ASPEN_DD and Repair_January_2010_Rev 0.pdf

Specifications for the Drydock and Repair of

USCGC ASPEN (WLB-208)

January 2010 Rev 0

UNITED STATES COAST GUARD

MAINTENANCE AND LOGISTICS COMMAND PACIFIC

NAVAL ENGINEERING DIVISION

RONALD V. DELLUMS FEDERAL BUILDING

1301 CLAY STREET, SUITE 807N

OAKLAND, CALIFORNIA 94612-5249

Specifications for the Drydock and Repair of January 2010 USCGC ASPEN (WLB-214) Rev 0 i

Table of Contents

Item SWBS Description Page

Vessel Description iii

Consolidated List of References iv

Consolidated List of Government Furnished Property x

General Requirements — Drydock 1

D-1 04100 Production Control, Gantt Bar Chart Provide 21

D-2 11000 Hull Plating, Underwater Body Inspect 23

D-3 11400 Appendages (Underwater) Leak Test 29

D-4 11400 Appendages Underwater Preserve Internal 31

D-5 11400 Propulsion Shaft Rope Guard Inspect and Repair 33

D-6 11400 Voids (Non-Accessible) Preserve, Internal 35

D-7 11400 Voids Non-Accessible Leak Test 36

D-8 12311 Tanks (MP Fuel Service) Clean and Inspect 38

D-9 12311 Tanks (MP Fuel Stowage and Overflow) Clean and Inspect 41

D-10 12314 Tanks (Forepeak) Clean and Inspect 44

D-11 12316 Sea Bay Clean and Inspect 46

D-12 16700 Scuttle Replacement 49

D-13 24300 Propulsion Shaft Seal Mechanical Overhaul & Inflatable Renewal 53

D-14 24310 Propulsion Shafting Remove, Inspect and Reinstall 62

D-15 24400 Propulsion Shaft Bearing Stave Renewal 75

D-16 24500 Controllable Pitch Propeller System Maintenance 77

D-17 24500 Hubs General Maintenance 81

D-18 25610 Air Conditioning Condenser Seawater Cooling Overboard Discharge Modification 87

D-19 25900 MDE Exhaust Stacks Commercial Clean 95

D-20 25900 SSDG Exhaust Stacks Commercial Clean 98

D-21 31100 Electric Meter Calibration 100

D-22 42400 Fathometer Transducers General Maintenance 104

D-23 43700 Level Wind Arm Safety Interlock Installation 107

D-24 50400 Pressure Gauges and Thermometers (Critical) Calibration 113

D-25 50400 Pyrometers and Thermocouples (Critical) Calibration 120

D-26 51200 Vent Ducts (Engine & Motor Room, All) Commercial Clean 122

D-27 51200 Vent Ducts (Galley & Pantry, All) Commercial Clean 124

D-28 51200 Vent Ducts (Laundry Exhaust) Commercial Clean 126

D-29 52000 Sea Strainers (All Sizes) Overhaul 128 ii

Item SWBS Description Page

D-30 52000 Sea Valve (<= 2.5 Inches) Renewal 132

D-31 52000 Sea Valve (> 2.5 Inches) Overhaul 137

D-32 56201 Rudder Inspect and Repair 145

D-33 56202 Rudder Stock Bearings Check Clearances 147

D-34 56810 Thruster Generator Clean & Inspect 150

D-35 57300 Hydraulic Chain Inhaul Winch Level 2 Inspect and Repair 160

D-36 57300 Hydraulic Chainstoppers (Gen) Level 2 Inspect and Repair 170

D-37 57300 Hydraulic Crossdeck Winches (Gen) Level 2 Inspect and Repair 175

D-38 57300 Mechanical Chain Stoppers (Gen) Level 2 Inspect and Repair 182

D-39 58100 Anchor Windlass (Gen) Level 2 Inspect & Repair 185

D-40 58110 Anchor Chain and Ground Tackle Inspect and Repair 191

D-41 58200 Warping Capstan (Gen) Level 2 Inspect & Repair 196

D-42 58300 Boat Boom (Gen) Level 2 Inspect & Repair 200

D-43 58300 Single Point Davit (Gen) Level 2 Inspect & Repair 209

D-44 58900 Buoy and Cargo Crane Level 2 Inspect and Repair 217

D-45 59310 Gray Water Holding Tank Clean and Inspect 241

D-46 59310 Sewage Holding Tank and Atmospheric Tank Clean & Inspect 244

D-47 61100 Recessed Padeyes Repair and Test 248

D-48 63120 Buoy Decks (Exterior) Preserve, 100% 253

D-49 63130 Hull Plating, Underwater Body Preserve, Partial 258

D-50 63140 Hull Plating, Freeboard Preserve 263

D-51 63300 Cathodic Protection, Zinc Anode Renewal 268

D-52 86351 Temporary Services, Drydock Provide 270

D-53 86850 Sea Trials 281

D-54 99700 Drydocking Accomplish 284

O-55 11400 Appendages (Underwater) Air Test 288

O-56 11400 Voids (Underwater) Air Test 290

O-57 24300 Skim Cut Propulsion Tailshaft Sleeve 292

O-58 63130 Hull Plating, Underwater Body Preserve (100%) 294

O-59 63130 Hull Plating, Underwater Body Preserve, Additional 298

Definite work items are identified by a “D” preceding the item number in the table above. Optional work items are designated by an “O” and shall be individually priced for possible performance.

iii

CUTTER DESCRIPTION — USCGC ASPEN (WLB 208)

[Design Class: 225B-WLB]

Hull Characteristics:

Length Overall 225’ 0” Length, Between Perpendiculars 206’ 0” Beam, Molded 46’ 0” Designed Draft 13’ 0” Displacement, Full Load 2,000 L. tons Displacement, Light Ship 1523 L. tons Displacement, Minimum Operating 1800 L. tons Frame Spacing Frames 0-12: 21” Frames 12-30: 22” Frames 30-102 24” Hull Material Steel Mast Height (Above 12’ Waterline) 67’5” (Approximately) Bilge Keels (Port & Starboard) Frames 42 to 79 Rudder One Ground Tackle Two 4000 lb Standard Navy Stockless Anchors, 8 shots each, port and starboard, 1-3/8 Die-lock chain

Machinery Characteristics:

