ATTACHMENT 17

FREIGHTLINER M2-106 DUMP TRUCK

Line Item # 2-2: Freightliner M2-106 Tandem Dump Truck

Description: New Freightliner M2-106 Tandem Dump Truck

Minimum Specifications:

Municipal License plate

Standard Equipment per manufacturer

Cummins L9 360 HP @ 2000 RPM, 2200 Gov. RPM, 1150 LB/FT @ 1200 RPM, With 2016 – 2019 onboard Diagnostics/2010 EPA/CARB/FINAL GHG21 configuration and 2008 Carb Emissions Certification – Clean Idle on lower forward corner of driver’s door

Allison 3500 RDS Automatic transmission with PTO provision LH side with push button electronic shift control, dash mounted and S5 Performance Limiting Primary/Secondary Shift Schedule, with 2200 RPM Primary/Secondary Mode Shift Speed

White cab

Opal Gray Vinyl Interior

Spare Key Set (Total of three), door locks and ignition switch keyed the same

Backup Alarm, 97 decibels

Triangle reflectors with Safety Flares

Fire Extinguisher 10 LB Dry Chemical BC Rated

Grade 8 threaded hex headed frame fasteners

Blinking lamp with each interaxle lock switch, interaxle unlock default with ignition off

(2) DTNA genuine, flooded starting, Min 2000CCA, 370RC,Threaded stud batteries

Pre-wired for lighted sight rods, no sight rods

Single battery box frame mounted LH side under cab

Positive load disconnect with cab mounted control switch mounted outboard driver seat

RH outboard under step mounted horizontal aftertreatment system assembly with RH B-pillar mounted curved vertical tailpipr

Stainless steel aftertreatment device/muffler/tailpipe shield

6 gallon diesel exhaust fluid tank mounted LH side

Dash mounted regeneration request switch

Phillips-Temro 1000 watt/115 volt block heater with receptacle mounted LH side under door

Meritor 16X5 Q+ Cast Spider Cam front brakes, double anchor, fabricated shoes

Meritor 16.5X8.92 Q Cast Spider Cam rear brakes, double anchor, fabricated shoes

Brake cams and chambers on forward side of drive axle

Front and Rear brake dust shields

Synthetic 75W-90 Front and Rear axle lube

Detroit DA-F-16.0-5 16,000# FF1 71.0 KPI/3.74 drop single front axle

16,000# Flat Leaf front suspension

MT-40-14xp 40,000# R-series tandem rear axle, 6.14 rear axle ratio

Hendrickson Haulmaax @40,000# Rear suspension

Driver controlled traction differential – both tandem rear axles

MXL 17T Meritor Extended Lube main driveline, and interaxle driveline, with half round yokes

Haldex automatic front and rear slack adjusters

Air brake package with WABCO 4S/4M ABS

Cummins exhaust brake integral with variable geometry turbo with on/off dash switch

Clear frame rails from back of cab to front rear suspension bracket, both rails outboard

Pull cables on wet tank, petcock drain valves on all other air tanks

7/16X3-9/16X11-1/8 inch steel frame 120KSI

Wheelbase setup for 14’ dump body

Three-piece 14 inch painted steel bumper with collapsible ends, spaced 3 inches forward

Front tow hooks – Frame mounted

50 gallon/189 liter rectangular aluminum fuel tank – LH side

Detroit fuel/water separator with water in fuel sensor

Michelin X Works Z 315/80R22.5 20 Ply Radial Front Tires

Michelin XDN2 11R22.5 16 Ply Radial Rear Tires

Conmet preset plus premium iron front and rear hubs

Accuride 29039 22.5X9.00 10-hub pilot 5.25 inset 5-hand steel disc front wheels

Accuride 28828 22.5X8.25 10-hub pilot 2-hand steel disc rear wheels

Air cab mounting

LH and RH exterior grab handles with single rubber insert

Hood liner, added firewall and floor heat insulation

Single 14 inch round Hadley air horn under LH deck with horn shield, single electric horn, single horn shield

LED aerodynamic marker lights

LED Headlight assembly and incandescent turn lamp

Daytime running lights with rocker/toggle momentary interrupter switch

Integral LED stop/tail/backup lights

Dual West Coast bright finish heated mirrors with LH and RH remote w/LH and RH 8 inch bright finish convex mirrors mounted under primary mirrors and RH down view mirror, door mounted

LH and RH Bright finish cross view compliant hood mounted convex mirrors with swing arm mounting, Freightliner part numbers VEL 713753 and VEL 714138.

