ECUA_027500_Asbestos_Cement_Pipeline_Abandonment_and_Disposal.pdf
PDF 51 KB Posted
- Solicitation number
- PD 25-26.072
- Issued by
- Escambia County, Florida
About this file
This is a technical specifications document for the Escambia County Board of County Commissioners' CDBG-DR Olive Road Street Improvement Project - Phase I Construction (HS005), specifically addressing asbestos cement pipeline abandonment and disposal requirements. The project involves the removal and proper disposal of abandoned asbestos cement (AC) pipe and appurtenances to accommodate water main improvements along Olive Road. All cutting, handling, and disposal of asbestos cement transite pipe must be performed by a Florida-licensed Asbestos Abatement Contractor in compliance with EPA 40 CFR Part 61, OSHA regulations, and Escambia County Department of Solid Waste Management requirements. The contractor is responsible for obtaining all required permits, providing labor and materials, securing appropriate insurance, and submitting notifications to applicable regulatory agencies. At least ten working days before removal begins, the contractor or designated asbestos subcontractor must complete and deliver a National Emission Standards for Hazardous Air Pollutants (NESHAP) "Notice of Renovation or Demolition" form by hand or certified mail to the Florida Department of Environmental Protection and Escambia County Department of Solid Waste Management.
All scrap asbestos cement material must be properly manifested and transported to a landfill permitted for disposal of non-friable asbestos-containing materials, with the Escambia County Waste Services - Perdido Landfill identified as an approved facility. Non-friable asbestos disposal costs are estimated at $45.06 per ton, while friable asbestos costs are estimated at $235.47 per ton, plus a minimum vehicle fee of $11.64, with all fees subject to change without notice. Friable materials must be sprayed with water, double-bagged, labeled, and placed in covered containers, while non-friable materials must be kept wet and placed in covered containers with no visible emissions permitted. Transite pipe must be transferred directly from the trench into lined containers and labeled with the owner's name and waste generation location. Trucks transporting asbestos-containing waste must be labeled with appropriate DANGER warnings. A Waste Shipment Record (WSR) must accompany all loads to the Perdido Landfill, with a signed copy submitted to the Engineer within 35 days of shipment. The landfill requires prior approval from Ryan Cummins at (850) 490-4136, accepts typical drop-offs between 2 pm and 3 pm on Fridays, and requires 24-hour advance notice from haulers with proper manifests. Payment is accepted by Visa, MasterCard, Discover, or debit cards only.
View the file
Other files
Show all 22
On GovTribe
Work with this file
- Download the original file
- Contacts named in this file
- Similar government files
- Ask GovTribe AI about this file
Text version
Olive Road Water Main Relocation
Technical Specifications
2/4/2026
02 75 00 Asbestos Cement Pipeline Abandonment and Disposal
SECTION 02 75 00
ASBESTOS CEMENT PIPELINE ABANDONMENT AND DISPOSAL
PART 1 – GENERAL
1.01 GENERAL
A. If it is necessary to remove any abandoned Asbestos Pipe (AC) and/or appurtenances to accommodate improvements, the AC line(s) and/or appurtenances shall be removed if requested by the Owner and disposed of in accordance with this entire standard.
B. Cutting and disposal of asbestos cement pipe (transite pipe) must be performed by a Florida-licensed
Asbestos Abatement Contractor. Use of compressed air to clean transite pipes is prohibited. At no time should transite pipe or pieces be mixed in with fill.
C. Contractor must furnish all permits, labor, material, services, insurance, tools, equipment, and notifications in accordance with EPA, OSHA, State, and all other applicable agencies to handle and remove asbestos material. Specifically, refer to EPA 40 CFR Part 61 and the Escambia County
Department of Solid Waste Management.
D. All work involved in the removal, salvage or disposal of AC shall be the responsibility and at the expense of the CONTRACTOR.
E. All scrap AC shall be properly manifested and prepared for transport. The scrap material shall be delivered to a landfill permitted for disposal of non-friable asbestos containing materials.
F. Friable asbestos-containing materials are regulated as hazardous waste. A friable material is defined as material that can be crumbled, pulverized, or reduced to powder in the hand. AC water main piping is generally considered to be a non-friable material.
1. The Escambia County Waste Services - Perdido Landfill will accept friable and non-friable asbestos-containing material under the following conditions:
a. Friable Asbestos (any asbestos-containing materials that, when dry, may be crumbled, pulverized or reduced to powder by hand pressure) – * Estimated Disposal cost: $235.47/Ton
(+/-) – Contact Landfill for updated cost.
1) Asbestos must be sprayed with water until wet, then double bagged, tied off, labeled and placed in a covered container.
b. Non-friable Asbestos (any asbestos-containing materials that remain solid when handled) – *
Estimated Disposal cost: $45.06/Ton (+/-) – Contact Landfill for updated cost.
c. Estimated Minimum Fee for All Vehicles - $11.64 each (+/-)
1) Asbestos must be sprayed with water until wet, and then placed in a covered container. Transite pipe shall be kept wet during all phases of removal. No visible emissions are permitted.
2) No asbestos will be accepted without approval from Ryan Cummins at (850) 490-4136 and/or rwcummins@myescambia.com. Typical drop-off is from 2 pm to 3 pm on
Fridays.
3) Haulers must have the proper manifests and call 24 hours in advance.
4) Disposal fees are subject to change without notice.
2. At least ten working days before actual removal, the Contractor or his designated subcontractor will complete a National Emission Standards for Hazardous Air Pollutants (NESHAP) “Notice of
Renovation or Demolition” form. The contractor or his asbestos subcontractor will deliver these completed forms by hand or certified mail to the following agencies (facsimiles are not
Olive Road Water Main Relocation
Technical Specifications
2/4/2026
02 75 00 Asbestos Cement Pipeline Abandonment and Disposal permitted). Haulers must submit a completed Waste Shipment Record to the following locations:
DEPARTMENT OF ENVIRONMENTAL PROTECTION
Division of Air Resources Management
2600 Blair Stone Road
Tallahassee, FL 32399-2400
ESCAMBIA COUNTY DEPARTMENT OF SOLID WASTE MANAGEMENT
13009 Beulah Road, Cantonment, FL 32533
850-937-2160
3. Method of payment: Visa, MasterCard and Discover or a Debit Card with a bank logo on it. They do not accept cash, or business or personal checks.
4. Important notice: If asbestos is being deposited in the Perdido Landfill, a Waste Shipment Record
(WSR) must accompany the load. Submit a copy of the WSR signed by the approved disposal facility to the Engineer within 35 days of shipment.
G. All loads may be subject to inspection by Owner personnel prior to admittance to the landfill. Label each container with the name of the owner and location at which the waste was generated. Transfer pipe directly from the trench into the lined container.
H. Label trucks used to transport asbestos-containing waste material during loading and unloading as follows (refer to 29 CFR 1910.145 (d)(4) for sign format)
DANGER ASBESTOS DUST CANCER
AND LUNG DISEASE HAZARD
AUTHORIZED PERSONNEL ONLY
PART 2 – PRODUCTS (NOT USED)
PART 3 – EXECUTION (NOT USED)
END OF SECTION 02 75 00
File details come from the government source that posted it. Updated .