Main Propulsion Diesel Reduction Diesel Engines Two Caterpillar 3608, TA, 3100 BHP each, at 900 RPM Propeller One 10’ diameter, reversible pitch, 4 blade Ship’s Service Diesel Generators Two Caterpillar 3508 TA rated at 450 kW Emergency Diesel Generator One Caterpillar 3406 DITA rated at 280 kW Shore Tie Two 450 VAC, 400 Amp, 3-wire Shaft Bearing, Forward Copper Bearing 01-BCP-1400-EX-TL Shaft Bearing, Aft Water Lubricated Cuttlass Bearing E2-2934

Tank Capacities:

Diesel Oil Capacity 76,498 gallons Fresh Water Capacity 8,056 gallons Hydraulic Oil Capacity 2,785 gallons Lube Oil Storage 764 gallons Grey Water Tank 2700 gallons Sewage Holding Tank 1700 gallons

Crew Size:

Number of Crew 35 Number of Officers 6 Number of Females 5 iv

CONSOLIDATED LIST OF REFERENCES

Drawings

225- WLB 573-11, Rev _; ATON Tie Downs 225-WLB 243-203, Rev E, Stern Tube Split Dovetail Carrier Casting 225-WLB 556-10, Rev B; CPP Hydraulics System A & D, Hull Block 940 225-WLB 556-8, Rev F; CPP Hydraulic Sys Diagram 225-WLB 561-003, Rev E; Steering Gear Arrangement 225-WLB 562-001, Rev F; Steering Components Arrangement and Detail 225-WLB 562-002, Rev F; Rudder Structural A & D 225-WLB 562-202, Rev -; Pintle Housing Bearing 225-WLB 581-001, Rev E; Anchor Handling System Arrgt 225-WLB 583-52, Rev C; Workboat Davit Installation & Related Modification 225-WLB 593-1, Rev G, Sewage and Waste Water System Diagram 225-WLB 593-9, Rev C, Sewage Holding Tank 225-WLB 601-001, Rev C; General Arrangement Inboard & Outboard Profiles 225-WLB 601-1, Rev J, General Arrangements Inboard and Outboard Profiles 225-WLB 611-1, Rev G; Lifting Pads Main and Aux Mach Room 225B-WLB 111-1, Rev A; Shell Expansion 225B-WLB 114-1, Rev C; Shell Appendages 225B-WLB 114-2, Rev -; Flow Accelerating Fin 225B-WLB 201-2, Rev C; Access Removal Routes 225B-WLB 437-7, Rev J; Dk Mchry Cont Sys Blk Wrg Dk Plan & Elem Wrg Diag 225B-WLB 562-2, Rev C; Rudder Structural A & D 225B-WLB 573-1, Rev C; Buoy Handling System Arrangement 225B-WLB 601-2, Rev F; Booklet of General Drawings 225B-WLB 631-1, Rev G; Painting Schedule 225B-WLB 801-5, Rev A; Tank Capacity Curves 225B-WLB 801-6, Rev A; Docking Drawing 225B-WLB 950-2, Rev E; Hull Block 950 – Modules 225B-WLB 111-001, Rev A; Shell Expansion, 4/23/1999 225B-WLB 114-001, Rev B; Shell Appendages, 4/16/2001 225B-WLB 167-1, Rev G, Structural Closures 225B-WLB 180-3, Rev E, Foundations Hull Block 920 225B-WLB 233-1, Rev B; Propulsion Train Installation Drawing 225B-WLB 243-001, Rev A; Propulsion Shafting Arrangement, 4/14/2000 225B-WLB 243-1, Rev B; Propulsion Shafting Arrangement 225B-WLB 243-2, Rev D; Stern Tube and Bearing A & D 225B-WLB 256-1, Rev L; Seawater System Cooling Diagram 225B-WLB 256-4, Rev E; SW Cooling System FR 66 Aft Block 940, 950 & 970 225B-WLB 256-5, Rev -; Mods to Seawater Cooling Ovbd–A/C Condensers 225B-WLB 259-001, Rev C; Combustion Intake & Exhaust Diagram 225B-WLB 259-005, Rev C; Combustion Intake & Exhaust A&D Hull Block 940 225B-WLB 259-006, Rev B; Combustion Intake & Exhaust A&D Hull Block 970 & 975 225B-WLB 259-1, Rev C; Combustion Intake & Exhaust Diagram 225B-WLB 259-5, Rev C; Combustion Intake & Exhaust A&D Hull Block 940 225B-WLB 259-6, Rev B; Combustion Intake & Exhaust A & D Hull Block 970 & 975 225B-WLB 424-1, Rev C, Acoustic Nav System Block and Isometric 225B-WLB 505-1, Rev C; General Requirements for Piping Systems 225B-WLB 508-1, Rev A; Thermal Insulation for Mchry, Equipment and Piping 225B-WLB 549-1, Rev A; Onboard Lubrication Requirements 225B-WLB 556-1, Rev B; Hydraulic System Diagram 225B-WLB 562-002, Rev C; Rudder–Struct A & D v

225B-WLB 562-2, Rev C; Rudder Structural A & D 225B-WLB 573-1, Rev C; Buoy Handling System Arrangement 225B-WLB 573-2, Rev -; Weight Handling System Arrangement 225B-WLB 581-1, Rev B; Anchor Handling System Arrangement 225B-WLB 583-1, Rev B; Boat Launching & Stowage A & D 225B-WLB 601-002, Rev -, Booklet of General Plans 225B-WLB 601-2, Rev E, Booklet of General Drawings 225B-WLB 633-002, Rev A; Cathodic Protection Passive, 2/22/2000 225B-WLB 635-001, Rev A; Hull Thermal & Acoustic Schedule 225B-WLB 801-006, Rev -; Docking Drawing, 5/22/2001 225B-WLB 801-6, Rev C; Docking Drawing 225B-WLB-111-001, Rev A; Shell Expansion FL 2605-29, Rev C; Chain Stopper Hydraulic Roller Assembly FL 2605-31, Rev B; Mechanical Chain Stopper, 1-7/8” Buoy Chain FL 2605-34, Rev B; Mechanical Chain Stopper Repair Kit: 1-7/8”, 1-5/8” FL 2605-37, Rev -; Mechanical Chain Stopper 175’ WLM & 225’ WLB Re-Install FL 2804-11, Rev D, Visual ID Numeral & Letter for Ships FL 2804-12, Rev -, U.S.C.G. Emblem FL 2804-13, Rev G, Visual ID Kit Sched FL 2804-15, Rev -, Draft Figs FL 4823-60, Rev G; Cast Steel Waster Pieces FL 6713-3, Rev E; An/SQN-13/18 Transducer Installation for Steel Hull

