LO-VO_Wash_50.xml

kyliec 2615.pdf B E P !WC F ' J S,. t0Sl2S'-"-:t t . ! ? : P ' - =-- DEPARTMENT OF HEALTH & HUMAN SERVICES Program Support Center Federal Occupationa l He alt h Servi 1301 Young Street, Suite 772 Dallas , Texas 75202 TO: FROM: DATE: Tony Maniaci !Ill David Bull, CIH, CSP J)a,v1, May 8 , 2015 PRODUCT NAME: HMIS Ratings LO-VO Wash 50 Health 1 Flammability 2 Physical Hazard 0 Safety Review: This product is recommended for approval. Reviewed by: David Bull, CSP , CIH ffiJ Environmental Review: This product is recommended for approval. Reviewed by: David Bull , CSP cf1I'Q Concurrence by: Virginia Baldw in, P MSDS MUST BE ATTACHED 8EP/WCF <"') I MS_D_$# .?'\. '-.0 MSDS Cover Memorandum Required By BEP Manual 70-09.40 Chapter 33 Request for review of chemicals Each Non-Bureau manufactured MSDS submitted must have the following information: 1. Name of Chemical or Product;

LO-VO WASH 50 (One Step Low V.O.C. Press Wash) -,MSDS S )J s· 2. Name and telephone number of COTR or Buyer; Tony Maniaci-3677 3. Date of request; May 7, 2015 4. Planned date(s) of use; May 2015 5. Location of use; Plate Printing 6. Quantity of material to be used per application; As needed 7. Brief description of process; Wet rag with solvent and wipe press to clean.. New Product _X_ Revised MSDS LO-VO WASH 50 SAFETY OAT A SHEET BEP /WCF MSDS# DATE: 1/1/2015 lt . CHEMICAL NAME AND COMPANY IDENTIFICATION Formulated/Manufactured By: Information Telephone Number: Tower Products, Inc. 2703 Freemansburg Avenue Easton, PA 1 8045 1-800-527-8626 or 6 10-2 53 -6 206 For Chemical Spill Emergency Call: CHEMTREC: 1- 800-424-9300 Product Na me: LO-VO WASH 50 (One Step Low V.O.C. Press Wash) CAS Number: Mixture- Not Estab li s hed I 2.HAZARDS IDENTIFICATION GH S Classification F lamm able Liquids (Category 4) Aspiration Hazard (Category 1) Specific Target Organ Toxicity- Single Exposure (Category 3) Skin Ini.tation (Category 2) Eye Irritation (Ca t egory 2A) GH S labe l elements , includin g hazar d an d precautionar y statements Pictogram(s) Signal Word DANGER! Hazard statement(s) H227: COMBUSTIBLE LIQUID. H304: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. H336: MAY CAUSE DROWSINESS OR DIZZINESS. H315: CAUSES SKIN IRRITATION. H319: CAUSES SERIOUS EYE IRRITATION. Precautionary statement(s) Prevention: P210: KEEP AWAY FROM HEAT / HOT SURFACES / SPARKS / OPEN FLAMES AND OTHER IGNITION SOURCES. NO SMOKING. P261: AVOID BREATHING FUME / MIST / DUST / GAS/VAPORS / SPRAY. P280: WEAR PROTECTIVE GLOV E S / EYE PROTECTION / FACE PROTECTION. P264: WASH SKIN THOROUGHLY AFTER HANDLING. Respon se : P370 + P378: IN CASE OF FIRE: USE DRY CHEMICAL OR CARBON DIOXIDE TO EXTINGUISH. P30 1 +P3 1 O+P331: IF SWALLOWED: IMM EDIATELY CALL A POISON CENTER OR DOCTOR. DO NOT INDUCE VOMITING. P304+P340 : IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. P302+P352: IF ON SKIN: WASH WITH PLENTY OF WATER. P305+P351 + P338: I F IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES , IF PRESENT AND EASY TO DO. CONTINUE