C-5_Technical_Orders.pdf

TO 1C-5A-2-1S-28

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS OS OS OS OS OPERATIONAL SUPPLEMENT OS OS OS OS OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS

OS OS OS OS OS OS OS OS OS OS OS OS OS OS OS OS OS

OPERATIONAL SUPPLEMENT

TECHNICAL MANUAL

ORGANIZATIONAL MAINTENANCE

GROUND HANDLING AND SERVICING

USAF SERIES C-5A AND C-5B AIRCRAFT

THIS PUBLICATION SUPPLEMENTS TO 1C-5A-2-1, DATED 1 OCTOBER 2000. Reference to this to supplement will be made on the title page of the basic publication by personnel responsible for maintaining the publication in current status.

COMMANDERS ARE RESPONSIBLE FOR BRINGING THIS SUPPLEMENT TO THE ATTENTION OF

ALL AFFECTED PERSONNEL

DISTRIBUTION STATEMENT D - Distribution authorized to the Department of Defense and US DoD contractors only (Administrative or Operational Use) (1 October 2000). Other requests for this document shall be referred to 730 ACSSS/ EN, 235 Byron St. Suite 19A, Robins AFB, GA 31098-1670.

WARNING - This document contains technical data whose export is restricted by the Arms Export Control Act (Title 22, U.S.C., Sec 2751, et seq.) or the Export Administration Act of 1979, as amended, Title 50, U.S.C., App. 2401 et seq.

Violations of these export laws are subject to severe criminal penalties. Disseminate in accordance with provisions of DoD Directive 5230.25.

HANDLING AND DESTRUCTION NOTICE - Comply with distribution statement and destroy by any method that will prevent disclosure of the contents or reconstruction of the document.

Published Under Authority of the Secretary of the Air Force

1 MARCH 2010

SHORT TITLE: INCORPORATION OF TO 1C-5-774

1. PURPOSE.

This purpose of this supplement is to incorporate TO 1C-5-774, Installation of Battery Control Electronics Module (BCEM) Upgrade.

2. INSTRUCTIONS.

a. Page xiv, in numerical order add TCTO 1C-5-774 to the Record of Applicable Time Compliance Technical Orders including the following information:

1C-5-774 15 October 2009 Installation of Battery Control Electronics Module (BCEM) Upgrade

b. Page 1-94.9, replace existing art (Figure 1-18) with art as shown on page 3 of this Operational Supplement.

c. Page 1-106, replace existing art (Figure 1-19) with art as shown on page 5 of this Operational Supplement.

THE END

Figure 1-18. Circuit Breaker Locations (AF66-8303 thru AF70-467) (Sheet 20 of 20)

Ammy.Pearson Typewritten Text 3/(4 blank)

Figure 1-19. Circuit Breaker Locations (AF83-1285 and Up) (Sheet 20 of 20)

5/(6 blank)

TO 1C-5A-2-1

TECHNICAL MANUAL

ORGANIZATIONAL MAINTENANCE

GROUND HANDLING

AND SERVICING

USAF SERIES

C-5A AND C-5B

AIRCRAFT

(ATOS)

THIS PUBLICATION IS INCOMPLETE WITHOUT THE ASSOCIATED FAULT ISOLATION AND JOB GUIDE MANUALS.

DISTRIBUTION STATEMENT D - Distribution authorized to the Department of Defense and U.S. DoD contractors only (Administrative or Operational Use) (1 October 2000). Other requests shall be referred to AFLCMC/WLSA, 235 Byron St., Suite 19A, Robins AFB, GA 31098-1670. Questions concerning technical content shall be referred to AFLCMC/WLSE, 235 Byron St., Suite 19A, Robins AFB, GA 31098-1670.

WARNING - This document contains technical data whose export is restricted by the Arms Export Control Act (Title 22, U.S.C., Sec 2751, et seq.) or the Export Administration Act of 1979, as amended, Title 50, U.S.C., App. 2401 et seq. Violations of these export laws are subject to severe criminal penalties. Disseminate in accordance with provisions of DoD Directive 5230.25.

HANDLING AND DESTRUCTION NOTICE - Comply with distribution statement and destroy by any method that will prevent disclosure of contents or reconstruction of the document.

Published Under Authority of the Secretary of the Air Force

1 OCTOBER 2000 CHANGE 39 - 20 JANUARY 2014

CURRENT

SUPPLEMENTS

1C-5A-2-1S-28

Basic and all changes and supplements have been merged to make this a complete publication.

INSERT LATEST CHANGED PAGES. DESTROY SUPERSEDED PAGES.

LIST OF EFFECTIVE PAGES

NOTE: The portion of the text affected by the changes is indicated by a vertical line in the outer margins of the page. Changes to illustrations are indicated by miniature pointing hands. Changes to wiring diagrams are indicated by shaded areas.

Dates of issue for original and changed pages are:

Original........................... 0..............1 October 2000 Change............................ 1......... 15 February 2001 Change............................ 2................ 15 June 2001 Change............................ 3..........1 November 2001 Change............................ 4................1 March 2002 Change............................ 5.................. 1 April 2002 Change............................ 6................... 1 July 2002 Change............................ 7..............1 October 2002 Change............................ 8.............1 January 2003 Change............................ 9.................. 1 April 2003 Change...........................10................... 1 July 2003 Change...........................11..............1 October 2003 Change...........................12.............1 January 2004 Change...........................13.................. 1 April 2004 Change...........................14................... 1 July 2004 Change...........................15..............1 October 2004 Change...........................16.............1 January 2005 Change...........................17.................. 1 April 2005 Change...........................18.........1 September 2005 Change...........................19.............1 January 2006

Change...........................20.................. 1 April 2006 Change...........................21................... 1 July 2006 Change...........................22..............1 October 2006 Change...........................23..........1 November 2007 Change...........................24.............1 January 2008 Change...........................25.................. 1 April 2008 Change...........................26................... 1 July 2008 Change...........................27..............15 March 2009 Change...........................28.................. 1 June 2009 Change...........................29........ 31 December 2009 Change...........................30.............15 August 2010 Change...........................31.............30 August 2011 Change...........................32..............23 March 2012 Change...........................33................ 30 April 2012 Change...........................34............31 October 2012 Change...........................35...........15 January 2013 Change...........................36................ 10 April 2013 Change...........................37.................. 5 June 2013 Change...........................38............15 October 2013 Change...........................39...........20 January 2014

TOTAL NUMBER OF PAGES IN THIS PUBLICATION IS 784, CONSISTING OF THE FOLLOWING:

Page *Change Page *Change Page *Change No. No. No. No. No. No.