Applicable Documents

Installation, Repair and/or Relocation of Electronic Equipment 15 USC §2601 to 2692, Toxic Substance Control Act (TSCA) 16 CFR §1303, Ban of Lead-Containing Paint and Certain Consumer Products Bearing Lead-

Containing Paint 29 CFR §1910, Occupational Safety and Health Standards 29 CFR §1915, Occupational Health and Safety Standards for Shipyard Employment 29 CFR §1926, Safety and Health Regulations for Construction 33 CFR §154, Facilities Transferring Oil or Hazardous Materials in Bulk 33 USC §1251 to 1387, Federal Water Pollution Control Act 33 USC §1342, National Pollutant Discharge Elimination System 33 USC §2701 to 2761, Oil Pollution Control Act of 1990 40 CFR §112, Oil Pollution Prevention 40 CFR §204, Noise Emission Standards for Construction Equipment 40 CFR §261, Identification and Listing of Hazardous Waste 40 CFR §262, Standards Applicable to Generators of Hazardous Waste 40 CFR §263, Standards Applicable to Transporters of Hazardous Waste 40 CFR §279, Used Oil Management Standards 40 CFR §300, National Oil and Hazardous Substances Pollution Contingency Plan 40 CFR §61, National Emission Standards for Hazardous Air Pollutants 40 CFR §761, Polychlorinated Biphenyls (PCB) Manufacturing, Processing, Distribution in

Commerce, And Use Prohibitions 42 USC §4851 to 4852, Residential Lead-Based Paint Hazard Reduction Act 42 USC §4901 to 4918, Noise Control Act (NCA) 42 USC §6901 to 6991(i), Resource Conservation and Recovery Act (RCRA) 42 USC §7401 to 7671(q), Clean Air Act 42 USC §9601 to 9675, Comprehensive Environmental Response, Compensation, And Liability Act

(CERCLA)

49 CFR §100 to 199, Hazardous Materials Transportation, Handling, And Storage Regulations 7 USC §136 to 136(y), Federal Insecticide, Fungicide, And Rodenticide Act (FIFRA) ASTM D5363-03; Standard Specification for Anaerobic Single-Component Adhesives (AN), 2003 http://www.access.gpo.gov/uscode/title15/chapter53_.html http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_06/16cfr1303_06.html http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1910_05.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=29:7.1.1.1.5&idno=29 http://www.access.gpo.gov/nara/cfr/waisidx_05/29cfr1926_05.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=33:2.0.1.5.22&idno=33 http://www.access.gpo.gov/uscode/title33/chapter26_.html http://frwebgate.access.gpo.gov/cgi-bin/getdoc.cgi?dbname=browse_usc&docid=Cite:+33USC1342 http://www.access.gpo.gov/uscode/title33/chapter40_.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:21.0.1.1.7&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:24.0.1.2.10&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.2&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.3&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:25.0.1.1.4&idno=40 http://www.access.gpo.gov/nara/cfr/waisidx_06/40cfr279_06.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:27.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:8.0.1.1.1&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=094a62612c31c4cade95984dfa2f2622&rgn=div5&view=text&node=40:30.0.1.1.17&idno=40 http://www.access.gpo.gov/uscode/title42/chapter63a_.html http://www.access.gpo.gov/uscode/title42/chapter65_.html http://www.access.gpo.gov/uscode/title42/chapter82_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://www.access.gpo.gov/uscode/title42/chapter85_subchapteri_.html http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?sid=094a62612c31c4cade95984dfa2f2622&c=ecfr&tpl=/ecfrbrowse/Title49/49tab_02.tpl http://www.access.gpo.gov/uscode/title7/chapter6_subchapterii_.html http://webstore.ansi.org/ansidocstore/product.asp?sku=ASTM+D5363%2D03 vi

Alaska Administrative Code, Title 18 American National Standards Institute (ANSI/NCSL) Z540.1, Rev 1994 (R2002), 8/1/1994; General

Requirements for Calibration and Measuring and Test Equipment American Petroleum Institute (API) 9A, Rev 25TH Edition; Specification for Wire Rope and ISO

10425:2003, Steel Wire Ropes for the Petroleum and Natural Gas Industries – Minimum Requirements and Terms for Acceptance

American Society for Testing and Materials (ASTM) A105/A105M, 2005; Standard Specification for Carbon Steel Forgings for Piping Applications

American Society for Testing and Materials (ASTM) A106/A106M, 2006A; Standard Specification for Seamless Carbon Steel Pipe for High-Temperature Service

American Society for Testing and Materials (ASTM) A181/A181M, 2006; Standard Specification for Carbon Steel Forgings, For General-Purpose Piping

American Society for Testing and Materials (ASTM) A27/A27M, 2005; Standard Specification for Steel Castings, Carbon, For General Application

American Society for Testing and Materials (ASTM) A36/A36M, 2005; Standard Specification for Carbon Structural Steel

American Society for Testing and Materials (ASTM) A519, 2006; Standard Specification for Seamless Carbon and Alloy Steel Mechanical Tubing

American Society for Testing and Materials (ASTM) B151/B151M, 2005; Standard Specification for Copper-Nickel-Zinc Alloy (Nickel Silver) And Copper-Nickel Rod and Bar

American Society for Testing and Materials (ASTM) B171/B171M, 2004; Standard Specification for Copper-Alloy Plate and Sheet for Pressure Vessels, Condensers, And Heat Exchangers

American Society for Testing and Materials (ASTM) D5363, 2003E1; Standard Specification for Anaerobic Single-Component Adhesives (An)

American Society for Testing and Materials (ASTM) D5363-03, Standard Specification for Anaerobic Single-Component Adhesives (An), 2003

American Society for Testing and Materials (ASTM) F683, 2003A; Standard Practice for Selection and Application of Thermal Insulation for Piping and Machinery

American Society of Mechanical Engineers (ASME) B16.24, Rev -, 2/1/2002; Cast Copper Alloy Pipe Flanges and Flanged Fittings: Class 150, 300, 400, 600, 900, 1500 and 2500

