USCGC SOCKEYE_Drydock and Repair_August_2009_Rev 1.pdf

Specifications for the Drydock and Repair of

USCGC SOCKEYE (WPB-87337)

August 2009 Rev 1

UNITED STATES COAST GUARD

MAINTENANCE AND LOGISTICS COMMAND PACIFIC

NAVAL ENGINEERING DIVISION

RONALD V. DELLUMS FEDERAL BUILDING

1301 CLAY STREET, SUITE 807N

OAKLAND, CALIFORNIA 94612-5249

Specifications for the Drydock and Repair of August 2009 USCGC SOCKEYE (WPB-87337) Rev 1 i

Table of Contents

Item SWBS Description Page

Vessel Description iii

Consolidated List of References iv

Consolidated List of Government Furnished Property ix

General Requirements — Drydock 1

D-1 04100 Production Control, Gantt Bar Chart Provide 21

D-2 11000 Forepeak Void Watertight Flat Installation 23

D-3 11000 Hull Plating, Underwater Body Inspect 37

D-4 11000 Hull Plating, Underwater Body Ultrasonic Testing 43

D-5 11400 Appendages (Underwater) Leak Test 47

D-6 11400 Appendages (Underwater) Preserve, Internal 49

D-7 11400 Voids (Non-Accessible) Leak Test 51

D-8 11400 Voids (Non-Accessible) Preserve, Internal 53

D-9 12311 Tanks (MP Fuel Service) Clean and Inspect 54

D-10 16700 Hatch Coaming Replacement 57

D-11 24300 Propulsion Shaft Seals Mechanical Overhaul & Inflatable Renewal 61

D-12 24400 Propulsion Shaft Bearings (External) Check Clearances 69

D-13 24500 Propeller Clean/ Inspect 72

D-14 25610 A/C Condenser Seawater Cooling Piping Renewal and Fitting Replacement 77

D-15 42400 Fathometer Transducer Renewal 83

D-16 52000 Sea Valve (<= 2.5 Inches) Renewal 86

D-17 52000 Sea Valve (> 2.5 Inches) Overhaul 89

D-18 52810 Grey Water Piping Clean and Inspect 94

D-19 55510 AFFF Engine Room Bilge Flooding Piping Installation 100

D-20 55600 Installation of New Hydraulic System 117

D-21 56100 Install Rudder Stock Split Seals 151

D-22 56200 Rudders and Rudder Stocks Removal and Inspection with El Seal EC 154

D-23 59310 Grey Water Holding Tank(s) Clean & Inspect 162

D-24 59310 Sewage Holding Tank Clean & Inspect 165

D-25 59310 Sewage Piping Cleaning and Inspection 168

D-26 63110 Lazarette Preserve 173

D-27 63130 Hull Plating, Underwater Body Preserve, Partial 177

D-28 63130 Rudders (Exterior) Preserve 181

D-29 63300 Cathodic Protection, Zinc Anode Renewal 184 ii

Item SWBS Description Page

D-30 63400 Deck Coverings (Interior Polymeric) Reseal 186

D-31 86351 Temporary Services, Drydock Provide 188

D-32 86850 Sea Trials 197

D-33 99700 Drydocking Accomplish 200

O-34 11100 Exhaust Port Hull Plating Repair 205

O-35 11400 Appendages (Underwater) Air Test 208

O-36 11400 Voids (Underwater) Air Test 210

O-37 51200 Vent Ducts Commercial Cleaning 212

O-38 63120 Mast(s) Preservation 214

O-39 63130 Hull Plating, Underwater Body Preserve (100%) 220

O-40 63140 Hull Plating, Freeboard Preserve (Partial) 224

Definite work items are identified by a “D” preceding the item number in the table above. Optional work items are designated by an “O” and shall be individually priced for possible performance.

iii

CUTTER DESCRIPTION — USCGC SOCKEYE (WPB-87337)

[Design Class: 87’ WPB ]

Hull Characteristics:

Length, Overall 86’ 11” Length, Between the Perpendiculars 81’ 7” Beam, Molded at Deck Amidships 19’ 5” Draft, Mean to Design Waterline 5’ 9” Full Load Displacement 89.6 long tons (7’ 3” Baseline Draft) Displacement, Minimum Operating 83.9 long tons Displacement, Light Ship 77.9 long tons Mast Height 56’ above baseline Framing Longitudinal Bulkheads Four watertight bulkheads located below the Main Deck Anchor 40 lb Fortress with 480 ft. 3 strand 5/8” dia. Line stayset

Material:

Hull BS-4360, GR 43A Steel Main Weatherdeck BS-4360, GR 43A Steel Softpatch on Weatherdeck 5086 Aluminum Alloy Superstructure 5086 Aluminum Alloy

Machinery Characteristics:

Main Propulsion Two MTU 8V396TE94, Sequential turbo charged Diesels Reduction Gears Two ZF Type BW 255 reduction gearboxes Propulsion Shaft Two Aquamet 22, 101.6MM (4”) dia.