Title A - D E Blank i ii iii iv v vi vii viii ix - x xi xii xiii - xiv xv - xvi xvii xviii xix Added xx Blank 1-1 1-2 1-2.1 Added 1-2.2 Blank 1-3 - 1-4 1-4.1 Added 1-4.2 Blank 1-5 - 1-20

1-21 1-22 - 1-24 1-25 - 1-26 1-26.1 - 1-26.2 Added 1-27 - 1-72 1-73 1-74 1-75 1-76 - 1-77 1-78 1-78.1 Added 1-78.2 Blank 1-79 - 1-80 1-80.1 1-80.2 Blank 1-81 1-82 1-82.1 - 1-82.2 Deleted 1-83 1-84 - 1-85 1-86 1-87 - 1-88 1-89 1-90 - 1-94 1-94.1 - 1-94.2 1-94.3 1-94.4 - 1-94.5 Added 1-94.6

1-94.7 - 1-94.9 Added 1-94.10 Blank 1-95 - 1-96 1-97 1-98 - 1-99 1-100 1-101 - 1-102 1-103 1-104 1-104A Added 1-104B Blank 1-104.1 1-104.2 - 1-104.3 Added 1-104.4 1-104.5 - 1-104.6 Added 1-104.7 1-104.8 1-104.8A Added 1-104.8B Blank 1-105 - 1-106 1-106.1 - 1-106.2 Deleted 1-107 - 1-108 1-108.1 1-108.2 - 1-108.3 1-108.4 - 1-108.6 1-108.7 - 1-108.8 Added 1-109 - 1-110 1-110.1 - 1-110.2

*Zero in this column indicates an original page

A Change 39 USAF

LIST OF EFFECTIVE PAGES (CONT)

Page *Change Page *Change Page *Change No. No. No. No. No. No.

1-111 1-112 - 1-113 1-114 1-114.1 Added 1-114.2 Blank 1-115 - 1-117 1-118 1-118.1 Added 1-118.2 Blank 1-119 1-120 1-121 1-122 1-122.1 1-122.2 Blank 1-123 1-124 Blank 2-1 2-2 2-2.1 2-2.2 Blank 2-3 2-4 - 2-11 2-12 Blank 2-13 2-14 Blank 2-15 - 2-16 2-17 - 2-18 2-18.1 Added 2-18.2 Blank 2-19 2-20 2-21 - 2-26 2-27 2-28 2-29 2-30 - 2-31 2-32 2-32.1 Added 2-32.2 Blank 2-33 2-34 2-34.1 2-34.2 Blank 2-35 2-36 2-37 2-38 2-39 2-40 2-41 2-42 2-43

2-44 2-45 - 2-47 2-48 2-48.1 2-48.2 Added 2-49 2-50 2-50.1 Added 2-50.2 Blank 2-51 2-52 2-53 - 2-54 2-55 - 2-58 2-58.1 - 2-58.2 2-59 2-60 2-61 2-62 - 2-63 2-64 2-65 2-66 2-66.1 2-66.2 Blank 2-67 2-68 - 2-77 2-78 2-79 2-80 2-81 2-82 2-83 2-84 2-85 2-86 - 2-87 2-88 - 2-89 2-90 - 2-96 2-96.1 - 2-96.2 Added 2-97 2-98 2-98.1 Added 2-98.2 Blank 2-99 - 2-100 2-101 2-102 2-103 - 2-106 2-107 - 2-108 2-108.1 - 2-108.2 Deleted 2-109 2-110 2-111 - 2-114 2-115 - 2-116 2-116.1 Added 2-116.2 Blank

2-117 - 2-118 2-119 - 2-120 2-121 2-122 - 2-124 2-125 - 2-126 2-127 - 2-132 2-132.1 - 2-132.2 2-132.3 - 2-132.5 Added 2-132.6 Blank 2-133 2-134 2-135 - 2-137 2-138 2-139 2-140 - 2-141 2-142 2-143 - 2-166 2-167 2-168 2-169 2-170 - 2-174 2-175 2-176 Blank 2-177 2-178 Blank 2-179 2-180 - 2-181 2-182 2-183 2-184 3-1 - 3-2 3-3 3-4 3-4.1 Added 3-4.2 Blank 3-5 - 3-6 3-6.1 3-6.2 3-7 - 3-12 3-13 3-14 3-14.1 - 3-14.2 3-14.3 - 3-14.4 Added 3-15 - 3-21 3-22 3-23 3-24 3-25 3-26 3-27 3-28 - 3-31 3-32 3-33 - 3-34

Change 39 B

LIST OF EFFECTIVE PAGES (CONT)

Page *Change Page *Change Page *Change No. No. No. No. No. No.

3-35 3-36 3-37 3-38 3-39 3-40 3-41 3-42 3-43 3-44 3-45 3-46 3-46.1 3-46.2 Blank 3-47 3-48 3-49 3-50 - 3-52 3-53 - 3-54 3-54.1 - 3-54.2 Added 3-55 3-56 - 3-57 3-58 - 3-62 3-63 3-64 3-65 3-66 3-66.1 - 3-66.2 3-66.3 - 3-66.4 Added 3-67 3-68 - 3-69 3-70 3-70.1 Added 3-70.2 Blank 3-71 3-72 3-72.1 - 3-72.2 3-72.3 Added 3-72.4 Blank 3-73 3-74 3-75 - 3-76 3-77 3-78 3-78.1 3-78.2 Blank 3-79 3-80 3-80.1 Added 3-80.2 Blank 3-81 - 3-82 3-83 3-84

3-84.1 3-84.2 3-85 3-86 3-87 - 3-88 3-89 - 3-90 3-91 3-92 3-92.1 3-92.2 Blank 3-93 3-94 3-94.1 3-94.2 3-95 - 3-96 3-97 - 3-98 3-98.1 Added 3-98.2 Blank 3-99 3-100 - 3-101 3-102 3-103 3-104 - 3-106 3-106.1 - 3-106.4 3-106.5 - 3-106.6 Added 3-106.7 3-106.8 Blank 3-107 3-108 - 3-111 3-112 3-113 3-114 3-114A - 3-114B Added 3-114C 3-114D - 3-114E Added 3-114F Blank 3-114.1 - 3-114.2 3-115 3-116 3-117 - 3-118 3-118A - 3-118C 3-118D - 3-118E Added 3-118F Blank 3-118.1 3-118.2 Blank 3-119 3-120 - 3-122 3-123 - 3-124 3-125 - 3-126 3-127 3-128 3-129 3-130

3-131 3-132 3-133 3-134 3-134.1 - 3-134.2 3-134.3 Added 3-134.4 Blank 3-135 3-136 Blank 3-136.1 3-136.2 Blank 3-137 3-138 - 3-141 3-142 3-143 - 3-147 3-148 3-149 - 3-164 3-165 3-166 3-166.1 - 3-166.2 Deleted 3-167 - 3-174 Deleted 3-175 - 3-176 3-177 - 3-178 3-179 - 3-180 3-181 3-182 3-183 3-184 3-184.1 - 3-184.2 3-185 3-186 - 3-187 3-188 3-188.1 Added 3-188.2 Blank 3-189 3-190 3-190.1 Added 3-190.2 Blank 3-191 3-192 3-192.1 Added 3-192.2 Blank 3-193 - 3-194 3-194.1 Added 3-194.2 Blank 3-195 - 3-196 3-197 3-198 3-199 Added 3-200 3-201 3-202 - 3-205 Added 3-206 Blank

C Change 39

LIST OF EFFECTIVE PAGES (CONT)

Page *Change Page *Change Page *Change No. No. No. No. No. No.

