Attachment_5_-_Historical_Repair_under_$10k.pdf

Description Lab # Labor Hours Subcontract

REPLACE BAD PRESSURE TRANSDUCER ON CHILLER 1 11

CHILLER DOWN 1 7.5

CHILLER DOWN 1 4

PROCESSED WATER INOP. - NO FLOW 1 1

REPLACE BAD PUMP SEAL ON BOOSTER PUMP 1 3.6

VACUUM PUMP LEAKING 1 2

REPLACE BAD PUMP/ MOTOR 1 0.5

REPLACE BAD PUMP/ MOTOR 1 3.5

REPAIR LEAK IN R.O WATER LINE 1 1

REPAIR LEAKS IN WATER LINE 1 8 Y

COMPRESSED AIR INOP. 1 2.7

REPLACE CONDENSATE FILTER ON AIR DRYER 1 0

REPAIR EXHAUST DUCT ON EXHAUST FAN 1 12

CLEAN FILTERS & DIFFUSERS 1 9

REPLACE BEARINGS ON AIR HANDLER # 7 1 1.5

AIR HANDLER INOP. 1 16.2

CLEAN BUGS FROM LENS OF CLEAN ROOM LIGHT FIXTURES 1 3

O2 SENSOR ALARM GOING OFF 1 4.8

OXYGEN SENSOR IS IN ALARM 1 7.6

REPAIR SCREEN ON CORROSIVE CABINET 1 3.5

VENTILATION SYSTEM TO CHEMICAL STORAGE CABINET INOP. 1 4.9

REPLACE LEAKING BALL VALVE ON CHILLED WATER LINE 1 5.5

CHILLER LEAKING 1 5

REPAIR DUPLEX BOOSTER PUMP 1 13.6

REPLACE FAULTY PHOTOHELIC GAUGE 1 4

INSTALL AUTOMATIC BLOW DOWN ON AIR COMPRESSOR 1 3

INVESTIGATE AND REPAIR OIL LEAK IN AIR COMPRESSOR 1 1 Y

CHECK FUME HOOD - LOW FLOW VELOCITY 1 1.5

CHECK FUME HOODS - LOW FLOW VELOCITY 1 1

REPLACE FAILING MOTOR ON AIR HANDLER 1 24 Y

AIR HANDLER #7 IS OFF 1 15

REPLACE BAD MOTOR ON AIR HANDLER 7 1 24 Y

REPLACE BAD BLOWER MOTOR 1 24 Y

REPLACE BEARINGS ON AIR HANDLER BLOWER 1 8

031-029 Unit Down, Server Rm Extremely hot 3 14

CONDENSATE OVER FLOWING 3 3

CONDENSATE DRAIN OVERFLOWING . 3 4

REPAIR WATER DISPENCER 3 1

REPAIR WATER DISPENSER 3 1

WATER POURING OUT OF UNIT 3 4

NO HEAT in BLGD 3 10

RELOCATE T-STAT 3 3.5

CHECK AIR FLOW AND LOUVERS FOR RANDY BLUE 3 17

REPLACE OUTDOOR AIR SENSOR - COLD CALL 3 6

EXHAUST FAN INOP 3 3.8

INSTALL EXHAUST FAN 3 4.5

NEEDS REWIRED & ANEW STARTER 3 12

REPLACE HOT WATER TANK 3 3

REPAIR AIR COMPRESSOR 3 7

PENTHOUSE - RECONNECTED AIR LINE HOSE 3 4

INSTALL DISCONNECT 3 8

NO HEAT 3 34

REPAIR LEAK IN HOT WATER PIPING 3 24

TECH TO SPEND TIME WITH CE A&E STUDY FIRM TO SHOW ALL HVAC EQUIPMENT 3 2

AUDITORIUM COLD 3 4.5

CHILLER NOT COOLING PROPERLY 3 18.5

HOT CALL TO 2-12 NO COOLING 3 1.5

TROUBLESHOOT CONTROLS 3 10.5

REPLACE CRANK CASE HEATER 3 0 Y

COLD CALL WARM AIR DUCT OFF V.A.V. BOX 3 6

UNIT OFF ON FREEZE STAT 3 6

HIGH HUMIDITY 3 15

INSTALL DEHUMIDIFIER FOR ALF LAB 3 2 Y

COLD CALL 3 15.5

ANALYZE RETURN AIR PROBLEM 3 4

INSTALL DEHUMIDIFER FOR CAVE ROOM 3 2 Y

REPLACE LIGHT BULBS & CHECK BALLASTS 3 8

CHECK TRIPPED BREAKER 3 3.5

REPLACE BEARINGS 3 22.5

CLEAN OUT VFD 3 8

REMOVE DAMAGED AND INSTALL NEW SUCTION DIFFUSER 3 2 Y

INSULATE SUCTION DIFFUSER 3 1 Y

IOM and FEC FAULTED OUT 3 1 Y

BEARING REPLACEMENT 3 16

PROCESSED CHILLED WATER PUMP PACKAGE 3 0 Y

CLEAN VFD CONTACTS 3 8

PROCESSED CHILLED WATER REVIEW 3 4

HELP RANDY BLUE AND CE GET HOT WATER SHUT DOWN FOR REPAIR BY CE CONTRACTOR 3 8

HEAT ISSUE ON DRIVE 3 16

REPLACE MECHANICAL SEAL 3 22

PUMP NEEDS REPLACED 3 0.7 Y

INSTALL REBUILT PUMP 3 6

COMPRESSOR WILL NOT PUMP UP TO 125PSI 3 24.5

UNIT INTAKE NOT FUNCTIONAL FAULTY VALVE 3 4 Y

COMPRESSOR WILL NOT PUMP UP TO 125PSI 3 0

CHECK ON AIR COMPRESSOR 3 3

REPLACE THERMOSTATS 3 5.5

CLEAN HEAT EXCHANGER 3 10.7

CLEAN PLUGGED HEAT EXCHANGER 3 42.5

REPAIR BY REPLACE 3 0

WORK BEING DONE TO REFRIG MONITOR TROUBLE ALARM ON 3 16.6

SET UP FOR CHILLER BARREL REPLACEMENT 3 2

CHEMICAL FEED PUMPS 3 0

RESTART CHILLER 3 4.5

CHANGE STARTER COOLANT 3 0 Y

FIX TWO LEAKY VALVES 3 6

INSULATE 3 VALVES 3 0.5 Y

WATER SPRAYING OUT FROM UNDER TOWER 3 4.5

REPLACE CHEMICAL PUMP 3 0

REPAIR BY REPLACE 3 0

COVER ALL CHEM LINES 3 4

REPLACE FLOAT VALVE / FILL VALVE 3 6

INSULATE AIR / DIRT SEPARATOR 3 2 Y

REPLACE BOOSTER PUMP HOT WATER PKG 3 8

ROOM HOT EQUIP RM (OVER HEATING) 3 10

ROOM HOT EQUIP RM (OVER HEATING) 3 13

P&L MEC IS INVESTIGATING SANYO ISSUES 3 4

HAVE CONTRACTOR LOOK AT SYSTEM 3 14 Y

CHECK DIFFUSERS/ CFMS and T-STAT LOCATIONS 3 25.5

COIL LEAKING 3 5

CHECK OPERATION OF O.A. DAMPERS 3 9

REPAIR THE SUPPLY FAN 3 9 Y

BEARINGS SQUEELING 3 4

CHECK RM 328 FOR BURNING SMELL 3 1

REPLACE RETURN FAN BEARINGS 3 10

FAN COIL WON'T COME UP 3 10 Y

TEST SYSTEM FOR PROPER OPERATION 3 11.5

REPAIR/ LEAKING FROM PIPING FITTING 3 16

REPAIR WATER LEAK IN PIPING 3 1

EYE WASH LEAKING 3 6

PUMP MOTOR BURNT OUT 3 16

FROZEN/ BURST PIPE TO STEAM CONDENSATE LINE ON HEATER 3 21

CALL NOISE COMPLAINT 3 2

SOUNDS LIKE MOTOR LOCKED UP 3 2

NO HEATING WATER GOING THRU A/H 3 20

FIX INSULATION TAPE ON DUCT 3 0.5 Y

REPLACE LEAKING PUMPS & PIPING 3 0

REPLACE LEAKING PUMPS & PIPING 3 0

REPLACE LEAKING PUMPS & PIPING 3 0

DRAIN DOWN PIPING 3 16

REPLACE LEAKING PUMP & PIPING 3 0

REPLACE CONDUCTIVITY PROBE 3 17.5

CALL-IN ROOM HOT 89 DEGREES/ FILL VALVE 3 5.5

REPLACE LIGHTS IN TOWER PIT 3 1

RE-START CHILLED WATER FROM WEEKEND WATER SHUT-DOWN 3 3.8

CHECK FOR LEAK ON SYSTEM RM 306F 3 1

COLD CALL RM 102 PERIMETER HEAT LOOP 3 28

REPLACE UV BULBS & FILTERS 3 1

SOLENOID VALVE NOT WORKING 3 3

REPLACE UV BULB & FILTERS 3 1

REPAIR WATER LEAK, BROKEN FITTING 3 3

CIRCULATION PUMP COUPLING SHEARED 3 11

CHECK VALVE FAILURE ON CONDENSATE STATION 3 5

ROOM COLD 3 10

RM 3000 - NO COOLING 3 2

NO COOLING, NO CHILLED WATER 3 4

NO COOLING, NO CHILLED WATER 3 4

BROKEN SHAFT SEAL NEEDS REPLACE 3 8

TROUBLESHOOT OFM ADN CONTRACTOR 3 16.5

REPAIR CONDENSATE LINE 3 5.5

AIR HANDLER NOT COOLING 3 26

CHECK AIR FLOW IN ROOMS 1-005/ 1-006/ 1-007/ 1-008 3 2

HOT CALL AREA HOT 3 10

A/H INOP 3 8

COLD CALL HALLWAY BY GARAGE DOOR 3 7

ROOMS HOT 3 5.4

INSTALL MECHANICAL SEAL LEAKS 3 35

REPLACE PUMP ASSEMBLY 3 12

REPLACE CONDENSATE PUMP ASSEMBLY 3 2

CHECK OPERATION OF FUME HOOD 3 2.5

CHECK OPERATION OF FUME HOOD 3 2.5

CHECK OPERATION OF FUME HOOD 3 3

