Drydock & repairs for CGC amberjack and CGC sturgeon

6/29/2012 SOLICITATION FOR CGC AMBERJACK AND CGC STURGEON

The United States Coast Guard, Surface Forces Logistics Center, Detachment Norfolk VA, intends to issue a Commercial Request for Proposal (RFP) for Dry-dock and repairs to the CGC AMBERJACK (WPB-87315) and CGC STURGEON (WPB-87336) both 87-Foot Patrol Boats. The NAICS Code is 336611.

The Coast Guard intends to conduct the procurement in accordance with Federal Acquisition Regulation (FAR) Part 12, Acquisition of Commercial Items, and FAR Part 15, Contracting by Negotiation for Certain Commercial Items. The simplified acquisition will be issued as a Service Disabled Veteran Owned Small Business Set-Aside. Request for Proposals (RFP) will be issued on or about June 29, 2012.

The acquisition is to perform drydock and repairs to the CGC AMBERJACK and CGC STURGEON. The vessels are geographically restricted to a facility located within an area no greater than 1200 nautical miles one-way and 2400 nautical miles roundtrip from Galveston, TX. The Period of performance for CGC AMBERJACK is one-hundred twenty three (123) calendar days from 29 OCT 2012 through 1 March 2013. August through 12 October 2012. The Period of performance for CGC STURGEON is fifty-eight (58) calendar days from 4 April through 31 May 2013. . All work will be performed at the contractor's facility within the geographical restriction as stated above.

The solicitation will be issued electronically via the Federal Business Opportunity web page at http://www.fedbizopps.gov. It is incumbent upon contractors to monitor the FEDBIZOPS web page for the RFP release and all subsequent amendments. Hard copies of the specification and solicitation will not be issued.

The scope of the acquisition is for the overhauling, renewing and repairing of various items aboard the CGC AMBERJACK and CGC STURGEON. This work may include, but is not limited to:

1. Perform Ultrasonic Thickness Measurements
2. Perform Ultrasonic Thickness Measurements
3. Overhead Surfaces (Port Lazarette), Preserve, Insulate
4. Bilge Surfaces (Engine Room), Preserve 100%
5. Preserve Bilge Surfaces 100%, Renew Galley & Mess Deck
6. Dirty Oil Tank, Clean and Inspect
7. Oily Water Tank, Clean, Inspect and Preserve
8. Tanks (MP Fuel Service), Clean and Inspect
9. Tanks (Potable Water), Clean and Inspect
10. Forepeak, Inspect and Preserve 100%
11. Superstructure, Preserve 100%
12. Pilothouse Deck (Aluminum), Inspect, Preserve, and Renew Electrical Matting
13. Depth Sounder, Capastic Fairing, Renew
14. Main Engine/Reduction Gear, Realign
15. Propulsion Shafts, Remove, Inspect, and Reinstall
16. Propulsion Shaft, Repair
17. Propulsion Shaft, Straighten
18. Intermediate Water-Lubricated Shaft Bearing, Renew
19. Aft Water-Lubricated Shaft Bearing, Renew
20. Intermediate Bearing Carrier, Renew
21. Aft Bearing Carrier, Renew
22. Stern Tubes, Interior Surfaces, Preserve 100%
23. Stern Tubes, Interior Surfaces, Repair
24. Propellers, Remove, Inspect, and Reinstall
25. Propeller, Minor Repair and Recondition, Perform
26. Fathometer Transducer, Renew
27. Speed Log, Skin Valve, Clean and Inspect
28. Sea Water System (Valves, Strainers, Piping), Clean, Inspect, and Repair
29. Rudder Assemblies, Remove, Inspect and Reinstall
30. RHIB Notch Skid Pads, Inspect
31. RHIB Notch Skid Pad Studs, Renew
32. Stern Launch Door, Remove, Inspect, and Reinstall
33. Grey Water Holding Tank, Clean and Inspect
34. Sewage Holding Tank, Clean and Inspect
35. Grey Water Piping, Clean and Flush
36. Sewage Piping, Clean and Flush
37. Decks-Exterior (Main Deck), Preserve 100%
38. U/W Body, Preserve 100%
39. Hull Plating Freeboard, Preserve 100%

A CD-ROM containing all applicable drawings will be sent via U.S. mail, if requested. Send all requests to Nancy.M.Brinkman@uscg.mil The CD-ROM sets are available of all cutters and will be free of charge to contractors upon request. The CD-ROM(s) contain WINDOWS compliant raster/vector formats (e.g.*.DWF, etc).

Proposals are due on or about July 30, 2012 at 10:00 a.m. Eastern Standard Time and may be sent via:

Email: nancy.m.brinkman@uscg.mil or mailed to

US Coast Guard
SFLC/C&P1/PBPL
Attn: Nancy Brinkman
300 East Main Street, Suite 600
Norfolk, VA 23510-9102