FY24 bldg 769 repair chillers
Award Notice Posted
- Solicitation number
- ACQR6069323
- Agency
-
Naval Facilities Engineering Command
Department of the Navy, Department of Defense
- Awarded
- to GKG Contractors LLC
- Set-aside
- 8(a) Sole Source
Opportunity facts
- Contract number
- N6945024C0073 Federal contract award
- NAICS code
- 236220 Commercial and Institutional Building Construction
- Place of performance
- Millington, Tennessee 38054, United States
- Points of contact
Notice details come from SAM.gov. Updated .
About this opportunity
This Award Notice is for a contract awarded by the Department of the Navy Naval Facilities Engineering Command to GKG CONTRACTORS LLC to repair the chillers in Building 769. The contract, valued at $228,742.00, includes work such as refrigerant recovery, compressor repair and replacement, filter and seal replacement, leak testing, and system recharge and verification. The award was made on August 30, 2024 under an 8(a) Sole Source set-aside.
Notice text
The work includes the following work to be completed on Building 769
chillers:
Lockout Tagout of electrical, Recovery of refrigerant and oil, Setup Gantry Crane over chiller, Disconnect Electrical for Motor to allow separation from compressor, Remove motor from compressor section with use of Gantry, Lift out compressor for tear down. Replace motor bearings, Breakdown compressor carefully not damage any sealing surfaces, Check all tolerances and clearances on shafts helical surfaces and any other moving parts, Inspect inlet guide vanes; Replace compressor bearings per factory equipment service manual, Replace wear rings and impeller only as needed. Carefully clean all gasket surfaces, Replace all gaskets, seals and o-rings in unit, Reinstall compressor back in place, Reinstall motor back on compressor and complete alignment, Change Driers and filters, Clean frequency drive cooler; Provide nitrogen charge on the system to leak test system minimum 24 hours, provide leak test in accordance with equipment service manual, Once leak test verification is complete. Pull vacuum on the system in accordance with manufacturer recommendations, Recharge system with refrigerant and oil as required for proper operation. Test run the system and verify proper operation and proper settings on system, Provide verification of system operation properly after 2 weeks run time, clean worksite, and incidental related work.
Awarded contract N6945024C0073 to GKG CONTRACTORS LLC for 228742.00 on 2024-08-30.
On GovTribe
Work this opportunity
- Track it in your pipeline
- Find teaming partners
- Similar opportunities
- Ask GovTribe AI about this opportunity