CLEAN DRAIN PAN & LINE 3 4

NOT COOLIONG PROPERLY 3 12

HIGH WATER ALARM 3 8

REPAIR FLOW SENSOR 3 5

REPIPE BROKEN PIPES ON CONDENSATE WATER 3 4.5

REPAIR WATER MAKE-UP LINE 3 7

A/C INOP - HOT ROOM 3 4

REPLACE CONDENSER FAN MOTOR 3 4.5

REPAIR DRAIN LINE TO COOLING COIL 3 7.1

MOTOR BAD 3 28.6 Y

REPAIR WATER LEAK 3 1

REPAIR FILTER RACK 3 1.5

INSULATE DRAIN 3 0

RETURN FAN SQUEALING 3 8

REPAIR LEAKS AROUND AIR HANDLER 3 7

ROOM HOT - A/C INOP 3 4.5

A/H OFF NO HEAT 3 40.5

2-4 HRS CHECK AHU in BLDGS 3 24

TROUBLESHOT FACE & BYPASS DAMPERS 3 1.5

A/H INOP 3 8

RESTART BLDG AUTOMATION 3 8.5

VWR REFRIGERATOR IS RUNNING TOO LOW 3 16.5

REMOVE REFRIGERANT & OIL FOR DRMO 3 10

ICE MACHINE INOP 3 11

ICE MACHINE INOP 3 2

REPAIR ICE MACHINE 3 21.5

REPLACE SOFTNER CELL WITH NEW 3 8 Y

SYSTEM OVER HEATING 3 8

REPLACE DAMPER ACTUATORS 3 15

REPLACE LEAKING PUMP SEAL 3 28 Y

REPAIR LEAKING PUMP SEAL 3 22

REPAIR LEAKING PUMP SEAL 3 8.5

REPAIR / REPLACE FLOAT ASSEMBLY 3 8.6

REPLACE LEAKING PUMP 3 15.5

REPLACE LEAKING PUMP SEAL 3 8.1

REPLACE BROKEN PUMP HEAD 3 2

SHORTED HEATERS ARE TRIPPING BREAKERS 3 15

REPLENISH SALT 3 1

SOFTNER NOT OPERATING PROPERLY 3 7.5

ORDER SALT 3 3

WATER SOFTNER IN-OP 3 11.7

REPLACE LEAKING PSI SWITCH 3 3.2

REBUILD OR REPLACE EXHAUST FAN 3 11.1

CORRIDOR HOT 3 8

REPAIR LEAKING TRAP 3 3.5

HOT WATER OVERHEATING 3 24

REPAIR WATER LEAK 3 5.1

REPLACE STEAM ACTUATOR 3 4.5

REPAIR MULTIPLE LEAKS IN HOT WATER SYSTEM 3 28.7

REPLACE HEATERS 3 6

HUMIDIFER IN-OP 3 8

REPAIR LEAK IN HUMIDIFIER 3 23.1

REPAIR STEAM LEAK 3 11

HUMIDIFER ALARM OVER PRESSURE 3 6.2

NO AIR FLOW 3 8

ANNEX HOT 3 4.5

START-UP CHILLER 3 21.2

WINTER MAINTANCE 3 20

HOT CALL/ NO COOLING 3 2

REPLACE OIL FILTER 3 1

REPAIR WATER LEAK 3 1.6

REPAIR LEAK IN MAKE-UP LINE 3 4

WINTERIZE COOLING TOWER 3 10.4

OUT ON FREEZE STAT ALARM 3 3.9

RM 109 COLD 3 12

REPAIR/ REPLACE REHEAT COIL 3 13.6

REPAIR LEAK IN CEILING 3 9.1

PERFORM AIR STUDY FOR AAALAC INSPECTION 3 0

ROOMS HOT 3 6

RESET BLDG DUE TO FIRE ALARM 3 4.9

RM 68 COLD 3 9.7

AIR HANDLER IN-OP 3 16

RM 21 COLD 3 7.5

ROOMS HOT 3 11.5

OFFICE AREA HOT 3 7.5

ROOMS COLD 3 9.2

A/H NOT RUNNING (AFTER HOURS CALL) 3 31.5

ADJUST AIRFLOW FOR AAALAC 3 10.8

JCI IN TO LOOK AT BLDG AUTOMATION 3 9 Y

EAST WING COLD 3 8.2

A/H IN-OP 3 18.1

RMS COLD WITH HIGH HUMIDITY 3 1

RMS COLD WITH HIGH HUMIDITY 3 11.5

REBUILD MIXING VALVE 3 18.5

FREEZER IN-OP 3 2.6

LOW TEMP FREEZER IN-OP 3 9.6

LOW TEMP FREEZER IN-OP 3 3

LOW-TEMP FREEZER IN-OP 3 4.6

LOW TEMP FREEZER IN-OP 3 3.5

FREEZER NOT COOLING 3 9.2

WASHER NOT HEATING PROPERLY 3 27.9

WASH TANK OVERFILLING 3 14.9

WASHER USING TOO MUCH DETERGENT 3 9.6

PERFORM BACTERIA TESTING 3 1.5

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 1.5 Y

SANITIZE ANIMAL WATER SYSTEM 3 6.9

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 2 Y

REPAIR LEAK IN WATER LINE 3 2.7

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

SANITIZE ANIMAL WATER SYSYTEM 3 9.3

REPLACE R.O. MEMBRANE 3 11

REPLACE SENSOR CABLE (RO LINE) 3 1.5

RM 24 - RO SYSTEM LEAKING 3 2

EMERGENCY START BATTERIES TO BE REPLACED 3 4

REPAIR LEAKING LAB SINK 3 2.3

REPAIR LEAK IN DRAIN LINE 3 5.2

REPAIR DRIPPING FAUCETS 3 1.9

REPAIR STEAM LEAK 3 7

INSTALL POWER GROMMET 3 0 Y

REPLACE BROKEN SHAFT SEALS 3 15

REPLACE 2 CONDENSER FANS 3 15

SYSTEM TRIPPING ON HIGH PRESSURE 3 1.5

INSTALL INSULATION ON PIPING OF AHU 3 0.5 Y

SPEED DRIVE INOP - UNDER VOLTAGE 3 7

HOT WATER DISPENSER NOT WORKING 3 2

REPLACE HOT TANK 3 6

INSTALL NEW WATER COOLER 3 2

STEAM LEAK IN PIPING OUTSIDE EQUIP ROOM 3 12.7

PUMP MOTOR LOCKED UP, REPLACE 3 12

COLD CALL LIEBERT 3 20

NO POWER TO LIEBERTS 3 1.5

100 DEGREES IN BLDG / NO WATER FROM CE SHUT DOWN 3 32

REPAIR PIPE LEAK CW PIPING 3 32.5

INSULATE NEW PIPING 3 0

(tk dupe of 732764 for billing tests) 3 0

INSULATE PIPING 3 16

FILTERED DRINKING FOUNTAIN WATER LEAK 3 3

REPLACE UV BULBS & FILTERS 3 1

REPAIR LEAKING SUMP PUMP 3 10.5

PUMP INOP 3 14

REPLACE STEAM CONDENSATE PUMP/ TANK 3 9.5 Y

REPAIR AIR COMP 3 5

STEAM CONDENSATE LEAKING 3 21.5 Y

REINSULATE PIPING 3 13

REPLACE BLOWER MOTOR 3 16

DRAINED CONDESATE FOR HEAT 3 4.2

REPAIR COND. WATER LEAK 3 4

CHILLER IN ALARM - CHECK SYSTEM 3 3.5

A/C NOT OPERATING 3 9.5

CHECK FOR REFRIGERANT LEAKS 3 12.5

AREA HOT 3 21

REPAIR WATER LEAK 3 1.6

COLD CALL NO HEAT 2ND FLR 3 17.2

NO FLOW ON COOLING 3 2

CLEAN CONDENSATE PAN & LINE 3 20

CLEAN UP DEBRIS FROM PAST REPAIRS 3 8

LEAKING CONDENSATE FAN 3 4.5

FIX LEAK IN REHEAT COIL 3 16

LOCATE AND REPAIR STEAM TRAP 3 4

LEAKING STM PIPE 3 10.9

INSULATE PIPING 3 11

REPLACE REHEAT COIL 3 9

NO HEAT 3 21.5

REPAIR CONDENSATE RETURN LINE 3 27

STEAM TRAP HAMMERING 3 12

LIEBERT INOP 90 DEGREES 3 2

LIEBERT UNIT HIGH HUMIDITY 3 1.5

LIEBERT IN ALARM FROM WEEKEND POWER OUTAGE 3 1

CLEAN OUTSIDE CONDENSER 3 3

LOWER TEMP ON T-STATS 3 1

UNCLOGGED DRAIN ON AHU 3 16

REPLACE COMPRESSOR 3 14

MOVE DUCT LINES TO RM 15 3 62.5

REPLACE HOT WATER TANK 3 16

A/H NOT WORKING 3 3

COLD CALL NO HEAT {50 DEGREES} IN BLDG 3 4

REPLACE LEAKING UNION IS STEAM PIPING 3 41.5

CONDENSER TANK LEAKING THRU TO 2ND FLR 3 12.5

NO HOT WATER / REPLACE VALVE ON STEAMLINE 3 48

REPLACEMENT OF COIL # 418-A STEAM WATER HEATER 3 15

INSULATION OF LINE SET AC UNIT 3 9.5

REPLACE LINE SET INSULATION AC UNIT 3 8.5

REPLACE INDOOR FAN MOTOR 3 22

A/C UNIT NOT COOLING 3 92

HOT CALL IN ROOM 2-115 3 2

COLD CALL - 2ND FLR 3 1.5

PRV BLOWING OFF STREAM / COLD CALL 2NF FLR 3 22

PRV STUCK OPEN 3 13

REPLACE CALIBRATE PNUEMATIC T-STAT RM 2-16 3 2

HIGH HEAT CALL 3 1

REPLACE 460 CONTACTOR FOR A/H 3 10

SMOKE TEST AHU 3 5.5

COLD CALL 3 7

ROOM 0-102 HOT 3 2

REPLACE LEAKING UNION IS STEAM PIPING 3 7

REPLACE HOT WATER TANK 3 4