Shaft Seal Two John Crane Mechanical Seals Shaft Bearings, Intermed Thordon Elastomeric Bearing Shaft Bearings, Aft Thordon Elastomeric Bearing Propellers Two propellers, 1040mm dia., nominal pitch 1230, 5-bladed Rudders Two 316L Stainless Steel construction Ship’s Service Generators Two MAN Model D08241F01 diesel with Stanford 60 KW Generator Engineroom Installed Firefighting Agent Two 100 lb. CO2 bottles 4 discharge ports/3 activation areas

Tank Capacities:

Tank Number Contents Capacity 3-9-1-F FUEL OIL 1402 Gals 3-9-2-F FUEL OIL 1402 Gals 3-12-2-F WASTE OIL 86 Gals 3-12-1-F OILY WATER 86 Gals 3-7-0-Q SEWAGE COLLECTION 352 Gals 3-7-1-Q GRAY WATER 52 Gals 3-12-1-W FRESH WATER 200 gals 3-12-2-W FRESH WATER 200 gals

Accommodations:

Officers 0 Enlisted 8 Male, 3 female iv

CONSOLIDATED LIST OF REFERENCES

Drawings

87-WPB 111-1, Rev B; Shell Expansion 87-WPB 131-1, Rev F; Deck Construction Plan 87-WPB 131-2, Rev -; Forepeak Void New Watertight Flat 87-WPB 165-1, Rev D; Transducer Details 87-WPB 167-2, Rev -; Replacement of Main Deck Hatches 87-WPB 185-2, Rev E; Anchor Windlass and Boat Winch Installation 87-WPB 252-1, Rev D; Pilothouse Console Arrangement 87-WPB 252-2, Rev J; Alarm Monitoring System 87-WPB 302-1, Rev P; Misc. Controls Wiring Diagram 87-WPB 321-4, Rev -A; Hydrauilc Power Unit (HPU) System Electrical Power Removal and

Installation 87-WPB 423-1, Rev L; Speed Log & Depth Sounder System 87-WPB 529-1, Rev E; Bilge Piping 87-WPB 556-4, Rev -; Anchor Windlass and Boat Winch Hydraulic System Installation 87-WPB 561-1, Rev G; Steering Sys Details 87-WPB 562-1, Rev -; Rudder Details 87-WPB 581-1, Rev F; Anchor Handling & Hawse Pipe Details 87-WPB 621-1, Rev F; Joiner Work Details 87-WPB 635-1, Rev C; Linings and Insulation Plan & Details 87-WPB 85-50, Rev -; Docking Plan General Information (Supercedes 85-3) 87-WPB 085-010, Rev C; Docking Plan (This Drawing Modifies Dwg. 87-WPB-085-003), 2/27/2003 87-WPB 085-011, Rev B; Lifting Slings 87-WPB 085-012, Rev A; Lifting Cradle 87-WPB 085-050, Rev -, Docking Plan (This Drawing Modifies Dwg. 87-WPB-085-010) 87-WPB 111-001, Rev A; Shell Expansion 87-WPB 161-001, Rev -; Skeg Construction 87-WPB 161-2, Rev -, Stern Tube Details — Anode Access Ports 87-WPB 163-001, Rev B; Sea Chest Details 87-WPB 163-1, Rev D, Sea Chest Details 87-WPB 165-001, Rev A; Transducer Details 87-WPB 171-1, Rev F; Mast Details 87-WPB 243-1, Rev M; Propulsion Shaft Details 87-WPB 245-2, Rev -; Propeller Details 87-WPB 256-1, Rev M, Seawater Cooling Piping 87-WPB 259-001, Rev C; Engine Exhaust Piping 87-WPB 405-1, Rev F, Antenna Arrangement 87-WPB 526-1, Rev H; Scuppers & Deck Drains Piping 87-WPB 555-2, Rev F; AFFF Eng Rm Bilge Flooding System Arrgt & Det 87-WPB 561-001, Rev D; Steering System Detail 87-WPB 562-001, Rev -; Rudder Details 87-WPB 593-1, Rev H; Sewage Piping 87-WPB 601-001, Rev A; Outboard Profile and General Arrangement 87-WPB 635-001, Rev C; Linings & Insulation Plan & Detail 87-WPB 85-10, Rev C, Docking Plan FL 2804-11, Rev D, Visual ID Numeral & Letter for Ships FL 2804-12, Rev -, U.S.C.G. Emblem FL 2804-13, Rev G, Visual ID Kit Sched FL 2804-15, Rev -, Draft Figs v

Applicable Documents

15 USC §2601 to 2692, Toxic Substance Control Act (TSCA) 150N NAVSEA S9528-AA-MMI-010, Tech Man, Ops & Maint Cleaning CHT Piping Sys W/Hi

Press. Water Jet Equipment Model WBD-150N 16 CFR §1303, Ban of Lead-Containing Paint and Certain Consumer Products Bearing Lead-

Containing Paint 29 CFR §1910, Occupational Safety and Health Standards 29 CFR §1915, Occupational Health and Safety Standards for Shipyard Employment 29 CFR §1926, Safety and Health Regulations for Construction 33 CFR §154, Facilities Transferring Oil or Hazardous Materials in Bulk 33 USC §1251 to 1387, Federal Water Pollution Control Act 33 USC §1342, National Pollutant Discharge Elimination System 33 USC §2701 to 2761, Oil Pollution Control Act of 1990 40 CFR §112, Oil Pollution Prevention 40 CFR §204, Noise Emission Standards for Construction Equipment 40 CFR §261, Identification and Listing of Hazardous Waste 40 CFR §262, Standards Applicable to Generators of Hazardous Waste 40 CFR §263, Standards Applicable to Transporters of Hazardous Waste 40 CFR §279, Used Oil Management Standards 40 CFR §300, National Oil and Hazardous Substances Pollution Contingency Plan 40 CFR §61, National Emission Standards for Hazardous Air Pollutants 40 CFR §761, Polychlorinated Biphenyls (PCB) Manufacturing, Processing, Distribution in