RINSING . SAFETY DATA SHEET LO-VO WASH 50 DATE: 1/1/2015 Storage: P403+P233+P405: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE LOCKED UP. Disposal: P50 1: DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL REGULATIONS. HMIS Classification Health Hazard: 1 Flammability: 2 Physical Hazard: 0 Personal Protection: B I 3. COMPOSITION /INFORMATION ON INGREDIENTS Component(s) Aliphatic Hydrocarbon Mineral Oil Nonylphenol Ethoxylated CA S Number 64742-88-7 8042-47-5 9016-45-9 *Concentration (weight) 45-55% 25-35% 1-10% * In accordance with paragraph (i) of§1910.1200, exact chemical percentages (concentration) of composition have been withheld as a trade secret. I 4. FIRST AID MEASURES Exposure Routes: Inhalation, Ingestion, Skin Eye Contact: Flush with large volume of water for at least 15 minutes. Get immediate medical attention. Inhalation: Remove to fresh air. Get immediate medical attention. Ingestion: Get immediate medical attention. Do not induce vomiting. Skin Contact: Flush area with large amounts of water for at least 15 minutes. Get immediate medical attention. Is. FIRE-FIGHTING MEASURES Suitable extinguishing media: Use dry chemical or carbon dioxide. Specific Hazards: Combustible Liquid. Upon combustion, the product may form carbon monoxide and other organic compounds. Product containers may rupture from vapor pressure when exposed to heat from fire. Special protective equipment for fire-fighters: Use self-contained breathing apparatus. I 6. ACCIDENTAL RELEASE MEASURES Personal precautions and protective equipment: Respiratory Protection: Use supplied air equipment or respirators with proper NIOSH approved cmiridges. Protective Gloves: Impervious or chemical resistant gloves (consult safety equipment supplier). Eye Protection: Chemical splash goggles recommended against potential eye contact. Other Protective Clothing and Equipment: Safety shoes and aprons recommended. Methods for Clean-Up: Minor Spills: Absorb material with ground clay, vermiculite, sand, or similar absorbent material and place into containers for disposal according to local and/or state regulations. Major Spills: Dike and contain spill. Eliminate potential sources of ignition, and shut off source of spill if possible. Remove liquid by chemical vacuum, absorbent material, or other safe and approved methods, and place into containers for disposal according to local and/or state regulations. Flush area with water to remove residue, and remove flushed solutions as above. I 7. HANDLING AND STORAGE Handling: Combustible Liquid- empty containers can be hazardous and contain explosive vapors. Do not reuse containers. Ground fixed equipment. Bond and ground transfer equipment and containers. Storage: Store in a cool, dry, ventilated area, away from incompatible substances. Keep containers closed when not in use. I 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION Exposure Guidelines: OSHA ACGIH ACGIH OTHER COMPONENT Aliphatic Hydrocarbon Mineral Oil Nonylphenol Ethoxylated CAS No.

