Damage Control and Firefightng Equip Layout.pdf

TECHNICAL MANUAL

FOR

[SGML VERSION; SEE RECORD OF

REVISIONS ]

DAMAGE CONTROL AND

FIREFIGHTING

EQUIPMENT LAYOUT

BOOK

DISTRIBUTION STATEMENT B: DISTRIBUTION AUTHORIZED TO U.S. GOVERNMENT

AGENCIES ONLY; ADMINISTRATIVE OR OPERATIONAL USE; 16 OCT 2007. OTHER

REQUESTS FOR THIS DOCUMENT SHALL BE REFERRED TO THE NAVAL SEA SYS-

TEMS COMMAND (SEA-09T).

WARNING: THIS DOCUMENT CONTAINS TECHNICAL DATA WHOSE EXPORT IS

RESTRICTED BY THE ARMS EXPORT CONTROL ACT (TITLE 22, U.S.C. SEC 2751, ET

SEQ.) OR THE EXPORT ADMINISTRATION ACT OF 1979, AS AMENDED, TITLE 50,

U.S.C., APP 2401 ET SEQ. VIOLATIONS OF THESE EXPORT LAWS ARE SUBJECT TO

SEVERE CRIMINAL PENALTIES. DISSEMINATE IN ACCORDANCE WITH PROVISIONS

OF DOD DIRECTIVE 5230.25(D).

DESTRUCTION NOTICE: DESTROY BY ANY METHOD THAT WILL PREVENT DISCLO-

SURE OF CONTENTS OR RECONSTRUCTION OF THIS DOCUMENT.

THIS PUBLICATION SUPERSEDES SS100-AG-MAN-010, DATED 1 NOV 1995 AND ALL

CHANGES THERETO.

SS100-AG-MAN-010

0910-LP-106-9842 REVISION 1

TITLE-1 / (TITLE-2 Blank)@@FIpgtype@@TITLE@@!FIpgtype@@ @@FIpgtype@@TITLE@@!FIpgtype@@

PUBLISHED BY DIRECTION OF COMMANDER, NAVAL SEA SYSTEMS COMMAND

16 OCT 2007

TITLE-2

@@FIpgtype@@BLANK@@!FIpgtype@@

RECORD OF REVISIONS

REVISION

NO. DATE TITLE AND/OR BRIEF DESCRIPTION/PREPARING ACTIVITY

1 16 OCTOBER

REVISION 1 IS DOCUMENTED FOR THE CONVERSION TO ELECTRONIC

TECHNICAL MANUAL.

NOTE

THIS TECHNICAL MANUAL (TM) HAS BEEN DEVELOPED FROM AN INTELLIGENT ELECTRONIC

SOURCE KNOWN AS STANDARD GENERALIZED MARKUP LANGUAGE (SGML). THERE IS NO LOEP.

ALL CHANGES, IF APPLICABLE, ARE INCLUDED. THE PAGINATION IN THIS TM WILL NOT MATCH THE PAGINATION OF THE ORIGINAL PAPER TM; HOWEVER, THE CONTENT IS EXACTLY THE SAME.

ANY CHANGES RECEIVED AFTER RECEIPT OF THIS TM WILL ONLY FIT IN THIS PAGINATED VERSION.

SS100-AG-MAN-010

RECORD OF REVISIONS-1 / (RECORD OF REVISIONS-2 Blank)

RECORD OF REVISIONS-2

FOREWORD

This Damage Control/Firefighting Equipment Layout Book was prepared by the Naval Sea Systems Com-mand at the request of damage control fleet personnel to improve the knowledge of the shipboard damage con-trol organization in damage control/firefighting equipment layout and usage.

The illustrated layouts in this booklet quickly convey the ways to rapidly set up equipment for the func-tions of access, dewatering, desmoking, shoring, hull repair, pipe patching, personnel protection, and firefighting.

The layouts presented in this book provide shipboard repair party personnel with effective ways of utiliz-ing damage control repair station equipment when combating casualties involving flooding, smoke, and fire.

This book can be used to assist shipboard personnel in training or in actual emergencies to identify equip-ment setups. The included sketches will illustrate the equipment’s intended use so that repair party personnel can gather the proper equipment and arrange the layout as required.

The Damage Control/Firefighting Equipment Layout Book is dedicated with appreciation to all the per-sonnel who have assisted in research, testing, validating and allowing us to draw on their years of fleet experi-ence and knowledge.

Recommendations for improvements and additional sketches to this document are welcome. Please for-ward comments or suggestions related to this book using the form in the back to:

Commander, Naval Sea Systems Command

Hank Kuzma (03G1)

2531 Jefferson Davis Hwy

Arlington, VA 22242-5160

Commercial phone: (703) 602-9295, ext 221

DSN 332-9295, ext 221

FAX (703) 602-3118

Ships, training activities, supply points, depots, Naval Shipyards and Supervisors of Shipbuilding are requested to arrange for the maximum practical use and evaluation of NAVSEA technical manuals. All errors, omissions, discrepancies and suggestions for improvement to NAVSEA technical manuals shall be forwarded to:

COMMANDER,

CODE 310 TMDER, BLDG 1388

NAVSURFWARCENDIV NSDSA

4363 MISSILE WAY

PORT HUENEME CA 93043-4307

on NAVSEA/SPAWAR Technical Manual Deficiency/Evaluation Report (TMDER), NAVSEA form 4160/1. All feedback comments shall be thoroughly investigated and originators will be advised of action resulting therefrom.

One copy of NAVSEA form 4160/1 is at the end of each separately bound technical manual 8-1/2 x 11 inches or larger. Copies of NAVSEA form 4160/1 may be requisitioned from the Naval Systems Data Support Activity Code 310 at the above address. Users are encouraged to transmit deficiency submittals via the Naval Systems Data Support Activity web site located at:

https://nsdsa2.phdnswc.navy.mil/tmder/tmder-generate.asp?lvl=1

FOREWORD-1

FOREWORD - Continued

Individual electronic TMs do not contain NAVSEA form 4160/1 but are linked to an electronic version on the resident CD-ROM. Therefore, we encourage the user to transmit deficiency submittals via the Naval Systems Data Support Activity web site located above.