Commerce, And Use Prohibitions 42 USC §4851 to 4852, Residential Lead-Based Paint Hazard Reduction Act 42 USC §4901 to 4918, Noise Control Act (NCA) 42 USC §6901 to 6991(i), Resource Conservation and Recovery Act (RCRA) 42 USC §7401 to 7671(q), Clean Air Act 42 USC §9601 to 9675, Comprehensive Environmental Response, Compensation, And Liability Act

(CERCLA)

49 CFR §100 to 199, Hazardous Materials Transportation, Handling, And Storage Regulations 7 USC §136 to 136(y), Federal Insecticide, Fungicide, And Rodenticide Act (FIFRA) ASTM D5363-03; Standard Specification for Anaerobic Single-Component Adhesives (AN), 2003 Alaska Administrative Code, Title 18 American Society for Nondestructive Testing (ASNT) SNT-TC-1A, 2006; Recommended Practice for

Nondestructive Testing Personnel Qualification and Certification American Society for Testing and Materials (ASTM) D5363, 2003E1; Standard Specification for

Anaerobic Single-Component Adhesives (An) American Society for Testing and Materials (ASTM) D5363-03, Standard Specification for Anaerobic

Single-Component Adhesives (An), 2003 American Society for Testing and Materials (ASTM) F1836M, Rev -, 1/1/2002; Standard

Specification for Stuffing Tubes, Nylon and Packing Assemblies (Metric) American Society of Mechanical Engineers (ASME) B16.11, Forged Steel Fittings, Socket-Welding and Threaded, 2001 American Society of Mechanical Engineers (ASME) B16.24-2001, Cast Copper Alloy Pipe Flanges and Flanged Fittings American Society of Mechanical Engineers (ASME) B16.5, Pipe Flanges & Flanged Fittings: Nps 1/2

Through Nps 24, 2003 American Welding Society (AWS) D1.1/D1.1M:2006, 2008 Rev 08; Structural Welding Code–Steel, 20TH Edition American Welding Society (AWS) D1.6/D1.6M, 2007; Structural Welding Code–Stainless Steel American Welding Society (AWS) D3.5, 1993R; Guide for Steel Hull Welding CG Tech Pub 3356, 3/12/1998; Manufacturer’s Information Book-SWBS Group(s) 167–202 CG Tech Pub 4506, 3/7/2005; Split Rudder–Type El CG Tech Pub 4529, 3/17/2003; Compact Vacuum Toilet–500 Series http://www.access.gpo.gov/uscode/title15/chapter53_.html http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1910_05.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=29:7.1.1.1.5&idno=29 http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1926_05.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=33:2.0.1.5.22&idno=33 http://www.access.gpo.gov/uscode/title33/chapter26_.html http://frwebgate.access.gpo.gov/cgi-bin/getdoc.cgi?dbname=browse_usc&docid=Cite:+33USC1342 http://www.access.gpo.gov/uscode/title33/chapter40_.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:21.0.1.1.7&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:24.0.1.2.10&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.2&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.3&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.4&idno=40 http://www.access.gpo.gov/nara/cfr/waisidx_06/40cfr279_06.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:27.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:8.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://www.access.gpo.gov/uscode/title42/chapter63a_.html http://www.access.gpo.gov/uscode/title42/chapter65_.html http://www.access.gpo.gov/uscode/title42/chapter82_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?sid=094a62612c31c4cade95984dfa2f2622&c=ecfr&tpl=/ecfrbrowse/Title49/49tab_02.tpl http://www.access.gpo.gov/uscode/title7/chapter6_subchapterii_.html http://webstore.ansi.org/ansidocstore/product.asp?sku=ASTM+D5363%2D03 http://touchngo.com/lglcntr/akstats/AAC/Title18.htm http://www.techstreet.com/index.tmpl http://www.techstreet.com/index.tmpl http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/DATABASE.CART/REDLINE_PAGES/D5363.htm?L+mystore+piqb3469 http://www.astm.org/cgi-bin/SoftCart.exe/DATABASE.CART/REDLINE_PAGES/D5363.htm?L+mystore+piqb3469 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://members.asme.org/catalog/ItemView.cfm?ItemNumber=M01601 http://members.asme.org/catalog/ItemView.cfm?ItemNumber=M01601 http://www.techstreet.com/cgi-bin/detail?product_id=1030584 http://www.techstreet.com/cgi-bin/detail?product_id=1030584 http://members.asme.org/catalog/ItemView.cfm?ItemNumber=M1503R http://members.asme.org/catalog/ItemView.cfm?ItemNumber=M1503R http://www.awspubs.com/ http://www.awspubs.com/ http://www.awspubs.com/ http://www.awspubs.com/ vi

CG Tech Pub 4564, 3/17/2003; Steering System;

CG Tech Pub 4593B, Seal, Rudderstock–Type Ej CG Tech Pub 4593C; Seal, Shaft – Type F.S.E.

CG Tech Pub 4624; Hydraulic Power Unit (HPU) CG Tech Pub 4625; Hydraulic Winch – Model PL2 CG Tech Pub 4630, Anchor Windlass COMDTINST 6260.21, Hazard Communications for Work Place Materials COMDTINST 9077.1, Equipment Tag-Out Procedure, Revision C COMDTINST M10360.3, Rev C; Coatings and Colors Manual COMDTINST M10360.3B, Coatings and Colors Manual, 6/12/2001 COMDTINST M10360.3C, Coatings and Colors Manual COMDTINST M16478.1, Hazardous Waste Management Manual COMDTINST M16478.2, Procurement, Handling and Disposal of Polychlorinated Biphenyls COMDTINST M6260.16A, Asbestos Exposure Control Manual, Ch-1 California Code of Regulations, Title 22, 4.5; Environmental Health Standards for the Management of

Hazardous Waste California Code of Regulations, Title 23, Waters California Health and Safety Code, Division 103; Disease Prevention And Health Promotion California Health and Safety Code, Division 104; Environmental Health.