American Society of Mechanical Engineers (ASME) B16.5, Rev 2003, 12/1/2003; Pipe Flanges & Flanged Fittings: Nps 1/2 Through Nps 24

American Society of Mechanical Engineers (ASME) B16.9, Rev 2003, 2/20/2003; Factory-Made Wrought Buttwelding Fittings

American Welding Society (AWS) D1.1/D1.1M:2006, 2008; Structural Welding Code–Steel, 21ST Edition

CG Tech Pub 3498, 10/30/2002; Buoy Chain Winch CG Tech Pub 3523, 5/21/1996; Manufacturer’s Instruction Book-SWBS Group(s) 241-242 CG Tech Pub 3524, 1/7/1997; Manufacturer’s Instruction Book-SWBS Group(s) 243-262 CG Tech Pub 3553, 1/7/1997; Manufacturer’s Instruction Book-SWBS Group(s) 551-556 CG Tech Pub 3554, 5/21/1996; Manufacturer’s Instruction Book-SWBS Group(s) 556 CG Tech Pub 3556, Manufacturer’s Instruction Book–SWBS Group(s) 568 CG Tech Pub 3557, 1/7/1997; Manufacturer’s Instruction Book-SWBS Group(s) 568-573 CG Tech Pub 3558, 5/21/1996; Manufacturer’s Instruction Book-SWBS Group(s) 573 CG Tech Pub 3559, 1/7/1997; Manufacturer’s Instruction Book-SWBS Group(s) 573-582 CG Tech Pub 3562, 5/21/1996; Manufacturer’s Instruction Book-SWBS Group(s) 583-589 CG Tech Pub 3574, 5/21/1996; Manufacturer’s Instruction Book-SWBS Group(s) 633-638 CG Tech Pub 3750, 1/7/1997; Manufacturer’s Instruction Book-SWBS Group(s) 573-582 CG Tech Pub 3762; Dual Point Davit – ATON Workboat – Model TWPIV5-0A COMDTINST 6260.21, Hazard Communications for Work Place Materials COMDTINST 9077.1, Equipment Tag-Out Procedure, Revision C COMDTINST M10360.3, Rev C; Coatings and Colors Manual COMDTINST M10360.3B, B, Coatings and Colors Manual, 11/24/2003 COMDTINST M10360.3C, Coatings and Colors Manual COMDTINST M16478.1, Rev B, Chg 3; Hazardous Waste Management Manual http://touchngo.com/lglcntr/akstats/AAC/Title18.htm http://www.techstreet.com/ http://www.techstreet.com/ http://www.techstreet.com/cgi-bin/detail?product_id=1149165 http://www.techstreet.com/cgi-bin/detail?product_id=1149165 http://www.techstreet.com/cgi-bin/detail?product_id=1149165 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.techstreet.com/cgi-bin/detail?product_id=1211477 http://www.techstreet.com/cgi-bin/detail?product_id=1211477 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.techstreet.com/cgi-bin/detail?product_id=1311322 http://www.techstreet.com/cgi-bin/detail?product_id=1311322 http://www.techstreet.com/cgi-bin/detail?product_id=1247043 http://www.techstreet.com/cgi-bin/detail?product_id=1247043 http://www.techstreet.com/cgi-bin/detail?product_id=1169544 http://www.techstreet.com/cgi-bin/detail?product_id=1169544 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/DATABASE.CART/REDLINE_PAGES/D5363.htm?L+mystore+piqb3469 http://www.astm.org/cgi-bin/SoftCart.exe/DATABASE.CART/REDLINE_PAGES/D5363.htm?L+mystore+piqb3469 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.astm.org/cgi-bin/SoftCart.exe/NEWSITE_JAVASCRIPT/index.shtml?L+mystore+osjf6594+1181277355 http://www.techstreet.com/cgi-bin/detail?product_id=1030584 http://www.techstreet.com/cgi-bin/detail?product_id=1030584 http://www.techstreet.com/ http://www.techstreet.com/ http://members.asme.org/catalog/ItemView.cfm?ItemNumber=J10903 http://members.asme.org/catalog/ItemView.cfm?ItemNumber=J10903 http://www.awspubs.com/ http://www.awspubs.com/ http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_6260_21B.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_9077_1C.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_10360_3C.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_10360_3C.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_16478_1B.pdf vii

COMDTINST M16478.2, Procurement, Handling and Disposal of Polychlorinated Biphenyls COMDTINST M6260.16A, Asbestos Exposure Control Manual, Ch-1 COMDTINST M9000.6, Rev E; Naval Engineering Manual (NEM) California Code of Regulations, Title 22, 4.5; Environmental Health Standards for the Management of

Hazardous Waste California Code of Regulations, Title 22, Division 4; Environmental Health California Code of Regulations, Title 23, Waters California Health and Safety Code, Division 103; Disease Prevention And Health Promotion California Health and Safety Code, Division 104; Environmental Health.

California Health and Safety Code, Division 20; Miscellaneous Health And Safety Provisions California Health and Safety Code, Division 26; Air Resources California Health and Safety Code, Division 37; Regulation Of Environmental Protection Commercial Item Descriptions (CID) A-A-59323, Rev A; Cloths, Cleaning, Low-Lint DOD-G-24508, Rev A(4); Grease, High Performance, Multi-Purpose Federal Specification HH-P-151, Rev F, Not 1; Packing, Rubber Sheet, Cloth Insert Federal Specification QQ-N-281, Rev Rev D, Amend 2; Nickel-Copper-Aluminum Alloy, Wrought

(UNS) N05500

Federal Standard FED-STD-595B(1), Rev B, 1/11/1994; Color Used in Government Procurement Hawaii Administrative Code, Title 11 International Standard Organization (ISO) 4406, Rev -; Hydraulic Fluid Power — Fluids — Method for Coding the Level of Contamination by Solid Particles MIL-A-18001, Rev K, Amd 2, 5/2/2005; Anodes, Sacrificial Zinc Alloy MIL-A-22262, Rev B, Amd 2; Abrasive Blasting Media Ship Hull Blast Cleaning MIL-A-22262B, Abrasive Blasting Media Ship Hull Blast Cleaning, 3/21/1996 MIL-C-24633, Rev A, Not 1; Chain, Stud Link, Anchor, Low Alloy Steel, Flash Butt Welded –