NO HEATING WATER PUMP PACKAGE [ COLD CALL] 3 5

LEAK FROZEN WATER 3 8

LEAK FROZEN WATER 3 6.5

RESEARCH WHERE AND WHY WATER LEAKING 3 18

REPLACE BEARINGS 3 6

LEAKING SEALS ON STEAM LINE 3 16

CHILLER IN-OP 3 13.3 Y

SHUTTING DOWN 3 4 Y

REPAIR BY REPLACE PUMP UNDER TOWER 3 39

REMOVE FOAM OUT OF TOWER 3 4

CHECK SYSTEM FOR PROPER REFRIGERANT CHARGE AT CONDENSER ALSO 3 27 Y

CHECK SYSTEM FOR PROPER REFRIGERANT CHARGE AT CONDENSER ALSO 3 1

INSTALL NEW CIRCUIT BOARD 3 11.5

UNITS PUSHING HOT AIR / NOT COOLING 3 4

REPAIR THE SUPPLY FAN 3 9

REPAIR SUPPLY FAN 3 6

ESCORD MSD FOR AIR STUDY 3 12

MOTOTR BEARINGS WINDING 3 11

AIR HANDLER MAKING NOISES 3 5

REPAIR WATER LEAK P.C.W. PIPE 1.5 INCH 3 21

RESTART FAN COIL UNITS 3 4.7

CHECK ON HOT CALL 3 3.5

REPLACE T-STAT 3 1

COLD ROOM 3 5

REPLACE AUTO DRAIN and TUBING for AIR COMPRESSOR 3 2

NO BLDG AIR, AIR DRYER / AIR COMP FAILURE 3 8

REPLACE PNEUMATIC CONTROLS & TUBING 3 4

REPLACE WORN MOTOR SHIEVE 3 7.5

HOT CALL ROOM 118 3 3

REPAIR STEAM LEAK TO A/H COIL 3 7

REPLACE HYSPAN EXPANSION JOINT 3 4

CHECK AND LOCATE WATER LEAK 3 21

SUB-BASE - WATER LEAK/ REVERSE ROTATION 3 8

REPLACE CHEMICAL PUMP 3 2.4

CONDUCTIVITY PROBE 3 4

REPAIR EXHAUST 3 10

WATER LEAK PAN OVER FLOWING 3 2

CHILLER CONTACTOR NOT PULLING IN 3 13 Y

REPLACEMENT OF TO HYSPAN COMPENSATOR 3 26

STEAM TRAP SURVEY 3 6

WATER LEAKS AT COMPRESS FITTINGS 3 2.5

COLD CALL 60 Degrees 3 4.5

NO COOLING RM 0-115 3 24

REPLACE INSULATION ON LINE SET - AC UNT 3 9.5

RE-INSULATE CW PIPE CONDENSING ON TILE 3 11

STEAM LEAK AT VALVE 3 2

AIR HANDLER NOT RUNNING 3 7

838 MECH RM - PUMP INOP 3 2.1

REPLACE CONDENSATE PUMP ASSEMBLY 3 11.5

REPLACE FLOAT ASSEMBLIES 3 7.5

REPAIR WATER LEAKS, SEVERAL LEAKS 3 7.5

REPLACE LEVEL PROBE 3 9.5

REPAIR WATER LEAK IN BASIN (HEATER) 3 34

REPLACE PULSAFEEDER PUMP BANDS 3 1

BUILDING FLOODED NEED COOLING TOWER SHUT DOWN 3 2

REPAIR WATER MAKE-UP 3 4.5

UNIT NO RUNNING 3 8

WATER COMING FROM CEILING 3 16

A/C NOT WORKING 3 4

RESTART DDC SYSTEM 3 5

DDC WILL NOT CONNECT 3 4

ROOM COLD 259 3 7

FREEZER TRIPPING SWITCH AT UNIT {AFTER HOURS CALL} 3 4

REMOVE REFRIGRANT 3 8

INSTALL WATER LINE & DRAIN / ICE MAKER 3 19

HOT CALL ROOM HOT 3 2.8

ROOM HOT 3 8

REPAIR WATER LEAK 3 8

REPLACE VALVE / ACTUATOR 3 12

CRACKED SINK REMOVE INSTALL SS SINK 3 6

REPAIR LEAK IN WATER LINE 3 12

REPAIR LEAK IN PIPING 3 4

WATER LEAKING THROUGH CEILING 3 4

REPLACE PUMP 3 1

REPLACE LEAKING PUMP SEAL 3 2

REPAIR LEAK IN PIPING 3 12

REPLACE CONDENSATE STATION 3 42

INSTALL CHLORI FLUSH SYSTEM / INSTALL SANITIZING STATION 3 34.5

PERFORM START-UP 3 20.2

CONTROLLER NOT OPERATING PROPERLY 3 18.4

SOFTNER IN-OP 3 4.3

ORDER SALT AND SUPPLIES FOR SOFTNER 3 6

REPLENISH SALT 3 4

REPLENISH SALT 3 6

REPLACE BAD MOTOR 3 4.5

REPLACE TEMP CONTROLLER 3 13.7

REPAIR LEAKING SEAL 3 6

MECH RM - BAD WATER FLOW TO REHEATS 3 24

MOVE HUMIDIFIER FOR CONTACTOR ON DRAIN REPAIR 3 5

HUMIDIFER IN-OP 3 21

FREEZER ROOM HOT 3 42.6

START- UP CHILLER FROM WINTERIZE 3 10

CLEAN COIL FOR CHILLER / REPAIR LEAK 3 24

WINTERIZE COOLING TOWER 3 15.6

REPLACE CHECK VALVE 3 1

REPAIR LEAKS IN MAKE-UP LINE 3 14.3

FREEZE STAT OUT - PRE HEAT IN-OP 3 8.7

REPAIR OR REPLACE LEAKING REHEAT COIL 3 45.6

PERFORM AIR STUDY FOR AAALAC INSPECTION 3 35

REPAIR REHEAT VALVE / ROOM HOT 3 8

NO AIR FLOW AFTER HOURS CALL 3 16

A/H INOP 3 11.1

AIR HANDLER MAKING LOUD NOISE 3 50.5

COIL LEAKING WATER ALL OVER 3 42.5 Y

REPAIR LOUD VIBRATIOIN 3 52.5

AIR HANDLER DOWN {AFTER HOURS CALL} 3 4

AIR HANDLER DOWN / REPAIR COIL 3 29.3

META SYS MONITORING DOWN IN 838 3 14.6

MAINTAIN TEMPERATURE THRU STEAM OUTAGE 3 5

A/H NOT RUNNING - OUT ON FREEZE PROTECTION 3 6.5

CHECK A/H FREEZE STAT 3 4.9

REPAIR WATER LEAK ON AIR HANDLER 3 15

LOW TEMP FREEZER IN-OP 3 5.1

WALK-IN REFRIGERATOR WARM 3 14

TUNNEL WASHER LEAKING 3 7.1

WASHER IN-OP 3 9

CAGE WASHER IN-OP 3 20

TUNNEL WASHER NOT RINSING PROPERLY 3 4.7

REPLACE LEAKING SOLENIOD VALVE 3 14

LEAK ON RACK WASHER 3 4

DRAIN ON TUNNEL WASHER CLOGGED 3 18.8

TUNNEL WASHER IN-OP 3 20.5

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 2 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 2

PERFORM BACTERIA TESTING 3 2 Y

SEMI-ANNUAL SANITIZE ANIMAL WATER SYSTEM 3 4.5

REPLACE BAD PUMP R/O 3 20

GENERATOR NOT RUNNING 3 3 Y

REPAIR LEAK IN CONDENSATE LINE 3 31

REPAIR STEAM LEAK RACK WASHER 3 16

REPAIR LEAK IN HOT WATER LINE 3 18

CHILLED WATER PIPE LEAK 3 9

REPLACE CONDENSATE PUMP (MOTOR ASSEMBLY) 3 9

WATER HEATER LEAKING 3 14.5

HAVE COMM BOARDS REPLACED 3 1.5 Y

OUTSIDE FAN MOTOR BEARING DETERIORATING 3 8

REPLACE / FIX DOOR HINGE 3 16

HOT CALL 2ND FLR 3 7

PUMP MOTOR LOCKED UP, REPLACE 3 16

LEAKING VALVE, REPLACE 3 36.2

NO HEAT TO 3RD FLR 3 14.5

REPLACE FAN/MOTOR BELT FAN #2 3 3

REPLACE FAN/MOTOR BELT FAN #1 3 3

SUB-BASE - HOT CALL ROOM B-08 3 8

REPAIR BY REPLACE WATER COOLER 3 7

REPAIR BY REPLACE CIRC. MOTOR CONTRACTOR 3 21

LEAKING STEAM PIPE 3 4

REPAIR TO CONDENSATE PUMP PIPING 3 26

CONDENSATE PUMP LEAKING 3 24

AIR COMPRESSOR NEEDS HIGHER PRESSURE OUTPUT 3 4

AIR REGULATOR BROKEN 3 8

REMOVE EXHAUST FAN 3 12

STEAM LEAK IN IRON PIPING 3 26

CHILLER IN-OP TROUBLE SHOOT 3 9 Y

ROOM III HOT CALL 3 6 Y

CLEAN CONDENSER COIL 3 4

REHEAT COIL HAS CONDESATE DRIPPING 3 30

LEAK IN COIL - BAD VACUUM BREAKER 3 8

COIL LEAKING 3 32

CHECK STEAM TRAP TO SEE IF IT NEEDS REPLACING 3 5

REPLACE MOTOR / CONTACTOR - DUPLICATE - 929216 3 20

LEAKING SEAL ON PUMP- CONDENSATE PUMP 3 10 Y

REPLACE STEAM ACTUATOR 3 8.5

AHU NOT COOLING 3 16 Y

RE-HEAT COILS BUSTING 3 42.5

FREEZER ROOM HOT 3 24.8 Y

LOW AIR FLOW - REPLACE BOARD 3 6.5 Y

LOW TEMP FREEZER 3 5

PERFORM BACTERIA TESTING 3 0.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