California Health and Safety Code, Division 20; Miscellaneous Health And Safety Provisions California Health and Safety Code, Division 26; Air Resources California Health and Safety Code, Division 37; Regulation Of Environmental Protection DOD-STD-2185, Rev -; Requirements for Repair and Straightening of Bronze Naval Ship Propellers Federal Specification QQ-N-281, Rev Rev D, Amend 2; Nickel-Copper-Aluminum Alloy, Wrought

(UNS) N05500

Federal Standard FED-STD-595B(1), Rev B, Not 1; Color Used in Government Procurement Hawaii Administrative Code, Title 11 MIL-A-18001, Rev K, Amd 2, 5/2/2005; Anodes, Sacrificial Zinc Alloy MIL-A-22262, Rev B, Amd 2; Abrasive Blasting Media Ship Hull Blast Cleaning MIL-A-22262B, Abrasive Blasting Media Ship Hull Blast Cleaning, 3/21/1996 MIL-DTL-15024F, Plates, Tags and Bands for Identification of Equipment, 11/28/1997 MIL-DTL-24643, Rev B, Not 1, 5/30/2007; Cables and Cords, Electric, Low Smoke, For Shipboard

Use, General Specification for MIL-DTL-5624, Rev U; Turbine Fuel, Aviation, Grades JP-4 and JP-5 MIL-DTL-5624U, Turbine Fuel, Aviation, Grades JP-4 and JP-5, 1/5/2004 MIL-F-1183J SUP 1, Fittings, Pipe, Cast Bronze, Silver-Brazing, General Specifications for, 5/5/1987 MIL-HDBK-291, Rev -; Cargo Tank Cleaning, 9/26/1986 MIL-P-24647, Rev D; Paint System, Anticorrosive and Antifouling, Ship Hull, 2/16/2005 MIL-PRF-1149, Rev D; Gasket Materials, Synthetic Rubber, 50 and 65 Durometer Hardness MIL-PRF-1149D, Gasket Materials, Synthetic Rubber, 50 and 65 Durometer Hardness, 6/10/1998 MIL-PRF-16173, Rev E, Int Amd 1; Corrosion Preventive Compound, Solvent Cutback, Cold-

Application MIL-PRF-16884, Rev L; Fuel, Naval Distillate MIL-PRF-16884K, Fuel, Naval Distillate (NATO Symbol F-76), 11/14/2002 MIL-PRF-17672, Rev D, Amd 3; Hydraulic Fluid, Petroleum, Inhibited MIL-PRF-24613, Rev -, Amd 2, Not 1, 12/26/1990; Deck Covering Materials, Interior, Cosmetic

Polymeric MIL-PRF-24635 Enamel, Silicone Alkyd Copolymer MIL-PRF-24635, Rev C, 6/6/2003; Enamel, Silicone Alkyd Copolymer MIL-PRF-24635C, Enamel, Silicone Alkyd Copolymer, 6/6/2003 MIL-R-21252, Rev B Not 1; Rubber Sheet, Solid, Synthetic, Shipboard Water Evaporator Gasketing MIL-S-45180, Rev D, Not 2; Sealing Compound, Gasket, Hydrocarbon Fluid and Water Resistant MIL-STD-1625, Rev C, Chg Not 1; Safety Certification Program for Drydocking Facilities and