4-1 4-2 - 4-3 4-4 4-5 4-6 - 4-15 4-16 - 4-20 4-21 - 4-22 4-23 4-24 4-25 - 4-26 4-27 4-28 4-29 4-30 - 4-31 4-32 4-32.1 Added 4-32.2 Blank 4-33 - 4-36 4-37 4-38 - 4-48 4-49 4-50 4-51 4-52 Blank 4-53 Blank 4-54 - 4-57 4-58 Blank 5-1 - 5-10 Added 5-11 5-12 - 5-14 Added 5-15 5-16 - 5-25 Added 5-26 Blank 5-27 Added 5-28 Blank 5-29 Added 5-30 Blank Index 1 Index 2 - Index 4 Index 5 Index 6 Index 7 Index 8 Index 8.1 - Index 8.2 Deleted

Index 9 Index 10 Index 11 Index 12 Blank

Change 39 D/(E blank)

TABLE OF CONTENTS

Section/Para Page

INTRODUCTION.............................................................................................................................. iii

I GENERAL INFORMATION .......................................................................................................... 1-1 1-1 General Airplane Information.................................................................................... 1-2 1-11 Metric Equivalents of U.S. Units of Measure......................................................... 1-30 1-13 General Maintenance Information........................................................................... 1-73 1-33 Anti-Icing, Deicing, and Snow and Frost Removal .............................................. 1-117 1-41 Extreme Climatic and Environmental Information ............................................. 1-121 1-46 General Safety Precautions ................................................................................. 1-122.1

II GROUND HANDLING................................................................................................................... 2-1 2-1 Extinguishing Ground Fires....................................................................................... 2-4 2-22 Towing........................................................................................................................ 2-19 2-39 Parking....................................................................................................................... 2-50 2-42 Mooring ...................................................................................................................... 2-52 2-46 Jacking ....................................................................................................................... 2-55 2-72 Leveling.................................................................................................................... 2-100 2-75 Hoisting Equipment ................................................................................................ 2-100 2-96 Hoisting Procedures ................................................................................................ 2-116 2-125 Ground Handling Equipment................................................................................. 2-142 2-148 Protective Covers..................................................................................................... 2-154 2-156 Ground Safety Locks and Pins............................................................................... 2-168

III SERVICING .................................................................................................................................... 3-1 3-1 Servicing Information ................................................................................................. 3-4 3-10 Fuel System Servicing ................................................................................................ 3-4 3-27 Concurrent Servicing ................................................................................................ 3-48 3-36 Hydraulic Systems Servicing.................................................................................... 3-56 3-43 MLG System Servicing ............................................................................................. 3-65 3-52 NLG System Servicing.............................................................................................. 3-77 3-61 Oxygen System Servicing ......................................................................................... 3-91 3-67 Liquid Nitrogen (LN2) Fuel Tank Inerting/Fire Suppression System

(FSS) Servicing.....................................................................................................3-102 3-72 Engine Servicing ...................................................................................................3-118D 3-80 Auxiliary Power Servicing ...................................................................................... 3-129 3-86 Precharging RAT Accumulator ........................................................................... 3-134.2 3-87 Pitot Static System Servicing................................................................................. 3-137 3-91 Crew Compartment Servicing ................................................................................ 3-142 3-96 Cleaning and Disinfecting the Crew Galley Potable Water System

(AF66-8303 through AF70-467, except AF69-006 and AF70-450) ...................3-148 3-97 Crew Lavatory Servicing ........................................................................................ 3-148 3-98 Crew Lavatory Waste Servicing (AF66-8303 through AF70-467, ex-cept AF69-006 and AF70-450).............................................................................3-149 3-99 Crew Lavatory Waste Servicing (AF69-006, AF70-450, and

AF83-1285 and Up)..............................................................................................3-149 3-104 Troop Compartment Servicing ............................................................................... 3-154 3-122 Potable Water System Servicing............................................................................ 3-166 3-130 Environmental Control System Servicing (AF66-8303 through

AF70-467)..............................................................................................................3-179 3-133 Escape Slide Servicing ............................................................................................ 3-180 3-135 Crew Door Accumulator Servicing...................................................................... 3-184.1

Change 38 i

TABLE OF CONTENTS - Continued

Section/Para Page

3-137 Relief Crew Compartment Liferaft Ejection Bottle Servicing............................. 3-188 3-140 ATM Accumulator Servicing ............................................................................... 3-190.1 3-142 Cargo Winch Servicing ........................................................................................... 3-193 3-147 Battery Servicing..................................................................................................... 3-197 3-149 Floor Covering Servicing ........................................................................................ 3-197

IV LUBRICATION............................................................................................................................... 4-1 4-1 Types of Lubrication ................................................................................................... 4-1

V CRASH HANDLING....................................................................................................................... 5-1 5-1 Preparation .................................................................................................................. 5-1 5-8 Emergency Removal Procedures ................................................................................ 5-2 5-13 Extent of Damage Due to Landing Gear Failure ................................................... 5-23 5-20 Inspection................................................................................................................... 5-23

LIST OF ILLUSTRATIONS - Titles included in Alphabetical Index .................................Index-1

LIST OF TABLES - Titles included in Alphabetical Index .................................................Index-1

INDEX .....................................................................................................................................Index-1 ii Change 37

INTRODUCTION

This manual is one of a series of specialized maintenance manuals for the C-5 airplane. It provides the information necessary for ground handling and servicing at the organizational (flight line) maintenance level. No instructions are included in this manual for maintenance which must be performed at the field or depot maintenance levels. The following is the list of organizational maintenance technical manuals applicable to the C-5 airplane:

1C-5A-2-1 Ground Handling and Servicing, C-5A and C-5B

1C-5A-2-1-1 Cross Servicing Guide for C-5A and C-5B

1C-5A-2-2 Airframe, C-5A and C-5B

1C-5A-2-3 Pneudraulics, C-5A and C-5B

1C-5A-2-3FI-1 Hydraulic Power Generation Systems - Fault Codes 45000-45511, C-5A and C-5B

1C-5A-2-4 Power Plant, C-5A and C-5B

1C-5A-2-4FI-1-1 Propulsion System - Fault Codes 22000 - 22087, 22100

- 22287, 22300 - 22487, 22500 - 22687, 22700 - 22831, 22895 - 22999, 23000 - 23099, and 23100 - 23139, C-5A and C-5B

1C-5A-2-4FI-1-2 Propulsion System - Fault Codes 22088, 22288, 22488, 22688, 22832, 22840, 22848, 22856, 22870, 22878, 22886, 22894, 23240 - 23739, C-5A and C-5B

1C-5A-2-4FI-1-3 Propulsion System - Fault Codes 23740 - 24099, 49400

- 49499, and 49520 - 49550, C-5A and C-5B

1C-5A-2-4JG-1-1 Throttles Component Rigging, C-5A and C-5B

1C-5A-2-4JG-1-2 Throttles Complete Rigging, C-5A and C-5B

1C-5A-2-4JG-2 Power Plant Removal and Installation, C-5A and C-5B

Change 20 iii

1C-5A-2-5 Fuel System, C-5A and C-5B

1C-5A-2-5FI-1-1 Fuel System - Fault Codes 46000 - 46749, C-5A and C-5B

1C-5A-2-5FI-1-2 Fuel System - Fault Codes 46750 - 46999, C-5A and C-5B

1C-5A-2-5JG-1 Emergency Fuel Shutoff Valve Rigging, C-5A and C-5B

1C-5A-2-6 Instruments, C-5A and C-5B

1C-5A-2-6-1 Instruments, C-5A and C-5B

1C-5A-2-6FI-1-1 Flight Director System No. 1 - Fault Codes 51130 - 51309, C-5A and C-5B