FOREWORD-2

TABLE OF CONTENTS

Chapter/Paragraph Page

1 ACCESS EVOLUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1

2 CASUALTY POWER SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1

3 DESMOKING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

4 DEWATERING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

5 EMERGENCY COMMUNICATIONS EVOLUTIONS . . . . . . . . . . . . . . . 5-1

6 EMERGENCY LIGHTING EVOLUTIONS . . . . . . . . . . . . . . . . . . . . . 6-1

7 FIREHOSES/FITTINGS EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . 7-1

8 FIREFIGHTING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1

9 NAVAL FIREFIGHTERS’ THERMAL IMAGER . . . . . . . . . . . . . . . . . . 9-1

10 PATCHING/PLUGGING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . 10-1

11 PIPE PATCHING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-1

12 REPAIR PARTY PERSONNEL PROTECTIVE CLOTHING . . . . . . . . . . . 12-1

13 SHORING EVOLUTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-1

14 SYSTEM RESTORE/RECONFIGURE EVOLUTION . . . . . . . . . . . . . . . 14-1

15 COMPLEX DAMAGE CONTROL EVOLUTION . . . . . . . . . . . . . . . . . . 15-1

i

LIST OF TABLES

Table Title Page ii

LIST OF ILLUSTRATIONS

Figure Title Page

1-1. Portable Exothermic Cutting Unit (PECU) Equipment . . . . . . . . . . . . . . . . . 1-2

1-2. Portable Exothermic Cutting Unit (PECU) - Gaining Access to Damaged Compartments Using PECU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3

1-3. Portable Hydraulic Access and Rescue System (PHARS) Equipment . . . . . . . . . 1-4

1-4. Portable Hydraulic Access and Rescue System (PHARS) . . . . . . . . . . . . . . . 1-5

1-5. Portable Hydraulic Access and Rescue System (PHARS) . . . . . . . . . . . . . . . 1-6

1-6. PHARS - Gaining Access through Watertight Door with Hydraulic Spreader . . . . . 1-7

1-7. Portable Hydraulic Access and Rescue System (PHARS) . . . . . . . . . . . . . . . 1-8

1-8. Rescue and Patient Transportation Devices . . . . . . . . . . . . . . . . . . . . . . . 1-9

1-9. One Man Moving A Casualty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-10

1-10. Two-Man Carries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-11

1-11. Cardiopulmonary Resuscitation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12

1-12. Preparing a Victim for Helicopter Evacuation . . . . . . . . . . . . . . . . . . . . . . 1-13

1-13. Example of Hoisting Equipment Using a Bowline and a Clove Hitch . . . . . . . . . 1-14

1-14. Bowline Knot - A Good Knot for Forming a Loop That Will Not Slip Under Strain and It May Be Easily Untied . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-15

1-15. Clove Hitch Knot - Used for Attaching a Rope to an Object Such as a Pole, Post, or Hose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-16

1-16. Clove Hitch - Tying the Clove Hitch around an Object . . . . . . . . . . . . . . . . . 1-17

1-17. Becket or Sheet Bend Knot - Used for Joining Two Ropes (Well-Suited for Joining Ropes of Unequal Diameters) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-18

1-18. Water Knot - Used for Joining Two Strips of Canvas or Rope . . . . . . . . . . . . . 1-19

1-19. Mariners Knot - a Knot System That Can Be Released under Load . . . . . . . . . . 1-20

2-1. Bulkhead Terminal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2

2-2. Supply Power to Equipment Designated to Receive Casualty Power . . . . . . . . . 2-3

2-3. Casualty Power Run . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4

3-1. Desmoking Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2

3-2. Smoke Curtain Set-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3

3-3. Smoke Blanket Set-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 iii

LIST OF ILLUSTRATIONS - Continued

3-4. Using Box Fan(s) Set in Watertight Door With Smoke Curtain . . . . . . . . . . . . 3-5

3-5. Using Box Fan Hung Across Watertight Door With Smoke Curtain . . . . . . . . . . 3-6

3-6. Using Two Fans Hung From Top of Watertight Door with Smoke Curtain . . . . . . 3-7

3-7. Optimum Placement of Desmoking Fans from Door (Seal Door Using Fan’s Air) . . 3-8

3-8. Desmoking with Water Driven Fan Placed Adjacent to Smoke Filled Compartment . 3-9

3-9. Using Water Driven Fan Placed Adjacent to Smoke Filled Compartment and Vent Duct Exhausting through Scuttle to Weather Deck . . . . . . . . . . . . . . . . . . 3-10

3-10. Desmoking with Water Driven Fan Placed Adjacent to Smoke Filled Compartment . 3-11

3-11. Using Water Driven Fan Placed on Weather Deck or Below Adjacent to Smoked Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12

3-12. Using Red Devil Blower Placed on Weather Deck or Below Adjacent to Smoked Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13

3-13. Using Water Driven Fan To Desmoke Compartment with Box Fan on Scuttle . . . . 3-14

3-14. Using Water Driven Fan To Desmoke Compartment with Box Fan on Hatch . . . . 3-15

3-15. Using Red Devil Blower Placed on Weather Deck . . . . . . . . . . . . . . . . . . . 3-16

3-16. Showing Portable Suction Duct Through the Smoke Curtain Located in Door Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-17

3-17. Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P250 Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18

3-18. Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P100 Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19

3-19. Using Electric Subpump Supplying Water to Water Driven Fan and to 1-1/2″ Firehose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-20

3-20. Negative Pressure Ventilation Explanation . . . . . . . . . . . . . . . . . . . . . . . . 3-21

3-21. Using Combinations of Box Fans in Negative Pressure (Sheet 1 of 2) . . . . . . . . 3-22

3-21. Using Combinations of Box Fans in Negative Pressure (Sheet 2 of 2) . . . . . . . . 3-23

3-22. Desmoking Passageway Through Vent Trunk Using Box Fans in Negative Pressure . 3-24

4-1. Dewatering Equipment (Sheet 1 of 3) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2

4-1. Dewatering Equipment (Sheet 2 of 3) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3

4-1. Dewatering Equipment (Sheet 3 of 3) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 iv

4-2. Using 1-1/2″ Eductor with or without Strainer . . . . . . . . . . . . . . . . . . . . . 4-5

4-3. Using 2-1/2″ Eductor or Peri Jet with or without Foot Valve Actuating from 2-1/2″ Fireplug or P100 or P250 Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6

4-4. Suction Lifts Under 20 Feet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7

4-5. Suction Lifts Under 20 Feet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8

4-6. Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet . . . . . . . . . . . 4-9

4-7. Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet . . . . . . . . . . . 4-10

4-8. Using P250 Pump and Eductor Pumping Contaminated Space . . . . . . . . . . . . . 4-11

4-9. Using P100 Pump and Eductor Pumping Contaminated Space . . . . . . . . . . . . . 4-12

4-10. Using 1-1/2″ Eductor Connected to a Standpipe . . . . . . . . . . . . . . . . . . . . . 4-13

4-11. Using Peri Jet Eductor and 1-1/2″ Fireplug . . . . . . . . . . . . . . . . . . . . . . . 4-14

4-12. Using P100 to Actuate Both the 1-1/2″ Eductor and the Foot Valve Strainer . . . . . 4-15

4-13. Using Both Peri Jet Eductor and 1-1/2″ Eductor . . . . . . . . . . . . . . . . . . . . 4-16

4-14. Using Peri Jet Eductor Supplied by 2-1/2″ and 1-1/2″ Hoses (Increased Capacity 20%) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17

4-15. 20 Foot Suction Lift Using Three P100 Pumps in Tandem . . . . . . . . . . . . . . . 4-18

4-16. Using Darley Pump and 1-1/2″ Eductor . . . . . . . . . . . . . . . . . . . . . . . . . 4-19