Shipbuilding Ways for U.S. Navy Ships MIL-STD-1625C(1), Safety Certification Program for Drydocking Facilities and Shipbuilding Ways http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_6260_21B.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_9077_1C.pdf http://www.uscg.mil/directives/cim/10000-10999/CIM_10360_3C.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_10360_3C.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F1b.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F2.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F6260%5F16a.pdf http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://assistdocs.com/search/document_details.cfm?ident_number=37312&StartRow=1&PaginatorPageNumber=1&doc%5Fnumber=2185&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=50916&StartRow=1&PaginatorPageNumber=1&doc%5Fid=QQ%2DN%2D281&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=50916&StartRow=1&PaginatorPageNumber=1&doc%5Fid=QQ%2DN%2D281&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=53815&StartRow=1&PaginatorPageNumber=1&doc%5Fid=FED%2DSTD%2D595&search%5Fmethod=BASIC http://www.hawaii.gov/health/about/rules/admrules.html http://www.assistdocs.com/search/document_details.cfm?ident_number=12627&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DA%2D18001&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=15260&StartRow=1&PaginatorPageNumber=1&doc%5Fnumber=22262&status%5Fall=ON&search%5Fmethod=BASIC http://stinet.dtic.mil/stinet/jsp/docread.jsp?K2DocKey=%2FstidataU2%2Fdodiss%2F1_5%2F14639.htm%40dodiss&querytext=%28%28abrasive+blasting+media+ship+hull+blast+cleaning%29+%3Cin%3E+ti%29 http://assist.daps.dla.mil/docimages/0001/06/85/15024F.PD9 http://www.assistdocs.com/search/document_details.cfm?ident_number=17614&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D24643&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17614&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D24643&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=2869&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DF%2D1183&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0004/64/16/24647.PD2 http://www.assistdocs.com/search/document_details.cfm?ident_number=2849&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D1149&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=2849&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D1149&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=275356&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16173&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=275356&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16173&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12454&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D17672&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17523&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24613&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17523&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24613&search%5Fmethod=BASIC http://66.102.7.104/search?q=cache:pT1qyTWzCB0J:www.uscg.mil/mlcpac/mlcp/Eng%2520Support/mlcpv/files/technical_resources/MLCP_vs_AppDocs.doc+mil+spec+mil-a-22262&hl=en&gl=us&ct=clnk&cd=3 http://www.assistdocs.com/search/document_details.cfm?ident_number=72486&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24635&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=72486&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24635&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=14621&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DR%2D21252&search%5Fmethod=BASIC http://assistdocs.com/search/document_details.cfm?ident_number=24523&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DS%2D45180&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC vii for U.S. Navy Ships, 12/30/1992 MIL-STD-1627, Bending of Pipe or Tube for Ship Piping System, 9/30/1994 MIL-STD-1627C, Bending of Pipe or Tube for Ship Piping System, 9/30/1994 MIL-STD-1689, Rev A; Fabrication, Welding and Inspection of Ships Structure, 11/23/1990 MIL-STD-1689A, Fabrication, Welding and Inspection of Ships Structure, 11/23/1990 MIL-STD-2035(SH), Nondestructive Testing Acceptance Criteria, 5/15/1995 MIL-STD-2035, Rev A, 5/15/1995; Nondestructive Testing Acceptance Criteria MIL-STD-2035A, Nondestructive Testing Acceptance Criteria, 5/15/1995 MIL-STD-22, Rev D, Not 3; Welded Joint Design MIL-STD-22D NOT 3, Welded Joint Design, 3/21/1991 MIL-STD-22D(3), Welded Joint Design, 3/21/1991 MIL-T-16420K(1), Tube, Copper-Nickel Alloy, Seamless and Welded (Copper Alloy Numbers 715 and 706), 9/16/1988 MLCPAC Instruction M9000.6, Rev E; Naval Engineering Organization and Operating Procedures MLCPAC Standard Specification 041, 1/1/2000; Production Control, Gantt Bar Chart MLCPAC Standard Specification 074, Welding and Allied Processes, 3/21/2003 MLCPAC Standard Specification 085.1, General Requirements for Drawing Preparation, 3/1/2000 MLCPAC Standard Specification 304.1, 3/1/2000; Shipboard Electrical Cable Test MLCPAC Standard Specification 304.2, 3/1/2000; Shipboard Electrical Cable Removal, Relocation, Splice, Repair and Installation MLCPAC Standard Specification 400, 3/1/1998; General Instructions for Installation, Repair, And/Or

Relocation of Electronic Equipment MLCPAC Standard Specification 634, 3/1/2000; Deck Covering Renewal MLCPAC Standard Specification 997, Drydocking, 3/29/2004 MLCPac Instruction 9000.6B, Naval Engineering Organization and Operating Procedures, 5/1/1996 NAVSEA 0900-LP-001-7000, Acn #1; Fabrication and Inspection of Brazed Piping Systems NAVSEA Dwg 803-1385721, Valves Bronze 1/4-2 Union End Swing Check, T NAVSEA Dwg 803-1385850, Piping, Instrument Pressure for All Service, J NAVSEA Dwg 803-1385866, Penetrations; Bulkhead and Deck, E NAVSEA Dwg 803-4384536, Valves; Bronze; 1/4”–2” Union End Globe; In-Line & Angle; Stop, Stop Check & Needle, J NAVSEA Dwg 803-4435837, Rev A; Propellers NAVSEA Dwg 803-6397256, Access, Covers, Ventilation Quick Acting NAVSEA Dwg 803-921865, Rev P; Cathodic Protection Hull Zinc Anodes NAVSEA Dwg 804-1385781, Pipe Hangers for Surface Ships (Superseding NAVSEA Dwg. 810-

1385781), E NAVSEA S9074-AR-GIB-010/278, Requirements for Fabrication Welding & Inspection & Casting

Inspection & Repair for Machinery, Piping & Pressure Vessels NAVSEA T9074-AS-GIB-010/271, Rev 97; Requirements for Non-Destructive Testing Methods NSTM S9086-RK-STM-010/CH-505R2, Naval Ships’ Technical Manual, Chapter 505, Piping

Systems, 2 NSTM S9086-VH-STM-010/CH-635R2, Naval Ships’ Technical Manual, Chapter 635, Thermal, Fire and Acoustic Insulation, 2 National Fire Protection Association NFPA 51 Standard for the Design and Installation of Oxygen-

Fuel Gas Systems for Welding, Cutting, And Allied Processes Naval Ships’ Technical Manual, Chapter 505, Piping Systems, 2 Naval Ships’ Technical Manual, Chapter 510, Heating, Ventilating and Air Conditioning Systems for

Surface Ships, 12/1/2001 Naval Ships’ Technical Manual, Chapter 541, Ship Fuel and Fuel Systems Naval Ships’ Technical Manual, Chapter 635, Thermal, Fire and Acoustic Insulation, 2 Naval Ship’s Technical Manual (NSTM) Chapter 074, Volume 1, Rev 5; Welding and Allied

Processes Naval Ship’s Technical Manual (NSTM) Chapter 074, Volume 3, Rev 4; Gas Free Engineering Naval Ship’s Technical Manual (NSTM) Chapter 081, Waterborne Underwater Hull Cleaning of Navy