Inactive, No Longer Used, Except for Replacement Purposes MIL-D-16791, Rev G; Detergents, General Purpose (Liquid, Non-Ionic), 1/15/1993 MIL-DTL-15024, Rev Rev F, 11/28/1997; Plates, Tags and Bands for Identification of Equipment MIL-DTL-23549, Rev D, Not 1; Grease, General Purpose MIL-DTL-24643, Rev B, Sup 1A; Cables and Cords, Electric, Low Smoke, For Shipboard Use, General Specification for MIL-DTL-5624, Rev U; Turbine Fuel, Aviation, Grades JP-4 and JP-5 MIL-DTL-5624U, Turbine Fuel, Aviation, Grades JP-4 and JP-5, 1/5/2004 MIL-F-24402, Rev E, Amd 1; Filters (Hydraulic), Filter Elements (High Efficiency), And Filter

Differential Pressure Indicators, General Specification for MIL-F-24702, Rev -, Amd 2 Not 1; Filter Elements, Hydraulic Disposable, General Specification for

(Metric) MIL-G-18458, Rev B, Amd 5; Grease, Wire Rope and Exposed Gear MIL-G-24696, Rev B, Amd 1; Gasket, Sheet, Non-Asbestos MIL-HDBK-291, Rev -, 9/26/1986; Cargo Tank Cleaning MIL-I-24092/1, Rev A; Insulating Varnish, Solvent Containing, Air-Dry for Spot Patching and

Emergency Repairs, Grades CA, Class 130 and 155 Thermal Class, 9/21/1993 MIL-P-24647, Rev D; Paint System, Anticorrosive and Antifouling, Ship Hull, 2/16/2005 MIL-PRF-1149, Rev D, 6/10/1998; Gasket Materials, Synthetic Rubber, 50 and 65 Durometer

Hardness MIL-PRF-16173, Rev E, Int Amd 1; Corrosion Preventive Compound, Solvent Cutback, Cold-

Application MIL-PRF-16884, Rev L; Fuel, Naval Distillate MIL-PRF-16884K, Fuel, Naval Distillate (NATO Symbol F-76), 11/14/2002 MIL-PRF-24139, Rev A, Amd 3; Grease, Multipurpose, Water Resistant MIL-PRF-24635 Enamel, Silicone Alkyd Copolymer MIL-PRF-24635, Rev C, 6/6/2003; Enamel, Silicone Alkyd Copolymer MIL-R-21252, Rev B Not 1; Rubber Sheet, Solid, Synthetic, Shipboard Water Evaporator Gasketing MIL-S-22473 , Rev E(8); Sealing, Locking, And Retaining Compounds: (Single Component), 11/18/2009 http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F2.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F6260%5F16a.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_9000_6E.pdf http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://government.westlaw.com/linkedslice/default.asp?SP=CCR-1000 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.leginfo.ca.gov/cgi-bin/calawquery?codesection=hsc&codebody=&hits=20 http://www.assistdocs.com/search/document_details.cfm?ident_number=206627&StartRow=1&PaginatorPageNumber=1&doc%5Fid=A%2DA%2D59323&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=50422&StartRow=1&PaginatorPageNumber=1&doc%5Fid=HH%2DP%2D151&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=50916&StartRow=1&PaginatorPageNumber=1&doc%5Fid=QQ%2DN%2D281&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=50916&StartRow=1&PaginatorPageNumber=1&doc%5Fid=QQ%2DN%2D281&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=53815&StartRow=1&PaginatorPageNumber=1&doc%5Fid=FED%2DSTD%2D595&search%5Fmethod=BASIC http://www.hawaii.gov/health/about/rules/admrules.html http://www.iso.ch/iso/en/CatalogueDetailPage.CatalogueDetail?CSNUMBER=21463&ICS1=23&ICS2=100&ICS3=60 http://www.iso.ch/iso/en/CatalogueDetailPage.CatalogueDetail?CSNUMBER=21463&ICS1=23&ICS2=100&ICS3=60 http://www.assistdocs.com/search/document_details.cfm?ident_number=12627&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DA%2D18001&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=15260&StartRow=1&PaginatorPageNumber=1&doc%5Fnumber=22262&status%5Fall=ON&search%5Fmethod=BASIC http://stinet.dtic.mil/stinet/jsp/docread.jsp?K2DocKey=%2FstidataU2%2Fdodiss%2F1_5%2F14639.htm%40dodiss&querytext=%28%28abrasive+blasting+media+ship+hull+blast+cleaning%29+%3Cin%3E+ti%29 http://www.assistdocs.com/search/document_details.cfm?ident_number=17565&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DC%2D24633&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17565&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DC%2D24633&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=11007&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D15024&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=16419&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D23549&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17614&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D24643&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17614&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D24643&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17291&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DF%2D24402&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17291&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DF%2D24402&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17770&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DF%2D24702&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=17770&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DF%2D24702&search%5Fmethod=BASIC http://www.techstreet.com/cgi-bin/detail?product_id=41219 http://www.assistdocs.com/search/document_details.cfm?ident_number=67061&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DG%2D24696&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=54003&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DHDBK%2D291&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0004/64/16/24647.PD2 http://www.assistdocs.com/search/document_details.cfm?ident_number=2849&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D1149&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=2849&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D1149&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=275356&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16173&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=275356&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16173&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=16850&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24139&search%5Fmethod=BASIC http://66.102.7.104/search?q=cache:pT1qyTWzCB0J:www.uscg.mil/mlcpac/mlcp/Eng%2520Support/mlcpv/files/technical_resources/MLCP_vs_AppDocs.doc+mil+spec+mil-a-22262&hl=en&gl=us&ct=clnk&cd=3 http://www.assistdocs.com/search/document_details.cfm?ident_number=72486&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D24635&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=14621&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DR%2D21252&search%5Fmethod=BASIC viii

MIL-S-45180, Rev D, Not 2; Sealing Compound, Gasket, Hydrocarbon Fluid and Water Resistant MIL-STD-1625, Rev C, Chg Not 1; Safety Certification Program for Drydocking Facilities and