4-17. Using Submersible Pumps Single or in Tandem . . . . . . . . . . . . . . . . . . . . . 4-20

4-18. Using Submersible Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-21

4-19. Using Electric Subpump to Provide Actuating Water to Peri Jet Eductor . . . . . . . 4-22

7-1. Operating Positions for Navy 1-1/2″ Vari-Nozzles . . . . . . . . . . . . . . . . . . . 7-2

7-2. Using Nozzle Tip and Applicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3

7-3. Operating Positions for Navy All-Purpose 1-1/2″ Nozzles Used at High Velocity . . 7-4

7-4. Navy All-Purpose 1-1/2″ Nozzles with Applicators . . . . . . . . . . . . . . . . . . . 7-5

7-5. Spanner Wrenches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6

7-6. Preparing Firehose for Stowage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7

7-7. Replacing Ruptured Fire Hose Using 2-1/2″ Hose Clamp . . . . . . . . . . . . . . . 7-8

8-1. Using Portable AFFF (In-Line) Eductor/Firemain . . . . . . . . . . . . . . . . . . . . 8-2 v

8-2. Using NAP Nozzle and 4 Foot Applicator . . . . . . . . . . . . . . . . . . . . . . . . 8-3

8-3. Using P250 Pump and In-Line Eductor . . . . . . . . . . . . . . . . . . . . . . . . . 8-4

8-4. Using P100 Pump and In-Line Eductor . . . . . . . . . . . . . . . . . . . . . . . . . 8-5

8-5. Using P250 Pump and Various Applicators . . . . . . . . . . . . . . . . . . . . . . . 8-6

8-6. Using P100 Pump and A 4 FT’ Applicator . . . . . . . . . . . . . . . . . . . . . . . . 8-7

8-7. Using P250 Pump Taking Suction from Overboard or Flooded Compartment . . . . 8-8

8-8. Using P100 Pump Taking Suction from Overboard or Flooded Compartment . . . . 8-9

8-9. Replacing Ruptured Firehose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10

8-10. Vertical Trunk Hose Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-11

8-11. Using Portable AFFF (In-Line) Eductor . . . . . . . . . . . . . . . . . . . . . . . . . 8-12

8-12. Hose Line and Nozzle Handling Methods (Sheet 1 of 2) . . . . . . . . . . . . . . . . 8-13

8-12. Hose Line and Nozzle Handling Methods (Sheet 2 of 2) . . . . . . . . . . . . . . . . 8-14

8-13. Fire Attack - Direct Attack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-15

8-14. Fire Attack - Attack from an Access . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-16

8-15. Fire Attack - Direct Attack with Vent to Weather . . . . . . . . . . . . . . . . . . . . 8-17

8-16. Indirect Attack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-18

8-17. Indirect Attack with Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-19

9-1. Allowing Sight through Dense Smoke and Light Steam to Locate Seat of Fire, in Overhaul Operations and for Search and Rescue of Personnel . . . . . . . . . . . 9-2

9-2. Typical Operating Scenario . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-3

10-1. Use of Wooden Plugs and Wedges in Filling Holes . . . . . . . . . . . . . . . . . . . 10-2

10-2. Plugging with Mattresses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-3

10-3. Box Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-4

10-4. Hinged Plate Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-5

10-5. Securing Patch with Hook Bolts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-6

10-6. Folding T-Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-7

10-7. Plate Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-8 vi

10-8. Bucket Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-9

10-9. Patching and Sealing Crack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-10

10-10. Caulking Thin Plating and Torn Seams . . . . . . . . . . . . . . . . . . . . . . . . . . 10-11

10-11. Cloth Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-12

10-12. Emergency Leak Plugging Using Flange Clamp . . . . . . . . . . . . . . . . . . . . . 10-13

11-1. Pipe Patching Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-2

11-2. Band-It Patch Isolated Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-3

11-3. Band-It Patch on Pressurized Pipe (Sheet 1 of 2) . . . . . . . . . . . . . . . . . . . . 11-4

11-3. Band-It Patch on Pressurized Pipe (Sheet 2 of 2) . . . . . . . . . . . . . . . . . . . . 11-5

11-4. Metal Banding Procedures for Band-It Patch (Sheet 1 of 2) . . . . . . . . . . . . . . 11-6

11-4. Metal Banding Procedures for Band-It Patch (Sheet 2 of 2) . . . . . . . . . . . . . . 11-7

11-5. Emergency Water Activated Repair Patch (EWARP) . . . . . . . . . . . . . . . . . . 11-8

11-6. Jubilee Pipe Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-9

11-7. Soft Patch on Low-Pressure Pipe Line . . . . . . . . . . . . . . . . . . . . . . . . . . 11-10

11-8. Clamp Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-11

11-9. Flange Pipe Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-12

11-10. Simple Pipe Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-13

11-11. Elbow Pipe Patch Using Plastic Pipe Patching Kit . . . . . . . . . . . . . . . . . . . 11-14

11-12. Severed Pipe Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-15

11-13. Compound Pipe Patch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-16

12-1. Firefighter’s Ensemble and Oxygen Breathing Apparatus (OBA) . . . . . . . . . . . 12-2

12-2. Repair Party Outfit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-3

12-3. Aircraft Fire Fighting and Chemical, Biological & Radiological (CBR) Protective Clothing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-4

13-1. Measuring Length and Angle of Shore Using Measuring Batten . . . . . . . . . . . . 13-2

13-2. Measuring and Cutting Shores Using Folding Rule or Steel Tape and Carpenter’s Square . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-3

13-3. I-Type Shoring Using 3-5 Ft. or 6-11 Ft. Metal Shore . . . . . . . . . . . . . . . . . 13-4 vii

13-4. I and K-Type Shoring Using Wooden and Adjustable 6-11 Ft. Metal Shores . . . . . 13-5

13-5. I and K-Type Shoring Using Adjustable 3-5 Ft and 6-11 Ft Metal Shores . . . . . . 13-6

13-6. I-Type Shoring as Erected in Passage on USS SAMUEL B. ROBERTS (FFG 58) . . 13-7

13-7. Shoring Split Seam After Bulkhead of Auxiliary Machinery Room on USS SAMUEL B. ROBERTS (FFG 58) . . . . . . . . . . . . . . . . . . . . . . . . . . 13-8

13-8. K-Type Shoring Forward Bulkhead in CMBD SPLY DEPT STRM Room USS SAMUEL B. ROBERTS (FFG 58) . . . . . . . . . . . . . . . . . . . . . . . . . . 13-9

13-9. H-Type Shoring with Wooden Shores . . . . . . . . . . . . . . . . . . . . . . . . . . 13-10

13-10. I-Type Shoring Using Wooden Shore to Support Sagging Overhead . . . . . . . . . . 13-11

13-11. I-Type Shoring Using Multiple Combination of 6-11 Ft. Metal Shores and Wooden Shore to Support Overhead Deck or Load . . . . . . . . . . . . . . . . . . . . . . 13-12

