SOW Supply Specs 1239 3657 3662 3685.pdf

4.0 TECHNICAL SPECIFICATIONS FOR FIRE COMMAND VEHICLE

a. LIGHT BAR The light bar will be 54”, mounted permanently or with the use of appropriate mounting brackets sized to fit the vehicle being outfitted. Whelen

Lighting can be a Whelen Cenator or Liberty II Solo IX54” or equivalent and will consist of low profile, light emitting diode (LED) or a combination of LED and strobe lighting.

Lenses will be clear with internal LED or strobe lighting illuminating the corresponding color as described in the specifications and lighting schematic sheet.

The lighting schematic will be set as follows:

• Two (2) forward facing white takedown modules in the two center positions.

• Two (2) Alley lights mounted one on each end.

• Two (2) forward facing, steady red modules, one outboard of each takedown light

• Two (2) forward facing. flashing red modules, one outboard of each steady red module

• Four (4) corner position red flashing modules.

• A traffic advisor shall be installed/integrated into the rear facing portion of the light bar.

The traffic advisor shall consist of six (6) amber lamps.

• Light Bar mount kit compatible with vehicle and light-bar manufacturer.

Two individual slim profile red LED light heads will be used on front of all four vehicles.

Whelen ION Series Super-LED Universal Lights or equivalent will be installed. Photos of acceptable installation:

Front grille lighting applies to all 4 vehicles: This extra rear lighting only applies to vehicle 1239:

will need additional lighting on the rear of the vehicle.

Only 1239

1240BE23Q0132

b. SIREN SPEAKER

Siren speakers will be compact and a minimum of 100 watts.

Recommended speakers:

Whelen Compact Federal Signal Gall’s 100 Watt Part No. SA315P Dynamax Concealment

Part No. ES100 Part No. SK145

Mounting brackets and locations will vary due to make and model of vehicles.

c. CONTROL HEAD - vehicle 1239 only

The control head must be similar to the Whelen 9 switch light control Part No.

295HFSA. If the 295HFSA is not available, the 295SLSA5 or Whelen CenCom CCSRN3** Control module equipped with the traffic advisor or equivalent is acceptable.

Installation of control head shall include ability to wire Forest Service radio into the control module to enable PA and Radio broadcasting.

d. CONTROL HEAD - vehicles 3657, 3662, 3685 only

Bench seating is to be retained in these 3 vehicles. Therefore we will not be installing a full center console. A Whelen HHS3200 or similar handheld lights and siren controller will be installed. Installation of control head shall include ability to wire Forest Service radio into the control module to enable PA and Radio broadcasting.

d. GRILLE and REAR LIGHTS

e. CENTER CONSOLE - for 1239 ONLY The existing front center seat will need to be removed to install a center console.

Console will need to be sized to allow 4WD shifter access at left of center floor while either fitting below the dash climate control or leaving sufficient room between. Removing any factory plastic cup holders on the floor will require adding a covering to fill the void.

Center console must have the following:

• Two Face plates, one for light controller and one for Forest Service Radio RLM-

150. Radio and antenna will be installed by FS technicians upon completion of upfitting after vehicle has been picked up from vendor.

• 1 Side map box

• 1 Locking storage box

• Map light

• 4 Cupholders, 2 available for the front seats and 2 available for the back seats

• Side armrests for front seats

• 2-12v DC outlets (mounted in a location available to both front and back seats)

• 2- USB charge outlets (mounted in a location available to both front and back)

• Floor Plate and Leg Kit to Mount console

f. BATTERY PROTECTOR A battery saver discharge timer shall be included in the install. Recommend a

Watchdog B120 or similar be used:

http://www.fleetsafety.com/watchdog-b120-120a-battery-saver-discharge-timer-by-d-r/

g. RADIO AND ANTENNA

The Forest Service radio and antenna will be installed by FS technicians upon completion of upfitting after vehicle has been picked up from vendor.

Radio install, coax, antenna mount, and antenna are not to be included in the bid.

http://www.fleetsafety.com/watchdog-b120-120a-battery-saver-discharge-timer-by-d-r/

h. FIRE COMMAND GRAPHICS All decals (including door shield with vehicle number) and striping are to be procured and installed by the vendor, following the “Fire Command, Operations Support, Prevention Pick-up Truck” illustrations dated July 2016.

Suggested vendor to procure fire graphics (has a govt. contract to produce FS door shields and fire striping packages):

Decal Details Kimberly Wood 2856 Cedar Dr.

Fruitland, ID 83619 208-452-5164 kim@decaldetails.com

Unit designator is OR-WWF (there is a dash between OR and WWF)

Equipment designator:

Vehicle 1239 (license plate A389829, VIN 3C7WRLFL5MG684468) the Equipment designator is C 51B (no dash between C and 51B, just a space)

Vehicle 3657 (license plate A398757, VIN 3C6UR5HJ9PG584316) the Equipment designator is BC 51 (no dash between BC and 51, just a space)

Vehicle 3662 (license plate A398762, VIN 3C6UR5HJ2PG584318) the Equipment designator is BC 52 (no dash between BC and 52, just a space)

Vehicle 3685 (license plate A398755, VIN 3C6UR5HJ0PG584317) the Equipment designator is BC 12 (no dash between BC and 12, just a space) mailto:kim@decaldetails.com