Attch 7 APP F Tire Carousel 0215.pdf

APPENDIX F

FOR

TIRE VERTICAL CAROUSEL

AT

TRUAX FIELD WISCONSIN

BUILDING 510

CSN: NWS912

DATE: 15 FEBRUARY 2023

PREPARED BY:

_Andrew J Huser_

ANDREW J HUSER

PROJECT ENGINEER

AFLCMC/EZPAE

_Brad Thompson_

BRAD THOMPSON

REVIEWER

AFLCMC/EZPAE

CSN: NWS912 Attachment 07 1

TRUAX FIELD – APP F - Page i

Table of Contents

1. SCOPE

1.1. GENERAL SCOPE

2. APPLICABLE DOCUMENTS

3. REQUIREMENTS

3.1. SYSTEM DESCRIPTION

3.1.1. STRUCTURE

3.1.2. MOTORS

3.2. ELECTRICAL CHARACTERISTICS

3.2.1. INDEPENDENT DISCONNECT

4. QUALITY ASSURANCE PROVISIONS

4.1. INSPECTIONS

4.2. TEST

4.3. CERTIFICATIONS

CSN: NWS912 Attachment 07 2

TRUAX FIELD – APP F - Page 1

1. SCOPE

1.1. GENERAL SCOPE

This appendix establishes the minimum requirements for one (1) tire vertical carousel for Building 510, at Truax Field

Wisconsin. The work shall be completed in accordance with this appendix, the cover purchase description (PD), and Air Force

Drawing NWS912-01. This appendix covers all equipment, materials, and labor necessary to complete installation of the system.

2. APPLICABLE DOCUMENTS

Applicable documents shall be in accordance with Section 2 of the Cover PD.

3. REQUIREMENTS

3.1. SYSTEM DESCRIPTION

The Contractor shall provide one (1) tire vertical carousel located as shown on AF Drawing NWS912-01

The tire carousels shall have the following characteristics:

Max Height: 15’-6”

Max Width: 15’

Max Depth: 9’-6”

Max tire carrier weight capacity: 2,000 pounds

Tire diameter: Up to 35” Dia.

Load off-balance lift capacity: 2,500 pounds

Controls: single speed forward/reverse, keypad operation, emergency stop button, imbalance load indicator

Guarding: 2” wire mesh both front and rear

Positionable Load/Offload Ramp

Tire Carousel shall be configured to store tires up to 35” diameter.

3.1.1. STRUCTURE

The carousel shall have a steel framework that shall support the fully loaded system and shall not be attached to the building, except for the floor. The carousel shall be anchored to the floor in a minimum of four places.

3.1.2. MOTORS

CSN: NWS912 Attachment 07 3

TRUAX FIELD – APP F - Page 2

Motors shall be of sufficient size for the duty to be performed and shall not exceed their full-rated load when the driven equipment is operating at the specified maximum capacity under the most severe conditions likely to be encountered. All motors shall be designed for continuous duty at ambient temperature, 32 to 104 degrees Fahrenheit. Motors shall be drip proof and shall be designed to operate on electrical power characteristics as they exist at the site. Motor shall have an electronically controlled soft start and shall be equipped with an overload device.

3.2. ELECTRICAL CHARACTERISTICS

The carousel shall operate on 208 volt, 3 phase, and 60 hertz electricity. The Contractor shall run electrical power from the

Government provided electrical source.

3.2.1. INDEPENDENT DISCONNECT

The carousel shall have a master on/off switch to control the carousel's electrical power. This switch shall have some means

(i.e. key switch, padlock, etc.) of locking it in the off position.

4. QUALITY ASSURANCE PROVISIONS

4.1. INSPECTIONS

The system shall be inspected to verify that it meets all the requirements of sections 1, 2, and 3 of this appendix and the

Cover PD. These inspections shall be completed as part of the system checkout test and again as a part of the quality conformance test.

4.2. TEST

The following test shall be performed on the system as part of the system checkout test and again as a part of the quality conformance test.

No. Paragraph Description

1. 3.1 The carousel shall be run fully loaded for at least one hour to ensure it can handle the maximum load.

4.3. CERTIFICATIONS

CSN: NWS912 Attachment 07 4

TRUAX FIELD – APP F - Page 3

The Contractor shall provide certification that the following requirements have been met. All certifications shall be provided in accordance with the Contract Data Requirements List.

No. Paragraph Certifications

1. 3.1.2. Motors are of sufficient size for the duty to be performed and will not exceed their full-rated load when the driven equipment is operating at the specified maximum capacity under the most severe conditions likely to be encountered. All motors are designed for continuous duty at ambient temperature, 32 to

104 degrees Fahrenheit. Motors are drip proof and designed to operate on electrical power characteristics as they exist at the site.

Motor have an electronically controlled soft start and are equipped with an overload device.

CSN: NWS912 Attachment 07 5

TECHNICAL PROPOSAL QUESTIONNAIRE

FOR

TRUAX FIELD – APP F - TPQ - Page 1 of 2

TIRE VERTICAL CAROUSEL

Solicitation Number: FA8604- -R-

Project Title: Storage Aids System, Building 510

Base: Truax Field WI CSN: NWS912

Appendix F, Tire Carousel, 15 FEBRUARY 2023

This questionnaire shall be completed by the Offeror. All entries to this questionnaire shall be typed. The questionnaire will be used to determine the Offeror's understanding of the requirements and acceptability of the proposed equipment.

Please attach product literature/cut sheets for all equipment detailed in this questionnaire and attach any exceptions to the

Purchase Description Appendix or recommendations/design alternatives as detailed below.

Tire Vertical Carousel Manufacturer: __________________________

Tire Vertical Carousel Model: _________________________________

Paragraph Characteristics

3.1. Height: _______

Width: _______

Depth: _______

Max tire carrier weight capacity: _________

Max tire diameter: _________

Load off-balance lift capacity: __________________

Controls:

Single Speed Forward/Reverse YES NO

Keypad Operation YES NO

Emergency Stop Button YES NO

Imbalance Load Indicator YES NO

Guarding: _______________________________________

Positionable Load/Off-Load Ramp YES NO

3.2. Electrical characteristic of carousels:

_________Volts _________Phase ________Hertz

CSN: NWS912 Attachment 07 6

Solicitation Number: FA8604- -R-

TRUAX FIELD – APP F - TPQ - Page 2 of 2

EXCEPTIONS

Please outline each exception taken to the Appendix in detail.

All exceptions will be reviewed to determine acceptability.

Are exceptions taken? YES NO

EXCEPTIONS:

CSN: NWS912 Attachment 07 7