13-12. I-Type Shoring on Watertight Door Using Wooden Shores . . . . . . . . . . . . . . . 13-13

13-13. I-Type Shoring on Watertight Door Using Metal Shores . . . . . . . . . . . . . . . . 13-14

13-14. I-Type Shoring on Hatch with Scuttle Using Wooden Shores . . . . . . . . . . . . . 13-15

13-15. I-Type Shoring on Hatch with Scuttle Using Metal Shores . . . . . . . . . . . . . . . 13-16

13-16. K-Type Shoring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-17

13-17. K-Type Shoring on Watertight Door Using Wooden Shores . . . . . . . . . . . . . . 13-18

13-18. K-Type Shoring on Watertight Door Using Metal Shores . . . . . . . . . . . . . . . . 13-19

13-19. Distributing Bulkhead Pressure over Stiffeners with K-Type Shoring (Using Wooden or/and Metal Shores) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-20

13-20. Compound Shoring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-21

13-21. Shoring from Bulkhead to Hatch and Providing Support for Weakened Overhead . . 13-22

13-22. General Rules for Shoring Against Horizontal Pressure . . . . . . . . . . . . . . . . . 13-23

13-23. General Rules for Setting Correct Shoring Angles . . . . . . . . . . . . . . . . . . . 13-24

13-24. Strengthening Shores . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-25

14-1. Providing Temporary Firemain Service Using Firehose Bypassing Damaged Firemain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-2

14-2. Providing Temporary Firemain Service by Hose Jumping at Flanges . . . . . . . . . 14-3

15-1. Dewatering and Desmoking Using Electric Sub Pump Discharge Actuating Water Driven Fan and 1-1/2″ Eductor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-2 viii

15-2. Dewatering and Desmoking Using Water Driven Fan and P250 Pump Taking Suction from Flooded Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . 15-3

15-3. Dewatering and Desmoking Using Water Driven Fan and P100 Pump Taking Suction from Flooded Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . 15-4 ix / (x Blank) x

CHAPTER 1

ACCESS EVOLUTIONS

FIGURE NO. TITLE OF SKETCH

1-1 Portable Exothermic Cutting Unit (PECU) Equipment - Arcair 1-2 Portable Exothermic Cutting Unit (PECU) - Gaining Access to Damaged Compartments Using PECU 1-3 Portable Hydraulic Access and Rescue System (PHARS) - Hurst Equipment 1-4 Portable Hydraulic Access and Rescue System (PHARS) 1-5 Portable Hydraulic Access and Rescue System (PHARS) 1-6 PHARS - Gaining Access through Watertight Door with Hydraulic Spreader 1-7 Portable Hydraulic Access and Rescue System (PHARS) - Use of Hydraulic Cutter and Extension Ram 1-8 Rescue and Patient Transportation Devices 1-9 One Man Moving a Casualty 1-10 Two-Man Carries 1-11 Cardiopulmonary Resuscitation 1-12 Preparing a Victim for Helicopter Evacuation 1-13 Example of Hoisting Equipment Using a Bowline and a Clove Hitch 1-14 Bowline Knot - A good Knot for Forming a Loop That Will Not Slip Under Strain and It May Be Eas-ily Untied 1-15 Clove Hitch Knot - Used for Attaching a Rope to an Object Such as a Pole, Post or Hose 1-16 Clove Hitch - Tying the Clove Hitch around an Object 1-17 Becket or Sheet Bend Knot - Used for Joining Two Ropes (Well-Suited for Joining Ropes of Unequal

Diameters) 1-18 Water Knot - Used for Joining Two Strips of Canvas or Rope 1-19 Mariners Knot - a Knot System That Can Be Released under Load

1.

1-1

1.

Figure 1-1. Portable Exothermic Cutting Unit (PECU) Equipment

SS100-A

G

-M A

N -010

1-2

Figure 1-2. Portable Exothermic Cutting Unit (PECU) - Gaining Access to Damaged Compartments Using PECU

SS100-A

G

-M A

N

1-3

Figure 1-3. Portable Hydraulic Access and Rescue System (PHARS) Equipment

SS100-A

G

-M A

N

1-4

Figure 1-4. Portable Hydraulic Access and Rescue System (PHARS)

SS100-A

G

-M A

N

1-5

Figure 1-5. Portable Hydraulic Access and Rescue System (PHARS)

SS100-A

G

-M A

N

1-6

Figure 1-6. PHARS - Gaining Access through Watertight Door with Hydraulic Spreader

SS100-A

G

-M A

N

1-7

Figure 1-7. Portable Hydraulic Access and Rescue System (PHARS)

SS100-A

G

-M A

N

1-8

Figure 1-8. Rescue and Patient Transportation Devices

SS100-A

G

-M A

N

1-9

Figure 1-9. One Man Moving A Casualty

SS100-A

G

-M A

N

1-10

Figure 1-10. Two-Man Carries

SS100-A

G

-M A

N

1-11

Figure 1-11. Cardiopulmonary Resuscitation

SS100-A

G

-M A

N

1-12

Figure 1-12. Preparing a Victim for Helicopter Evacuation

SS100-A

G

-M A

N

1-13

Figure 1-13. Example of Hoisting Equipment Using a Bowline and a Clove Hitch

SS100-A

G

-M A

N

1-14

Figure 1-14. Bowline Knot - A Good Knot for Forming a Loop That Will Not Slip Under Strain and It May Be Easily Untied

SS100-A

G

-M A

N

1-15

Figure 1-15. Clove Hitch Knot - Used for Attaching a Rope to an Object Such as a Pole, Post, or Hose

SS100-A

G

-M A

N

1-16

Figure 1-16. Clove Hitch - Tying the Clove Hitch around an Object

SS100-A

G

-M A

N

1-17

Figure 1-17. Becket or Sheet Bend Knot - Used for Joining Two Ropes (Well-Suited for Joining Ropes of Unequal Diameters)

SS100-A

G

-M A

N

1-18

Figure 1-18. Water Knot - Used for Joining Two Strips of Canvas or Rope

SS100-A

G

-M A

N

1-19

Figure 1-19. Mariners Knot - a Knot System That Can Be Released under Load

G

-M A

N

1-20

CHAPTER 2

CASUALTY POWER SYSTEM

FIGURE NO. TITLE OF SKETCH

2-1 Bulkhead Terminal 2-2 Supply Power to Equipment Designated to Receive Casualty Power 2-3 Casualty Power Run

1.