1C-5A-2-6FI-1-2 Flight Director System No. 2 - Fault Codes 51310 - 51489, C-5A and C-5B

1C-5A-2-6FI-1-3-1 Central Air Data Computer (CADC) Subsystem - Fault Codes 51001 - 51008 and 51598 - 51899, C-5B

1C-5A-2-6FI-1-4-1 Malfunction Detection Analysis and Recording Sys-tem (MADARS) - Fault Codes 55000 - 55449, C-5B

1C-5A-2-6FI-1-5-1 Malfunction Detection Analysis, and Recording Sys-tem (MADARS) - Fault Codes 55450 - 55999, C-5B

1C-5A-2-6FI-6 Inclinometer - Fault Codes 51126 - 51129; Multifunc-tion Display Unit (MFDU) - Fault Codes 82000, 82011

- 82018; Cursor Control Device (CCD) - Fault Codes 82001 - 82002; Cursor Control Panel (CCP) - Fault Codes 82003 - 82004; Communication Navigation Panel (CNP) - Fault Codes 82005 - 82006; Multifunc-tion Control Display Unit (MCDU) - Fault Codes 82008 - 82010; C-5A and C-5B

1C-5A-2-7 Electrical Systems, C-5A and C-5B

1C-5A-2-7-1 Electrical Systems, C-5A and C-5B

1C-5A-2-7FI-1 Electrical Systems - Fault Codes 42000 - 42514, C-5A and C-5B

1C-5A-2-7FI-1-1 Electrical Systems - Fault Codes 42001 - 42520, C-5A and C-5B

1C-5A-2-7FI-1-2 Flight Station Lighting System - Fault Codes 44001 - 44036, C-5A and C-5B

1C-5A-2-8-1 Radio, Communications and Navigation Systems, Vol.

1, C-5A and C-5B

1C-5A-2-8-1-1 Radio Communications and Navigation Systems, Vol.

1, C-5A and C-5B

1C-5A-2-8-2 Radio Communications and Navigation Systems, Vol.

2, C-5A and C-5B

1C-5A-2-8-2-1 Radio Communications and Navigation Systems, Vol.

2, C-5A and C-5B

1C-5A-2-8-4 Defensive Systems iv Change 27

1C-5A-2-8FI-1-1 Interphone System - Fault Codes 64000 - 64232; Pub-lic Address System - Fault Codes 64250 - 64278;

Emergency Locator Transmitter - Fault Codes 66032 - 66036; Cockpit Voice Recorder - Fault Codes 66011 - 66029; Digital Flight Data Recorder - Fault Codes 66000 - 66009, C-5B

1C-5A-2-8FI-1-1-1 Interphone System - Fault Codes 64000 - 64232; Pub-lic Address System - Fault Codes 64250 - 64278;

Emergency Locator Transmitter - Fault Codes 66032 - 66036; Cockpit Voice Recorder - Fault Codes 66011 - 66029; Digital Flight Data Recorder - Fault Codes 66000 - 66009, C-5B

1C-5A-2-8FI-1-2 Ground Proximity Warning System (GPWS) - Fault Codes 50000 - 50099; Radar Altimeter System - Fault Codes 72000 - 72099, C-5A and C-5B

1C-5A-2-8FI-1-2-1 Enhanced Ground Proximity Warning System (EGPWS) - Fault Codes 72057 - 72095, 72758; Com-bined Altitude Radar Altimeter (CARA) System - Fault Codes 72762 - 72775; Multimode Receiver (MMR) Navigation System - Fault Codes 71198 - 71221, C-5A and C-5B

1C-5A-2-8FI-2-1 Inertial Navigation System - Fault Codes 72000 - 72999, C-5A and C-5B

1C-5A-2-8FI-2-1-1 Aero-I Satellite Communication System - Fault Codes 68001 - 68018, 82027; Embedded Global Positioning/ Inertial Navigation System - Fault Codes 72700 - 72753; Micro Inertial Reference System - Fault Codes 72756, 72776 - 72779, C-5A and C-5B

1C-5A-2-8FI-2-2 Inertial Navigation System - Fault Codes 72000 - 72999, C-5A and C-5B

1C-5A-2-8FI-3 AN/APS-133 Color Weather Radar - Fault Codes 72800 - 72999, C-5A and C-5B

1C-5A-2-8FI-3-1 AN/APS-133 Color Weather Radar - Fault Codes 73000 - 73031, C-5A and C-5B

1C-5A-2-8FI-4 Air Defensive Systems - Fault Codes 76000 - 76999, C-5A and C-5B

1C-5A-2-8FI-5 Core Processing System - Fault Codes 82019 - 82047;

Integrated Standby Instrumentation System - Fault Codes 82100 - 82128, 82500 - 82508, C-5A and C-5B

1C-5A-2-8FI-6 Traffic Collision Avoidance System - Fault Codes 72759 - 72761, 72780 - 72794; AN/APX-100 Identifica-tion Friend or Foe/Mode S System - Fault Codes 65001 - 65018, C-5A and C-5B

1C-5A-2-8FI-7 ARC-210 VHF/UHF Radio System - Fault Codes 63200 - 63217; ARC-190 HF Radio System - Fault Codes 61070 - 61099, 61200 - 61202, C-5A and C-5B

1C-5A-2-9 Flight Controls, C-5A and C-5B

1C-5A-2-9-1 Flight Controls, C-5A and C-5B

1C-5A-2-9FI-1-1 Primary Mechanical Flight Controls, Ailerons, Flight Spoilers, Elevators, and Rudders - Fault Codes 14000

- 14299, C-5A and C-5B

Change 20 v

1C-5A-2-9FI-1-2 Secondary Flight Controls, Flaps and Slats, Ground Spoilers, and Pitch Trim - Fault Codes 14300 - 14511, C-5A and C-5B

1C-5A-2-9FI-1-3 AFCS Active Lift Distribution Control System (ALDCS), Go-Around Attitude Subsystem, and Stal-limiter Subsystem - Fault Codes 52725 - 52999, C-5A and C-5B

1C-5A-2-9FI-1-3-1 AFCS Active Lift Distribution Control Subsystem (ALDCS) - Fault Codes 57091 - 57094, 57152, 57153;

Stallimiter Subsystem - Fault Codes 57039 - 57042, 57129, 57130, 57150, 57151, 57570 - 57592; Angle-of- Attack (AOA) Subsystem - Fault Codes 57035 - 57038, 57560 - 57568; Takeoff/Go-Around (TOGA) Subsys-tem - Fault Codes 57012, 57013, 57043, 57044, C-5A and C-5B

1C-5A-2-9FI-1-4 Autopilot Subsystem Pitch Autopilot and Pitch PACS - Fault Codes 52000 - 52239, C-5A and C-5B

1C-5A-2-9FI-1-4-1 Autopilot Subsystem - Fault Codes 57001 - 57005, 57008 - 57017, 57019 - 57029, 57032 - 57034, 57043 - 57044, 57096, 57098, 57105 - 57106, 57108 - 57114, 57131, 57132, 57134, 57135, 57148, 57149, 57500 - 57524, 57527 - 57539; Pilot Assist Cable - Fault Codes 57025 - 57026, 57095, 57097, 57101 - 57104, 57117 - 57120, 57138 - 57141, 57148, 57149, 57158, 57159, 57540 - 57543, C-5A and C-5B