PERFORM BACTERIA TESTING 3 1.5 Y

REMOVE HEAT COIL AND REPAIR / REPLACE PUMP 3 44

NO HEAT (NEED TO REPLACE OLD STEAM COIL) 3 32

NO RUNNING WATER IN RO SYSTEM 4 1.5

REWIRE CONTRACTOR FOR BOOSTER MOTOR 4 4

REPLACE MOTOR / PUMP COUPLING 4 1

NO HOT WATER 4 34

CRITICAL SPARE PARTS 4 0

REPAIR BY REPLACE 4 0

REPAIR BY REPLACE 4 0

CRITICAL SPARE PARTS 4 0

RO FILTERS 4 0

RO FILTERS 4 0

REPAIR BY REPLACE 4 7.5 Y

LIEBERT NOT COOLING 4 20

CHILLER OFF ON LOW TEMP ALARM 4 6

WATER CHILLER MOD 1 INOP 4 16

REBUILD CIRCULATING PUMP 4 8

LEAK IN STEAM HUMIDIFER 4 6.5

CHILLED WATER A/H NOT WORKING PROPERLY 4 5

REPAIR/REPLACE ADJUSTABLE MOTOR BASE NEEDS 4 8

REPLACEMENT LEAK DETECTION 4 0

REPLACEMENT LEAK DETECTION 4 0

NO CHILL WATER CALL 4 1.5

UNIT INOP 4 14

REPAIR AIR PIPING LEAK AT AIR COMPRESSOR 4 6

NO COMPRESSED AIR 4 6

NO AIR FROM COMPRESSOR 4 29 Y

REPLACE UNIT HEATER 4 32

AIR HANDLER OUT ON REMOTE SHUT DOWN 4 3

REPLACE THERMOSTAT ON WALL 4 5.9

ROOM HOT NO COOLING 4 2

REPLACE UNDER-FLOOR WATER ALARM CABLE 4 1.8

NO COOLING IN RM 8200 4 1

CONDENSATE PAN OVER FLOW 4 1.5

LIEBERT UNIT NOT WORKING PROPERLY 4 4

DRAIN PAN OVER FLOWING 4 2

LIEBERT UNIT DOWN 4 10

HOT CALL UNIT NOT WORKING 4 5.5

REPLACE UV LIGHTS 4 0

POWER OUTAGE CHILLER'S DOWN 4 13

HIGH TEMP ALARM 4 9.5

NO COOLING CALL CHILLER INOP 4 3

REPLACE UV LIGHTS 4 0

REPLACE UV LIGHTS 4 0

REPLACE UV LIGHTS 4 0

NEW BELT ON CONVEYOR 4 3 Y

SHREDDER IS DOWN 4 7 Y

CHANGE OIL AND PLUG 4 4

INSTALL NEW ROLLER AND TRACK BELT 4 2 Y

REPAIR/REPLACE ELECTRIC CLUTCH ON CONVERYOR 4 33 Y

REPAIR RAM & RELOCATE TANK 4 24 Y

CHANGE OIL IN COMPACTOR & HOSES 4 41

COMPACTOR NOT OPERATING 4 21

EVALUATE COMPACTOR PERFORMANCE 4 2

REPAIR DUST COLLECTOR PER INSPECTION REPORT "CRITICAL RECOMMENDATION" 4 1.5

SALT FOR SOFTNER BULK DELIVERY 4 3

SOFTENER PUTTING OUT HARD WATER 4 3.5 Y

HARD WATER 4 2.5

BULK SALT DELIVERY FOR WATER SOFTENER 4 3

HIGH WATER ALARM 4 2

AIR COMPRESSOR NOT WORKING PROPERLY 4 0

AIR DRYER NOT WORKING 4 0

REPLACE UNDER FLOOR WATER ALARM CABLE 4 1.8

CUSTOMER COLD CALL 4 1

PUMP IN-OP 4 5

RO HEATER OVER HEATING 4 21

REPLACE R.O. FILTERS 4 13

SYSTEM COMPLETELY DOWN 4 4

REPLACE R.O. FILTERS 4 16

BRAZE LEAK IN REFRIGERANT LINE 4 42.5

ALARM KEEP GOING OFF/ RAISING TEMP IN COOLER (FILM STORAGE) 4 1.5

BACK PRESSURE ALARM 4 23.5

HUMIDIFIER NOT RUNNING 4 13.5

VALVE KEAKING BY DRAIN VALVE ACTUATOR 4 4.5

STEAM TRAP SURVEY 4 1

WATER ON FLOOR OF AHU 4 2

LOSE COMM W/ SITE SCAN (OVER WEEKEND) 4 4

AIR COMPRESSOR RUNNING WHEN SHUT OFF 4 0.5

STEAM TRAP SURVEY 4 1

UNITS DOWN, NO COOLING IN SERVER ROOM 4 8

CHILLER IN-OP 4 2

NO A./C HIGH TEMP 4 1

ROOM HOT, HIGH TEMP ROOM IS 82 DEGREE ANG CLIMBING 4 4.4

REPLACE LIEBERT A/H MOTOR 4 19

CHILLER # 9 OUT ON LOW SUCT 4 2

CONTACTOR, OR OUTDOOR FAN MOTOR IN-OP 4 2

CONVEYOR BELT NOT TRACKING / SLIDING TO THE LEFT 4 0.5 Y

OUTSIDE COMPACTOR WON'T COME ON / POSSIBLE ELECTRICAL RELAY ISSUES 4 4

EVALUATE ELECTRICAL PROBLEM FOR NASIC 4 2

REPAIR DUST COLLECTOR PER INSPECTION REPORT "CRITICAL RECOMMENDATION" 4 2.5

BEARING ON BAGHOUSE WORN DOWN / EQUIP SHUT OFF, CAUSE WORK STOPPAGE 4 6.5

WATER SOFTENER LEAKING / LEAKING ON ELECTRICAL EQUIPMENT 4 2

WATER SOFTNER / TAKES 21 DROPS BEFORE WATER SOFTENS 4 1 Y

AIR COMPRESSOR NOT WORKING PROPERLY 4 3 Y

HIGH TEMP ALARM 4 2

CONDENSATE RELEASE VALVE KEEPS STICKING / CAUSES AIR TO BE EMPTIED FROM TANK 4 5

LEAKING OIL / SHUT DOWN CURRENTLY 4 4 Y

STEAM TRAP SURVEY 4 0.5

REMOVE FILTERS FROM DUMPSTER 4 1.5

REPLACE IN-LINE BOOSTER PUMP 5 15

REPAIR BEARING ASSEMBLY ON PUMP 5 38

REPLACE EXPANSION TANK 5 1

REPLACE EXPANSION TANK 5 3

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 2 Y

PERFORM BACTERIA TESTING 5 0.5 Y

SANITIZE WATERING SYSTEM 5 8

PERFORM BACTERIA TESTING 5 0

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 1 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

AIR COMPRESSOR INOP (RUNNING HOT) 5 8

SYSTEM LEAKING OIL 5 14

REMOVE AND INSTALL TEMP UNIT FOR REPAIR HYDROVANE 5 10 Y

REPLACE EXHAUST FAN MOTOR 5 4

INSTALL STERLIZER 5 16

REPAIR ELECTRIC HEAT 5 7

NO A/C 5 8

TROUBLESHOOT SPEED DRIVES & MOTORS 5 31.5

REPAIR STEAM COIL & CHECK SPEED DRIVE 5 11

INSTALL SENSAPHONE 5 13

REPLACE REFRIGERANT COMPRESSOR 5 19

REPAIR ICE MACHINE 5 14

REPLACE SYSTEM WITH NEW ICE MACHINE & RELOCATE TO RM 150 5 40

REPAIR LEAK ON R.O. SYSTEM 5 17

REPLACE PUMP CONTROLLER 5 58

SUMP NOT PUMPING OIL ALARM SOUNDING 5 19

REPLACE OIL SMART PUMP SWITCH 5 12

SUMP PUMP ALARM GOING OFF 5 12

SUMP PUMP PIT OVER PUMPS NOT PUMPING 5 8

PUMPS NOT WORKING IN SUMP PIT 5 4

CHECK ON SUMP PUMPS NOT WORKING PROPERLY 5 10

REPLACE BEARINGS 5 16

PULL PUMP & INSPECT VIBRATION 5 2

80 DEGRESS PROCESSED CHILLED WATER 5 8

REBUILD HEADS 5 20.5

ORDER SALT 5 0

CONTROLLER NOT WORKING 5 10

CONTROLS ISSUE 5 2.7 Y

TROUBLESHOOT AIR COMPRESSOR / NO AIR 5 4

MECH RM - REPLACE UNLOADER 5 11

CHECK COMPRESSOR FOR METAL & CHANGE OIL AND FILTERS 5 9.7 Y

CLEAN PLUGGED HEAT EXCHANGER 5 15

REPAIR BY REPLACE 5 0

INSTALL NEW TEMPORARY HOT WATER HEATER 5 65

REPAIR WATER LEAK 5 1

CHANGE STARTER COOLANT 5 0 Y

REPLACE FLOAT VALVE / FILL VALVE 5 6

REPLACE TRANSFORMER 5 0.3

ROOM IS COLD - NO AIR FLOW 5 8

EYE WASH STATION NEEDS TO BE LOOKED AT 5 5

NO STEAM TO HEAT EXCHANGERS 5 9

DISPLAY PANEL INOP / SYSTEM DOWN 5 8 Y

REPAIR BURNT WIRING ON HIGH FREQ FILTERS 5 0

CONTROL MOTOR 5 4

BACTERIA TESTING 5 1 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.7 Y

BACTERIA TESTING 5 0.5

BACTERIA TESTING 5 0.5 Y

1/4 INCH LINE LEAKING / SPRAYING WATER 5 4

SANITIZE RO UV UNIT 5 5

PERFORM BACTERIA TESTING 5 4.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