Ships, Rev 4 http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0001/26/16/1627C.PD1 http://www.assistdocs.com/search/document_details.cfm?ident_number=37025&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1627&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37098&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1689&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0002/78/77/STD1689.PD7 http://assist.daps.dla.mil/docimages/0000/73/91/2035.PD2 http://www.assistdocs.com/search/document_details.cfm?ident_number=72749&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D2035&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=72749&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D2035&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=35349&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D22&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=35349&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D22&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0001/65/91/22D.PD9 http://www.assistdocs.com/search/document_details.cfm?ident_number=11860&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DT%2D16420&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=11860&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DT%2D16420&search%5Fmethod=BASIC http://cgweb.mlcpac.uscg.mil/mlcpv/SOPs/MLC_Instructions/M9000_6E.pdf?iSiteID=6435 http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec041rev01.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec_074_Mar03.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec085-1.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-1.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-2.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-2.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec400.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec400.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec634.pdf http://www.uscg.mil/mlcpac/mlcp/Eng Support/mlcpv/files/platform_support/mlcpacstandspec997_29Mar04.pdf http://store.ihs.com/specsstore/controller?event=DOCUMENT_DETAILS&docId=EPMIIAAAAAAAAAAA http://store.ihs.com/specsstore/controller?event=DOCUMENT_DETAILS&docId=EPMIIAAAAAAAAAAA http://store.ihs.com/specsstore/controller?event=LINK_DOCDETAILS&mid=W097&getCurVer=false&docId=NCTWCBAAAAAAAAAA http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 http://www.metalwebnews.org/ftp/navy-welding.pdf http://www.metalwebnews.org/ftp/navy-welding.pdf viii

Naval Ship’s Technical Manual (NSTM) Chapter 245, Propellers, Rev 5 Naval Ship’s Technical Manual (NSTM) Chapter 505, Rev 3; Piping Systems Naval Ship’s Technical Manual (NSTM) Chapter 593, Rev 5; Pollution Control Naval Ship’s Technical Manual (NSTM) Chapter 631, Volume 1, Rev 2; Preservation of Ships in

Service–General Naval Ship’s Technical Manual (NSTM) Chapter 635, Rev 3; Thermal, Fire and Acoustic Insulation Naval Ship’s Technical Manual (NSTM) S9086-T8-STM-010, Rev 4, 9/1/1999; Chapter 593, Pollution Control Nondestructive Testing Handbook, American Society for Non-Destructive Testing, Volume 1, Section

Oregon Administrative Rules, Chapter 340;

SAE-AMS-C-6183, Rev -; Cork and Rubber Composition Sheet for Aromatic Fuel and Oil Resistant

Gaskets, 12/18/1998 The Society for Protective Coatings (SSPC)-SP 3, Power Tool Cleaning, 11/1/1982 The Society for Protective Coatings SSPC -SP 10/NACE No.2, Near-White Blast Cleaning, 9/1/2000 The Society for Protective Coatings SSPC -SP 12/NACE No.5, Surface Preparation and Cleaning of

Steel & Other Hard Materials by High and Ultrahigh Pressure Water Jetting Prior to Recoating, 7/1/2002

The Society for Protective Coatings SSPC -SP VIS-1-02, Guide and Reference Photographs for Steel Surfaces Prepared by Dry Abrasive Blast Cleaning

The Society for Protective Coatings SSPC-SP 1, Rev -, 11/1/2004; Solvent Cleaning The Society for Protective Coatings SSPC-SP 10/NACE No.2, Near-White Blast Cleaning The Society for Protective Coatings SSPC-SP 11, 11/1/2004; Power Tool Cleaning to Bare Metal The Society for Protective Coatings SSPC-SP 12/NACE No.5, Surface Preparation and Cleaning of

Steel & Other Hard Materials by High and Ultrahigh Pressure Water Jetting Prior to Recoating, 7/1/2002

The Society for Protective Coatings SSPC-SP 15, Rev -, 11/1/2004; Commercial Grade Power Tool Cleaning

The Society for Protective Coatings SSPC-SP 3, Power Tool Cleaning The Society for Protective Coatings SSPC-SP 7/NACE No.4, Brush-Off Blast Cleaning The Society for Protective Coatings SSPC-SP VIS-1-02, Guide and Reference Photographs for Steel

Surfaces Prepared by Dry Abrasive Blast Cleaning The Society for Protective Coatings SSPC-VIS 1, Guide and Reference Photographs for Steel Surfaces

Prepared by Dry Abrasive Blast Cleaning The Society for Protective Coatings SSPC-VIS 3, Rev -; Guide and Reference Photographs for Steel

Surfaces Prepared by Hand and Power Tool Cleaning The Society for Protective Coatings SSPC-VIS 4/NACE VIS 7, Guide and Visual Reference

Photographs for Steel Cleaned by Waterjetting The Society for Protective Coatings SSPC/NACE VIS 4/NACE No. 7, Guide and Visual Reference

Photographs for Steel Cleaned by Waterjetting Washington Administrative Code, Chapter 173-303; Dangerous Waste Regulations http://www.fas.org/man/dod-101/sys/ship/nstm/ http://cgweb.lant.uscg.mil/vdiv/References/NSTM/books/S9086-VD-STM-010.pdf http://cgweb.lant.uscg.mil/vdiv/References/NSTM/books/S9086-VD-STM-010.pdf http://www.asnt.org/publications/handbook/handbook.htm http://www.asnt.org/publications/handbook/handbook.htm http://arcweb.sos.state.or.us/rules/OARs_300/OAR_340/340_tofc.html http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP3.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP10.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP1.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP10.htm?L+sspcstore+wukd3494+1057295146 http://www.sspc.org/standards/scopes.html http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.11.80.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP15.htm?L+sspcstore+uowz9441+1148197887 http://208.11.80.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP15.htm?L+sspcstore+uowz9441+1148197887 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP3.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP7.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.11.80.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0407.htm?L+sspcstore+jswq6654+1087520318 http://208.11.80.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0407.htm?L+sspcstore+jswq6654+1087520318 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://apps.leg.wa.gov/WAC/default.aspx?cite=173-303 ix