1C-5A-2-9FI-1-5 Autopilot Subsystem Roll Autopilot and Roll PACS - Fault Codes 52240 - 52389, C-5A and C-5B

1C-5A-2-9FI-1-6 Autopilot Subsystem Autothrottle - Fault Codes 57003, 57030, 57031, 57045, 57046, 57099, 57100, 57115, 57116, 57136, 57137, 57154, and 57155, C-5A and C-5B

1C-5A-2-9FI-1-7 Pitch Augmentation Subsystem and Yaw/Lateral Augmentation Subsystem - Fault Codes 52530 - 52724, C-5A and C-5B

1C-5A-2-9FI-1-7-1 Stability Augmentation System - Lateral Augmenta-tion Fault Codes 57047 - 57053, 57068 - 57074, 57123, 57124, 57142, and 57143; Pitch Augmentation Fault Codes 57054 - 57060, 57075 - 57081, 57121, 57122, 57144, and 57145; Yaw Augmentation Fault Codes 57061 - 57067, 57084 - 57090, 57125, 57126, 57146, and 57147; C-5A and C-5B

1C-5A-2-9JG-1-1 Aileron System Rigging, C-5A and C-5B

1C-5A-2-9JG-1-2 Flight Spoiler Rigging, C-5A and C-5B

1C-5A-2-9JG-1-3 Aileron/Flight Spoilers Complete Rigging, C-5A and C-5B

1C-5A-2-9JG-1-4 Ground Spoiler Rigging, C-5A and C-5B

1C-5A-2-9JG-1-5 Ground Spoilers Complete Rigging, C-5A and C-5B

1C-5A-2-9JG-2-1 Flap System-Less Power Package Assembly (PPA) Rigging, C-5A and C-5B

1C-5A-2-9JG-2-2 Flap System Power Package Assembly (PPA) Rigging, C-5A and C-5B

1C-5A-2-9JG-2-3 Flap System Complete Rigging, C-5A and C-5B vi Change 37

1C-5A-2-9JG-2-4 Slats Systems Rigging, C-5A and C-5B

1C-5A-2-9JG-2-5 Slats Systems Complete Rigging, C-5A and C-5B

1C-5A-2-10 Landing Gear, C-5A and C-5B

1C-5A-2-10FI-1-1 Landing Gear, MLG/NLG - Fault Codes 13000 - 13499, C-5A and C-5B

1C-5A-2-10FI-1-2 Landing Gear, Brakes and Skid Control, Caster Powerback and Steering, Kneeling - Fault Codes 13500 - 13649, 13700 - 13999, C-5A and C-5B

1C-5A-2-10JG-1-1 Main Landing Gear Rigging (Part I), C-5A and C-5B

1C-5A-2-10JG-1-2 Main Landing Gear Rigging (Part II), C-5A and C-5B

1C-5A-2-10JG-1-3 Main Landing Gear Rigging (Part III), C-5A and C-5B

1C-5A-2-10JG-2-1 Nose Landing Gear Rigging, C-5A and C-5B

1C-5A-2-10JG-2-2 Nose Landing Gear Rigging, C-5A and C-5B

1C-5A-2-10JG-3 Kneeling Crosswind Position Caster Powerback and Steering System Rigging, C-5A and C-5B

1C-5A-2-10JG-4-1 Removal and Installation of Main Landing Gear Shock Strut Components and Assemblies, C-5A and C-5B

1C-5A-2-10JG-4-2 Removal and Installation of Main Landing Gear Shock Strut Components and Assemblies, C-5A and C-5B

1C-5A-2-10JG-5 Removal and Installation of Nose Landing Gear Shock Strut Components and Assemblies, C-5A and C-5B

1C-5A-2-11-1 Airplane Wiring Diagrams, C-5A

1C-5A-2-11-1-1 Airplane Wiring Diagrams, C-5B

1C-5A-2-11-2 Airplane Wiring Diagrams, C-5A

1C-5A-2-11-2-1 Airplane Wiring Diagrams, C-5B

1C-5A-2-11-3 Airplane Wiring Diagrams, C-5A

1C-5A-2-11-3-1 Airplane Wiring Diagrams, C-5B

1C-5A-2-12 Forward and Aft Loading Systems, C-5A and C-5B

1C-5A-2-12FI-1-1 Forward Loading System - Fault Codes 11001 - 11251, C-5A and C-5B

1C-5A-2-12FI-1-2 Aft Loading System - Fault Codes 11271 - 11556, 11800 - 11899, C-5A and C-5B

1C-5A-2-12FI-1-3 Aerial Delivery System - Fault Codes 11576 - 11758, C-5A and C-5B

1C-5A-2-12JG-1-1 Forward Loading System Rigging Verification, C-5A and C-5B

1C-5A-2-12JG-2-1 Visor Rigging, C-5A and C-5B

1C-5A-2-12JG-3-1 Forward Ramp Rigging, C-5A and C-5B

1C-5A-2-12JG-3-2 Forward Ramp Extension Rigging, C-5A and C-5B

1C-5A-2-12JG-4-1 Forward Ramp Complete Rigging, C-5A and C-5B

1C-5A-2-12JG-4-2 Forward Ramp Extension Complete Rigging, C-5A and C-5B

Change 20 vii

1C-5A-2-12JG-4-3 Visor Complete Rigging, C-5A and C-5B

1C-5A-2-12JG-5-1 Aft Loading System Rigging Verification, C-5A and C-5B

1C-5A-2-12JG-6-1 Aft Ramp Mechanical Rigging, C-5A and C-5B

1C-5A-2-12JG-6-2 Aft Ramp Electrical Rigging, C-5A and C-5B

1C-5A-2-12JG-7-1 Pressure Door Upper Hinges, Lower Hinges, Upper Rollers, and Retractable Rollers Rigging, C-5A and C-5B

1C-5A-2-12JG-7-2 Pressure Door Interlock System Rigging, C-5A and C-5B

1C-5A-2-12JG-7-3 Pressure Door Seals, Unlock System, and Wedge Toes Rigging, C-5A and C-5B

1C-5A-2-12JG-7-4 Pressure Door Electrical Rigging, C-5A and C-5B

1C-5A-2-12JG-7-5 Movable Pressure Bulkhead Rigging, C-5A (AF68-213 and AF68-216)

1C-5A-2-12JG-8-1 Side Cargo Doors Rigging, C-5A and C-5B (AF66-8303 through AF68-212, AF68-214, AF68-215, AF68-217 through AF70-467, and AF83-1285 and Up)

1C-5A-2-12JG-8-2 Center Cargo Doors Rigging, C-5A and C-5B (AF66- 8303 through AF68-212, AF68-214, AF68-215, AF68- 217 through AF70-467, and AF83-1285 and Up)

1C-5A-2-12JG-8-3 Aft Cargo Doors Electrical Rigging, C-5A and C-5B (AF66-8303 through AF68-212, AF68-214, AF68-215, AF68-217 through AF70-467, and AF83-1285 and Up)