RH aftertreatment system cab access with plain diamond plate cover with dual level cab entry steps on both sides

RH and LH electric powered windows, passenger switches on door(s)

2 gallon windshield washer reservoir without fluid level indicator, frame mounted

Dash mounted ash trays and lighter

(2) Cup holders LH and RH dash

Forward roof mounted console with upper storage compartments and additional center compartment without netting

Smart Switch expansion module

(1) 12 Volt power supply in dash

Basic High Back air suspension driver seat with mechanical lumbar and integrated cushion extension

Vinyl with vinyl insert driver and passenger seat

Inboard driver seat armrest, no passenger seat armrest

LH and RH integral door panel armrests

High visibility orange seat belts

Adjustable tilt and telescoping steering column, 18 inch 4-spoke steering wheel

Standard HVAC ducting with snow shield for fresh air intake

Standard plumbing with ball shutoff valves and insulated lines

Heater, defroster and Air Conditioner with Valeo heavy duty A/C refrigerant compressor

Premium insulation

Dome door activated LH and RH, dual reading lights, forward cab roof

LH and RH electric door locks

2 man tool box mid back non suspension passenger seat

Dash mounted AM/FM/WB World tuner radio with Bluetooth for phone and USB and Auxiliary inputs, J1939 and with (2) radio speakers

Four on/off rocker switches in the dash with indicator lights and wire routed to chassis at back of cab, label opt mounted together in dash

Self canceling turn signal switch with dimmer, washer/wiper and hazard in handle

Vehicle interface wiring connector with blunt cuts, at back of cab

Electronic Transmission customer access connector firewall mounted

Primary Connector/Receptacle wired for combination stop/turn, center pin powered through ignition with stop signal prewire package for electric brake trailer

SAE J560 7-way primary trailer cable receptacle mounted end of frame

Air powered on/off engine fan clutch

Transmission oil check and fill with electronic oil level check

U.S. FMVSS Certification

Dump body up-fit:

Body

Hardox Body

FMT CS130-5.5-3 DA Hoist

Body length 14’0”

Inside width 87”

Outside width 96”

Side height 42”

Side material 1/8” HDX

Front material 1/8” HDX

Box top top and gate rail

Dirt-shredder rubrail

1/4” HDX floor

Full length fender flares connected to front shield and rear flaps

Cove (Radius)

Formed longitudinals

Cab shield 24” ½ roll

Roll style 5” STD style

Gate height 48”

Gate material 3/16” HDX, single panel formed gate

Gate panels (1)

H.D. offset top hardware

Elec/air gate release

Coal door (1) 16”

Double coal door linkage

Straight skirt w/no lights

Formed sidewalls

Flat tarp rail

Mud flaps

Stone shields

Safety prop (2)

Min. roll-cab clearance 4”

Inside Radius corner

TG chains and hardware

Aero tarper with tension arm (Mount tarp arms as tight as possible to sides of body)

Mount tool box curbside

Pintle height 26” to center

2” Combo hook, ¾” plate

Chains to be 36” longer than tailgate, omit top chain loop

Tail chain covers

Full length grab handle

Shovel bracket spring type S/S mounted left front

Install special body props

Heatable body heating and spring box kit with manual box (Body shall heat floor, sidewall, front and rear post, bulkhead

Lighted guide poles on front bumper

Hydraulics

PTO gear pump

Sectional valve – cable

Double-acting hoist

Custom Console

Sq. alum. oil tank

Hotshift direct mount pump

Cab controls as required

Hydraulics filter 2/send unit, sight/temp gauge + drain plug

Muncie

Electrical

6 Pin trailer plug

LED Clearance lights

Body-up light

Rear post LED strobes 6” oval, amber

Rear post LED stop/turn/tail 6” oval

Front & side cab shield lighting oval LED strobes, amber

Rear vision camera, quad screen with single camera, mount in rear skirt w/protective shield

Backup sensors

4 Axle proportional brake controller, digital

Alum. Tool box 18”X18”X30”

3 – step slide-out ladder, left front

Two steps mounted front DS above slideout ladder

Grab handle (1)

Wood side boards (10)

Electric asphalt tarp

Hooks for mud flap mounted on rear skirt