1-8_-_Freightliner_Truck_Coverage_4_Inclusion___Exclusion_Overview.pdf

150915 – Truck Coverage 4 Page 1

DAIMLER TRUCKS NORTH AMERICA

AFTERMARKET SERVICE PRODUCTS

TRUCK COVERAGE 4 – INCLUSION/EXCLUSION OVERVIEW

Updated as of 9/15/2015

INCLUDED SYSTEMS INCLUDED ASSEMBLIES AND/OR PARTS EXCLUDED ASSEMBLIES AND/OR PARTS

AIR CONDITIONING, HEATING &

VENTILATING SYSTEM

• COMPRESSOR

• EVAPORATOR CORE

• CONDENSER ASSEMBLY

• BLOWER MOTOR

• HEATER ASSEMBLY

• RECEIVER DRYER

• WIRING

• LINES

• SELECT AUXILIARY HVAC COMPONENTS (IF

FACTORY EQUIPPED)

• BATTERIES

• PARKSMART SYSTEM

• REFRIGERANT

SUSPENSION, FRONT/REAR • STEEL SPRINGS

• SPRING HANGER BRACKETS

• SHACKLES AND PINS AND TORQUE RODS

• AIR SUSPENSION

• KING PIN BUSHINGS & BEARINGS

• WHEEL END COMPONENTS

• TAG AXLE ASSEMBLY

• PUSHER AXLE ASSEMBLY

• NUTS, BOLTS, KITS, AND MOUNTING HARDWARE

• STEERING ARM

• DRIVE AXLES

• STEER AXLES

ALTERNATOR & CHARGING SYSTEM • ALTERNATOR ASSEMBLY

• HARDWARE, MOUNTING - ALTERNATOR

ASSEMBLY

• ALTERNATOR WIRING HARNESS

• VOLTAGE REGULATOR

• BATTERY CHARGE EQUALIZER

• BOLT - ALTERNATOR HOUSING

• BOLT - ALTERNATOR FRAME

• BOLT - ADJUSTMENT, ALTERNATOR

150915 – Truck Coverage 4 Page 2

STARTER & CRANKING SYSTEM • STARTER MOTOR ASSEMBLY

• STARTER SOLENOID

• BATTERY CABLES

• GROUND STRAP

• BATTERY DISCONNECT SWITCH

• GLOW PLUG

• BATTERIES

AIR INTAKE SYSTEM • CHARGE AIR COOLER HOUSING

• CHARGE AIR COOLER MOUNTING HARDWARE

• CHARGE AIR COOLER COLD SIDE PIPE

• CHARGE AIR COOLER HOT SIDE PIPE

• CHARGE AIR COOLER ELBOW

• AIR CLEANER

• PRE-CLEANER ASSEMBLY

• FILTER ELEMENTS

• SEALS & GASKETS & KITS

• TURBOCHARGER

IGNITION SYSTEM • IGNITION SWITCH

• STARTER INTERLOCK WIRING

• REMOTE START WIRING/SWITCH/ANTENNA

SELECT FRAME COMPONENTS:

• BRACKETS

• BUMPER ASSEMBLY FRONT & REAR

• ENGINE MOUNTINGS

• CAB & BODY MOUNTINGS

• BATTERY BOX & SUPPORT

• FUEL TANK SUPPORT

• LICENSE CARRIER

• ATTACHING DEVICES - HOSES, LINES, TUBES &

WIRE

• SLEEPER MOUNTING

• CAB SHOCK ABSORBER

• TOOLBOX ASSEMBLY & MOUNTINGS

• NOISE SHIELD

• RADIATOR SUPPORTS

• LIFTING HOOKS

• STEP & BRACKETS - FRAME MOUNTED STEP

ASSEMBLY

150915 – Truck Coverage 4 Page 3

DRIVE SHAFTS • DRIVE SHAFT

• YOKE – DRIVE SHAFT END

• UNIVERSAL JOINT – FRONT, CENTER, REAR

• BEARING ASSEMBLY – DRIVE SHAFT

• PINION END YOKE

COOLING SYSTEM • RADIATOR ASSEMBLY

• RADIATOR SHUTTER

• COOLANT RECOVERY SYSTEM

• SURGE TANK ASSEMBLY

• RADIATOR MOUNTING HARDWARE

• RADIATOR PLUMBING

• FAN CLUTCH

• FAN HUB SEAL & BEARING

• FAN BLADE

• OIL COOLER ASSEMBLY – TRANSMISSION

• RADIATOR FAN SHROUD ASSEMBLY

• BELTS

• HOSES

• SEALS

• GASKETS

• FITTINGS

SPARE WHEEL MOUNTING • CARRIER - SPARE WHEEL

• HOLD-DOWN CLAMPING PARTS

• CHAIN-LINK, SPARE TIRE CARRIER

BRAKES • BRAKE CYLINDER ASSEMBLIES OR CHAMBERS

• BRAKE CALIPER ASSEMBLIES

• BRAKE AIR LINES

• SLACK ADJUSTERS

• SELECT VALVES

• LEVER - PEDAL & SECTOR ASSEMBLY, PARKING

BRAKE

• MASTER CYLINDER – BRAKE

• AIR TANK

• AIR REGULATOR OR GOVERNOR

• AIR DRIER W/DRAIN VALVES

• ANTILOCK BRAKES ECU & TCV

• BRAKE LINING

• DISC BRAKE PAD

• REPAIR KITS

• BRAKE DRUMS

• BRAKE ROTORS

CHASSIS LUBRICATOR • BODY - GREASE RESERVOIR, AUTOMATIC

CHASSIS LUBRICATOR

• PUMP ELEMENT, GREASE PUMP

• BLOCK ASSEMBLY -GREASE DISTRIBUTION

150915 – Truck Coverage 4 Page 4

• WIRING HARNESS - CHASSIS LUBRICATION

• CONTROLLER ASSEMBLY - AUTOMATIC

CLUTCH SYSTEM* • CLUTCH PEDAL

• SHAFT - CLUTCH PEDAL

• CLUTCH PEDAL LINKAGE

• CLUTCH RELEASE BEARING

• MASTER CYLINDER ASSEMBLY – CLUTCH

• CONTROL ASSEMBLY - HYDRAULIC CLUTCH

• SLAVE CYLINDER ASSEMBLY – CLUTCH

• FORK - CLUTCH RELEASE

• PLATE ASSEMBLY - DRIVEN DISC, CLUTCH

• FACINGS – CLUTCH

• PLATE – INTERMEDIATE

• PRESSURE PLATE & COVER ASSEMBLY