1C-5A-2-12JG-8-4 Aft Cargo Doors Rigging, C-5A (AF68-213 and AF68- 216)

1C-5A-2-12JG-8-5 Aft Cargo Doors Electrical Rigging, C-5A (AF68-213 and AF68-216)

1C-5A-2-12JG-9-1 Aft Ramp Complete Rigging, C-5A and C-5B

1C-5A-2-12JG-9-2 Pressure Door Complete Rigging, C-5A and C-5B

1C-5A-2-12JG-9-3 Aft Cargo Doors Complete Rigging, C-5A and C-5B (AF66-8303 through AF68-212, AF68-214, AF68-215, AF68-217 through AF70-467, and AF83-1285 and Up)

1C-5A-2-12JG-9-4 Aft Cargo Doors Complete Rigging, C-5A (AF68-213 and AF68-216)

1C-5A-2-13 Environment Control and Oxygen System, C-5A and C-5B

1C-5A-2-13FI-1-1 Environmental Control System - Fault Codes 40000 - 41194, C-5A and C-5B

1C-5A-2-13FI-1-2 Environmental Control System - Fault Codes 40000 - 41194, C-5A and C-5B

1C-5A-2-13FI-1-3 Environmental Control System - Fault Codes 41195 - 41729, C-5A and C-5B

1C-5A-2-13FI-1-4 Environmental Control System - Fault Codes 41730 - 41894, 41910 - 41999, C-5A and C-5B

1C-5A-2-13FI-1-5 Fire Extinguishing and Fire Suppression System - Fault Codes 49000 - 49399, C-5A and C-5B

1C-5A-2-14 Interior Trim, C-5A and C-5B viii Change 37

1C-5A-2-15 Seal Repair and Replacement, C-5A and C-5B

Additional information on operation, repair, parts listing, inspection, storage, weight and balance, cargo loading, power package buildup, airplane inventory, and critical alloys and precious metals may be found in the following publications:

1C-5A-1 Flight Manual, C-5A and C-5B

1C-5A-1-1 Performance Data, C-5A and C-5B

1C-5A-1-2 Partial Flight Manual, C-5A (SCM)

1C-5A-3 Structural Repair Instructions, C-5A and C-5B

1C-5A-3-1 Overhaul Instructions with Illustrated Parts Break-down - Pylon Assembly, C-5A and C-5B

1C-5A-3-2 Overhaul Instructions with Illustrated Parts Break-down - Cowl Door Assemblies and Pylon Aprons, C-5A and C-5B

1C-5A-4-1 Illustrated Parts Breakdown, Airframe Group, C-5A and C-5B

1C-5A-4-2 Illustrated Parts Breakdown, Hydraulic System, C-5A and C-5B

1C-5A-4-3 Illustrated Breakdown, Fuel System, C-5A and C-5B

1C-5A-4-4 Illustrated Parts Breakdown, Utilities, Pneumatic System, C-5A and C-5B

1C-5A-4-5 Illustrated Parts Breakdown, Flight Control and In-strument System, C-5A and C-5B

1C-5A-4-6 Illustrated Parts Breakdown, Electrical System, C-5A and C-5B

1C-5A-4-7 Illustrated Parts Breakdown, Electronic System, C-5A and C-5B

1C-5A-4-8 Illustrated Parts Breakdown, Alternate Mission Kits, C-5A and C-5B

1C-5A-4-9 Illustrated Parts Breakdown, Special Support Equip-ment, C-5A and C-5B

1C-5A-4-10 Illustrated Parts Breakdown, Numerical Index and Reference Designation Index, C-5A and C-5B

1C-5A-5-1 Basic Weight Checklist, C-5A and C-5B

1C-5A-5-2 Loading Data, C-5A and C-5B

1C-5A-6 Scheduled Inspection and Maintenance Require-ments, C-5A and C-5B

1C-5A-6CF-1 Acceptance and/or Functional Check Flight Proce-dures Manual, C-5A and C-5B

1C-5A-6WC-1 Preflight, Thru-Flight Inspection Work Cards, C-5A and C-5B

1C-5A-6WC-2 Basic Post Flight/Home Station Check Inspection Work Cards, C-5A and C-5B

1C-5A-6WC-5 Major/Minor Inspection Work Cards, C-5A and C-5B

1C-5A-6WC-8 Palletized Troop Compartment Kit Work Cards, C-5A and C-5B

1C-5A-6WC-10 Refurbish Inspection Work Cards, C-5A and C-5B

Change 20 ix

1C-5A-6WC-13 Lubrication Requirements After Washing Aircraft, C-5A and C-5B

1C-5A-8 RESCINDED

1C-5A-8-1 General Software Manual, Flight Programs Configu-rations and Loading, C-5A and C-5B

1C-5A-9 Cargo Loading

1C-5A-9-1 Partial Loading Instructions Manual, C-5A (SCM)

1C-5A-10 Buildup Instructions Aircraft Power Package, C-5A and C-5B

1C-5A-10-1 Test Instructions Engine Build up Unit, C-5A and C-5B

1C-5A-10FI-1 Field Maintenance, Power Package, C-5A and C-5B

1C-5A-10JG-1-1 Buildup Instructions, Aircraft Power Package, C-5A and C-5B

1C-5A-10JG-1-2 Buildup Instructions, Aircraft Power Package, C-5A and C-5B

1C-5A-10JG-1-3 Buildup Instructions, Aircraft Power Package, C-5A and C-5B

1C-5A-10JG-1-4 Buildup Instructions, Aircraft Power Package, C-5A and C-5B

1C-5A-17 Aircraft Storage, C-5A and C-5B

1C-5A-21 Master Guide Aircraft Inventory Record, C-5A and C-5B

1C-5A-23 System Peculiar Corrosion Control Manual, C-5A and C-5B

1C-5A-36-1 Nondestructive Inspection, C-5A and C-5B

1C-5A-36-2 Nondestructive Inspection Manual, C-5A and C-5B

1C-5A-36-3 Nondestructive Inspection Manual, C-5A and C-5B

1C-5A-39 Aircraft Battle Damage Repair Inspection, C-5A and C-5B

1C-5A-102 Operating Instructions - Air Crew/Ground Crew - Malfunction Detection, Analysis, and Recording Sys-tem (MADARS), C-5

1C-5A-102-1 Operating Instructions - Air Crew/Ground Crew - Malfunction Detection, Analysis, and Recording Sys-tem (MADARS), C-5

1C-5A-103 RESCINDED

1C-5A-01 List of Applicable Publications, C-5A and C-5B

1C-5A-06 Work Unit Code Manual, C-5A and C-5B

2J-TF39-6 Field Maintenance Instruction Turbofan Engine Model TF39-GE-1

00-25-113-C5 Critical Alloys and Precious Metals Parts List, C-5A and C-5B

00-25-06-2-4 C-5 Aerospace Ground Equipment Work Unit Code Manual, C-5A and C-5B x Change 20

Maintenance and operational checklists are provided on the C-5 which are instructions in abbrevi-ated form to enable qualified personnel to perform maintenance and operational procedures with-out omission of steps and without reference to the basic maintenance manuals. The procedures in these checklists are presented in the shortest practical form for use by qualified personnel and are not intended to provide adequate instructions for less experienced personnel. Checklist technical manual numbers are derived from the basic manual numbers, allowing each reference between checklist and manuals:

