(02) SOW.pdf

Project:

Upfit of Fire Command Pickups

1.0 Scope of Work:

Upfit two each Chevy Silverado 1500 4x4 Crew cab pickups to function as Fire Command vehicles. Cost will be split 50/50 and paid with WCF funds. Payment to vender must be made through IPP.

2.0 Background:

Base trucks have been purchased via GSA Auto Choice and are ready to be upfitted as soon as contract is awarded.

Vehicle Number 3774 VIN: 3GCPDAEK1RG178513 Vehicle Number 3775 VIN: 3GCPDAEK4RG178487

Contractor is responsible for upfit to Fire Command vehicle in accordance with requirements below.

3.0 Technical Requirements / Tasks

Vender is responsible for installation of all equipment and associate wiring.

Emergency lighting will include a full-size roof mounted LED light bar and LED lights in lower Zone A, B, C, & D. Light colors will be red and yellow Emergency Lighting will meet minimum NFPA 1901 Standards. . See appendix for diagram.

Siron/PA system: Speaker to be mounted behind grill. Controls can either be integrated with emergency lighting system or stand alone. Stand alone, control box will be mounted in center console.

Center console: Console must be bolted to floor; sheet metal screw will not fulfil this requirement. The console is required to fit between the front driver’s seat and extend to the front passenger seat. There must be approximately 2 inches between the sides of the console to each seat but no more than 4 inches. The console must mount two each, BK M-150 radios, control boxes for siren and light bar, Blank space for additional control box or Radio, 4 ea. standard cup holders. 2 front and 2 rear. Console will need 1 compartment at least 10 in deep by 12 in length measured from front to back of vehicle for storage. Console may extend in to back passenger area to rear seat. Removed center seat section will be returned to the Forest Service and Fleet will store until vehicle is removed from service.

Markings: Vender will provide striping and marking in accordance with diagram and specifications in Appendix. Specific unit designator and equipment designator will be provided upon award of contract. Vender is response for purchasing all marking materials except for door badges already on the trucks.

Appendix

VEHICLE:

4x4 wheel drive pick-up truck; single, extended or crew cab, white in color. Include the following options: short bed body, special traction differential, towing/ mountain ratio, engine block heater, all terrain tires, increased output alternator, 50-state legal tinting, and cruise control. The following options are authorized on pickups but must be approved by both regional fleet and fire management: power mirrors, power windows, power door locks with keyless entry, & trailer brakes/receiver hitches. OPTIONAL MINIMUM RLS EQUIPMENT: Lightbar (forward, side, & rear facing warning lights), grill lights, console and siren/speaker/ control head.

FIRE

STRIPE ILLUSTRATION:

1" white reflective stripe centered on 4" green reflective stripe, cut at 45° angle to allow for designators.

SIDE:

1" white reflective stripe centered on 4" green reflective stripe, cut at 45° angle to allow for 4" FIRE decal white reflective over rear wheels and;

4" Equipment designator on front fender.

REAR:

4" Unit designator, black non-reflective on drivers's side;

4" Equipment designator, black non reflective passenger's side.

DOOR DECAL:

* 1O' FS shield white with brown border/ lettering.

* 7/16' FOR OFFICIAL USE ONLY, brown

* 5/8" US GOVERNMENT, brown

• 1-1/2" Equipment number, brown

• All reflective vinyl, placed middle of door below stripe.

FOR OFFICIAL USE ONLY

US GOVERNMENT

FRONT:

4" Equipment designator, black non-reflective on driver's side; 4" unit designator, black non- reflective passenger's side.

USDA FOREST SERVICE Fire Command, Operations Support, Prevention-Pick-up Truck July 2018

DATE

NFPA 1901 Lighting Specifications -

NFPA 1901

Minimum requirements

Thewarningsystemis configured to have two operatingmodes.

CallingRight of Way (Responding) and BlockingRight of Way(At theScene)

ZONE A

FRONT

ZONE C

REAR

Large Apparatus - Greater than 25' Large apparatus, defined as apparatusthat has a bumper to bumper length of 25 feet or greater. Large apparatushas four (4) separate zones.Eachof the four (4) zones are divided into an upper and lower level zones. In zone B, and D the lower level warning lights used cannot exceed a distance of 25 feet between the cen-ters of adjacent lower level optical warning devices.If the optical warning devices exceed 25 feet, additional mid-ship optical devices are required. Refer to the NFPA1901 Standard for Automotive FireApparatus 2009 Edition, Chapter 13 Low Voltage Electrical Systems and Warning Devices.

NOTE All values are m candela-seconds/mmute H::c Horizontalplane passing throughthe optical center.

Small Apparatus - Less than 25' Small apparatus, defined as apparatus that has a bumper to bumper length of 25 feet or less. Small apparatus has four (4) separate zones.Each of the four (4) zones combined upper and lower level zones as one zone.Refer to the NFPA1901Standard for Automotive Fire Apparatus 2009 Edition, Chapter13 Low Voltage Electrical Systems and Warning Devices.

CALLING BLOCKING

COLOR FOR RIGHT RIGHT OF

I OF WAY WAY

Red

I NOTE All values arem candela-seconds/mmute. H= Horizontalplanepassing through the optical center.

Blue

Any Zone

I Any Zone

Any Zone Not White except Permitted

CREAR Any Zone

CALLING FOR RIGHT OF WAY I BLOCKING RIGHT OF WAY

ZONE LEVEL H ANYHPOINT

I +/-5ANYH H ANYH POINT +/-5 ANY H I

A

C

D

Upper & Lower

Combined

1,000,000 10,000

3,500

400,000 10,000

3,500

200,000 8,000 200,000 8,000

400,000 10,000 800,000 10,000

200,000 8,000 200,000 8,000

I CALLING FOR RIGHT OF WAY BLOCKING RIGHT OF WAY

ZONE LEVEL H I ANYHPOINT +/-SANYH H ANYH POINT I +/-5 ANY H

Upper 1,000,000

I 10,000 3,500 400,000 10,000 3,500

A Lower 150,000 3,750 1,300 150,000 3,750

I 1,300

B Upper 400,000 I 10,000 3,500 400,000 10,000 I 3,500

C

Upper 400,000 10,000 3,500 800,000 10,000 3,500

1,300 150,000 3,750

I 1,300 Lower 150,000 3,750

D

Upper 400,000 10,000 3,500 400,000 10,000 3,500

CALLING

COLOR FOR RIGHT

OF WAY

BLOCKING

RIGHT OF

WAY

Red

Any Zone Blue

Amber

AnyZone except

A FRONT

Any Zone White except

CREAR I

Not Permitted

4.0 Government Furnished

Government will provide base trucks listed below purchased via GSA Auto Choice and are ready to be upfited as soon as contract is awarded.

Vehicle Number 3774 VIN: 3GCPDAEK1RG178513

Vehicle Number 3775 VIN: 3GCPDAEK4RG178487

Government has also provided NFPA ligh�ng standards and template for vehicle markings.

Government will provide door badges already installed on vehicles.

5.0 Deliverables / Schedule

Vender has 30 days from award of contract to start upfit of trucks and 60 days to finish all work once vehicles are delivered to them.