cp4Manual.pdf

INSTALLATION INSTRUCTIONS FOR

CP-4 AUTOMATIC GATE OPENER*

1. SERIAL NUMBER

There is a barcode serial number on the bottom of “puck” and on the product box. When calling to talk about your product, please have this number handy.

PRODUCT

CODE

YEAR

MADE

SERIAL

NUMBER

2. TRENCH PIPE & CABLE

NOTE:

Warranty void if cable not run in conduit

3. CONDUIT & SLIP JOINT

After pulling cable through plastic conduit, insert conduit inside slip joint on “puck.”

DO NOT GLUE (to un-install later, if needed).

NOTE: IN MOST CASES DO NOT

ADJUST SENSITIVITY OR REMOVE LID.

5. TEST SENSITIVITY

4. CONNECT TO GATE

RED

BLACK

POWER +

WHITE COMMON

YELLOW EXIT N.C.

BLUE EXIT N.O.

POWER ─

DUAL EXIT TERMINAL SINGLE EXIT TERMINAL

RED POWER +

BLACK

WHITE

BLUE FREE EXIT

or OPEN

TERMINAL

GND or COM

CP-4 works with all gate operators―powered or solar, single or dual free exit terminals.

VOLTAGE CURRENT

8-24 VAC

8-30 VDC

Standby: 30-70 µA Alarm: 40-60 mA

SENSITIVITY ADJUSTMENT

HIGH (Default) Detects vehicle going 5 MPH 12-14’ away 1 & 2 in OFF position

MEDIUM

Detects vehicle going 5 MPH 6-8’ away 1 ON & 2 OFF position

LOW

Detects vehicle going 5 MPH 2-3’ away 1 & 2 in ON position 1 2

ON

1 2

ON

1 2

ON

6. BURY CONDUIT & “PUCK”

Test unit with gate by swinging steel over puck (or driving vehicle by). If it opens the gate correctly, finish installation by burying conduit and puck 3-5" below surface.

80' - 100'

12' Note: Dip switch color may vary

• Trench 1/2" PVC pipe to placement of CP-4

• Smooth out entire length of cable before pulling thru PVC pipe

• Gently pull cable thru PVC pipe (may need wire lubricant)

*Patent Pending

Technical Specifications

Power Required 8–24 VAC or 8–30 VDC

Stand-By Current 30–70 Microamps (μA)

Alarm Current 30–40 Milliamps (mA)

Relay Time 2–3 seconds

Relay Contacts SPDT, floating, N.O. or

N.C. (Form C)

Relay Contact Rating 1 amp/24 VDC

(1 mA at 5 VDC min. load)

Enclosure Rating IP67

Strength Rating

9.53 ton-force

8646 kgf

Temperature Range -25° F. – +140° F.

-32° C. – 60° C.

Dimensions 4.5 in. dia. x 2.5 in. high

Weight 5 lbs. with 100 ft. cable

The CP-4 complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

OTHER INSTRUCTIONS

• CP-4 may be installed above ground by screwing “puck” directly to an immovable post or building

• If installed above ground, use conduit to mechanically protect cable (animals will eat)

• Car should be going at least 5 MPH at sensor to be detected

Install CP-4 at least:

• 6-10 feet away from buried power, telephone, or invisible dog fence

transformer

power lines

• 80-100 feet back from gate operator

RETURNING MERCHANDISE

CONSUMER: Contact your installer

INSTALLER: CALL BEFORE DIGGING UP

Call (717) 532-0033, option 1 to troubleshoot and receive a Return Merchandise Authorization (R.M.A.) number. Write R.M.A. number on return shipping box and any correspondence included with defective product.

DISTRIBUTOR: Send installers directly to Cartell, using 717-532-0033, option 1 as phone number.

5 YEAR WARRANTY

All Cartell products are warranted against defects in material and workmanship for five years.

This warranty does not cover defects caused by, but not limited to: acts of God, improper installation, abuse, fire damage, electrical surges, integrated system failures, improper lid/gasket installation, and damage to cable (if applicable) caused by slicing, pulling, tangling, improper splicing or not running in non-metalic conduit.

WARRANTY

W

A R

RANTY WARRA

N

TY

Y

E A R

CONTACT INFORMATION

TECH SUPPORT 717-532-0033, option 1

RMA’s 717-532-0033, option 1

SHIPPING 717-532-0033, option 2

ACCOUNTING 717-532-0033, option 3

INSIDE SALES 717-532-0033, option 4

EMAIL info@cartell.com

ORDERING

(Distributors only) orders@cartell.com

ADDRESS 510 West King Street Shippensburg, PA 17257

WEBSITE www.cartell.com

Copyright © 2020 by Cartell