CHECKLIST NO. SUBJECT

1C-5A-1CL-1 Pilots’ Flight Crew Checklist, C-5A and C-5B 1C-5A-1CL-1-1 Pilots’ Scroll Checklist, C-5A and C-5B 1C-5A-1CL-2 Flight Engineer’s Flight Crew Checklist, C-5A and

C-5B 1C-5A-1CL-2-1 Flight Engineer’s Scroll Checklist, C-5A and C-5B 1C-5A-1CL-4 Loadmaster’s Abbreviated Checklist, C-5A and

C-5B 1C-5A-1CL-4-1 Loadmaster (Fwd) Scroll Checklist, C-5A and

C-5B 1C-5A-1CL-4 Loadmaster (Aft) Scroll Checklist, C-5A and C-5B 1C-5A-1CL-5 Scanner’s Flight Crew Checklist, C-5A and C-5B 1C-5A-1-1CL-1 Pilots’ Flight Crew Checklist, C-5A (SCM) 1C-5A-1-1CL-2 Flight Engineer’s Flight Crew Checklist, C-5A

(SCM)

1C-5A-1-1CL-4 Loadmaster’s Abbreviated Checklist, C-5A (SCM) 1C-5A-1-1CL-5 Scanner’s Flight Crew Checklist, C-5A (SCM) 1C-5A-2-1CL-1 Towing/Mooring, C-5A and C-5B 1C-5A-2-1CL-2 Jacking, C-5A and C-5B 1C-5A-2-1CL-3 Liquid Oxygen Servicing, C-5A and C-5B 1C-5A-2-1CL-4 Nitrogen Servicing, C-5A and C-5B 1C-5A-2-1CL-6 Refueling/Defueling, C-5A and C-5B 1C-5A-2-4CL-1 Engine Ground Operation, C-5A and C-5B 1C-5A-2-4CL-2 APU/ATM Ground Operation 1C-5A-2-5CL-1 Fuel Tank Preparation, Entry and Closing, C-5A and C-5B 1C-5A-2-10CL-1 Airplane Kneeling System, C-5A and C-5B 1C-5A-2-12CL-1 Cargo Doors and Ramps, C-5A and C-5B 1C-5A-6CL-1 Acceptance and/or Functional Check Flight Proce-dures Checklist, C-5A and C-5B 1C-5A-9CL-1 Loadmaster On/Off Loading Procedures, C-5A and

C-5B

USE OF WARNINGS, CAUTIONS AND NOTES WARNINGS, CAUTIONS and Notes are used in this manual to emphasize important or critical instructions. The WARNING, CAUTION or Note will always precede the step or procedure to which it applies. The heading used, and the definition of each, are as follows:

WARNING

A WARNING is used to emphasize procedures or practices which, if not correctly followed, will result in injury to personnel.

Change 37 xi

CAUTION

A CAUTION is used to emphasize procedures or practices which, if not strictly observed, will result in damage to, or destruction of, equipment.

Note A note is used to put special emphasis on a step, procedure, or condition which might otherwise be overlooked or misinterpreted.

HOW TO LOCATE INFORMATION

The instructions in this technical manual are organized for quick reference. To aid you, this manual contains a general table of contents, listing sections and sectional contents for the complete manual, as well as a table of contents at the beginning of each section which list the major items discussed in that section.

An alphabetical index locating text and illustrations of systems and components by paragraph number or illustration number appears in the back of this manual.

When it becomes necessary in this manual to differentiate between C-5 airplanes, reference will be made to the Air Force serial number.

C-5A Serialization

AF TAIL NUMBER CONTRACT END ITEM

AF66-8303 - AF66-8307 001 - 005

AF67-167 - AF67-174 006 - 013

AF68-211 - AF68-228 014 - 031

AF69-001 - AF69-027 032 - 058

AF70-445 - AF70-467 059 - 081

C-5B Serialization

AF TAIL NUMBER CONTRACT END ITEM

AF83-1285 0082

AF84-059 - AF84-062 0083 - 0086

AF85-001 - AF85-010 0087 - 0096

AF86-011 - AF86-026 0097 - 0112

AF87-027 - AF87-045 0113 - 0131

Note All and up serialization contained in this publication shall apply to C-5B serials as well as C-5A serials. C-5A TCTO which apply to the C-5B will have C-5B applicability added. C-5A TCTO that do not indicate C-5B serialization are applicable to C-5A airplanes only.

Particular care has been taken to organize the material in this manual so you can find the information you need immediately. The sections of the manual are written so the more specific maintenance instructions are separate from the general descriptive information. Except for the general information section found in the front of each manual, most sections of the -2 series manuals are divided into the following subsections:

DESCRIPTION AND LEADING PARTICULARS

Provide all descriptive information pertaining to the particular system, and provides a general working knowledge of the complete subsystem.

xii Change 20

OPERATIONAL CHECKOUT

Describes in detail the procedures to operationally check the complete subsystem involved. This check ensures that each system meets its minimum performance standards.

TROUBLESHOOTING

Provides all trouble isolation procedures and remedies that can be accomplished at the organizational level of maintenance, using authorized aerospace ground equipment, built-in test equipment, and visual and audible indications. Although the C-5 is equipped with a Malfunction Detection Analysis and Recording Subsystem, the troubleshooting procedures in this manual are provided in addition to the malfunction monitoring system.

ELECTROSTATIC DISCHARGE SENSITIVE (ESDS) EQUIPMENT

Care must be exercised during the handling of Line Replacement Units (LRU) indicated as Electrostatic Discharge Sensitive (ESDS). Refer to TO 00-25-234 for ESDS device handling procedures.

REMOVAL AND INSTALLATION

Provides detailed instructions for the removal and installation of all line replaceable units if the procedure for the removal and installation of these units is not obvious. For those line replaceable units that can be removed and installed at the organizational level of maintenance, illustrations are provided locating each unit in the airplane.

If a warning tag is required per applicable airplane technical order or fault isolation manual, comply with all guidance contained in AFI 21-101 and applicable AFOSH Standards regarding lockout and warning tags when removing components.

ADJUSTMENTS

Provides step-by-step procedures for adjustments to all system units that can be accomplished at the organi-zational level of maintenance.

CLEANING, DRAINING, AND LUBRICATION

Contains instructions for the cleaning and draining of each system and its various units. Lubrication instruc-tions are provided in each of the subsystem manuals, but are limited to lubrications that must be accom-plished as a result of a maintenance function. Complete lubrication requirements for the entire airplane are given in TO 1C-5A-2-1.

CLIMATIC AND ENVIRONMENTAL INFORMATION

Includes maintenance information for adverse weather or other conditions.

YOUR RESPONSIBILITY TO LET US KNOW

It is your responsibility to submit recommended changes for this publication on AFTO Form 22 to the 565 ACSS/GFLB TO Manager in accordance with TO 00-5-3.

TIME COMPLIANCE TECHNICAL ORDERS.