CONSOLIDATED LIST OF GOVERNMENT FURNISHED PROPERTY

Description Manufacturer Part Number NIIN Qty UOI

ITEM 10: HATCH COAMING REPLACEMENT

24 in. x 24 in. QAWT Raised Hatch Coaming, Stainless Steel, 4-Dog ISC Miami 3 ea

24 in. x 24 in. QAWT Flush Hatch Coaming, Stainless Steel, 4-Dog Freeman Marine, Inc 2464-USCG 1 ea

ITEM 11: PROPULSION SHAFT SEALS MECHANICAL OVERHAUL & INFLATABLE RENEWAL

87’WPB Major Overhaul Kit;

WLP001381-001 Rev C John Crane–FSE Type WLP001381-001 01-521-3217 2 ea

ITEM 13: PROPELLER CLEAN/ INSPECT

87’ Propeller Nut Anode 87WPB243-001

ITEM 39 01-481-8403 2 ea

Propeller end nut wrench Onboard Cutter 1 ea

ITEM 15: FATHOMETER TRANSDUCER RENEWAL

Transducer Raytheon Marine Corp or Airmar

M78733 or SS555-DT-7 or 31-462-3-01 or 31-811-3-01

01-465-9723 1 ea

ITEM 20: INSTALLATION OF NEW HYDRAULIC SYSTEM

Hardware Kit CG-ELC; ACN-2030-01-

F07-1078

USCG-87-

Commercial

01-F07- 1078 1 ea

Valve Kit CG-ELC; ACN-2030-01- F07-1079

05122-05123- 05124

01-F07- 1079 1 ea

HPU Kit CG-ELC; ACN-2030-01- F07-1080 05121 01-F07-

1080 1 ea

Accumulator Kit CG-ELC; ACN-2030-01- F07-1081 05125 01-F07-

1081 1 ea

Electrical Box Kit CG-ELC; ACN-2030-01- F07-1082

87WPB 321-

004, Piece 4

01-F07- 1082 1 ea

Motor Controller Kit CG-ELC; ACN-2030-01- F07-1092 285236 01-F07-

1092 1 ea

Blanking Plates Hydraulic Supply Company/at NESU A-D03-COP 3 ea

ITEM 21: INSTALL RUDDER STOCK SPLIT SEALS

Split Rudder Seal CG-ELC 01-565-9776 2 ea

GENERAL REQUIREMENTS — DRYDOCK

GR_00000_JMS_0308_Fleet

1 INTENT

This document invokes general requirements applicable to ship repair contracts for work performed at a contractor-provided facility and requiring a Coast Guard vessel to be placed in drydock. The items discussed in the General Requirements are an amplification of, or are in addition to, the specific items of the Specification. Other sections of the contract establish requirements for work on Coast Guard cutters. The General Requirements are a part of the contract and, as such, compliance is a contractual requirement. The Contractor is responsible for understanding and complying with all requirements established in the Specifications.

Government Furnished Property: NONE

2 REFERENCES

Coast Guard Drawings: NONE

Applicable Documents:

COMDTINST M6260.16A, Asbestos Exposure Control Manual, Ch-1 COMDTINST 6260.21, Hazard Communications for Work Place Materials COMDTINST 9077.1, Equipment Tag-Out Procedure, Revision C COMDTINST M16478.1, Hazardous Waste Management Manual COMDTINST M16478.2, Procurement, Handling and Disposal of Polychlorinated Biphenyls COMDTINST M10360.3, Rev C; Coatings and Colors Manual Federal Standard FED-STD-595B(1), Rev B, Not 1; Color Used in Government Procurement MIL-A-22262, Rev B, Amd 2; Abrasive Blasting Media Ship Hull Blast Cleaning MIL-DTL-5624, Rev U; Turbine Fuel, Aviation, Grades JP-4 and JP-5 MIL-PRF-16884, Rev L; Fuel, Naval Distillate MIL-STD-1625, Rev C, Chg Not 1; Safety Certification Program for Drydocking Facilities and

Shipbuilding Ways for U.S. Navy Ships MLCPAC Standard Specification 997, Drydocking, 3/29/2004 MLCPAC Standard Specification 085.1, General Requirements for Drawing Preparation, 3/1/2000 National Fire Protection Association NFPA 51 Standard for the Design and Installation of Oxygen-

Fuel Gas Systems for Welding, Cutting, And Allied Processes Nondestructive Testing Handbook, American Society for Non-Destructive Testing, Volume 1, Section

7 USC §136 to 136(y), Federal Insecticide, Fungicide, And Rodenticide Act (FIFRA) 15 USC §2601 to 2692, Toxic Substance Control Act (TSCA) 33 USC §1251 to 1387, Federal Water Pollution Control Act 33 USC §1342, National Pollutant Discharge Elimination System 33 USC §2701 to 2761, Oil Pollution Control Act of 1990 42 USC §4851 to 4852, Residential Lead-Based Paint Hazard Reduction Act 42 USC §4901 to 4918, Noise Control Act (NCA) 42 USC §6901 to 6991(i), Resource Conservation and Recovery Act (RCRA) 42 USC §7401 to 7671(q), Clean Air Act 42 USC §9601 to 9675, Comprehensive Environmental Response, Compensation, And Liability Act

