Vent SOW 17 reviewed bmp 112124.pdf

OCTOBER 2024

ZAU MEN’S RESTROOM 1002A AND 1003B VENT PIPE REPLACEMENT

CHICAGO Air Route Traffic Control Center

AURORA, ILLINOIS

DESCRIPTION / SPECIFICATION

FAA Personnel have been expereincing a foul smell that has been lingering in the facility for some time.

After investigation, a vent pipe that had rotted out was found. This pipe has holes in it and is releasing sewage gasses into the facility.

SCOPE

Air Route Traffic Control Center (ARTCC) 619 Indian Trail Aurora, Kane County Illinois 60506 Men’s Restrooms 1002A and 1003b vent pipe replacement.

The contractor will provide all tool, materials and personnel to complete the following:

a. Coordinate with an FAA Contractor Office Representative (COR) for any shutdowns and disconnects to the plumbing and system.

b. FAA personnel will operate all equipment, valves, and disconnects. Coordinate with the Contracting Officer Representative prior to equipment or system shutdown.

c. Contractor must replace all iron pipes with Polyvinyl Chloride pipe below ceiling.

d. all materials and equipment will be provided by the contractor who is doing the work

e. Prior to demobilization the work site and staging areas must be made clean and if damaged restore to its original state.

f. Provide safety data sheets for all materials especially containing volatile organic compound (VOC) to FAA for approval prior to delivery on site. When cleaning and preparing surfaces, proper vapor extraction and fresh air ventilation must be provided for each area of activity and vapors must be vented outside as directed by the FAA Contracting Officer.

g. Any welding, brazing or soldering and grinding needs to be approved prior to any work to protect the facility and personnel for health and safety to which contractor must comply. Proper vapor extraction and fresh air ventilation must be provided, and the vapor must be directed outside as directed by the FAA Contracting Officer.

h. Due to the hours or operation required for this facility, the work schedule and hours of work activity would be discussed by the facility to the contractor who is doing the project.

i. Monday - Friday, 6:00 am to 4:00 pm

Linda Hennequant Highlight FAA Personnel have been experiencing a foul smell...

ZAU MEN’S RESTROOM 1002A AND 1003B VENT PIPE REPLACEMENT PAGE 2 OF 3

CHICAGO ARTCC OCTOBER 2024

AURORA, ILLINOIS

PERFORMANCE TIME:

The project must be completed within 15 calendar days from the issuance of the Notice to Proceed (NTP), including all construction and restoration tasks

NEW WORK

• Any work in Confined Spaces must be done in accordance with OSHA

`Requirements 29 CFR 1910.146 and 1926.21(B)(6)

• Contractor must remove one urinal, two mirrors, and one lavatory sink.

• Contractor must ensure fixtures are not damaged during removal.

• Contractor must make necessary wall penetrations in the tiled cinderblock wall to complete the vent pipe replacement.

• Contractor must replace all iron pipes with PVC pipe below ceiling.

• Contractor must replace the old cast iron vent stack pipe with new Polyvinyl Chloride pipe that penetrates through roof.

• Contractor must reinstall all removed fixtures upon completion of wall repair.

REFERENCE DRAWING

• Provided is Drawing No. ZAU-CE-D-6510-M01 06/20/1969 Basement and First

Floor Plumbing Plans and is marked “FOR REFERACE ONLY.” Reference drawing must be used as a guide. Field verify all dimensions.

Amber N Jones Comment on Text Replace "shall" with "must"

ZAU MEN’S RESTROOM 1002A AND 1003B VENT PIPE REPLACEMENT PAGE 3 OF 3

CHICAGO ARTCC OCTOBER 2024

AURORA, ILLINOIS

1. Scope Notes:

a. Flow of work, as presented on the Scope of Work, is suggestive of minimum work to be accomplished and may be reordered or re-prioritized based on expediency or project.

b. Contractor must furnish all materials, equipment, and labor to complete the job in an orderly and timely fashion.

c. Prior to demobilization, the work sites and staging areas must be made clean and if damaged restored to its original state. Damage to any components or any facility property, during construction activity due to contractor’s unauthorized actions or actions not part of this project scope, must be corrected or replaced at the expense of the contractor.

d. Any work in Confined Spaces must be done in accordance with OSHA

`Requirements 29 CFR 1910.146 and 1926.21(B)(6)

(END OF STATEMENT OF WORK)

Linda Hennequant Sticky Note Be prepared to provide this drawing separately. This is very difficult to read.