• BOLT - CLUTCH DRIVEN PLATE HUB

TRANSMISSION – MAIN, MANUAL* • TUBE - DIPSTICK, MANUAL TRANSMISSION

• DIPSTICK - MANUAL TRANSMISSION

• ROD - TRANSMISSION SUPPORT STRUT

• HOUSING – CLUTCH

• FITTING – AIR LINE, EXTERNAL CONTROL,

MANUAL TRANSMISSION

• FITTING – OIL COOLER HOSE, MANUAL

TRANSMISSION

• GEAR SHIFT LEVER AND KNOB

• MOUNTING BRACKET, EXTERNAL SHIFT,

MANUAL TRANSMISSION

• TRANSMISSION ASSEMBLY

• AUTOMATED TRANSMISSION

• TRANSMISSION CASE

• BELL HOUSING

• OIL FILTER

• SEALS & GASKETS

• BOLTS - CLUTCH HOUSING TO ENGINE

TRANSMISSION – AUTOMATIC* • TUBE - OIL DIPSTICK

• BRACKET - TUBE, OIL CHECK

• MODULE - SHIFT SELECTOR

• ROD ASSEMBLY – PARKING LOT ACTUATOR

• HARDWARE, MOUNTING - BELL HOUSING TO

ENGINE

• BRACKET - REAR SUPPORT

• SENSOR - TEMPERATURE, AUTOMATIC

TRANSMISSION

• ROD ASSEMBLY - PARKING LOCK ACTUATOR

• SHIFT SELECTOR

• WIRING HARNESS - SPEED SENSOR

• SHIFT CONTROL LINKAGE

• AUTOMATIC TRANSMISSION

• AUTOMATIC TRANSMISSION CASE

• CONVERTER ASSEMBLY, AUTOMATIC

TRANSMISSION

150915 – Truck Coverage 4 Page 5

• COOLER, MANIFOLD - ASSEMBLY

AUXILIARY TRANSMISSION* • CASE ASSEMBLY - AUXILIARY TRANSMISSION

• HARDWARE, MOUNTING - AUXILIARY

TRANSMISSION CASE COVER

• BRACKET - AUXILIARY TRANSMISSION

• BRACKET - CROSS MEMBER, AUXILIARY

TRANSMISSION

• SHIFT LEVER - PTO, AUXILIARY TRANSMISSION

• AUXILIARY TRANSMISSION ASSEMBLY COMPLETE

LIGHTING SYSTEM • HOUSING ASSEMBLY – HEADLAMP

• WIRING HARNESS – HEADLAMP

• HOUSING ASSEMBLY - REAR LAMP

(TAIL/STOP/TURN SIGNAL)

• LAMP ASSEMBLY - TAIL, STOP, & LICENSE

COMBINATION, REAR

• LED - REAR TAIL LIGHT / STOP LIGHT

ASSEMBLY

• HOUSING – TRUN SIGNAL OPERATING SWITCH

• LEVER - TURN SIGNAL OPERATING

• HOUSING - FRONT TURN SIGNAL & PARKING

LAMP

• HOUSING ASSEMBLY - TURN SIGNAL, REAR

• HOUSING ASSEMBLY – SIDE TURN SIGNAL

• WIRING HARNESSES (INCLUDING: POWER

WINDOWS, POWER DOOR LOCKS, POWER

SEATS, ABS SYSTEM, SPEED CONTROL,

INFORMATION CENTER ASSEMBLY, et al)

