Attachment 1- PWS.pdf

Performance Work Statement (PWS) Hertz Converter Assessment

Minot AFB, ND 9 May 2024

Part I: General Information

A. Introduction:

Conventional Maintenance of the 5th Munitions Squadron of Minot AFB is requesting a comprehensive assessment of their 400 hertz frequency converters and repair of one unserviceable 400 hertz unit. This PWS will specify the requirements of this service.

Manufacturer: Controlled Systems Frequency Converter Rating 7.5 KVA, 0.8 PF INPUT 480/277 V, 3ph, 60Hz, 3w, 17A OUTPUT 115/200 V, 3ph, 400 Hz, 4 w, wye, + gnd, 27 A NEMA Nems 12, Indoor AMBIENT 0 degrees C to +55 degrees C WEIGHT 595 pounds S/N (J13-1097-01-13110250) DATE January 2014

-Model – FC-7.5-400-CSI-P

B. Background:

Building 6025 is not fully mission capable for conducting munitions component testing due to one of six hertz converter units (Ser No. J13-109-01-13110250) being unserviceable. This limits munitions assembly operations to 83% for the overall facility and 50% for the bay with the inoperable unit. Additionally, an assessment of the remaining five converters is requested to ensure uninterrupted functionally is maintained and no further degradation develops.

C. Scope:

Conventional Maintenance requires a technical expert for a comprehensive assessment of the unserviceable hertz frequency converter unit to provide an appraisal for the necessary repairs to make the unit fully functional again.

D. Applicable Regulations:

T.O. 33D7-3-372-11, AN/GYQ-79A Test Program Set, “CMBRE”.

Part II. Work Requirements

A. General Requirements:

1. At the moment, the depth of labor is expected to be a replacement of a blown capacitor (60 ohms 450v DC), which requires only common hand tools. Until the unit is assessed in person however, the extent will not be fully known.

Part III. Supporting Information

A. Security:

1. All products, discussions and work areas are to remain unclassified and will not include any classified material. Work bays will be cleared of any classified material prior to contractor entrance into the bays. Removal of classified will be done by a member of the government.

2. Contractors should allow sufficient time for entrance to the base and should anticipate delays due to unforeseen base security requirements.

3. Contractors may eat at any of the food establishments on base with the exception of the Military Dining Facility.

B. Place of Performance:

1. Building 6025 bays 1, 2 & 3.

C. Period of Performance:

1. The assessment is expected to take two business day for a thorough inspection of all six units distributed between all three bay areas.

Part IV. Base/Site Access

The Contractor shall be responsible for obtaining all necessary passes, or other items required for access to the areas in which work will be performed. The Contractor shall request contractor passes through the CO by providing the full name, social security number, date of birth, work phone, home phone, and driver’s license state/number of employees requiring passes no later than 10 days after contract award.

Personnel must adhere to the REAL ID Act of 2005 to ensure access to base is granted. Pass requests will be forwarded by the CO to the 5th Security Forces Squadron Visitor’s Control Center for approval and issuance. Upon completion or termination of the contract, or an individual’s release from employment, the Contractor shall retrieve the identification issued above and surrender it to the 5th Security Forces Squadron Pass and Registration Section located in the Visitor Control Center. The following can be reason for denial to Minot Air Force Base:

From Minot Integrated Defense Plan 31, Volume 1

3.4. Causes for Debarment and Installation Pass Denial:

3.4.1. Objective Rules. Although debarment decisions are made on a case-by-case basis, debarment action should be considered whenever the offenses in table 1 are committed. NOTE:

The list of cited offenses is not all-inclusive nor is it meant to exclude other offenses that raise concerns about security, safety, good order and discipline.

3.4.2. Base Pass Denial. Personnel will be denied base access if;

3.5.2.1. Is known to be or reasonably suspected of being a terrorist or belongs to an organization with known terrorism links/support.

3.4.2.2. Is individual’s name appears on any or State agency’s watch list or hit list for criminal behavior or terrorist activity.

3.4.2.3. The individual has knowingly and willfully engaged in acts or activities designed to overthrow the U.S. Government by force.

3.4.2.4. The individual has an active warrant

3.4.2.5. The individual is barred by another DoD Installation/Activity

3.4.2.6. The individual has any conviction for espionage, sabotage, treason, terrorism, or murder.

3.4.2.7. The individual has been convicted of a firearms or explosive violation.

3.4.2.8. The individual has been convicted of sexual assault, armed robbery, rape, child molestation, child pornography, trafficking in humans, drug possession with intent to sell, or drug distribution.

3.4.2.9. Has a felony conviction within the last 10 years.

3.4.2.10. Persons with an arrest for the above offenses, but where no disposition is listed on the criminal history report, will be required to provide legal documents showing disposition. If the disposition or severity is dismissed, not filed or adjudicated; the pass may be issued. If the disposition or severity is guilty or not provided the pass will be denied.

3.4.2.11. Any situation not covered in paragraphs 3.4.2.1. – 3.4.210. that is deemed to have a potential detrimental impact on good order or discipline may be grounds for pass denial.