SANITIZE SYSTEM CHANGE RU LIGHTS 5 13.4

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5

PERFORM BACTERIA TESTING 5 0.5 Y

INSTALL STERLIZER 5 5

REPLACE 3" BALL VALVE 5 8

REPAIR STEAM COIL & CHECK SPEED DRIVE 5 40

FROZEN BUSTED COIL 5 17

REPLACE REHEAT COIL 5 6 Y

AIR HANDLER IN-OP 5 28

REMOVE REFRIGERANT 5 7.5

REMOVE REFRIGERANT 5 11.5

OIL AND FILTER CHANGE 5 4

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5

BACTERIA TESTING 5 0.5 Y

LEAKING WATER ON CONTROL PANEL 5 4.5

CHECK ON PUMPS IN SUMP / NOISES 5 8

CHECK ON SUMP PITT PUMPS 5 2

HOT WATER LEAK 5 76 Y

AFTER HOURS CALL WATER HAMMER 5 4

REPLACE BEARINGS 5 15

REPLACE CHEMICAL PUMP 5 8

REMOVE AIR LINES IN FAB SHOP 5 8 Y

INSTALL VALVE AND RE-INSULATE PIPE ON HOT WATER HEATER 5 12

CHECK ON LEAK 5 12

MECH RM - CHILLER LEAKING OIL 5 2 Y

CHILLER IN-OP 5 13

REPAIR LEAK IN FILL LINE 5 7.5

AIR HANDLER NOT RUNNING 5 4

TAKE FILTER OUT OF EACH AH / REPLCAE W/ NEW 5 1

SHUT DOWN AIR HANDLER FOR SAMPLES 5 1.5

CHECK FOR LEAK - REMOVE INSULATION 5 8

HEAT FLEX LINES NEED REPAIR 5 21

HEAT FLEX LINES NEED REPAIR 5 12

RE-WORK PIPING AT EYE WASH STATION 5 12

DISPLAY PANEL INOP / SYSTEM DOWN 5 4

NO POWER TO GENERATOR 5 5

2 HR LIFE SAFETY GENERATOR RUN 5 8 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

PERFORM BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

BACTERIA TESTING 5 0.5 Y

CHECK OUT VACUUM PUMP OPERATION 6 4.5

CURTIS AIR COMPRESSOR IS OUT ON HIGH DISCHARGE TEMPERATURE 6 13.3

RM 204 - FUME HOOD ACTUATOR INOPERABLE 6 0

2ND FL - KNOB FOR GAS IS STRIPPED OUT 6 3

FUME HOOD ACTUATOR INOPERABLE 6 2

ASSIST TRAME MECHANICAL IN REPLACING HVAC UNIT FOR THE RAIN RIG 7 10 Y

RM A115 - SUMP PUMP INOP/ REPLACEMENT NOT ORDERED 7 14.5

EQ RM - GREASE CHILLED WATER CIRC PUMP 3332 7 2

PUMP NOT WORKING 7 9.7

MECH RM - CONDENSATE LEAKING ON FLOOR 7 39

EQ RM - CONDENSATE PUMP IS LEAKING 7 9.5

EQ RM - REPLENISH SALT FOR SOFTNER 7 2

EQ RM - ORDER SALT FOR SOFTNER 7 7

EQ RM - ORDER SALT FOR SOFTNER 7 1

EQ RM - ORDER SALT FOR SOFTNER 7 8

EQ RM - COMPRESSOR SUPPORTING A/C INOP TROUBLESHOOTING & MAKE REQUIRED REPAIRS/ KAESER 7 74 Y

CLEAN UP OIL & SEE WHY OIL IS LEAKING 7 23.7

C-136 - INSTALL NEW LIGHTS IN INSTRUMENT PANEL 7 9

RM C123 & HALLWAY - REPLACE TILES THAT WERE REMOVED IN PREPARATION TOWARD MAKING WATER LEAK REPAIRS 7 8

EQ RM - RUN NEW COMPRESSED AIR PIPING TO SANDBLASTER 7 80

EQ RM - CHANGE DRIER FILTER ELEMENT 7 9

EXHAUST FAN/ RAF NEEDS BELTS CHANGED & GREASED 7 4.5

REPLACE BAD STEAM ACTUATING VALVE 7 56

EQ 2ND FL - STEAM COIL LEAK UPSTAIRS EQ RM 7 35

TROUBLESHOOT MCC PANEL 7 13

REMOVE FENCING TO GET ACCESS TO THE MCC FOR TROUBLESHOOTING 7 46.5

EQ RM - CHILLER COMPRESSOR 2ND STAGE IS BURNT OUT & NEEDS A NEW CONTACTOR 7 9

CHILLER DOWN 7 7.5

EQ RM - CHECK OUT CHILLER TO TROUBLESHOOT FAULTS 7 7

RM C136 - CHILLER COMPRESSOR NOT WORKING 7 10

MECH RM - REPAIR OR REPLACE SWITCHGEAR ON MCC FOR CHILLER 7 11.5

EQ RM - REPROGRAM CHILLERS FOR LEAD/ LAG OPERATION 7 3.5

EQ RM - CHILLER NOT RUNNING 7 10.5

EQ RM - CHILLER LEAKING OIL 7 10

MULTIPLE ROOMS ARE COLD 7 8

BLDG VERY HUMID/ AC DOESN'T APPEAR TO BE WORKING VERY WELL 7 34.5

EQ RM - BLDG HAD FIRE ALARM/ NEED TO RESET AHU 7 4

EQ RM - FRONT AREA IS 80 DEGREES 7 55.5

RM 114A - RM IS COLD 7 8

EQ RM - CHILLED WATER VALVE FAILED 7 3

RMS 228, 229 & RANGE A ARE HOT 7 5.5

HALLWAY - SUPPLY AIR DUCTWORK HAS FALLEN DOWN FROM THE CEILING/ 1ST FL HALLWAY 7 125.5

NO STEAM TO AH R/R VALVE SUPPORTS TEMP. CONTROL 2ND FL 7 4

A RANGE - AIR HANDLER COIL LEAKING, MAKE REPAIRS, SUPPORTS TEMP CONTROL 2ND FL 7 4

MEZZ - CONDENSATE LEAKING FROM OLD AHU CONDENSATE DRAIN 7 47.5

MEZZ - REPAIR STEAM LEAK ON AHU 7 40.5

RM A114 - STEAM REGULATOR NOT WORKING 7 50

CONF RM 1ST FL - NO HEAT 7 12.5

1ST FL NO COOLING 7 4

RM A114 - STEAM LEAK IN A RANGE 7 2.5

HIGH BAY - EXTEND RETURN AIR DUCT ON HI-BAY AIR HANDLER TO THE FLOOR OF HI-BAY 7 0

C123 - NO COOLING 7 11

RM C136 - RM IS HOT 7 9.5

1ST FL IS HOT PER SARGENT MORAN 7 6

CENTER AREA - AREA COLD 7 32.5

EQ RM - TOO COLD RM 228 & 229/ EQ RM 2ND FL 7 23.5

UNIT NOT RUNNING & THE 2ND FL IS VERY HOT 7 6

HALLWAY/ MAIN FL - WET CEILING TILE IN HALLWAY NEAR SOUTH ENTRANCE/ VERY WET & SAGGING 7 67

EQ RM - 2ND FL HOT 7 12.5

2ND FL - FRONT OFFICES ARE COLD (60 DEGREES) PER TERRY H. 7 7

EQ RM - STEAM LEAK ON SAFETY RELIEF 7 9.5

RM 203 - ROOMS ARE HOT 7 9

CONDENSATE PAN LEAKING IN EQ RM 7 21.8

EQ RM - EQ RM FLOODED/ STEAM LEAK 7 15.5

2ND FL - REPLACE BAD STEAM TRAPS 7 55

ROOM IS HOT 7 5.5

MECH RM - STEAM LEAK 7 3

RM A113 - STEAM VALVE EXPELLING STEAM EVERY FEW SECONDS 7 40.3

RM A114 - STEAM LEAK 7 6

2ND FLOOR STEAM LEAKING/ HISSING 7 29

A114 - WATER LEAKING FROM STEAM VALVE THAT'S OVERHEAD, INSIDE DOUBLE DOORS 7 12.6

EQ RM - STEAM TRAPS IN 2ND FL MECH RM HAMMERING 7 19.5

EQ RM - REPAIR LIGHT THRU OUT EQ RM 7 35.5

MECH RM - PERFORM INFRARED SCAN ON ALL ELECTRICAL CONNECTIONS 7 22.5

WATER LEAKING FROM HEATER 7 15

EQ RM - REPAIR PIPING BEFORE STEAM COMES ON 7 14

7 STAND - INSTALL PIPING TO HEATER 7 34.9

RM 1ST - UNIT HEATER INOPERABLE 7 8

RM 300 - UNIT NOT COOLING/ WARM IN AREA 7 16

NO AC 7 11.6

ROOF - UNIT NOT OPERATING 7 5.5

MIMMS LAB - NO HEAT OR AIR IN LAB 7 16

MIMS LAB - UNIT NOT COOLING 7 24.1

MIMMS - RM TOO COLD 7 8

2 STAND - CONDENSATE PUMP NOT OPERATING 7 10.1

2 STAND - COIL IN UNIT LEAKING ABOVE CEILING 7 24

WATER LEAK ABOVE CEILING 7 16

EQ RM - WATER LEAKING FROM 2" WATER LINE 7 16

NO HEAT IN 3 & 4 STAND 7 29

7 STAND - NO STEAM FLOW THROUGH 7 STAND 7 16

1 STAND - STRONG ODOR OF STEAM & HIGH HUMIDITY IN OFFICE/ POSSIBLE STEAM LEAK 7 8

7 STAND - STEAM LEAK IN MIDDLE BAY 7 16

1 STAND - STEAM LEAKING ON FL & CARPET 7 52

2 STAND - REPAIR STEAM MAIN ENTERING BLDG WHILE STEAM IS DOWN 7 24

REPLACE REGULATOR & PIPING 7 25.5

2 STAND - STEAM LEAKING FROM MAIN SHUT OFF VALVE 7 18.4

2ND FL - STEAM LEAK IN WALL 7 8

HI ROOF - EXHAUST FAN MAKING LOUD NOISE 7 6

HI ROOF - EXHAUST FAN INOPERABLE 7 16

HI ROOF - EXHAUST FAN INOPERABLE 7 16

EXHAUST FAN NOT WORKING 7 16

6 STAND - NO HEAT 7 15