(CERCLA)

http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F6260%5F16a.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_6260_21B.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_9077_1C.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F1b.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F2.pdf http://www.uscg.mil/directives/cim/10000-10999/CIM_10360_3C.pdf http://www.assistdocs.com/search/document_details.cfm?ident_number=53815&StartRow=1&PaginatorPageNumber=1&doc%5Fid=FED%2DSTD%2D595&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=15260&StartRow=1&PaginatorPageNumber=1&doc%5Fnumber=22262&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.uscg.mil/mlcpac/mlcp/Eng Support/mlcpv/files/platform_support/mlcpacstandspec997_29Mar04.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec085-1.pdf http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 http://www.asnt.org/publications/handbook/handbook.htm http://www.asnt.org/publications/handbook/handbook.htm http://www.access.gpo.gov/uscode/title7/chapter6_subchapterii_.html http://www.access.gpo.gov/uscode/title15/chapter53_.html http://www.access.gpo.gov/uscode/title33/chapter26_.html http://frwebgate.access.gpo.gov/cgi-bin/getdoc.cgi?dbname=browse_usc&docid=Cite:+33USC1342 http://www.access.gpo.gov/uscode/title33/chapter40_.html http://www.access.gpo.gov/uscode/title42/chapter63a_.html http://www.access.gpo.gov/uscode/title42/chapter65_.html http://www.access.gpo.gov/uscode/title42/chapter82_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html

16 CFR §1303, Ban of Lead-Containing Paint and Certain Consumer Products Bearing Lead- Containing Paint

29 CFR §1910, Occupational Safety and Health Standards 29 CFR §1926, Safety and Health Regulations for Construction 29 CFR §1915, Occupational Health and Safety Standards for Shipyard Employment 33 CFR §154, Facilities Transferring Oil or Hazardous Materials in Bulk 40 CFR §61, National Emission Standards for Hazardous Air Pollutants 40 CFR §112, Oil Pollution Prevention 40 CFR §204, Noise Emission Standards for Construction Equipment 40 CFR §261, Identification and Listing of Hazardous Waste 40 CFR §262, Standards Applicable to Generators of Hazardous Waste 40 CFR §263, Standards Applicable to Transporters of Hazardous Waste 40 CFR §279, Used Oil Management Standards 40 CFR §300, National Oil and Hazardous Substances Pollution Contingency Plan 40 CFR §761, Polychlorinated Biphenyls (PCB) Manufacturing, Processing, Distribution in

Commerce, And Use Prohibitions 49 CFR §100 to 199, Hazardous Materials Transportation, Handling, And Storage Regulations California Code of Regulations, Title 22, 4.5; Environmental Health Standards for the Management of

Hazardous Waste California Code of Regulations, Title 22, 4.5; Environmental Health Standards for the Management of

Hazardous Waste California Code of Regulations, Title 23, Waters California Health and Safety Code, Division 20; Miscellaneous Health And Safety Provisions California Health and Safety Code, Division 26; Air Resources California Health and Safety Code, Division 37; Regulation Of Environmental Protection California Health and Safety Code, Division 103; Disease Prevention And Health Promotion California Health and Safety Code, Division 104; Environmental Health.

Washington Administrative Code, Chapter 173-303; Dangerous Waste Regulations Oregon Administrative Rules, Chapter 340;

Alaska Administrative Code, Title 18 Hawaii Administrative Code, Title 11 MIL-DTL-5624U, Turbine Fuel, Aviation, Grades JP-4 and JP-5, 1/5/2004 MIL-PRF-16884K, Fuel, Naval Distillate (NATO Symbol F-76), 11/14/2002 MIL-STD-1625C(1), Safety Certification Program for Drydocking Facilities and Shipbuilding Ways for U.S. Navy Ships, 12/30/1992 MLCPAC Standard Specification 997, Drydocking, 3/29/2004

3 ADMINISTRATION

3.1 DEFINITIONS

3.1.1 Unless otherwise stated, the phrase as shown, as indicated, as detailed, or words of similar import refer to the contractual documents including drawings referenced in the specification.

3.1.2 The phrase as directed, as required, as permitted, approved, acceptance, or words of similar import refer to the direction, requirements, permission, approval, or acceptance by the Contracting Officer or a properly designated Contracting Officer’s Representative (COR).

3.1.3 Remove/Reinstall – To remove the original item and then later install the same original item back in its place after performing specified work on it.

3.1.4 Renew or renewal–To remove the original item and to install a new item in new condition, identical or of like size, material and quality to that removed (i.e. “Renew-in-Kind”).

http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1910_05.html http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1926_05.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=29:7.1.1.1.5&idno=29 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=33:2.0.1.5.22&idno=33 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:8.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:21.0.1.1.7&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:24.0.1.2.10&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.2&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.3&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.4&idno=40 http://www.access.gpo.gov/nara/cfr/waisidx_06/40cfr279_06.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:27.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?sid=094a62612c31c4cade95984dfa2f2622&c=ecfr&tpl=/ecfrbrowse/Title49/49tab_02.tpl http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://apps.leg.wa.gov/WAC/default.aspx?cite=173-303 http://arcweb.sos.state.or.us/rules/OARs_300/OAR_340/340_tofc.html http://touchngo.com/lglcntr/akstats/AAC/Title18.htm http://www.hawaii.gov/health/about/rules/admrules.html http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.uscg.mil/mlcpac/mlcp/Eng Support/mlcpv/files/platform_support/mlcpacstandspec997_29Mar04.pdf

3.1.5 Replace – To remove the original item and to install in its place a different item as described in the specification.

3.1.6 Restore – To bring back to the former, original or normal condition before alteration or removal.

3.1.7 Underwater body includes the external hull, all appendages, and sea chests from the keel up to and including the upper edge of the boot-top area.

3.1.8 The Contracting Officer’s Representative (COR) is the person delegated by the Contracting Officer as the on-scene representative for matters concerning performance of work.