BARBARA_LOIS_DRY_DOCK_SOLICITATION__BID_ABSTRACT-2019.pdf

DRYDOCK WORK ITEMS

0001 DRY-DOCKING AND UNDOCKING OF THE VESSEL

0002 Underwater above water coatings

0003 Sea chest Maintenance

0004 Sea Valve Maintenance

0005 PROPELLER SHAFT AND RUDDER SHAFT BEARING AND PACKING

0006 PROPELLER SHAFT AND RUDDER SHAFT WITHDRAW

0007 Bow Thruster Rea Seal

0008 Hull Ultarsonic Gauging

0009 Tank Cleaning and testing and gas freeing

0010 FOREPEAKE BALLAST TANK REPAIRS

0011 NO 1 PORT BALLAST TANK REPAIRS

0012 NO 1 STARBOARD BALLAST TANK REPAIRS

0013 NO 5 PORT BALLAST TANK REPAIRS

0014 NO 5 STARBOARD BALLAST TANK REPAIRS

0015 NO 6 PORT BALLAST TANK REPAIRS

0016 NO 6 STARBOARD BALLAST TANK REPAIRS

0017 AFT PEAK PORT BALLAST TANK REPAIRS

0018 AFT PEAK STARBOARD BALLAST TANK REPAIRS

0019 Keel Kooler Flushing

0020 Forward Deck Drains repair

0021 Remove Asbestos from Exhaust engine room

0022 Remove Asbestos Main Teck Exhaust

0023 Fresh Water Tanks

0024 Tank Vent Pipes

0025 Fuel Containment area Port FWD.

0026 Fuel Containment Area Starboard FWD

0027 Fuel Containment Area Port AFT.

0028 Fuel Containment Area Starboard AFT.

0029 #3 and #4 Fuel Tank Sounding Tubes

0030 Port Stack House Repairs

0031 #3 and #4 Ballast Tanks Sounding Tubes

M/V Barbara Lois

SOLICITATION

2019 - REPAIR AND DRYDOCK

Contractor 1

SUB TOTAL Dry Dry Dock Work Items

ITME NO. TITLE/DESCRIPTION

COMPANY NAME:

0001 Deck Removal/ Reinstall Engine Change Out C6:C40C6:C38

1. Clean/Gas free engine room for hot work / Chemist

2. Remove deck boards/Crop deck plates.

3. Remove/Reinstall Electrical Interferences.

4. Disconnect exhaust

5. Disconnect shaft/Transmission coupling

6. Disconnect Keel cooler plumbing

7. Disconnect throttle system

8. Disconnect air intakes

9. Disconnect gear oil lines

10. Disconnect Starter

11. Disconnect all gauges

12. Disconnect wire harness

13. Remove the engine and transmission

14. Install rebuilt engine and Transmission

15. Perform engine alignment

16. Reconnect all systems to new engine.

17. Reinstall Exhaust

18. Reinstall deck boards /deck plates and make watertight.

19. Provide Chemist/Competent Person for hot work permit.

20. Modify Stbd engine and gear box foundations if necessary

0002. Purchase Rebuilt Engine and all parts used to install fully functioning engine. Genuine MTU/Detroit Diesel new or remanufactured Parts

1. Detroit Diesel 16V149 N/A Rebuilt Engine 1025 HP @ 1800 RPM (Dyno Tested)

& all Parts and Fluids needed to install engine.

Coolant

Hoses

Hose clamps

Exhaust Flange gaskets

Bolts

Nuts

Lock washers

Flat washers

Exhaust Manifold gaskets

Oil

Misc. Rags, Bags, Cleaners, Glue, etc

Misc. Nuts, Bolts, Washers, etc.

0004. HazMat / HazWaste Removal and Disposal

1. Removal and Disposal of all Hazardous materials and oils.

0005. Replenish engine of all fluids

1. Replenish engine cooling system of all coolant. Coolant shall be replenished per manufacturer recommendation.

2. Replenish lubricating oil system as per manufacturer recommendations.

0006. Overhaul of Port and Stbd Gear boxes

1. Inspect gears, shafts, bearings and seals.

2. Replace seals and Oil

0007. Perform Engine Run-In / Break- in test

1. Engine Run-In/Break-In test shall be performed as instructed in

Detroit Diesel Service Manual 6SE285( REV. 3/80), SEC.13.2.1

M/V Barbara Lois

Vendors List 2019 - M/V Barbara Lois Stbd Main Engine Detroit Diesel 16v149na Rebuilt Engine

ITME NO. TITLE/DESCRIPTION $$$$

BEAUMONT RESERVE FLEET

2. An Engine Test Report shall be fill out and submitted to the Beaumont

Reserve Fleet. Reference Detroit Diesel Service Manual 6SE285(

REV. 3/80), SEC.13.2.1

Cost SUB TOTAL Work Items

0001 Spare parts 16v149na

MTU/Detroit Diesel Corp. New or Remanufactured parts.

1. Cylinder Heads

2. Cylinder head bolt washers

3. Cylinder head bolts

4. Bolts 5/16 – 18 x 2.5

5. Washers 5/16

6. Tubes

7. Elbows

8. Cylinder head Seal Rings

9. 149 Cylinder head gasket set

10. Main Bearing Set

11. Thrust washers

12. Washers

13. Front Timing cover damper

14. Vibration Kit

15. 18” O.D. Viscous Vibration damper

16. Connecting Rods

17. Connecting Rods shell set

18. Cylinder install kit

19. Intermediate Camshaft bearings

20. Rocker cover gasket

21. Injectors

22. Fuel Pump

23. Fuel Pump fork

24. Fuel Cartridge

25. 3/8” inverted flare nuts

26. Connectors

27. Seal Assemblies

28. Seal Rings

29. Seal Ring fuel connectors

30. Connectors

31. Hydraulic Governor

32. 5/16” copper washers

33. Governor drive gasket

34. Blower end plate gasket

35. Governor to cylinder head gaskets

36. Injector control tube link boot

37. Front Blower

38. Blower install kits

39. Blower screen assemblies

40. Washers

41. Oil tubes

42. Clips

43. Bolts

44. Center shaft blower

45. Rear shaft blower

M/V Barbara Lois

Vendors List

2019 - Detroit Diesel 16v149na Spare Parts

ITME NO. TITLE/DESCRIPTION $ $ $ $ $

BEAUMONT RESERVE FLEET

46. Rings

47. Snap Rings

48. Pins

49. Shims

50. Oil pump inlet gaskets

51. Regulator valves

52. Relief valve assembly

53. Oil Filters

54. Oil filter bypass valves

55. Gaskets

56. Oil cooler gasket kit

57. 30 plate Oil cooler

58. Oil Pan joint gasket

59. Oil Pan gaskets

60. Upper oil pan cover gasket

61. Shims

62. Water pump rotator

63. 170* Thermostat

64. Thermostat Seals

65. Themostat Housing gaskets

66. 15lb Expansion tank cap

67. Oil cooler bypass cover gaskets

68. Exhaust Manifold gaskets

69. Water temperature switch gaskets

70. Overhaul gasket set

71. Clamps

72. Nuts

73. Washers

74. Oil Cooler tube shell gasket kit Cost TOTAL Items