C-BAY - CLEAN & FLUSH 15 HEAT EXCHANGERS 7 40

C BAY - CLEAN & FLUSH ALL HEAT EXCHANGERS & PIPING 7 48.5

C-BAY - REPAIR CORRODED PIPE ON HX 7 32

C BAY - REPLACE CORRODED & LEAKING PIPING ON HEAT EXCHANGER 7 31

C-BAY - CLEAN & FLUSH HX-NO FLOW 7 16

C BAY - NO FLOW THRU HX FLUSH & CLEAN STRAINERS 7 27.2

C-BAY - NO FLOW IN HEAT EXCHANGER 7 24

C-BAY - WATER LEAKING ABOVE VACUUM PUMP 7 20

NO FLOW THROUGH & HAS WATER SEPAGE ON HEAT EXCHANGER 7 21.4

CBAY - NO FLOW ON HX 7 24

EQ RMS - HEAT EXCHANGER HAS NO FLOW 7 8

C-BAY - REPAIR LEAKING PIPE TO HEAT EXCHANGER 7 16.1

NO FLOW THROUGH HEAT EXCHANGER 7 20

C-BAY - NO FLOW THROUGH THE HEAT EXCHANGER 7 32

A-BAY - REMOVE UNIT FOR REMODELING 7 24

A-BAY EXTERIOR - AC UNIT NOT FUNCTIONING 7 10

UNIT NOT COOLING 7 43.5

EQ RMS - UNIT NOT COOLING 7 12

OS/S - REPIPE ENTIRE UNIT TO ELIMINATE LEAKS & RECHARGE UNIT 7 72.3

O/S SOUTH - UNIT FREEZING UP 7 18

OS/S - TROUBLESHOOT UNIT 7 5

RM E3 - A/C COIL IS FROZEN/ ROOM NOT COOLING 7 20

UNIT NOT COOLING 7 8

RM 515 - REMOVE CONDENSATE UNIT FOR RENOVATIONS/ TO BE REINSTALLED 7 16

2ND FL - UNIT DUMPING WATER ON FLOOR & DESKS 7 8

B-BAY - WATER LEAKING ON FLOOR FROM AHU UNIT 7 8

2ND FL - STEAM FROM THE HEATER IS FILLING ROOM 7 24

2ND FL - AIR HANDLER NOT OPERATING 7 8

2ND FL - UNIT CONDENSATE PIPING LEAKING WATER ON LIGHT & FLOOR 7 27

2ND FL - UNIT FREEZING & DRAINING TO FLOOR 7 35.5

2ND FL - NOT HEAT 7 8

LHMEL-1 - BEARING ON AIR HANDLER MAKING NOISE 7 8.9

C-BAY - COIL LEAKING 7 8

LHMEL 1 - HIGH HUMIDITY POSSIBLE PE SWITCH 7 4.1

A-BAY - AC UNIT IS TRIPPING THE OVERLOAD ON KOOLQUICK CHILLER/ WORK STOPPAGE 7 28.7

2 STAND - HEAT NOT WORKING/ ELECT PROBLEM 7 24

B-BAY - NO AIR FLOW 7 8

A MEZZ - STEAM LEAK IN COIL 7 24

O/S - CLEAN & FLUSH ALL HEAT EXCHANGERS 7 34

EQ RM - CLEAN & FLUSH PIPING AFTER TOWER CLEANING 7 46

RM B-29 - RE-ROUTE WATER LINE FO RENOVATION 7 24

MENS REST ROOM - HOT WATER TANK LEAKING (SURGE TANK) 7 0.5

A-BAY - WATER LEAKING ABOVE A BAY CHAMBER 7 21

MENS RESTROOM - HOT WATER TANK LEAKING (SURGE TANK) ACCUMALATOR ABOVE THE SURGE TANK 7 8

C-BAY - WATER LEAKING ABOVE MEZZ 7 22

EQ RM - WATER LEAKING ON ELECTRIC PANEL 7 18

A-C BAY - WATER LEAK FROM 2" COPPER LINE 7 16

NO STEAM TO PORTIONS OF THE BLDG 7 24

PERFORM THERMOSCAN ON ALL ELECTRICIAL CONNECTIONS 7 18

THRU OUT - REBUILD 1 VALVE & REPLACE 1 VALVE ON THE HIGH PRESSURE NITROGEN 7 11

EQ RM - BALL VALVE CIRCULATING PUMP 3-1 IS LEAKING/ TIGHTEN UP VALUE PACKING 7 2

RM 67 - HOT WATER HEATING PUMP LEAKING AT SEAL 7 2.9

RM 67 - BASEBOARD HEAT HOT WATER PUMP STARTER SORTED OUT 7 3

EQ RM - REPLACE CONDENSATE PUMP/ BEARINGS LOCKED UP/ HAVE NEW PUMP IN HAND 7 24

RM 67 - REPIPE CHEMICAL STATION 7 16

RM 67 - REPLACE BAD FLOW METER IN CHEMICAL STATION CONTROLLER 7 2

EQ RM - REPAIR CHEMCIAL PUMP (BIOCIDE) 7 1

RM 71 - REPLACE PULSAFEEDER CHEMICAL CONTROLLER 7 3

RM 71 - RELAY #4 CHEMICAL PUMP NOT WORKING 7 0

ROOF - CHECK OUT ALL RR EXH FANS, REPAIR AS NEEDED, POSSIBLE REPLACEMENT/ UPGRADE 7 11

EQ RM - VFD DRIVE FOR FAN 3-1 FAULTED OUT, CURRENTLY DRIVE IS IN BY-PASS 7 14

EQ RM - AHU IS TRIPPED OUT ON FREEZE STAT 7 1

RM 67 - INSTALL 1/2" CONDUIT FROM COMM CLOSET TO THE NEW CHILLERS BAS CONTROLS 7 12.3

DIVERSITECH CHILLER TRAINING 7 26.5

EQ RMS - LARGE CHILLER DOWN BECAUSE LACK OF FLOW/ CALLED RIECK 7 5

EQ RM - CHILLER TRIPPED OUT ON HIGH BEARING TEMP/ CALLED TRANE TO CHECK/ UNIT UNDER WARRANTY 7 17.5

RM 67 - ASSIST WAIBEL TRANE TO PERFORM 1,000 OIL CHANGE 7 3.5

EQ RM - SWITCH FROM THE LARGE CHILLER TO THE SMALLER ONE TO GET RUN TIME 7 5

EQ RM - CHECK OUT SMALL CHILLER/ LOST CONDENSER WATER FLOW 7 12.5

SHUTDOWN COOLING TOWER & CLEAN 7 20

EQ RM - CHECK COOLING TOWER FAN & GEARBOX OUT/ NOISY 7 6

ALL LAB 7 - GATHER UP ALL OLD CHEMICALS IN 655 FOR DISPOSAL 7 16

RM 186 - OFFICE HAS CONSISTENTLY RUN IN THE HIGH 70'S TO LOW 80'S FOR THE LAST FEW WEEKS 7 2

RM 72 - OFFICE IS 64 DEGREES/ ALSO COLD LAST WEEK 7 1

R OR R 2 OUTSIDE AIR DAMPER MOTOR ON LARGE AHU 7 11.5

EQ RM - REROUTE LOW LIMITS IN LARGE AIR HANDLER TO PREVENT FALSE TRIPS IN COLD WEATHER 7 6.6

EQ RM - ATTEMPT TO REPAIR LEAKS IN HOT WATER COIL 7 6

EQ RM - SUPPLY FAN VFD DRIVE FOR FAN 3-2 KEEPS TRIPPING OUT 7 2

EQ RM - ADJUST PREHEAT CONTROLS FOR COOLER WEATHER 7 2

RM 250 - VERY COOL IN LADIES RR ON THE 2ND FL OF BLDG 651 7 2

RM 176 - NW 1ST FL HALLWAY OF 651 IS HOTTER THAN THE REST OF THE 1ST FL 7 2

RM 177 - TOO MUCH AIR GETS THROUGH VENT/ NEEDS PARTIALLY BLOCKED TO CUT DOWN AIR FLOW 7 2

EQ RM - CHECK OUT CHILLED WATER COIL IN AHU 7 53.9

EQ RM - REPAIR LIGHTING IN THE OUTSIDE AIR SECTION/ COULD BE WIRING PROBLEM 7 8.5

RMS 62, 64, 65 & 66 - NO HEAT 7 2

RM 72 - TEMP IS 60 DEGREES & HAS BEEN ALL MORNING/ NO MOVEMENT OF AIR 7 2

RM 61 - NO HEAT IN OFFICE/ NO HEAT IN RMS 62, 64, 65 & 66 7 10

RM 251 - OFFICE HAS BEEN COLD FOR SEVERAL WEEKS 7 6

RM 76 - LARGE TEMP DIFFERENCE BETWEEN 76A & 76B/ 76A TEMP IS 64 DEGREES & 76B TEMP IS 79 DEGREES 7 32

RM 242 - EXTREMELY COLD IN OFFICE/ NO HEAT FOR ABOUT A MONTH 7 6

RM 226 - CHECK THERMOSTAT IN RM 226/ COLD 7 2

RM 175 - RM TEMP IS 65 DEGREES 7 9.5

CHECK HVAC CONTROLS IN RMS 171, 190 & 259/ BEING RENOVATED BEFORE TILES GO BACK IN 7 7

RM 67 - SW CORNER MAKE UP WATER REGULATOR FOR PERIMETER HEAT EXCHANGER LEAKING 7 16

RM 75J - WATER LEAK FROM CEILING / LEAKING VAV BOX 7 1

RM 67 - REPAIR PIPING FOR THE CHILLED WATER MAKEUP/ PIPING RUSTED & LEAKING 7 72

MECH RM - DUE TO HEAVY RAINS, THE DRAINS ARE BACKING UP & DUMPING WATER ALL OVER THE FLOOR 7 1

REPLACE BAD PILOT VALVE & RELIEF VALVE 7 8

EQ RM - INSTALL ALL SHUT OFF VALVE ON THE MAIN STEAM SUPPLY TO 651/ SW CORNER 7 4 Y

RM 67 - REPLACE LEAKING CONDENSATE RETURN PIPE ON AHU 3-2 7 3

RM 67 - BRING UP THE STEAM IN ALL 65X COMPLEXES/ ADJUST PRESSURE & LEAKS 7 15

Replace all damaged & missing insulation on the piping in the ceiling to prevent future condensate 7 0 Y

RM 67 - INSULATE NEW STEAM PIPING & DAMAGED INSULATION ON TRANE AHU 7 0 Y

N Side-Replace all damaged & missing insulation on piping in ceiling to prevent future condensate 7 0 Y