64742-88-7 8042-47-5

9016-45-9 PEL/TWA

lOOppm(l) 5mg/m3

N/E TLV/TWA

lOOppm 5mglm3

N / E TLV/STEL

10mg/m3 RATING (1) Based on 1989 VPEL levels for Stoddard Solvent; current PEL is 500ppm. Exposure Controls: Avoid open electrical sources near product vapor areas. Personal Protection Equipment: Eyes: Chemical sp lash goggles recommended . Skin and body: Impervious or chemical resistant gloves (consult safety equipment supplier). Respiratory : Ventilation in work area should be sufficient to maintain atmosphere with vapor level below lowest listed TLV. IfTL V's are exceeded , use a respirator wi th appropriate NJOSH approved ca1tridges or supp li e d air e quipm ent. I 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Tan co lored liquid. Odor: Petroleum odor pH : N/A Melting point: N / A Boiling Point: (IBP) > 200° F Flash Point: (Tag Closed Cup Method) 155 ° F Flammable Limits: Calculated LEL: 1.4% UEL: 9.3% Vapor Pressure: (mmHg, Calculated) < 5.0@ 68° F (20° C) Vapor Density: (Air= 1) N/D Specific Gravity: (Water= 1) 0.824 Solubility in water : Negligible Maximum VOC Content: 3.45 Lb/Gal (414 Gm / L) Maximum VOC %: 50% Odor Threshold: N / A Evaporation Rate : N/ A Relative Density : N / A Partition Coefficient: N-Octano/Wate1·: N / A Auto-ignition Temperature: N / A Decomposition Temperature: N / A Viscosity: N / A Ito. sTABILITY AND REACTIVITY Chemical Stability: Stable Incompatible Materials: Avoid strong oxidizing agents. Hazardous Decomposition Products: Carbon monoxide and other compounds during combustion. Hazardous Polymerization: Will not occur. Conditions to Avoid: Avoid exposure to high he at sources, e lectrical and welding arcs, open flame and stro ng oxidizing agents. Warning : Spontaneous combustion may occur when so l vent soa k e d combustible materials (paper , cotton etc . ) are allowed to stan d in confined areas. 11. TOXICOLOGICAL INFORMATION (ATE) FOR MIXTURE: Specific tests have not been conducted on this product. Our evaluations based on information from the ingredients and teclmical literature. Data for this material has been used to estimate the symptoms and effects of exposure. Oral LDSO: LD50 Oral - ::: 4,464 mglkg Dermal LDSO: LD50 Dermal- :::4,901 mg!kg Inhalation LCSO: LC50 Inhalation- No data available Other information on Acute Toxicity: No data available Routes of exposure: Inhalation, Ingestion , Skin Acute: Overexposure may lead to central nervous system depression, leading to headaches , nausea and unconsciousness. Chronic: Overexposure in high concentrations may produce central nervous system depression. Signs and Symptoms of Exposure: Overexposure may lead to dizziness, headaches, dermatitis and eye initation. Medical Conditions Aggravated by Exposure: Pre e xisting eye, skin, kidney, or respiratory disorders may be aggravated by exposure. Carcinogenicity (NTP, IARC, OSHA): Components of this product have not shown any evidence of carcinogenicity. 112 . ECOLOGICAL INFORMATION Ecotoxicity: No data available Persistence and degradability: No data available Bioaccumulative potential: No data available Mobility in the soil: No data available Other adverse effects: No data available 113. DISPOSAL CONSIDERATIONS Waste disposal methods: Dispose o f in accordance with all applicable local, state and federal regulations. Do not discharge this product into lakes, streams , ponds or estuaries , oceans, or other waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System (NPDES) permit , and the permitting authority has been notified in writing prior to discharge. Do not discharge this product into sewer systems without previously notifying the local sewage treatment plant authority. For guidance, contact your State Water Board or Regional Office of the EPA. lt4. TRANSPORTATIO N INFORMATION U.S. D.O.T.D ESIGNATION Cleaning Liquid. Not Regulated ID NUMBER HAZARD CLASS PACKING GROUP U.S. D.O.T.DESIGNATION- BULK Combustible Liquid , N.O.S. (contains Naphtha, Solvent) NA1993 COMB III Its. REGULATORY INFORMATION Regulatory Information: This infonnation may be useful in complying with various federal and state regulations: Components present in this product at a level which could require reporting under EPA Regulation 40CFR302 (CERCLA) Section 102 and EPA Regulation 40CFR372 (SARA) 313: None. Product may contain components which are further regulated by state and/or local agencies- Consult Appropriate Agencies. Notification status: U.S.A.: Toxic Substances Control Act (TSCA) Y Canada: Domestic Substances List (DSL): Y lt6. OTHER INFORMATION For More Information, Consult Tower Products, Inc. This Information Herein Is Given In Good Faith, But No Warranty, Express Or Implied Is Made. Date ofPreparation: January 1, 2015