Shipbuilding Ways for U.S. Navy Ships MIL-STD-1625C(1), Safety Certification Program for Drydocking Facilities and Shipbuilding Ways for U.S. Navy Ships, 12/30/1992 MIL-STD-1627, Rev Rev C, 9/30/1994; Bending of Pipe or Tube for Ship Piping Systems MIL-STD-1628, 6/28/1974; Fillet Weld Size, Strength and Efficiency Determination MIL-STD-1689, Rev Rev A, 11/23/1990; Fabrication, Welding and Inspection of Ships Structure MIL-STD-2035(SH), Nondestructive Testing Acceptance Criteria, 5/15/1995 MIL-STD-2035, Rev Rev A, 5/15/1995; Nondestructive Testing Acceptance Criteria MIL-STD-22, Rev Rev D, Not 3, 3/21/1991; Welded Joint Design MIL-T-16420, Rev Rev K, Amd 1, 9/16/1988; Tube, Copper-Nickel Alloy, Seamless and Welded

(Copper Alloy Numbers 715 and 706) MLCPAC Standard Specification 041, 1/1/2000; Production Control, Gantt Bar Chart MLCPAC Standard Specification 074, Welding and Allied Processes, 3/21/2003 MLCPAC Standard Specification 085.1, General Requirements for Drawing Preparation, 3/1/2000 MLCPAC Standard Specification 304.1, Shipboard Electrical Cable Test, 3/1/2000 MLCPAC Standard Specification 304.2, Shipboard Electrical Cable Removal, Relocation, Splice, Repair and Installation, 3/1/2000 MLCPAC Standard Specification 400, General Instructions for MLCPAC Standard Specification 997, Rev -, 3/29/2004; Drydocking MLCPac Instruction 9000.6B, Naval Engineering Organization and Operating Procedures, 5/1/1996 NAVSEA 0900-LP-001-7000, Rev Acn #1, 1/1/1981; Fabrication and Inspection of Brazed Piping

Systems NAVSEA Dwg 803-1385664, Rev H; Bearings, Stern Tube & Strut NAVSEA Dwg 803-1385866, Rev Rev E; Penetrations; Bulkhead and Deck NAVSEA Dwg 803-2145807, Rev C; Propulsion Shafting & Components NAVSEA Dwg 803-6397256, Access, Covers, Ventilation Quick Acting NAVSEA Dwg 803-921865, Rev P; Cathodic Protection Hull Zinc Anodes NAVSEA Dwg 804-1385781, Rev E; Pipe Hangers for Surface Ships (Superseding NAVSEA Dwg.

810-1385781) NAVSEA Dwg 810-1385880, Rev Rev D; Fittings, Cu-Ni Alloy, Slip on Sleeve NAVSEA S6430-AE-TED-010, Rev -; Technical Directive for Piping Devices, Flexible Hose

Assemblies NAVSEA S9074-AR-GIB-010/278, 8/1/1995; Requirements for Fabrication Welding & Inspection &

Casting Inspection & Repair for Machinery, Piping & Pressure Vessels NAVSEA S9243-AW-TRS-011, Rev -; Surface Ships Main Propulsion Shafting Refurbishment

Procedures, Volume I, Part 1 NAVSEA S9243-AW-TRS-012, Rev -; Surface Ships Main Propulsion Shafting Examination, Test and Repair Action Record, Volume 1, Part 2 NAVSEA T9074-AS-GIB-010/271, Rev Change Notice 1; Requirements for Non-Destructive Testing

Methods National Fire Protection Association NFPA 51 Standard for the Design and Installation of Oxygen-

Fuel Gas Systems for Welding, Cutting, And Allied Processes Naval Ships’ Technical Manual, Chapter 074, Volume 3, Gas Free Engineering, 4/23/1998 Naval Ships’ Technical Manual, Chapter 079, Volume 4, Damage Control–Compartment Testing and

Inspection Naval Ships’ Technical Manual, Chapter 491, 1, Electrical Measuring and Test Instruments, 9/1/1999 Naval Ships’ Technical Manual, Chapter 504, 2, Pressure, Temperature and Other Mechanical and

Electrical Measuring Instruments, 12/1/2001 Naval Ships’ Technical Manual, Chapter 510, Heating, Ventilating and Air Conditioning Systems for

Surface Ships, 12/1/2001 Naval Ships’ Technical Manual, Chapter 593, Pollution Control Naval Ship’s Technical Manual (NSTM) Chapter 074, Volume 1, Welding and Allied Processes, Rev http://assistdocs.com/search/document_details.cfm?ident_number=24523&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DS%2D45180&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37025&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1627&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37026&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1628&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37098&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1689&search%5Fmethod=BASIC http://assist.daps.dla.mil/docimages/0000/73/91/2035.PD2 http://www.assistdocs.com/search/document_details.cfm?ident_number=72749&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D2035&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=35349&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D22&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=11860&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DT%2D16420&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=11860&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DT%2D16420&search%5Fmethod=BASIC http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec041rev01.pdf http://www.uscg.mil/mlcpac/mlcp/Eng Support/mlcpv/Platform_Support/Platform_Specifications/Standard_Specifications/mlcpacstandspec_074_Mar03.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec085-1.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-1.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-2.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec304-2.pdf http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec997_29Mar04.pdf http://store.ihs.com/specsstore/controller?event=DOCUMENT_DETAILS&docId=EPMIIAAAAAAAAAAA http://store.ihs.com/specsstore/controller?event=DOCUMENT_DETAILS&docId=EPMIIAAAAAAAAAAA http://store.ihs.com/specsstore/controller?event=LINK_DOCDETAILS&mid=W097&getCurVer=false&docId=NCTWCBAAAAAAAAAA http://store.ihs.com/specsstore/controller?event=LINK_DOCDETAILS&mid=W097&getCurVer=false&docId=NCTWCBAAAAAAAAAA http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 http://www.nfpa.org/aboutthecodes/AboutTheCodes.asp?DocNum=51&cookie%5Ftest=1 ix

Naval Ship’s Technical Manual (NSTM) Chapter 074, Volume 3, Rev Rev 4, 7/15/2003; Gas Free Engineering

Naval Ship’s Technical Manual (NSTM) Chapter 243, Propulsion Shafting, Rev - Naval Ship’s Technical Manual (NSTM) Chapter 244, Propulsion Bearings and Seals, Rev 10 Naval Ship’s Technical Manual (NSTM) Chapter 262, Lubricating Oils, Grease, Specialty Lubricants, And Lubrication Systems, Rev 6 Naval Ship’s Technical Manual (NSTM) Chapter 505, Rev Rev 3, 12/1/2006; Piping Systems Naval Ship’s Technical Manual (NSTM) Chapter 541, Rev 2, 3/11/1997; Ship Fuel and Fuel Systems Naval Ship’s Technical Manual (NSTM) Chapter 556, Hydraulic Equipment Power Transmission and