2-1

Figure 2-1. Bulkhead Terminal

SS100-A

G

-M A

N

2-2

Figure 2-2. Supply Power to Equipment Designated to Receive Casualty Power

G

-M A

N

2-3

Figure 2-3. Casualty Power Run

G

-M A

N

2-4

CHAPTER 3

DESMOKING EVOLUTION

FIGURE NO. TITLE OF SKETCH

3-1 Desmokinq Equipment 3-2 Smoke Curtain Set-Up 3-3 Smoke Blanket Set-Up 3-4 Using Box Fan(s) Set in Watertight Door With Smoke Curtain 3-5 Using Box Fan Hung Across Watertight Door With Smoke Curtain 3-6 Using Two Fans Hung From Top of Watertight Door With Smoke Curtain 3-7 Optimum Placement of Desmoking Fans from Door (Seal Door Using Fan’s Air) 3-8 Desmokinq with Water Driven Fan Placed Adjacent to Smoked Filled Compartment 3-9 Using Water Driven Fan Placed Adjacent to Smoke Filled Compartment and Vent Duct Exhausting through Scuttle to Weather Deck 3-10 Desmoking with Water Driven Fan Placed Adjacent to Smoke Filled Compartment 3-11 Using Water Driven Fan Placed on Weather Deck or Below Adjacent to Smoked Compartment 3-12 Using Red Devil Blower Placed on Weather Deck or Below Adjacent to Smoked Compartment 3-13 Using Water Driven Fan To Desmoke Compartment with Box Fan on Scuttle 3-14 Using Water Driven Fan To Desmoke Compartment with Box Fan on Hatch 3-15 Using Red Devil Blower Placed on Weather Deck 3-16 Showing Portable Suction Duct Through the Smoke Curtain Located in Door Frame 3-17 Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P250 Pump 3-18 Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P100 Pump 3-19 Using Electric Subpump Supplying Water Driven Fan and to 1-1/2″ Firehose 3-20 Negative Pressure Ventilation Explanation 3-21 Using Combinations of Box Fans in Negative Pressure 3-22 Desmoking Passageway Through Vent Trunk Using Box Fans in Negative Pressure

1.

3-1

Figure 3-1. Desmoking Equipment

SS100-A

G

-M A

N

3-2

Figure 3-2. Smoke Curtain Set-Up

SS100-A

G

-M A

N

3-3

Figure 3-3. Smoke Blanket Set-up

SS100-A

G

-M A

N

3-4

Figure 3-4. Using Box Fan(s) Set in Watertight Door With Smoke Curtain

SS100-A

G

-M A

N

3-5

Figure 3-5. Using Box Fan Hung Across Watertight Door With Smoke Curtain

SS100-A

G

-M A

N

3-6

Figure 3-6. Using Two Fans Hung From Top of Watertight Door with Smoke Curtain

SS100-A

G

-M A

N

3-7

Figure 3-7. Optimum Placement of Desmoking Fans from Door (Seal Door Using Fan’s Air)

SS100-A

G

-M A

N

3-8

Figure 3-8. Desmoking with Water Driven Fan Placed Adjacent to Smoke Filled Compartment

SS100-A

G

-M A

N

3-9

Figure 3-9. Using Water Driven Fan Placed Adjacent to Smoke Filled Compartment and Vent Duct Exhausting through Scuttle to Weather Deck

SS100-A

G

-M A

N

3-10

Figure 3-10. Desmoking with Water Driven Fan Placed Adjacent to Smoke Filled Compartment

SS100-A

G

-M A

N

3-11

Figure 3-11. Using Water Driven Fan Placed on Weather Deck or Below Adjacent to Smoked Compartment

SS100-A

G

-M A

N

3-12

Figure 3-12. Using Red Devil Blower Placed on Weather Deck or Below Adjacent to Smoked Compartment

SS100-A

G

-M A

N

3-13

Figure 3-13. Using Water Driven Fan To Desmoke Compartment with Box Fan on Scuttle

SS100-A

G

-M A

N

3-14

Figure 3-14. Using Water Driven Fan To Desmoke Compartment with Box Fan on Hatch

SS100-A

G

-M A

N

3-15

Figure 3-15. Using Red Devil Blower Placed on Weather Deck

SS100-A

G

-M A

N

3-16

Figure 3-16. Showing Portable Suction Duct Through the Smoke Curtain Located in Door Frame

SS100-A

G

-M A

N

3-17

Figure 3-17. Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P250 Pump

SS100-A

G

-M A

N

3-18

Figure 3-18. Desmoking from Weather Deck or Clear Space with Water Driven Fan Actuated by P100 Pump

SS100-A

G

-M A

N

3-19

Figure 3-19. Using Electric Subpump Supplying Water to Water Driven Fan and to 1-1/2″ Firehose

SS100-A

G

-M A

N

3-20

Figure 3-20. Negative Pressure Ventilation Explanation

SS100-A

G

-M A

N

3-21

Figure 3-21. Using Combinations of Box Fans in Negative Pressure (Sheet 1 of 2)

SS100-A

G

-M A

N

3-22

Figure 3-21. Using Combinations of Box Fans in Negative Pressure (Sheet 2 of 2)

G

-M A

N

3-23

Figure 3-22. Desmoking Passageway Through Vent Trunk Using Box Fans in Negative Pressure

G

-M A

N

3-24

CHAPTER 4

DEWATERING EVOLUTION

FIGURE NO. TITLE OF SKETCH

4-1 Dewatering Equipment (Sheets 1, 2 and 3) 4-2 Using 1-1/2″ Eductor with or without Strainer 4-3 Using 2-1/2″ Eductor or Peri Jet with or without Foot Valve Actuating from 2-1/2″ Fireplug or P100 or

P250 Pump 4-4 Suction Lifts Under 20 Feet 4-5 Suction Lifts Under 20 Feet 4-6 Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet 4-7 Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet 4-8 Using P250 Pump and Eductor Pumping Contaminated Space 4-9 Using P100 Pump and Eductor Pumping Contaminated Space 4-10 Using 1-1/2″ Eductor Connected to a Standpipe 4-11 Using Peri Jet Eductor and 1-1/2″ Fireplug 4-12 Using P100 to Actuate both the 1-1/2″ Eductor and the Foot Valve Strainer 4-13 Using Both Peri Jet Eductor and 1-1/2″ Eductor 4-14 Using Peri Jet Eductor Supplied by 2-1/2″ and 1-1/2″ Hoses (Increased Capacity 20%) 4-15 20 Foot Suction Lift Using Three P100 Pumps in Tandem 4-16 Using Darley Pump and 1-1/2″ Eductor v17 Using Submersible Pumps Single or in Tandem 4-18 Using Submersible Pump 4-19 Using Electric Subpump to Provide Actuating Water to Peri Jet Eductor

1.

