TRELL_en.pdf

Identification of the substance/preparation and company/undertaking

SAFETY DATA SHEET

TRELL

Conforms to EU regulation EC 1907/2006 and amendments

1.

Identification of the substance or preparation

TRELLProduct name :

Company/undertaking identification

: Manual Warewashing Detergent

Product is for professional use only

Product use

Date of revision : 28 April 2008Version : 3102341ECode :

Hazards identification2.

Classification Xi; R36:

The preparation is classified as dangerous according to Directive 1999/45/EC and its amendments.

:Human health hazards Irritating to eyes.

See section 11 for more detailed information on health effects and symptoms.

Composition/information on ingredients

Linear Alkylbenzenesulphonates 246-680-4 25155-30-0 5 - 10 Xn; R22 Xi; R41, R37/38

Alkylethersulphates 500-234-8 68891-38-3 2 - 5 Xi; R36/38

3.

Substance/preparation Preparation

Occupational exposure limits, if available, are listed in section 8.

EINECS % ClassificationIngredient name

See section 16 for the full text of the R-phrases declared above

CAS

≥5 - <15% anionic surfactants contains preservatives: (Sodium Benzoate, Glutaral) Contains Perfumes: (Limonene, Citral)

Ingredient declaration according to detergent regulation 648/2004/EC:

Wash out mouth with water. Move exposed person to fresh air. Do not induce vomiting unless directed to do so by medical personnel. Get medical attention if adverse health effects persist or are severe.

Skin contact

Immediately flush eyes with plenty of water, occasionally lifting the upper and lower eyelids. Get medical attention.

Flush contaminated skin with plenty of water. Remove contaminated clothing and shoes.

4.

First-aid measures

Move exposed person to fresh air. Get medical attention if adverse health effects persist or are severe.

Ingestion

Inhalation

Eye contact

First aid measures

Specific treatments Not available.:

See section 11 for more detailed information on health effects and symptoms.

Date of issue : 28 April 2008 Page: 1/4

TRELL

Fire-fighting measures5.

Hazardous thermal decomposition products

Decomposition products may include the following materials:

carbon oxides nitrogen oxides sulfur oxides halogenated compounds metal oxide/oxides

Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode.

Special protective equipment for fire-fighters

In case of fire, use water spray (fog), foam, dry chemical or CO2.Extinguishing media - Suitable :

Extinguishing media - Not suitable

None known.:

Environmental precautions

Personal precautions

6. Accidental release measures

Note: see section 8 for personal protective equipment and section 13 for waste disposal.

: Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spilt material. Avoid breathing vapour or mist. Provide adequate ventilation.

Avoid dispersal of spilt material and runoff and contact with soil, waterways, drains and sewers.

Small spill: : Dilute with water and mop up if water-soluble or absorb with an inert dry material and place in an appropriate waste disposal container.

Large spill : Prevent entry into sewers, water courses, basements or confined areas.

Contain and collect spillage with non-combustible, absorbent material e.g.

sand, earth, vermiculite or diatomaceous earth and place in container for disposal according to local regulations (see section 13).

Handling

Handling and storage

Storage

7.

Do not ingest. Avoid contact with eyes, skin and clothing. After handling, always wash hands thoroughly with soap and water.

Packaging materials

Use original container.

Store in accordance with local regulations. Store in original container protected from direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials (see section 10) and food and drink. Keep container tightly closed and sealed until ready for use.

Recommended

Not available.:Specific uses

Store between the following temperatures: 5 and 40°C

Exposure limit values

8. Exposure controls/personal protection

Hand protection

(EN 374)

Exposure controls

A respirator is not needed under normal and intended conditions of product use.

1 - 4 hours : butyl rubber , nitrile rubber

Safety glasses.Eye protection

(EN 166)

Respiratory protection

(EN 143, 141)

Not available.:

If workers are exposed to concentrations above the exposure limit, they must use appropriate, certified respirators.

Occupational exposure controls

Skin protection

(EN 467)

No special recommendations.:

Date of issue : 28 April 2008 Page: 2/4

Physical and chemical properties

Physical state Liquid.

citrusOdour

Green.Colour

9.

General information

Appearance

Not available.

Melting point

Boiling point

Vapour pressure

Relative density

Vapour density

Solubility

Not available.

1.03 to 1.04 g/cm3 (20 °C)

Not available.

Not applicable.

Easily soluble in cold water, hot water.

pH

Evaporation rate (butyl acetate = 1)

Not applicable.

Flash point > 100°C

Not applicable.

Not applicable.Flammability (solid, gas)

Not applicable.

6.3 to 6.9 (100%)

Viscosity Dynamic: 515 mPa·s (515 cP)

Octanol/water partition coefficient

Explosion limits

Explosive properties

Not available.Oxidising properties :

Important health, safety and environmental information

Not applicable.

Stability and reactivity

Stability

10.

Do not mix with other products.

Stable under normal conditions.

Toxicological information11.

No known significant effects or critical hazards.Carcinogenicity :

No known significant effects or critical hazards.Mutagenicity :

No known significant effects or critical hazards.Reproductive toxicity :

Potential acute health effects

Inhalation : Exposure to decomposition products may cause a health hazard. Serious effects may be delayed following exposure.

No known significant effects or critical hazards.:Ingestion

Skin contact : No known significant effects or critical hazards.

Irritating to eyes.:Eye contact

Ecological information12.

The surfactants contained in the product are biodegradable according to the requirements of the detergent regulation 648/2004/EC

The product is not subject to ecological classification according to directive 1999/45/EC.

Ecotoxicity

Persistence and degradability

Date of issue : 28 April 2008 Page: 3/4

Disposal considerations13.

200129*European waste catalogue

(EWC)

The generation of waste should be avoided or minimised wherever possible.

Disposal of this product, solutions and any by-products should at all times comply with the requirements of environmental protection and waste disposal legislation and any regional local authority requirements. Avoid dispersal of spilt material and runoff and contact with soil, waterways, drains and sewers. Can be added to general waste collection after completely emptying. Use packages for recycling only when totally empty.

:Methods of disposal

ADR/RID Class

14.

International transport regulations

IMDG Class - - -

Transport information

Regulatory information

UN number Proper shipping name Class Packing group

Label

Not regulated.

Not regulated.

Follow special pack instructions for air transport.

Regulatory information15.

Hazard symbol/symbols

EU regulations

Safety phrases S2- Keep out of the reach of children.

S26- In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.

R36- Irritating to eyes.Risk phrases

Irritant

Other information16.

R22- Harmful if swallowed.

R41- Risk of serious damage to eyes.

R36- Irritating to eyes.

R36/38- Irritating to eyes and skin.

R37/38- Irritating to respiratory system and skin.

Full text of R-phrases referred to in sections 2 and 3 - Europe

28 April 2008

History

Date of printing

Date of revision

Version

Prepared by

28 April 2008

Version

The above information is believed to be correct with respect to the formula used to manufacture the product in the country of origin. As data, standards, and regulations change, and conditions of use and handling are beyond our control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE

COMPLETENESS OR CONTINUING ACCURACY OF THIS INFORMATION.

Notice to reader

: Ecolab Regulatory Department Europe

Page: 4/4