Control, Rev 4 Naval Ship’s Technical Manual (NSTM) Chapter 581, Rev 3; Anchoring Naval Ship’s Technical Manual (NSTM) Chapter 589, Cranes, Rev 6 Naval Ship’s Technical Manual (NSTM) Chapter 613, Wire and Fiber Rope and Rigging, Rev 3 Naval Ship’s Technical Manual (NSTM) Chapter 635, Rev 3; Thermal, Fire and Acoustic Insulation Naval Ship’s Technical Manual (NSTM), Chapter 997, Rev 3, 11/25/1996; Docking Instructions and

Routine Work in Drydock Nondestructive Testing Handbook, American Society for Non-Destructive Testing, Volume 1, Section

Oregon Administrative Rules, Chapter 340;

Society of Automotive Engineers (SAE) AMSC6183, Rev -, 7/1/1998; Cork and Rubber Composition

Sheet; For Aromatic Fuel and Oil Resistant Gaskets Society of Automotive Engineers (SAE) AMSG6032, Rev -; Grease, Plug Valve, Gasoline and Oil

Resistant, NATO Code Number G-363, Metric Society of Automotive Engineers (SAE) AMSQQS763, Rev B; Steel, Corrosion Resistant, Bars, Wire, Shapes, And Forgings (Noncurrent Feb 2003) Steel Structures Painting Council, SSPC-SP 10, Near White Blast Cleaning, 9/1/2000 Steel Structures Painting Council, SSPC-SP 11, Power Tool Cleaning to Bare Metal–Surface

Preparation Specification No. 11, 9/1/2000 The Society for Protective Coatings (SSPC)-SP 3, Power Tool Cleaning, 11/1/1982 The Society for Protective Coatings SSPC -SP 10/NACE No.2, Near-White Blast Cleaning, 9/1/2000 The Society for Protective Coatings SSPC -SP 12/NACE No.5, Surface Preparation and Cleaning of

Steel & Other Hard Materials by High and Ultrahigh Pressure Water Jetting Prior to Recoating, 7/1/2002

The Society for Protective Coatings SSPC -SP VIS-1-02, Guide and Reference Photographs for Steel Surfaces Prepared by Dry Abrasive Blast Cleaning

The Society for Protective Coatings SSPC-SP 1, Solvent Cleaning, 11/1/1982 The Society for Protective Coatings SSPC-SP 10/NACE No.2, Near-White Blast Cleaning, 9/1/2000 The Society for Protective Coatings SSPC-SP 11, 11/1/2004; Power Tool Cleaning to Bare Metal The Society for Protective Coatings SSPC-SP 12/NACE No.5, Surface Preparation and Cleaning of

Steel & Other Hard Materials by High and Ultrahigh Pressure Water Jetting Prior to Recoating, 7/1/2002

The Society for Protective Coatings SSPC-SP 3, Rev -; Power Tool Cleaning The Society for Protective Coatings SSPC-SP 6/NACE No.3, 11/1/2004; Commercial Blast Cleaning The Society for Protective Coatings SSPC-SP 7/NACE No.4, Brush-Off Blast Cleaning The Society for Protective Coatings SSPC-SP VIS-1-02, Guide and Reference Photographs for Steel

Surfaces Prepared by Dry Abrasive Blast Cleaning The Society for Protective Coatings SSPC-VIS 1, Rev -, 11/1/2004; Guide and Reference Photographs for Steel Surfaces Prepared by Dry Abrasive Blast Cleaning The Society for Protective Coatings SSPC-VIS 4/NACE VIS 7, Rev -; Guide and Visual Reference

Photographs for Steel Cleaned by Waterjetting The Society for Protective Coatings SSPC/NACE VIS 4/NACE No. 7, Guide and Visual Reference

Photographs for Steel Cleaned by Waterjetting Washington Administrative Code, Chapter 173-303; Dangerous Waste Regulations http://www.fas.org/man/dod-101/sys/ship/nstm/ch613.pdf http://www.asnt.org/publications/handbook/handbook.htm http://www.asnt.org/publications/handbook/handbook.htm http://arcweb.sos.state.or.us/rules/OARs_300/OAR_340/340_tofc.html http://www.sae.org/servlets/productDetail?PROD_TYP=STD&PROD_CD=AMSC6183 http://www.sae.org/servlets/productDetail?PROD_TYP=STD&PROD_CD=AMSC6183 http://www.sae.org/servlets/productDetail?PROD_TYP=STD&PROD_CD=AMSG6032 http://www.sae.org/servlets/productDetail?PROD_TYP=STD&PROD_CD=AMSG6032 http://www.sae.org/technical/standards/AMSQQS763B http://www.sae.org/technical/standards/AMSQQS763B http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP3.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP10.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP1.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP10.htm?L+sspcstore+wukd3494+1057295146 http://www.sspc.org/standards/scopes.html http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP12.htm?L+sspcstore+wukd3494+1056767423 http://208.11.80.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP3.htm?L+sspcstore+uowz9441+1148145316 http://www.sspc.org/standards/scopes.html http://208.233.211.117/cgi-bin/SoftCart.exe/STORE/PAGES/SP7.htm?L+sspcstore+wukd3494+1057295146 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+gzjz1081 http://208.11.80.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+uowz9441+1148131664 http://208.11.80.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0212.htm?L+sspcstore+uowz9441+1148131664 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://208.233.211.117/cgi-bin/SoftCart.exe/BOOKSTORE/PAGES/0105.htm?L+sspcstore+unkm3073 http://apps.leg.wa.gov/WAC/default.aspx?cite=173-303 x

CONSOLIDATED LIST OF GOVERNMENT FURNISHED PROPERTY

Description Manufacturer Part Number NIIN Qty UOI

ITEM 12: SCUTTLE REPLACEMENT

Steel WTH, 30” X 30” Raised Hatch;

8 dog, with 21” Quick Acting Scuttle Railway Specialties Corp. B-930812-17 3 EA

Steel WTH, 36” X 36” Raised Hatch;

