RECOVERY Y--Recovery Act - Upgrade HVAC & Plumbing System East Orange Project # 561-08-105

This notice is for project No. 561-08-105, Recovery Act - Upgrade HVAC and Plumbing Systems at VA New Jersey Healthcare System, East Orange Campus, 385 Tremont Avenue East Orange, NJ 07018-1023.

This shall be a Service Disabled Veteran Owned Small Business Set-Aside (SDVOSB). As a result all SDVOSB's may submit a bid, which shall be considered by the agency. This project is classified under NAICS code 236220, and has a size standard of $33.5 Million. The cost estimate for this project is between $2,000,000.00 and $3,000,000.00



The work for this requirement consists of, but is not limited to:



Contractor shall be responsible for furnishing and installing the upgrade and renovation of select HVAC & Plumbing systems at the East Orange NJ campus. The following work shall be provided:



5C-TB Ward Add dedicated steam to hot water convertor with 25% glycol pump package and piping distribution system to serve existing rooftop unit heating coil located at the southwest wing, 6th floor roof.

Water Softener at level C Replace existing water softener system with 3 new tanks system as specified.

Prosthetics - Replace existing chilled water air handler with new Dx split air handler and outdoor condensing unit.

Directors Suite - Replace/Upgrade HVAC Units with new variable refrigerant volume (VRV) system, fan coil units and associated outdoor condensing unit.

Bldg 15 - Replace Storage tank heater with Instantaneous heater.

Bldg 15, 16 17 & 18 - Replace Fan coil units and Dual Temp piping system. Total building area is 61,140 gsf. The scope includes the replacement of the entire DTS & R piping distribution system and associated FCU's in all four (4) buildings with a 4 pipe system. The existing chiller is 275 tons and is to remain. Associated cooling tower and main pumps to be replaced. The MER is attached to bldg 15 and its 1560 sq.ft. The MER Houses the chiller and circ pumps serving bldg 15, 16 17 & 18. The existing heat exchanger supplies HW. Cooling and heating is accomplished by individual cooling and heating control valves. These valves to be replace with new DDC control valves. The new 4 pipe distribution system connects to all buildings via interconnecting corridors in the hung ceiling and partial roof. Once in the building, the piping is then distributed within the attic space serving each floor mounted fan coil unit and air handler.

Replace Penthouse VFDs: (Estimated at 12 units).



All other Details and information shall be contained in the solicitation which shall be posted on www.fedbizopps.gov. The solicitation will be released on or around January 4, 2010. The bid submittal address, date and time will be included in the solicitation. This project requires bonding and all bid submission shall be in hardcopies; faxed or e-mailed bids will not be accepted. All bidders shall be registered in www.ccr.gov, www.vetbiz.gov, www.orca.bpn.gov, and http://vets100.vets.dol.gov.



End of Description