RM 198 - SOUNDS LIKE SOMEONE IS SMACKING A PIPE WITH A SLEDGEHAMMER ABOUT ONCE PER MINUTE 7 2

DAILY INSPECTIONS OF MECH RMS, CHEKCING EQ OPERATIONS, LEAKS, ETC. 7 29.5

MECH RM - ASSIST REICK WITH CW PIPING PRESSURE TESTING ON NEW PIPING 7 44

DAILY INSPECTIONS OF MECHANICAL ROOMS, CHECK 7 42

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 30

65X - RESET AIR HANDLERS & EQ AFTER FIRE ALARM EVACUATION (10: 43 AM ON 5/5/14) 7 4

ALL EQ RMS - CLEAN ALL EQ RMS & CLEAN OUT HAZARDOUS MATLS (WPAFB SPRING CLEAN UP DAY 5/9/14) 7 59.5

REQUIRED CI CLASS (2 - 3:30 PM) 7 9

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 30

MANUALLY ADJUST CHILLED WATER TEMPS AT ALL AHU'S DUE TO STEAM BEING DOWN (6/1 - 6/4/) 7 17

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 38.5

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 28

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 15

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 15

THRU OUT - RESTORE WATER TO REHEAT PUMP 7 18

EQ RM - REMOVE OLD HOIST & TAKE OUT OF SERVICE/ INSTALL NEW ELECT HOIST 7 21

RM 67 - REPLACE OLD CPVC TO THE TOWER CHEMICAL INJECTION & TEST COUPON HOLDERS 7 8

RM 67 - ASSIST RIECK & CLA VALVE WITH REBUILDING THE CONDENSOR WATER VALVE TO THE CHILLERS 7 4

EQ RM - REPLACE STARTER IN MCC FOR CONDENSATE PUMP 7 6

RM 156 - GFCI UNDER AIR DRIER HAS NO POWER 7 4.6

RM 71 - RUN CONDUIT & GROUND FOR CHEMICAL CABINETS IN 651 MATERIAL ROOM 7 19.5

RM 67 - RUN CONDUIT & A 110V CIRCUIT TO CHAIN HOIST 7 0.5

EQ RM - CHECK OUT BREAKER IN RM 226 CORE (LABELED DON'T TURN ON & IT'S ON) 7 2.5

RM 67 - RUN CONDUIT & A 110 VOLT CIRCUIT TO CHAIN HOIST 7 17

EQ RM - REPLACE BAD LIGHT IN MECH RM 7 2

WHISTLING SOUND ABOVE THE CEILING THAT COMES & GOES EVERY 10 MINUTES 7 2

RM 226 - CHANGE OUT FILTERS 7 6

RM 232 - OFFICE VERY CHILLY (10 DEGREES COOLER THAN NEIGHBORING OFFICES) 7 6

RM 65 - LACK OF HEAT IN RMS 64A, 64, 65 & 66 (RM TEMP 65 DEGREES) 7 26

O/S - CLEAN OUT ACID NEUTRALIZATION PIT 7 0

2ND FL - BLDG PURGE IS NOT OPERATING 7 28.5

ROOF - CHECK OUT ALL RR EXH FANS, REPAIR AS NEEDED, POSSIBLE REPLACEMENT/ UPGRADE 7 6

RM G17 - OFFICE TEMP IS TOO COLD 7 2.5

SERVER - SEE BOB HEMMING ABOUT LEAKS ON ROOF UNIT 7 15

RM G-15 - REPAIR LEAKING STEAM PREHEAT COIL IN AHU 2-1 7 12

EQ RM - LOW LIMIT CONTROLLER IS JUMPED OUT/ BY PASSED 7 1.5

RM 121 - HOT IN OFFICE YESTERDAY & HOTTER TODAY 7 2

RM G15 - R OR R EXHAUST FAN DAMPER ACTUATOR/ SW AREA 7 7

RM 120 - FREEZING IN HERE AGAIN/ PLEASE CHECK 7 1

MECH RM - REPAIR OR REPLACE FACE BY PASS DAMPER MOTOR LARGE AHU 7 6.5

EQ RM - REROUTE LOW LIMITS IN LARGE AIR HANDLER TO PREVENT FALSE TRIPS IN COLD WEATHER 7 5.2

RM 36/37 - RM TEMP TOO COLD (FL REGISTERS HAVE INSULATION INSTALLED BLOCKING AIR FLOW) 7 5

EQ RM - ADJUST PREHEAT CONTROLS FOR COOLER WEATHER 7 2

RM G17 - OFFICE TEMP IS TOO COLD/ MUCH COLDER THAN LAB 7 2

RM 133 - ROOM IS HOT 7 2

RM 120 - COLD AGAIN 7 1

MECH RM - REPAIR OR REPLACE LIGHTS IN SMALL AHU 7 1.1

RMS 57, 58, 59 & 60 - WHOLE RXS DIVISION COMPLEX IS TOO COLD 7 8

RM 32 - OFFICES 41-46 ARE TOO HOT & THERMO IS SET TO 65 7 7.5

EQ RM - CLOGGED DRAIN 7 6.5

RM 133 - RM TOO COLD/ THERE'S A DRAFT COMING FROM ONE OF THE VENTS IN THE CEILING 7 2

EQ RM - CHILLED WATER GEARBOX IS STUCK/ NEED TO TAKE APART & GREASE 7 12

RM 147 - SERVER RM LIEBERT UNIT IS NOISY 7 2.5

SERVER - CHECK THE BELTS ON THE CW UNIT 7 8

RM 147 - ORDER & REPLACE THE WORN SHEAVES ON THE COMPUTER ROOM LIEBERT 7 10

WATER IS LEAKING INTO A CEILING TILE IN THE HALLWAY BETWEEN RM 146 & 147 7 5.8

RM 137 & 138 - IN UTILITY CORES OF 137-138 ARE 2 WHITE PVC PIPES WHICH AREN'T CONNECTED 7 1.2

RM 135 - REPLACE BROKEN GLASS DRAIN PIPE/ FL AREA N LAB CORE DOOR RM 135 7 0.3

EQ RM - AFTER HRS WORK FOR WATER LEAK/ CALLED IN BY CE, STEVE RIECHART & ALEC LEGG 7 24

RM 28 - REMOVE UNUSED PIPING IN LAB 28 7 8

RM 145 - WATER LEAKING FROM CEILING 7 7

EQ RM - STEAM LINE FEEDING THE DISTILLER UNIT IS LEAKING 7 8

RM 134 - BETWEEN 82 & 84 DEGREES IN OFFICES ON WEST SIDE OF 2ND FL/ HEAT REGISTERS ARE STILL ON 7 1

PERFORM THERMOSCAN ON ALL ELECTRICAL CONNECTIONS 7 16.5

RM G-15 - REPLACE DEFECTIVE 480V, 100AMP BUSS PLUG 7 8

RM 132 - OVERHEAD ROOM LIGHTS ARE OUT IN RMS 126 & 136 7 4

RM 120 - WARMER THAN THE HALLS OR ROOMS NEARBY 7 2

RMS 57, 58, 59 & 60 - OFFICES ARE STILL VERY COLD (60 DEGREES) 7 19

EQ RM - REPLACE BROKEN WATER SEPERATOR/ FILTER 7 4

RM G5 - CHILLY IN OFFICE 7 6

O/S - CLEAN OUT ACID NEUTRALIZATION PIT 7 0

EQ RM - CONDENSATE PUMP LEAKING 7 4.5

EQ RM - REPLACE VALVE ACTUATOR & TROUBLESHOOT HEAT EXCHANGER 7 12

EQ RM - RE-HEAT STEAM COIL LEAKING IN AC 1-2/ FURTHEST UNIT NORTH 7 83

3RD & 4TH FL HOT 7 4.8

MECH RM - REPLACE BELTS ON THE AHU RETURN AIR FAN 7 5.5

EQ RM - ROOM COLD 7 5.5

RM 109 - RM COLD/ DON'T ENTER DURING MTG 7 1

EQ RM - REPLACE BUSTED HOT DECK COIL IN AHU AC 1-2 7 31

RM 106A - OFFICE COLD/ IF POSSIBLE CLOSE OFF VENT TILE WITH A SOLID DROP CEILING TILE 7 5.5

CONFERENCE RM 208 TEMPS ARE UNSTABLE 7 18

EQ RM - R OR R HOT DECK TEMP SENSOR/ VALVE 100% OPEN TEMP READS 40 DEGREES 7 12.5

CAFÉ - RELOCATE HVAC LOUVER/ VENT AWAY FROM THE NEW PROJECTOR 7 3

RM 09A - 54 DEGREES IN OFFICE/ ONLY GETS UP TO 60 - 62F WHEN DOOR IS OPEN 7 13

EQ RM - REPAIR OR REPLACE REHEAT COIL CONTROLS 7 5.5

ROOM #2 IS HOT 7 1

EQ RM - ROOM #2 TOO HOT 7 1

EQ RM - REPAIR LEAKING PREHEAT COIL LEAKING 7 12

RM 213 - 61 DEGREES (COLD FOR THE LAST COUPLE WEEKS) 7 6

RM 323 - ADJUST TEMP TO A COOLER/ COMFORTABLE TEMP ASAP 7 2

RM 104 - OFFICE COLD/ BLOWING COLD AIR 7 2

EQ RM - TOO HOT RM 106 LONG TERM FIX NEEDED 7 15.5

EQ RM - REPAIR OA DAMPER CONTROLS 7 6

EQ RM - PREHEAT CONTROLS INOPERABLE 7 13

EQ RM - REPAIR OR REPLACE FACE & BYPASS DAMPER MOTOR 7 4

EQ RM - OUTSIDE AIR DAMPERS ARE FROZE UP & ACTUATORS ARE BAD 7 1

RM 215 - ROOM IS HOT 7 14

RM 215 - ROOM IS HOT 7 0

RM 326 - MOVE EGG CRATE AIR VENT TO ANOTHER LOCATION 7 7.5

RM 208 - CONFERENCE RM 55 DEGREES & GETTING COLDER/ REQUEST IMMEDIATE ACTION TO CORRECT 7 2

RM 403 - FREEZNG 7 2

EQ RM - TROUBLESHOOT AHU CONTROL PROBLEM 7 9

RM 213 - NO AIR FLOW IN OFFICE & OTHERS ADJACENT 7 24

CHECK THERMOSTAT IN RM 321/ SOUTH HALLWAY IS HOT 7 6

RM 323 - TEMP IN RM IS HOT (80+ DEGREES) OVER THE PAST 6 WEEKS 7 8

THRU OUT - 4TH FL COLD 7 4

RM 10B - CHECK OUT AIR HANDLER FOR PROPER OPERATION (HEAT IS NOT ON) 7 35.3

RM 010A - HAZ MAT TEMP STORAGE RM TOO HOT/ TEMP IN RM IS ABOVE 80 DEGREES 7 9

RM 010 - LOADING DOCK HEATER DRAIN LINE LEAKING ON PRESSURIZED SIDE 7 8

REPAIR LEAK IN PIPING TO UNIT HEATER 7 12

EQ RM - NEED TO ORDER & REPLACE 3" & 4" STEAM VALVE (JUNE STEAM OUTAGE) 7 42.5

EQ RM - CUT & INSTALL NEW GASKETS IN STEAM PRESSURE REDUCING STATION_33 7 59

RM 100 - REMOVE WATER & SATURATED CEILING TILES RESULTING FROM DUCT CONDENSATION 7 1

RM 100 - INSULATE EXISTING DUCTWORK IN CEILING/ CONDENSATE DRIPS ON LIGHT FIXTURES & CEILING TILES 7 0 Y

RM 11A - REPAIR CONDENSATE LEAK IN CHEMICAL RM BY BACK SHOP 7 11

RM 16 - LOUD NOISE FROM 653 EQ RM STEAM TRAP BLOWING FAILED (CALLED BY STEVE RIECHARD) 7 4

EQ RM - CONTRACT MK MOORE TO INSULATE PRESSURE REDUCING SYSTEM, AHU HW PIPING DUE TO RECENT REPAIRS 7 0 Y

RM 010 - LOADING DOCK HEATER DRAIN LINE LEAKING ON PRESSURIZED SIDE 7 5

EQ RM - STEAM SHUTDOWN DUE TO LEAK/ REQUIRES AHU & CHILLERS TO SHUTDOWN 7 14

RM 010 - LOADING DOCK HEATER ABOVE COMPUTER STORAGE AREA LEAKING HOT WATER 7 2

DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 20

65X COMPLEX - DAILY INSPECTIONS OF MECH RMS, CHECK EQ OPERATIONS, LEAKS, ETC. 7 18

DOCK AREA INSIDE - TOO COLD 7 3

SHIP/REC - REPAIR RUSTED PIPING ON UNIT HEATER IN SHIPPING AREA 7 4

CHECK OUT RAF VFD - SHOWS RUNNING/ NOT RUNNING 7 3

EQ RM-TIGHTEN ALL LOOSE CONNECTIONS & CHECK FOR HOT SPOTS WITH THERM CAMERA FOR ALL SUPPORTING ELEC 7 26

EQ RM - TROUBLESHOOT & REPAIR HOT SPOTS FOUND WITH THERMAL IMAGER 7 29

RUN CONDUIT & ADD LIGHT BY STEAM STATION 7 8.5

VARY - ENSURE COMFORT CLIMATE 7 7.5

RMS 319, 320, 321, 322, 325, 327 & 328 - HOT (85 + DEGREES) 7 3.4

MEN'S ROOM - CHECK EXHAUST FAN 7 10

ROOF - CHECK OUT ALL RR EXH FANS, REPAIR AS NEEDED, POSSIBLE REPLACEMENT/ UPGRADE 7 10

BREEZEWAY BETWEEN 653-654 DUCTING IS BLOWING INTO AREA ABOVE CEILING TILE & BLOWING OUT PANELS 7 2