• LIGHT BULBS, LAMPS, FUSES, FLUOURECENT

BALLAST AND TUBES, LENS, HALOGEN CAPSULE,

TRAILER WIRING CONNECTORS

FUEL SYSTEM • FUEL TANK, FILLER PIPE, VENT PIPE, GAUGE

• PEDAL & LINKAGE ASSEMBLY – ACCELERATOR

• CONTROL MODULE – SPEED

• WIRING HARNESS - CRUISE CONTROL SYSTEM

• GPS MODULE - PREDICTIVE CRUISE CONTROL

• FUEL HEATER

• FUEL TANK COOLER, FUEL TANK CAP, FILTERS,

FILTER ELEMENTS, FILTER ASSEMBLIES, LABELS,

SIGHT GLASS, FUEL PUMP ASSEMBLIES

INCLUDING WIRING & HARDWARE &

ELECTRONICS, FUEL INJECTION ASSEMBLIES

INCLUDING WIRING & HARDWARE &

ELECTRONICS, FUEL COMPONENTS PROVIDED BY

ENGINE MANUFACTURER WITH THE ENGINE

150915 – Truck Coverage 4 Page 6

VEHICLE COUPLING SYSTEM • PLATE - LOWER COUPLER, FIFTH WHEEL

• CYLINDER (AIR) - FIFTH WHEEL

• SLIDE OR SADDLE PLATE - SLIDING LOWER

COUPLER ASSEMBLY

• LOCK ASSEMBLY - FIFTH WHEEL

• STOP - SLIDING FIFTH WHEEL

• FIFTH WHEEL ASSEMBLY - LOWER ELEVATING

• LEVER - OPERATING LINKAGE

• HOOK – PINTLE

• RAMP – FIFTH WHEEL

• DRAW BAR

• COMBINATION TAG AXLE/CONVERTER DOLLY

• STEERING HITCH SYSTEM

AUXILIARY POWER UNIT (APU) • AUXILIARY POWER UNIT (APU) ASSEMBLY –

COMPLETE

• PIPE – EXHAUST, APU

• BATTERY, APU, FILTERS, FILTER ELEMENTS,

CAB & SHEET METAL • GRILLE – RADIATOR

• FENDER ASSEMBLY - CAB, FRONT

• FENDER - CAB, REAR

• PANEL ASSEMBLY – HOOD

• PANEL ASSEMBLY - COWL, CAB

• PANEL - ROOF, CAB

• PILLAR A, B, & C

• STORAGE COMPARTMENT – CAB, SIDE

• DASH ASSEMBLY

• MIRROR - MOTORIZED & HEATED

• WIRING HARNESS – MIRROR

• ARMREST - CAB OR FRONT DOOR

• SEAT BELT & RETAINER ASSEMBLY

• ROCKER PANEL

• FLOOR PAN - CAB OR FRONT

• CAB ASSEMBLY – COMPLETE

• DOOR ASSEMBLY - CAB OR FRONT

• FRAME - DOOR, FRONT OR ENTRANCE

• WIRING HARNESS - POWER WINDOW

• ACTUATOR - ELECTRIC DOOR LOCK

• MOTOR & TRANSMISSION - ELECTRIC

• MUD FLAPS, HANGER - MUD FLAP, HARDWARE,

MOUNTING - MUD FLAP, CLIPS, SPRINGS, GLASS,

WINDSHIELD GLASS, WINDSHIELD GLASS -

CORNER, WINDOW SEAL - MEETING RUBBER,

GLASS - QUARTER WINDOW, GLASS - SIDE

SLIDING, GLASS - REAR DOOR, GLASS - CAB OR

FRONT DOOR, GLASS - BACK WINDOW, GLASS -

SIDE DOOR, WINDSHIELD RUBBER SEAL, WIRING

HARNESS – HEATED WINDSHIELD, DECALS,

FLOOR MATS, CARPET – FLOOR, MIRROR GLASS

150915 – Truck Coverage 4 Page 7

WINDOW REGULATOR

• AIR BAG – ASSEMBLY, DRIVER SIDE, FRONT

• SEAT ASSEMBLY

• MOTOR ASSEMBLY - WINDSHIELD WIPER

INSTRUMENTS, GAUGES, WARNING • OIL PRESSURE GAUGE & LINE

• AMMETER

• WATER TEMP GAUGE & SENDING UNIT

• FUEL GAUGE ASSEMBLY & SENDING UNIT

• DOOR CHIME RELAY

• SPEEDOMETER HEAD & ODOMETER

• WIRING HARNESS - SPEEDOMETER

• MULTIPLEXER CAB

• WIRING HARNESS – MULTIPLEXER

• SOFTWARE - CPU, MULTIPLEXER UNIT

AERODYNAMIC DEVICES • DEFLECTOR - AIRFOIL, ROOF MOUNTED

• MOUNTING BRACKET - ROOF AIR DEFLECTOR

• FAIRING – ASSEMBLY, COMPLETE, ROOF

MOUNTED

• FAIRING – CHASSIS

• FAIRING – CAB EXTENDER

• AIR DEFLECTOR - CAB FRONT

STEERING • STEERING WHEEL ASSEMBLY

• STEERING COLUMN

• WIRING - HARNESS, STEERING COLUMN

• STEERING GEAR ASSEMBLY

• ARM – PITMAN

• TIE ROD – RIGHT & LEFT

• TIE ROD END ASSEMBLY

• PRESSURE RELIEF VALVE - POWER STEERING

PUMP

• COOLER ASSEMBLY - OIL PUMP

• PUMP ASSEMBLY - POWER CYLINDER

• MOUNTING HARDWARE – POWER STEERING

PUMP

• STEERING STABILITY SYSTEM

150915 – Truck Coverage 4 Page 8

• STEERING SHAFT

TIRES, TUBES, LINERS & VALVES

• VALVE - RELIEF - TIRE PRESSURE INFLATION

AND MONITORING SYSTEMS

• PNEUMATIC CONTROL UNIT (PCU)

