RFI - QGS 25 100psi CAGI data sheet.pdf
PDF 184 KB Posted
- Attached to
- 355 CMS Fuel Compressors Maintenance
- Solicitation number
- FA487726QA185
About this file
This is a Compressor Data Sheet for a Quincy Compressor Model QGS 25, dated September 17, 2024, prepared in accordance with the Federal Uniform Test Method for Certain Lubricated Air Compressors. The document provides performance specifications for a single-stage, air-cooled, screw-type rotary compressor with fixed speed operation.
The compressor has a rated capacity of 109.8 actual cubic feet per minute (acfm) at full load operating pressure of 100 psig, with a maximum full flow operating pressure of 107 psig. The unit is powered by a 25 horsepower drive motor with 91.7 percent nominal efficiency and no fan motor (N/A). Total package input power at rated capacity and full load operating pressure is 21.86 kilowatts, with package specific power of 19.91 kW/100 cfm and isentropic efficiency of 66.75 percent. At zero flow conditions, the compressor requires 5.5 kilowatts of input power. The data presented reflects measurements taken in accordance with ISO 1217, Annex C, with verification tolerances specified based on volume flow rate ranges. Items marked with asterisks have been verified by third-party administrator through the CAGI Performance Verification Program.
View the file
Other files
| File | Type | Posted |
|---|---|---|
| RFI - Quincy Equipment Photos Bldg 4891.pdf | ||
| RFI - Quincy-Compressor-QPNC-Series.pdf | ||
| RFI - Quincy qsf data sheets.pdf | ||
| RFI - Questions and Answers.docx | DOCX document | |
| 355 CMS Fuel Compressors Mx - COMBO.pdf | ||
| 5. CLIN Pricing Sheet.docx | DOCX document | |
| 1. PWS 355 CMS Compressors Long Term MX.pdf | ||
| 3. WD 2015-5473.pdf | ||
| 4. Clauses and Provisions_FA487726QA185.pdf |
On GovTribe
Work with this file
- Download the original file
- Contacts named in this file
- Similar government files
- Ask GovTribe AI about this file
Text version
Date: 9/17/2024
X Air-cooled Water-cooled Type: Screw
# of Stages: 1
3* 109.8 acfma,e
4* Full Load Operating Pressure b 100 psigb
5 Maximum Full Flow Operating Pressure c 107 psigc
6 Drive Motor Nominal Rating 25 hp
7 Drive Motor Nominal Efficiency 91.7 percent
8 Fan Motor Nominal Rating (if applicable) N/A hp
9 Fan Motor Nominal Efficiency N/A percent
10* Total Package Input Power at Zero Flowe
5.5 kWe
11 21.86 kWd
12* 19.91 kW/100 cfme
13 66.75 Percent
*For models that are tested in the CAGI Performance Verification Program, these items are verified by the third party administrator.
Consult CAGI website for a list of participants in the third party verification program: www.cagi.org
NOTES: a. Measured at the discharge terminal point of the compressor package in accordance with ISO 1217, Annex C; ACFM is actual cubic feet per minute at inlet conditions.
b. The operating pressure at which the Capacity (Item 3) and Electrical Consumption (Item 11) were measured for this data sheet.
c. Maximum pressure attainable at full flow, usually the unload pressure setting for load/no load control or the maximum pressure attainable before capacity control begins. May require additional power.
d. Total package input power at other than reported operating points will vary with control strategy.
e. Tolerance is specified in ISO 1217, Annex C, as shown in table below:
NOTE: The terms "power" and "energy" are synonymous for purposes of this document.
Specific Energy Consumption m3 / min % % %
Below 0.5 +/- 7 +/- 8
0.5 to 1.5 +/- 6 +/- 7
1.5 to 15 +/- 5 +/- 6
ROT 030.1 Above 15 +/- 4 +/- 5
12/19 Rev 3 This form was developed by the Compressed Air and Gas Institute for the use of its members participating in the PVP. CAGI has not independently verified the reported data.
COMPRESSOR DATA SHEET
In Accordance with Federal Uniform Test Method for Certain Lubricated Air Compressors
Rotary Compressor: Fixed Speed
MODEL DATA - FOR COMPRESSED AIR
Manufacturer: Quincy Compressor
Member ft3 / min
Model Number: QGS 25
Rated Capacity at Full Load Operating Pressure a, e
Total Package Input Power at Rated Capacity and Full Load Operating Pressured
Package Specific Power at Rated Capacity and Full Load Operating
Pressuree
Isentropic Efficiency
Volume Flow Rate Volume Flow Rate
No Load / Zero Flow Powerat specified conditions
Below 17.6
+/- 10%
17.6 to 53
53 to 529.7
Above 529.7 http://www.cagi.org/
QGS 25, 100
File details come from the government source that posted it. Updated .