4-1

Figure 4-1. Dewatering Equipment (Sheet 1 of 3)

SS100-A

G

-M A

N

4-2

Figure 4-1. Dewatering Equipment (Sheet 2 of 3)

SS100-A

G

-M A

N

4-3

Figure 4-1. Dewatering Equipment (Sheet 3 of 3)

SS100-A

G

-M A

N

4-4

Figure 4-2. Using 1-1/2″ Eductor with or without Strainer

SS100-A

G

-M A

N

4-5

Figure 4-3. Using 2-1/2″ Eductor or Peri Jet with or without Foot Valve Actuating from 2-1/2″ Fireplug or P100 or P250 Pump

SS100-A

G

-M A

N

4-6

Figure 4-4. Suction Lifts Under 20 Feet

SS100-A

G

-M A

N

4-7

Figure 4-5. Suction Lifts Under 20 Feet

SS100-A

G

-M A

N

4-8

Figure 4-6. Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet

SS100-A

G

-M A

N

4-9

Figure 4-7. Using 1-1/2″ Eductor and Peri Jet Eductor for Lift Over 20 Feet

SS100-A

G

-M A

N

4-10

Figure 4-8. Using P250 Pump and Eductor Pumping Contaminated Space

SS100-A

G

-M A

N

4-11

Figure 4-9. Using P100 Pump and Eductor Pumping Contaminated Space

SS100-A

G

-M A

N

4-12

Figure 4-10. Using 1-1/2″ Eductor Connected to a Standpipe

SS100-A

G

-M A

N

4-13

Figure 4-11. Using Peri Jet Eductor and 1-1/2″ Fireplug

SS100-A

G

-M A

N

4-14

Figure 4-12. Using P100 to Actuate Both the 1-1/2″ Eductor and the Foot Valve Strainer

SS100-A

G

-M A

N

4-15

Figure 4-13. Using Both Peri Jet Eductor and 1-1/2″ Eductor

SS100-A

G

-M A

N

4-16

Figure 4-14. Using Peri Jet Eductor Supplied by 2-1/2″ and 1-1/2″ Hoses (Increased Capacity 20%)

G

-M A

N

4-17

Figure 4-15. 20 Foot Suction Lift Using Three P100 Pumps in Tandem

4-18

Figure 4-16. Using Darley Pump and 1-1/2″ Eductor

SS100-A

G

-M A

N

4-19

Figure 4-17. Using Submersible Pumps Single or in Tandem

SS100-A

G

-M A

N

4-20

Figure 4-18. Using Submersible Pump

G

-M A

N

4-21

Figure 4-19. Using Electric Subpump to Provide Actuating Water to Peri Jet Eductor

G

-M A

N

4-22

CHAPTER 5

EMERGENCY COMMUNICATIONS EVOLUTIONS

FIGURE NO. TITLE OF SKETCH

TBD

5-1 / (5-2 Blank)

5-2

CHAPTER 6

EMERGENCY LIGHTING EVOLUTIONS

FIGURE NO. TITLE OF SKETCH

TBD

6-1 / (6-2 Blank)

6-2

CHAPTER 7

FIREHOSES/FITTINGS EVOLUTION

FIGURE NO. TITLE OF SKETCH

7-1 Operating Positions for Navy 1-1/2″ Vari-Nozzles 7-2 Using Nozzle Tip and Applicator 7-3 Operating Positions for Navy Ail-Purpose 1-1/2″ Nozzles Used at High Velocity 7-4 Navy All-Purpose 1-1/2″ Nozzles with Applicators 7-5 Spanner Wrenches 7-6 Preparing Firehose for Stowage 7-7 Replacing Ruptured Fire Hose Using 2-1/2″ Hose Clamp

1.

7-1

Figure 7-1. Operating Positions for Navy 1-1/2″ Vari-Nozzles

SS100-A

G

-M A

N

7-2

Figure 7-2. Using Nozzle Tip and Applicator

SS100-A

G

-M A

N

7-3

Figure 7-3. Operating Positions for Navy All-Purpose 1-1/2″ Nozzles Used at High Velocity

SS100-A

G

-M A

N

7-4

Figure 7-4. Navy All-Purpose 1-1/2″ Nozzles with Applicators

SS100-A

G

-M A

N

7-5

Figure 7-5. Spanner Wrenches

SS100-A

G

-M A

N

7-6

Figure 7-6. Preparing Firehose for Stowage

G

-M A

N

7-7

Figure 7-7. Replacing Ruptured Fire Hose Using 2-1/2″ Hose Clamp

G

-M A

N

7-8

CHAPTER 8

FIREFIGHTING EVOLUTION

FIGURE NO. TITLE OF SKETCH

8-1 Using Portable AFFF (In-Line) Eductor/Firemain 8-2 Using NAP Nozzle and 4 Foot Applicator 8-3 Using P250 Pump and In-Line Eductor 8-4 Using P100 Pump and In-Line Eductor 8-5 Using P250 Pump and Various Applicators 8-6 Using P100 Pump and A 4 FT Applicator 8-7 Using P250 Pump Taking Suction from Overboard or Flooded Compartment 8-8 Using P100 Pump Taking Suction from Overboard or Flooded Compartment 8-9 Replacing Ruptured Firehose

8-10 Vertical Trunk Hose Handling 8-11 Using Portable AFFF (In-line) Eductor 8-12 Hose Line and Nozzle Handling Methods 8-13 Fire Attack - Direct Attack 8-14 Fire Attack - Attack from an Access 8-15 Fire Attack - Direct Attack with Vent to Weather 8-16 Indirect Attack 8-17 Indirect Attack with Venting

1.

8-1

Figure 8-1. Using Portable AFFF (In-Line) Eductor/Firemain

SS100-A

G

-M A

N

8-2

Figure 8-2. Using NAP Nozzle and 4 Foot Applicator

SS100-A

G

-M A

N

8-3

Figure 8-3. Using P250 Pump and In-Line Eductor

SS100-A

G

-M A

N

8-4

Figure 8-4. Using P100 Pump and In-Line Eductor

SS100-A

G

-M A

N

8-5

Figure 8-5. Using P250 Pump and Various Applicators

SS100-A

G

-M A

N

8-6

Figure 8-6. Using P100 Pump and A 4 FT’ Applicator

SS100-A

G

-M A

N

8-7

Figure 8-7. Using P250 Pump Taking Suction from Overboard or Flooded Compartment

SS100-A

G

-M A

N

8-8

Figure 8-8. Using P100 Pump Taking Suction from Overboard or Flooded Compartment

SS100-A

G

-M A

N

8-9

Figure 8-9. Replacing Ruptured Firehose

SS100-A

G

-M A

N

8-10

Figure 8-10. Vertical Trunk Hose Handling

SS100-A

G

-M A

N

8-11

Figure 8-11. Using Portable AFFF (In-Line) Eductor

SS100-A

G

-M A

N

8-12

Figure 8-12. Hose Line and Nozzle Handling Methods (Sheet 1 of 2)

SS100-A

G

-M A

N

8-13

Figure 8-12. Hose Line and Nozzle Handling Methods (Sheet 2 of 2)

SS100-A

G

-M A

N

8-14

Figure 8-13. Fire Attack - Direct Attack

SS100-A

G

-M A

N

8-15

Figure 8-14. Fire Attack - Attack from an Access

SS100-A

G

-M A

N

8-16

Figure 8-15. Fire Attack - Direct Attack with Vent to Weather

SS100-A

G

-M A

N

8-17

Figure 8-16. Indirect Attack

G

-M A

N

8-18

Figure 8-17. Indirect Attack with Venting

G

-M A

N -010

8-19 /(8-20

B lank)

8-20

CHAPTER 9

NAVAL FIREFIGHTERS’ THERMAL IMAGER

FIGURE NO. TITLE OF SKETCH

9-1 Allowing Sight through Dense Smoke and Light Steam to Locate Seat of Fire, in Overhaul Operations and for Search and Rescue of Personnel

9-2 Typical Operating Scenario 1.