Time Compliance Technical Orders (TCTO) authorize and give instructions for inspection or modification of the airplane. When a TCTO is issued for a change which modifies an airplane system or component, information applicable to the change is added to the manual and identified by reference to the TCTO. The TCTO in the following list titled Record of Applicable Time Compliance Technical Orders have been included

Change 27 xiii in this manual. After the TCTO has been incorporated on all affected airplanes, the information which was applicable to the unmodified airplanes is removed from the manual and reference to the TCTO will be removed from the manual. However, in some cases where the TCTO does not affect all airplanes covered by the manual, reference to the TCTO may be retained to avoid using cumbersome serialization.

Record of Applicable Time Compliance Technical Orders

TO NO. DATE TITLE

1C-5-632 1 December 1997 Installation of Defensive Systems with ALE-47 CMDS, C-5 Aircraft

1C-5-674 30 April 1999 Installation of Multifunction Radio on C-5 Aircraft

1C-5-701 12 January 2000 Installation of Traffic Alert and Collision Avoidance System (TCAS) on C-5 Aircraft

1C-5-714 1 July 2005 Installation of C-5 Avionics Moderniza-tion Program (AMP) on C-5 Aircraft

1C-5-736 15 April 2004 Emergency Power Generating System Modification, Emergency Power System Upgrade (EPSU), C-5 Aircraft

1C-5-737 22 August 2003 Installation of MADARS III on C-5 Aircraft

1C-5-749 22 September 2003 Installation of Circuit Breaker Identifi-cation Collars - Orange

1C-5-799 1 Jan 2009 Installation of AN/AAQ-24 (V) Infrared Countermeasures System (IRCM) on Selected C-5 Aircraft

1C-5A-2070 1 December 1977 C-5A Troop Compartment Lavatory and Potable Water System Improvements xiv Change 27

1096942377E Text Box See SUPP S-28

GLOSSARY

Abbreviation Description

AC Alternating Current

ACP Automatic Communication Processor

ADU Air Data Unit

AIL STA Aileron Station

AIU Avionics Interface Unit

ANDVT Advanced Narrowband Digital Voice Terminal

APU Auxiliary Power Unit

ATM Air Turbine Motor

AUX Auxiliary

BIP Backup Integrating Processor

BAT Battery

BATT Battery

BCEM Battery Charger Electronic Module

BL Buttock Line

BOX BM STA Box Beam Station

BSIU Bus Subsystem Interface Unit

BTRY Battery

C Celsius (Centigrade)

CADC Central Air Data Computer

CARA Combined Altitude Radar Altimeter

CC Cubic Centimeter(s)

CCD Cursor Control Device

CCP Cursor Control Panel

CDU Control Display Unit

CG Center of Gravity

CO2 Carbon Dioxide

CSD Constant Speed Drive

CU Cubic

DB Decibel(s)

DC Direct Current

DIA Diameter

EED Electro Explosive Devices

ELEV STA Elevator Station

EPR Engine Pressure Ratio

ESDS Electrostatic Discharge Sensitive

Change 24 xv

Abbreviation Description

EXT Extended

F Fahrenheit

FMS Flight Management System

FR BM STA Front Beam Station

FS Fuselage Station

FSS Fire Suppression System

FT Foot, Feet

FWD Forward

G Gram(s)

GCU Generator Control Unit

GPS Global Positioning System

GSU Ground Servicing Unit (Flightline LN2 servicing tank truck)

HMG Hydraulic Motor Generator

HORIZ STAB STA Horizontal Stabilizer Station

IN Inch(es)

INBD Inboard

INS Inertial Navigation System

IWBR STA Inner Wing Box Rib Station

LB Pound(s)

LBL Left Buttock Line

LN2 Liquid Nitrogen

LOX Liquid Oxygen

MAC Mean Aerodynamic Chord

MAX Maximum

MCDU Multipurpose Control Display Unit

MFDU Multifunction Display Unit

MIN Minimum

MLG Main Landing Gear

MM Millimeter(s)

MPH Miles Per Hour

NLG Nose Landing Gear

NO. Number

NSN National Stock Number

OUTBD Outboard

OWBR STA Outer Wing Box Rib Station

PCC Production Control Center xvi Change 24

Abbreviation Description

PMI Periodic Maintenance Inspection

PSI Pounds Per Square Inch

P/TA Pointer/Tracker Assembly

PTU Power Transfer Unit

QEC Quick Engine Change

RAT Ram Air Turbine

RBL Right Buttock Line

RG Range

RPM Revolutions Per Minute

RTRU Regulated Transformer Rectifier Unit

SAI Standby Attitude Indicator

SATCOM Satellite Communications

SCM Space Cargo Modification

SE Support Equipment

SPR Single Point Refueling

VIA Versatile Integrated Avionics

SUPPR Suppression

VSBR STA Vertical Stabilizer Box Rib Station

WG STA Wing Station

WIAGO Wireless Intercom for Aircraft Ground Operations

WL Water Line

Change 27 xvii

Figure 1-0. The Airplane xviii Change 20

Table 1-0 contains approved solvents recommended for cleaning within the categories specified.

WARNING

Keep solvent cleaners/chemicals in approved safety containers and in mini-mum quanties. Some solvent cleaners/chemicals may have an adverse effect on skin, eyes, and respiratory tract. Observe manufacturer’s WARNING labels and current directives. Use solvent cleaners/chemicals only in author-ized areas. Good general ventilation is required. Discard soiled clothes into safety cans. Unless otherwise indicated in the text, application as described in this TO should not result in any immediate health concerns.

WARNING

When solvent cleaners are being applied, approved explosion-proof lights, blowers, and other equipment shall be used. Ensure firefighting equipment and emergency eye wash are readily available and in working order.

Table 1-0. Approved Cleaning Solvents

Cleaning Process Approved Solvents

Prior to Painting Isopropyl Alcohol (TT-I-735)

Methyl Isobutyl Ketone (ASTM D-1153)

Prior to Sealing Aliphatic Naphtha (TT-N-95)

Dry Cleaning Fluid (MIL-PRF-680, Type II or Type III)

DS-108 (Commercial)

Isopropyl Alcohol (TT-I-735)

Shopmaster RC (Commercial)

Prior to Adhesive Bonding Acetone (ASTM D-329)

Aliphatic Naphtha (TT-N-95)

Isopropyl Alcohol (TT-I-735)

Toluene (A-A-59107)

General Cleaning Dry Cleaning Solvent (MIL-PRF-680, Type II or Type III)

Penetone Formula 724

Change 20 xix/(xx blank)

SECTION I

GENERAL INFORMATION

Contents Page

GENERAL AIRPLANE INFORMATION ................................................................................................. 1-2 Airplane Description.............................................................................................................................. 1-2 Airplane Dimensions ............................................................................................................................. 1-2 Major Component Weights.................................................................................................................... 1-2 Airplane Stations ................................................................................................................................... 1-2 Danger Areas.......................................................................................................................................... 1-2 Airplane Exterior Walkways and No-Step Areas................................................................................ 1-3 Airplane Maintenance and Ground Handling Markings.................................................................... 1-3 Fuel Quantity Indicator Failure (AF83-1285 and up) ........................................................................ 1-3 Confined Spaces and Entry Permit Classification Listing................................................................. 1-3 Access Provisions ................................................................................................................................... 1-30

METRIC EQUIVALENTS OF U.S. UNITS OF MEASURE................................................................... 1-30

GENERAL MAINTENANCE INFORMATION........................................................................................ 1-73 Personnel Restraint Equipment .................................................