pensky-Martens Closed Cup

Evaporation rate Not available.

Flammability (solid, gas) Not available.

Upper/lower flammability or explosive limits

Flammability limit - lower

Not available.

Flammability limit - upper

Not available.

Vapor pressure 0.47 hPa estimated

Vapor density Not available.

Solubility(ies)

Solubility (water) 100 %

Partition coefficient (n-octanol/water)

Not available.

Auto-ignition temperature Not available.

Decomposition temperature Not available.

Viscosity water thin

Specific gravity 0.99

VOC (Weight %) 94.6 %

10. Stability and reactivity

Reactivity The product is stable and non-reactive under normal conditions of use, storage and transport.

Chemical stability Stable at normal conditions.

Possibility of hazardous reactions

Will not occur.

Conditions to avoid Do not mix with other chemicals. Contact with incompatible materials.

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

4 / 7

Incompatible materials Strong oxidizing agents Strong acids.

Hazardous decomposition products

Carbon oxides. Nitrogen oxides (NOx).

11. Toxicological information

Information on likely routes of exposure

Eye contact Risk of serious damage to eyes.

Skin contact Causes severe skin burns. May cause sensitization by skin contact.

Ingestion Toxic if swallowed.

Inhalation Harmful by inhalation.

Symptoms related to the physical, chemical and toxicological characteristics

Not available.

Acute toxicity Acute LD50: 950 mg/kg, Rat, Oral Acute LD50: 735 mg/kg, Rat, Dermal Acute LC50: 1820 mg/l/4h, Rat, Inhalation Causes severe burns.

Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.

IARC Monographs. Overall Evaluation of Carcinogenicity

2-Butoxyethanol (CAS 111-76-2) 3 Not classifiable as to carcinogenicity to humans.

US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)

Not listed.

Reproductive toxicity Not available.

Chronic effects Prolonged exposure may cause chronic effects. Prolonged skin contact may cause skin irritation and/or dermatitis. Harmful: danger of serious damage to health by prolonged exposure if swallowed. May cause damage to organs through prolonged or repeated exposure. Repeated or prolonged skin contact may cause skin irritation and/or dermatitis and sensitization of susceptible persons.

12. Ecological information

Ecotoxicity Components of this product have been identified as having potential environmental concerns.

Persistence and degradability Not available.

Bioaccumulative potential Not available.

Other adverse effects Not available.

13. Disposal considerations

Disposal instructions Dispose in accordance with all applicable regulations. This product, in its present state, when discarded or disposed of, is not a hazardous waste according to Federal regulations (40 CFR

261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal, whether the product meets RCRA criteria for hazardous waste. Do not contaminate ponds, waterways or ditches with chemical or used container. Triple rinse containers.

Hazardous waste code Not regulated.

Waste from residues / unused products

Not available.

Contaminated packaging Triple rinse containers. Can be offered for recycling, re-conditioning or puncture.

14. Transport information

DOT

UN2491UN number

Ethanolamine or Ethanolamine solutionsUN proper shipping name

8Class

Transport hazard class(es)

-Subsidiary risk

8Label(s)

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

5 / 7

IIIPacking group

Not available.Special precautions for user

IB3, T4, TP1Special provisions

154Packaging exceptions

203Packaging non bulk

241Packaging bulk

IATA

UN2491UN number

Ethanolamine solutionUN proper shipping name

8Class

Transport hazard class(es)

-Subsidiary risk

IIIPacking group

No.Environmental hazards

8LERG Code

Not available.Special precautions for user

Allowed.Passenger and cargo aircraft

Other information

Allowed.Cargo aircraft only

60 L

A3

IMDG

UN2491UN number

ETHANOLAMINE or ETHANOLAMINE SOLUTIONUN proper shipping name

8Class

Transport hazard class(es)

-Subsidiary risk

IIIPacking group

No.Marine pollutant

Environmental hazards

F-A, S-BEmS

Not available.Special precautions for user

DOT

IATA; IMDG

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

6 / 7

15. Regulatory information

US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200.

All components are on the U.S. EPA TSCA Inventory List.

TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)

Not regulated.

CERCLA Hazardous Substance List (40 CFR 302.4)

Not listed.

US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)

Not listed.

CERCLA (Superfund) reportable quantity

Not listed.

Superfund Amendments and Reauthorization Act of 1986 (SARA)

Hazard categories Immediate Hazard - Yes Delayed Hazard - No Fire Hazard - Yes Pressure Hazard - No Reactivity Hazard - No

SARA 302 Extremely hazardous substance

No

SARA 311/312 Hazardous chemical

No

SARA 313 (TRI reporting)

Not regulated.

Other federal regulations

Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List

Not regulated.

Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)

Not regulated.

Safe Drinking Water Act

(SDWA)

Not regulated.

US state regulations

US. California Proposition 65

Not Listed.

16. Other information, including date of preparation or last revision

HMIS® ratings Health: 3* Flammability: 2 Physical hazard: 0 Personal protection: B

NFPA ratings Health: 3 Flammability: 2 Instability: 0

Issue date 04-10-2014

Version # 01

Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release.

Material name: FLOOR STRIPPER

4856 Version #: 01 Issue date: 04-10-2014

7 / 7