9-1

Figure 9-1. Allowing Sight through Dense Smoke and Light Steam to Locate Seat of Fire, in Overhaul Operations and for Search and Rescue of Personnel

SS100-A

G

-M A

N

9-2

Figure 9-2. Typical Operating Scenario

G

-M A

N -010

9-3 /(9-4

9-4

CHAPTER 10

PATCHING/PLUGGING EVOLUTION

FIGURE NO. TITLE OF SKETCH

10-1 Use of Wooden Plugs and Wedges in Filling Holes 10-2 Plugging with Mattresses 10-3 Box Patch 10-4 Hinged Plate Patch 10-5 Securing Patch with Hook Bolts 10-6 Folding T-Patch 10-7 Plate Patch 10-8 Bucket Patch 10-9 Patching and Sealing Crack

10-10 Caulking Thin Plating and Torn Seams 10-11 Cloth Patch 10-12 Emergency Leak Plugging Using Flange Clamp

1.

10-1

Figure 10-1. Use of Wooden Plugs and Wedges in Filling Holes

G

-M A

N

10-2

Figure 10-2. Plugging with Mattresses

10-3

Fi gu re

-3

B ox

Pa tc h

10-4

Figure 10-4. Hinged Plate Patch

SS100-A

G

-M A

N

10-5

Figure 10-5. Securing Patch with Hook Bolts

SS100-A

G

-M A

N

10-6

Figure 10-6. Folding T-Patch

SS100-A

G

-M A

N

10-7 gu re

-7

Pl at e Pa tc h

10-8 gu re

-8

B uc ke t

Pa tc h

10-9

Figure 10-9. Patching and Sealing Crack

SS100-A

G

-M A

N

10-10

Figure 10-10. Caulking Thin Plating and Torn Seams

SS100-A

G

-M A

N

10-11

Figure 10-11. Cloth Patch

G

-M A

N

10-12

Figure 10-12. Emergency Leak Plugging Using Flange Clamp

G

-M A

N -010

10-13 /(10-14

10-14

CHAPTER 11

PIPE PATCHING EVOLUTION

FIGURE NO. TITLE OF SKETCH

11-1 Pipe Patching Equipment 11-2 Band-It Patch Isolated Pipe 11-3 Band-It Patch on Pressurized Pipe 11-4 Metal Banding Procedures for Band-It Patch 11-5 Emergency Water Activated Repair Patch (EWARP) 11-6 Jubilee Pipe Patch 11-7 Soft Patch on Low-Pressure Pipe Line 11-8 Clamp Patch 11-9 Flange Pipe Patch 11-10 Simple Pipe Patch 11-11 Elbow Pipe Patch Using Plastic Pipe Patching Kit 11-12 Severed Pipe Patch 11-13 Compound Pipe Patch

1.

11-1

Figure 11-1. Pipe Patching Equipment

SS100-A

G

-M A

N

11-2

Figure 11-2. Band-It Patch Isolated Pipe

SS100-A

G

-M A

N

11-3

Figure 11-3. Band-It Patch on Pressurized Pipe (Sheet 1 of 2)

SS100-A

G

-M A

N

11-4

Figure 11-3. Band-It Patch on Pressurized Pipe (Sheet 2 of 2)

SS100-A

G

-M A

N

11-5

Figure 11-4. Metal Banding Procedures for Band-It Patch (Sheet 1 of 2)

SS100-A

G

-M A

N

11-6

Figure 11-4. Metal Banding Procedures for Band-It Patch (Sheet 2 of 2)

SS100-A

G

-M A

N

11-7

Figure 11-5. Emergency Water Activated Repair Patch (EWARP)

SS100-A

G

-M A

N

11-8

Figure 11-6. Jubilee Pipe Patch

SS100-A

G

-M A

N

11-9

Figure 11-7. Soft Patch on Low-Pressure Pipe Line

SS100-A

G

-M A

N

11-10 gu re

-8

C la m p

Pa tc h

11-11

Figure 11-9. Flange Pipe Patch

SS100-A

G

-M A

N

11-12

Figure 11-10. Simple Pipe Patch

SS100-A

G

-M A

N

11-13

Figure 11-11. Elbow Pipe Patch Using Plastic Pipe Patching Kit

SS100-A

G

-M A

N

11-14

Figure 11-12. Severed Pipe Patch

G

-M A

N

11-15

Figure 11-13. Compound Pipe Patch

G

-M A

N

11-16

CHAPTER 12

REPAIR PARTY PERSONNEL PROTECTIVE CLOTHING

FIGURE NO. TITLE OF SKETCH

12-1 Firefighter’s Ensemble and Oxygen Breathing Apparatus (OBA) 12-2 Repair Party Outfit 12-3 Aircraft Fire Fighting and Chemical, Biological & Radiological (CBR) Protective Clothing

1.

12-1

Figure 12-1. Firefighter’s Ensemble and Oxygen Breathing Apparatus (OBA)

SS100-A

G

-M A

N

12-2

Figure 12-2. Repair Party Outfit

G

-M A

N

12-3

Figure 12-3. Aircraft Fire Fighting and Chemical, Biological & Radiological (CBR) Protective Clothing

G

-M A

N

12-4

CHAPTER 13

SHORING EVOLUTION

FIGURE NO. TITLE OF SKETCH

13-1 Measuring Length and Angle of Shore Using Measuring Batten 13-2 Measuring and Cutting Shores using Folding Rule or Steel Tape and Carpenter’s Square 13-3 l-Type Shoring Using 3-5 Ft. or 6-11 Ft. Metal Shore 13-4 I and K-Type Shoring Using Wooden and Adjustable 6-11 Ft. Metal Shores 13-5 I and K-Type Shoring Using Adjustable 3-5 Ft and 6-11 Ft. Metal Shores 13-6 I-Type Shoring as Erected in Passage On USS SAMUEL B. ROBERTS (FFG 58) 13-7 Shoring Split Seam After Bulkhead of Auxiliary Machinery Room on USS SAMUEL B. ROB-

ERTS (FFG 58)

13-8 K-Type Shoring Forward Bulkhead in CMBD SPLY DEPT STRM Room FFG 58 13-9 H-Type Shoring with Wooden Shores

13-10 I-Type Shoring Using Wooden Shore to Support Sagging Overhead 13-11 I-Type Shoring Using Multiple Combination of 6-11 Ft. Metal Shores and Wooden Shore to Sup-port Overhead Deck or Load 13-12 I-Type Shoring on Watertight Door Using Wooden Shores 13-13 I-Type Shoring on Watertight Door Using Metal Shores 13-14 I-Type Shoring on Hatch with Scuttle Using Wooden Shores 13-15 I-Type Shoring on Hatch with Scuttle Using Metal Shores 13-16 K-Type Shoring 13-17 K-Type Shoring on Watertight Door Using Wooden Shores 13-18 K-Type Shoring on Watertight Door Using Metal Shores 13-19 Distributing Bulkhead Pressure over Stiffeners with K-Type Shoring (Using Wooden or/and Metal

Shores) 13-20 Compound Shoring 13-21 Shoring from Bulkhead to Hatch and Providing Support for Weakened Overhead 13-22 General Rules for Shoring Against Horizontal Pressure 13-23 General Rules for Setting Correct Shoring Angles 13-24 Strengthening Shores

1.