RM 105 - PLEASE CLOSE AC VENT (GETTING A BIT COLD) 7 8

RMS 100, 102, 103 & 104 - OFFICES STILL HAVE COLD AIR BLOWING OUT OF THE CEILINGS 7 4

EQ RM - CWR PUMP AND/ OR MOTOR IS LOCKED UP 7 14.5

EQ RM - ALIGN CHILLED WATER PUMP COUPLING 7 16

EQ RM - CWP SEALS ARE LEAKING/ NEEDS REBUILT 7 12

EQ RM - REBUILD HOW WATER RECIRCULATING PUMP, PRIMARY & SPARE 7 97

EQ RM - PERIMETER HEAT CONTROLLER INOP (MID RM EAST WALL) 7 3.3

EQ RM - REBUILD PERIMETER PUMP AGAINST THE WALL 7 50.8

EQ RM - PUMP SEAL LEAKING/ NEEDS NEW SEAL 7 36

EQ RM - REBUILD/ REPAIR PUMP 7 41

EQ RM 23 - OVERHAUL/ REBUILD PUMP FOR SPARE 7 39.6

EQ RM - CHEMICAL STATION FEED PUMP #4 IS INOP 7 10

RM 303 - VENTILATION FAN HAS BEEN ON CONTINUOUSLY/ NOISE IS LOUD 7 4

EQ RM - REPLACE GAUGES ON CONTROL PANEL 7 1

EQ RM - OUTSIDE AIR TEMP ON HX PANEL WILL NOT RESPOND 7 10

EQ RM - REPAIR OR REPLACE HEAT EXCHANGER CONTROLS INOPERABLE 7 8

EQ RM - REPAIR OR REPLACE FAULTY HWS SUPPLY TEMP SENSOR ON HX-1 7 0.5

EQ RM - PURGE MOTOR LOCKED UP/ ACTUATOR FOR THE CONDENSOR WATER NEEDS REPAIRED (NE AREA OF EQ RM) 7 27.5

EQ RM - REPLACE BAD PURGE MODULE RELAY BOARD & REPAIR BROKEN AIR LINE 7 3.5 Y

EQ RM - TROUBLE SHOOT CHILLER #1/ PUT ON TO HELP COOL THRU BLDG 7 8

O/S - REPLACE LIGHT ON MAKE UP CONTROL BOX 7 5

SHUTDOWN COOLING TOWER & CLEAN 7 7

OUTSIDE - CLEAN UP DEBRIS AWAY FROM COOLING TOWER TO PERFORM MAS 7 30

RM 349A - AIR INLET IS VERY LOUD & COVERED WITH DUST/ PLEASE ADJUST, ADD FILTER & CLEAN 7 1

EQ RM - REPAIR FACE & BYPASS DAMPERS ON AC-3 7 5

MECH RM - VORTEX DAMPER MOTOR INOPERABLE 7 6

RM 106 - OFFICE IS STUFFY & HOT/ VERY UNCOMFORTABLE 7 22

RM 005 - OFFICE ALWAYS HOTTER THAN THE HALLWAY & OTHER OFFICES 7 6

EQ RM - SUPPLY AIR IS WEAK 7 16

RM 217 - CEILING VENT FAN IN OFFICE HAS BEEN RUNNING CONSTANTLY ALL WEEK 7 2.5

EQ RM N - DISCHARGE AIR TEMP SENSOR DOESN'T RESPOND ON TEMP CHANGES ON AC-3 7 7

EQ RM - REPAIR & REPLACE RELIEF DAMPER CONTROLS ON AHU #3 7 4

EQ RM - UNIT NOT SUPPLYING ADEQUATE AIR FLOW TO BLDG 7 28

RM 231 - CHECK OUT AHU & THERMOSTAT FOR RM 231 7 54.2

EQ RM - REPAIR OR REPLACE OA DAMPER CONTROLS ON AHU 7 8

EQ RM - REPLACE ALL AHU'S CONDENSATE PIPING 7 34

EQ RM - REPLACE THE AHU'S CONDENSATE DRAINS 7 19

RM 122 - 85 DEGREES/ PLEASE COOL DOWN 7 6

EQ RM - AHU FOR CHEMICAL STORAGE RM WILL NOT START 7 6

RM 117 - VERY WARM 81 DEGREES/ ADJUSTED THERMOSTAT & DIDN'T WORK 7 4

RM 232 - RELOCATE THERMOSTAT 7 30.5

3RD FL - ENTIRE 3RD FL IS COLD/ 65 DEGREES 7 16

RM 210 IS COLD 7 2

AIR HANDLER IS TOO LOUD & NOISY/ DIFFICULT TO CONCENTRATE 7 1

LEAK ON STEAM COIL PIPING INSIDE LARGE SOUTH AH-UNIT 7 14 Y

RM 202 - RELOCATE STAT FOR GLEN COX (SELECT TECH) 7 7

EQ RM - LARGE SOUTH AHU DOWN ON EXTERNAL FAULT/ WILL NOT START 7 8.5

R/R LIGHT IN SUPPLY FAN CHAMBER OF LARGE SOUTH AHU 7 1.5

EQ RM - CHW VALVE CONTROLS INOPERABLE ON LARGE SOUTH AHU 7 12.5

EQ RM - AIR HANDLERS DOWN BECAUSE OF A FIRE ALARM 7 2

RMS 219, 220, 339, 336, 335, 309 & 305 - NARROW DOWN HOT SPOTS 7 9.8

EQ RM - DISCHARGE AIR SENSOR IS NOT READING TEMP 7 6.5

EQ RM - PREHEAT CONTROLS INOP ON STEAM VALVE ON LARGE SOUTH AHU 7 5

RM 332 - OFFICE IS 65 DEGREES 7 1

RM 237 - OFFICE FREEZING THE PAST COUPLE OF WEEKS 7 1

RM 132 - ASSIST JOHN BLACK IN REDOING DUCTWORK TIN RM 132/ REPLACE REHEAT VAV VALVE 7 11

CHECK HVAC CONTROLS IN RMS 323 & 324/ BEING RENOVATED BEFORE TILES GO BACK IN 7 43.5

ROOMS 117 & 118 ARE VERY WARM 7 6

EQ RM - CW PIPE LEAKING NEXT TO VFD AT LARGE NORTH AHU 7 4

RM 224 - RM TEMP TOO HIGH/ CHECK HVAC OPERATION 7 13.4

EQ RM - AHU'S ALL DOWN DUE TO FIRE ALARM SYSTEM HAS THEM SHUTDOWN 7 4

EQ RM - REPAIR DISCHARGE AIR SENSOR/ READS 20 DEGREES 7 4

EQ RM - REHEAT CONTROLS ON LARGE AHU INOP 7 12

EQ RM - DRAIN PAN FOR CW COIL PLUGGED 7 51

EQ RM - ADJUST DISCHARGE AIR TEMP ON AHU 7 2

EQ RM SOUTH - ENSURE SUBSTATIONS ARE CLEAN, NOT RUNNING HOT & PROPER VENTALATION EXISTS 7 3.5

EQ RM - SUPPLY LINE TO WATER SOFTNER HAS MULTIPLE LEAKS/ EAST WALL 7 1

EQ RM - WATER PIPE FLANGE LEAK ABOVE REHEAT/ BY STAIRS 7 11

RM 148 - LEAKING GATE VALVE ON WATER PIPING IN CORE 7 1

REPAIR LEAK IN COPPER 7 20

EQ RM - NEED TO REPLACE BAD SAFETY RELIEF VALVE ON HOT WATER TANK 7 10

EQ RM - REPAIR LEAK ON THE LINE FEEDING THE WATER METER MU TO THE COOLING TOWER 7 8

EQ RM - WATER LEAK BY NORTH CHILLER OVERHEAD 7 24

EQ RM - DOMESTIC HW LINE LEAKING ABOVE LIGHT FIXTURE BETWEEN CHILLER #1 & CHW PUMPS 7 18

THRU - OUT - REPAIR WATER LEAK 7 92.5

RM 148 - WATER DRIPPING FROM CEILING IN NW CORNER BY THE POWER PANEL & RENISHAW RAMAN SPECTROMETER 7 8

EQ RM - WATER LINE LEAKING 7 7.5

EQ RM - REPAIR/ REPLACE WATER LINE FEEDING MAKE UP WATER TO THE COOLING TOWER 7 65

EQ RM - REPAIR LEAKING WATER LINE 7 11.5

EQ RM - STEAM REG FAILED & PRESSURIZED THE 30PSI WITH 120 PSI OF PRESSURE CAUSING SAFETY TO FAIL 7 28

REBUILD THE STEAM STATION PER WADE BROWER (JUNE STEAM SHUTDOWN) 7 111

WYE STRAINER IS BLOWING OUT STEAM 7 34

EQ RM - REPLACE GASKETS ON STEAM REGULATOR 7 22

RM 253 - 4-5" WET SPOT ON CEILING TILE ABOVE VERY EXPENSIVE X-RAY SCANNING EQ 7 1

EQ RM - REPAIR STEAM LEAK IN 654 7 25

EQ RM - CONTRACT MK MOORE TO INSULATE LARGE HIGH PRESSURE STEAM STATION PIPING 7 0 Y

MECH RM - SHUT DOWN STEAM & REPLACE LEAKING JOINT 7 19.8

EQ RM - CONTRACT MK MOORE TO INSULATE STEAM STATION PIPING 7 0 Y

EQ RM - THE STEAM STATION BETWEEN THE 2 LARGE AHU IS LEAKING 7 20

RM 354 - WATER LEAKING FROM CEILING 7 25

REPLACE BAD MOTOR ON HOT WATER UNIT HEATER 7 16.5 Y

RM 253 - CEILING PANEL IS WET ABOVE XRAY XTEK CT DETECTOR EQUIPMENT 7 6.5

EQ RM - CHECK OUT HOT WATER SYSTEM/ NO HW IN RR 7 49

EQ RM - HOT WATER HEATER IS NOT OPERATIONAL 7 42

RM 104 - CHECK OUT/ REPLACE ALL VAV HW VALVES & AIR VALVES 7 23

EQ RM - TOWER MAKE UP WATER LINE LEAKING BEFORE WATER METER 7 12

EQ RM - REPLACE CORRODED PIPING ON FEEDWATER PIPING TO COOLING TOWER 7 49.8

RM 23 - REPLACE LEAKING VALVE ON COUPON RACK 7 2

EQ RM - CLEAN, INSPECT & TIGHTEN ALL LOOSE CONNECTIONS ON LARGE SUPPLY FAN VFD 7 5

EQ RM - MOTOR ON BASEBOARD HEAT PUMP LOCKED UP 7 7

EQ RM - CLEAN, INSPECT & TIGHTEN ALL LOOSE CONNECTIONS ON LARGE SUPPLY FAN VFD 7 5.5

REPAIR LIGHTING THROUGHT OUT EQUIPMENT 7 6.5

EAST END OF VAULT AREA - REMOVE COMBUSTIBLE ITEMS FROM ELECTRICAL VAULT 7 8

RM 033 - ASSESS/ REPAIR RETURN AIR VENTS (AIR FLOW IS VERY LOUD & 1 VENT HAS A PIERCING WHISTLE) 7 2

RM 336 - AIR HANDLER IN OFFICE SEEMS TO BE STUCK IN THE ON POSITION & IS BLOWING COLD AIR OVER DESKS 7 6

RM 240 - REPLACE BROKEN THERMOSTAT IN HALLWAY 7 1.1

RM 350 - STRONG SMELL OF DEAD ANIMAL COMING THRU OVERHEAD VENTS 7 2

RM 115-MOVE CEILING GRATE FROM NORTH END OF THE RM TO THE SOUTH END/REPLACE N END WITH CEILING TILE 7 3

ROOF - CHECK OUT ALL RR EXH FANS, REPAIR AS NEEDED, POSSIBLE REPLACEMENT/ UPGRADE 7 6.5

HALLWAY BASEMENT NE - HIGH HUMIDITY/ ELEVATED TEMPS 7 1

RM 005 - THERMOSTAT KNOCKED OFF WALL/ LEAKING AIR VERY LOUDLY 7 5

EQ RM - TROUBLESHOOT EXHAUST FAN PNEUMATIC DAMPER CONTROLS 7 14

EQ RM - CLEAN COTTON WOOD OFF OF THE OUTSIDE AIR INTAKE LOUVERS 7 11

RM 217 - CEILING VENT FAN HAS BEEN RUNNING CONSTANTLY ALL WEEK 7 1

RM 323 - INCREASE TEMP IN LAB/ 63 DEGREES WITH 54 DEGREE AIR COMING OUT OF THE CEILING 7 4

RM 151 - RM IS VERY COLD/ CHECK THERMOSTAT 7 3.5

RMS 208 & 209 UNUSUALLY HOT 7 16

BREEZEWAY - BRIDGE COLD/ FLEX DUCT BLOWN OFF VAV BOX 7 18

EQ RM - REPAIR RE REPLACE DAMPER MOTOR FOR RELIEF DAMPER 7 4

RM 219 - DUST COMING OUT OF VENT IN OFFICE & COVERING WORK AREA & DESK 7 6

RM 224 - RM TEMP HAS INCREASED FROM 64 TO 75 DEGREES/ PLEASE REPAIR THE AC 7 7

RM 005 - ALL HEAT GOES TO THE RM NEXT DOOR & ALL COLD AIR GOES TO OUR OFFICE 7 8

RM 305 - VENT ABOVE RIGHT HAND CORNER OF DESK IS BLOWING COLD AIR & DUST IS COMING OUT OF VENT 7 6

RM 338 - OFFICE FEELS UNUSUALLY COOL (66 DEGREES) 7 1

RM 243 - NO HEAT/ COLD ON 2ND FL 7 1

RMS 303, 304, 332 & 333 - LOUD NOISE EMITTED FROM SUPPLY DUCT VENTS 7 8

RM 143 - OFFICE CHILLY (NE OFFICE TEMPS 65-67 DEGREES)/ PLEASE INCREASE TEMP 7 6

O/S - CLEAN OUT ACID NEUTRALIZATION PIT 7 0

RM 205 - OFFICE IS OVER 90 DEGREES 7 6

EQ RM - 2ND FL LARGE HW PUMP SEAL IS LEAKING 7 4.2

RM 56 - REPLACE THE 5TH HWP FOR THE…