8 dog, with 21” Quick Acting Scuttle Railway Specialties Corp. 805-162470-

MOD 1 EA

Steel WTH, 36 x 60” Raised Hatch; 8 dog, with 25” Quick Acting Scuttle

Railway Specialties Corp. 4 EA

Steel WTH, 36 x 72” Raised Hatch; 8 dog, with 25” Quick Acting Scuttle

Railway Specialties Corp. 3 EA

ITEM 13: PROPULSION SHAFT SEAL MECHANICAL OVERHAUL & INFLATABLE RENEWAL

225’ WLB Seat (Split) John Crane (Wartsila) H81826-A03 1 Ea

225’ WLB Major Overhaul Kit John Crane (Wartsila) JCL001169-000 Rev C 01-520-5284 1 Kit

ITEM 17: HUBS GENERAL MAINTENANCE

Blade Lifting Rig 1 ea

ITEM 35: HYDRAULIC CHAIN INHAUL WINCH LEVEL 2 INSPECT AND REPAIR

Level wind hydraulic cylinder

MP1-2H-

NC8.00-51-

RSMG-SAE

01-441-3721 1 ea

ITEM 38: MECHANICAL CHAIN STOPPERS (GEN) LEVEL 2 INSPECT AND REPAIR

Spring pack, U-bolts, cotter pins, and bushings 01-485-7215 2 ea

Pins and grease fittings 01-485-7209 2 ea

ITEM 42: BOAT BOOM (GEN) LEVEL 2 INSPECT & REPAIR

Workboat cradle unk unk unk 1 ea (14 mm x 40m), prefabricated with eye on one end, and tapered/welded on the other end

Welin Lambie 5616-3501B 99-225-7786 1 ea

(14 mm x 37.75m), prefabricated with eye on one end, and tapered/welded on the other end

Welin Lambie 5616-3501C 99-859-7924 1 ea

ITEM 47: RECESSED PADEYES REPAIR AND TEST

Cleat, Flush, Lashing, with 1-1/2 inch dia. Bar, steel ASTM A27 Gr 65-35 Schoellhorn-Albrecht S301 2 ea

GENERAL REQUIREMENTS — DRYDOCK

GR_00000_JMS_0308_FLEET

1 INTENT

This document invokes general requirements applicable to ship repair contracts for work performed at a contractor-provided facility and requiring a Coast Guard vessel to be placed in drydock. The items discussed in the General Requirements are an amplification of, or are in addition to, the specific items of the Specification. Other sections of the contract establish requirements for work on Coast Guard cutters. The General Requirements are a part of the contract and, as such, compliance is a contractual requirement. The Contractor is responsible for understanding and complying with all requirements established in the Specifications.

Government Furnished Property: NONE

2 REFERENCES

Coast Guard Drawings: NONE

Applicable Documents:

COMDTINST M6260.16A, Asbestos Exposure Control Manual, Ch-1 COMDTINST 6260.21, Hazard Communications for Work Place Materials COMDTINST 9077.1, Equipment Tag-Out Procedure, Revision C COMDTINST M16478.1, Rev B, Chg 3; Hazardous Waste Management Manual COMDTINST M16478.2, Procurement, Handling and Disposal of Polychlorinated Biphenyls COMDTINST M10360.3, Rev C; Coatings and Colors Manual Federal Standard FED-STD-595B(1), Rev B, 1/11/1994; Color Used in Government Procurement MIL-A-22262, Rev B, Amd 2; Abrasive Blasting Media Ship Hull Blast Cleaning MIL-DTL-5624, Rev U; Turbine Fuel, Aviation, Grades JP-4 and JP-5 MIL-PRF-16884, Rev L; Fuel, Naval Distillate MIL-STD-1625, Rev C, Chg Not 1; Safety Certification Program for Drydocking Facilities and

Shipbuilding Ways for U.S. Navy Ships MLCPAC Standard Specification 997, Rev -, 3/29/2004; Drydocking MLCPAC Standard Specification 074, Welding and Allied Processes, 3/21/2003 MLCPAC Standard Specification 085.1, General Requirements for Drawing Preparation, 3/1/2000 National Fire Protection Association NFPA 51 Standard for the Design and Installation of Oxygen-

Fuel Gas Systems for Welding, Cutting, And Allied Processes Nondestructive Testing Handbook, American Society for Non-Destructive Testing, Volume 1, Section

7 USC §136 to 136(y), Federal Insecticide, Fungicide, And Rodenticide Act (FIFRA) 15 USC §2601 to 2692, Toxic Substance Control Act (TSCA) 33 USC §1251 to 1387, Federal Water Pollution Control Act 33 USC §1342, National Pollutant Discharge Elimination System 33 USC §2701 to 2761, Oil Pollution Control Act of 1990 42 USC §4851 to 4852, Residential Lead-Based Paint Hazard Reduction Act 42 USC §4901 to 4918, Noise Control Act (NCA) 42 USC §6901 to 6991(i), Resource Conservation and Recovery Act (RCRA) 42 USC §7401 to 7671(q), Clean Air Act 42 USC §9601 to 9675, Comprehensive Environmental Response, Compensation, And Liability Act

(CERCLA)

http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F6260%5F16a.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_6260_21B.pdf http://www.uscg.mil/ccs/cit/cim/directives/CI/CI_9077_1C.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_16478_1B.pdf http://www.uscg.mil/ccs/cit/cim/directives/cim/cim%5F16478%5F2.pdf http://www.uscg.mil/ccs/cit/cim/directives/CIM/CIM_10360_3C.pdf http://www.assistdocs.com/search/document_details.cfm?ident_number=53815&StartRow=1&PaginatorPageNumber=1&doc%5Fid=FED%2DSTD%2D595&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=15260&StartRow=1&PaginatorPageNumber=1&doc%5Fnumber=22262&status%5Fall=ON&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=5558&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DDTL%2D5624&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=12122&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DPRF%2D16884&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://www.assistdocs.com/search/document_details.cfm?ident_number=37023&StartRow=1&PaginatorPageNumber=1&doc%5Fid=MIL%2DSTD%2D1625&search%5Fmethod=BASIC http://cgweb.mlcpac.uscg.mil/mlcpv/Technical_Resources/MLCP_Resources/Standard_Specs/mlcpacstandspec997_29Mar04.pdf…