13-1

Figure 13-1. Measuring Length and Angle of Shore Using Measuring Batten

SS100-A

G

-M A

N

13-2

Figure 13-2. Measuring and Cutting Shores Using Folding Rule or Steel Tape and Carpenter’s Square

SS100-A

G

-M A

N

13-3

Figure 13-3. I-Type Shoring Using 3-5 Ft. or 6-11 Ft. Metal Shore

SS100-A

G

-M A

N

13-4

Figure 13-4. I and K-Type Shoring Using Wooden and Adjustable 6-11 Ft. Metal Shores

SS100-A

G

-M A

N

13-5

Figure 13-5. I and K-Type Shoring Using Adjustable 3-5 Ft and 6-11 Ft Metal Shores

SS100-A

G

-M A

N

13-6

Figure 13-6. I-Type Shoring as Erected in Passage on USS SAMUEL B. ROBERTS (FFG 58)

SS100-A

G

-M A

N

13-7

Figure 13-7. Shoring Split Seam After Bulkhead of Auxiliary Machinery Room on USS SAMUEL B. ROBERTS (FFG 58)

SS100-A

G

-M A

N

13-8

Figure 13-8. K-Type Shoring Forward Bulkhead in CMBD SPLY DEPT STRM Room USS SAMUEL B. ROBERTS (FFG 58)

SS100-A

G

-M A

N

13-9

Figure 13-9. H-Type Shoring with Wooden Shores

SS100-A

G

-M A

N

13-10

Figure 13-10. I-Type Shoring Using Wooden Shore to Support Sagging Overhead

SS100-A

G

-M A

N

13-11

Figure 13-11. I-Type Shoring Using Multiple Combination of 6-11 Ft. Metal Shores and Wooden Shore to Support Overhead Deck or Load

SS100-A

G

-M A

N

13-12

Figure 13-12. I-Type Shoring on Watertight Door Using Wooden Shores

SS100-A

G

-M A

N

13-13

Figure 13-13. I-Type Shoring on Watertight Door Using Metal Shores

SS100-A

G

-M A

N

13-14

Figure 13-14. I-Type Shoring on Hatch with Scuttle Using Wooden Shores

SS100-A

G

-M A

N

13-15

Figure 13-15. I-Type Shoring on Hatch with Scuttle Using Metal Shores

SS100-A

G

-M A

N

13-16

Figure 13-16. K-Type Shoring

SS100-A

G

-M A

N

13-17

Figure 13-17. K-Type Shoring on Watertight Door Using Wooden Shores

SS100-A

G

-M A

N

13-18

Figure 13-18. K-Type Shoring on Watertight Door Using Metal Shores

SS100-A

G

-M A

N

13-19

Figure 13-19. Distributing Bulkhead Pressure over Stiffeners with K-Type Shoring (Using Wooden or/and Metal Shores)

SS100-A

G

-M A

N

13-20

Figure 13-20. Compound Shoring

SS100-A

G

-M A

N

13-21

Figure 13-21. Shoring from Bulkhead to Hatch and Providing Support for Weakened Overhead

SS100-A

G

-M A

N

13-22

Figure 13-22. General Rules for Shoring Against Horizontal Pressure

SS100-A

G

-M A

N

13-23

Figure 13-23. General Rules for Setting Correct Shoring Angles

G

-M A

N

13-24 gu re

-2 4.

St re ng th en in g Sh or es

13-25 / (13-26 Blank)

13-26

CHAPTER 14

SYSTEM RESTORE/RECONFIGURE EVOLUTION

FIGURE NO. TITLE OF SKETCH

14-1 Providing Temporary Firemain Service Using Firehose Bypassing Damaged Firemain 14-2 Providing Temporary Firemain Service by Hose Jumping at Flanges

1.

14-1

Figure 14-1. Providing Temporary Firemain Service Using Firehose Bypassing Damaged Firemain

G

-M A

N

14-2

Figure 14-2. Providing Temporary Firemain Service by Hose Jumping at Flanges

G

-M A

N -010

14-3 /(14-4

14-4

CHAPTER 15

COMPLEX DAMAGE CONTROL EVOLUTION

FIGURE NO. TITLE OF SKETCH

15-1 Dewatering and Desmoking Using Electric Sub Pump Discharge Actuating Water Driven Fan and 1-1/2″ Eductor

15-2 Dewatering and Desmoking Using Water Driven Fan and P250 Pump Taking Suction from Flooded Compartment

15-3 Dewatering and Desmoking Using Water Driven Fan and P100 Pump Taking Suction from Flooded Compartment

1.

15-1

Figure 15-1. Dewatering and Desmoking Using Electric Sub Pump Discharge Actuating Water Driven Fan and 1-1/2″ Eductor

SS100-A

G

-M A

N

15-2

Figure 15-2. Dewatering and Desmoking Using Water Driven Fan and P250 Pump Taking Suction from Flooded Compartment

G

-M A

N

15-3

Figure 15-3. Dewatering and Desmoking Using Water Driven Fan and P100 Pump Taking Suction from Flooded Compartment

SS100-A

G

-M A

N

15-4

15-5

15-6

REAR SECTION

TECHNICAL MANUAL DEFICIENCY/EVALUATION REPORT (TMDER)

NOTE

Ships, training activities, supply points, depots, Naval Shipyards and Supervisors of Shipbuilding are requested to arrange for the maximum practical use and evaluation of NAVSEA technical manuals. All errors, omissions, discrepancies and suggestions for improvement to NAVSEA technical manuals shall be for-warded to:

COMMANDER,

CODE 310 TMDER, BLDG 1388

NAVSURFWARCENDIV NSDSA

4363 MISSILE WAY

PORT HUENEME CA 93043-4307

on NAVSEA/SPAWAR Technical Manual Deficiency/Evaluation Report (TMDER), NAVSEA form 4160/1. To facilitate such reporting, print, complete and mail NAVSEA form 4160/1 below or submit TMDERS at web site:

https://nsdsa2.phdnswc.navy.mil/tmder/tmder-generate.asp?lvl=1 All feedback comments shall be thoroughly investigated and originators will be advised of action resulting therefrom. Copies of NAVSEA form 4160/1 may be requisitioned from the Naval Systems Data Support Activity Code 310 at the above address.

TMDER / MAILER

Rear-1 / (Rear-2 Blank)

Rear-2