• DISPLAY - TIRE PRESSURE MONITORING

SYSTEM

• CONTROLS, CENTRAL TIRE INFLATION SYSTEM

• TIRES

WHEELS, RIMS, HUBS & BEARINGS • HUB ASSEMBLY - PREADJUSTED, FRONT STEER

WHEEL

• HUB & DRUM ASSEMBLY - FRONT STEER

WHEEL

• HUB & ROTOR - ASSEMBLY, FRONT STEER

WHEEL

• HUB ASSEMBLY - PREADJUSTED, REAR DRIVE

WHEEL

• HUB & ROTOR ASSEMBLY - REAR DRIVE AXLE

• WHEEL ASSEMBLY - STEER AXLE

• WHEEL ASSEMBLY - DRIVE AXLE

• WHEEL ASSEMBLY - PUSHER AXLE

• WHEEL ASSEMBLY - TAG AXLE

• HUB & CUP ASSEMBLY - TAG OR PUSHER

WHEEL

TRANSFER CASE • SHIFT SHAFT - TRANSFER CASE

• MOUNTING HARDWARD – TRANSFER CASE

• WIRING HARNESS – TRANSFER CASE

• SKID PLATE – TRANSFER CASE

• TUBE – LUBE, OIL COOLER, TRANSFER CASE

• SPEED SENSOR - TRANSFER CASE

• TRANSFER CASE ASSEMBLY

SUPPLEMENTAL INFORMATION

DEVICES

• CPU - COLLISION AVOIDANCE SYSTEM

• CAMERA - COLLISION AVOIDANCE SYSTEM

• DISPLAY UNIT - DRIVER, COLLISION

AVOIDANCE SYSTEM

• SOFTWARE - COLLISION AVOIDANCE SYSTEM

• ASSET TRACKING ASSEMBLY – COMPLETE

• SURVEILLANCE SYSTEM

150915 – Truck Coverage 4 Page 9

• LANE DEPARTURE CAMERA

MODULES/RELAYS – ELECTRICAL • MODULE – BULKHEAD

• MODULE - CHASSIS

EXHAUST SYSTEM • MUFFLER

• PIPE ASSEMBLY – EXHAUST

• PIPE - STACK, EXHAUST

• TURBOCHARGER ASSEMBLY

• EXHAUST BRAKE AND RELATED COMPONENTS

• FILTER - DIESEL PARTICULATE, EXHAUST AFTER-

TREATMENT DEVICES

• EXCLUDES ENGINE COMPONENTS

DTNA CHASSIS ATS COMPONENTS • BELLOWS - CONNECTOR, AFTERTREATMENT

TO EGR

• PIPE - INTERMEDIATE, AFTERTREATMENT TO

EGR

• WIRING HARNESS - EXHAUST AFTER-

TREATMENT DEVICE

• DOSER VALVE ASSEMBLY

• INJECTOR - DOSER VALVE

• BELLOWS - EXHAUST PIPE, AFTER-TREATMENT

DEVICE

• SENSOR - PRESSURE, DIESEL OXIDATION

CATALYST (DOC)

• TANK - DIESEL EXHAUST FLUID

• SENSOR - PRESSURE, METERING DEVICE

• ENGINE CONTROL MODULE (ECM) - SELECTIVE

CATALYTIC REDUCTION

• AFTERTREATMENT CONTROL MODULE (ACM) -

SELECTIVE CATALYTIC REDUCTION

• NOZZLE - INJECTION, DIESEL EXHAUST FLUID

• WIRING HARNESS - AFTERTREATMENT

CONTROL MODULE TO METERING DEVICE

• 1-BOX

• ALL ATS COMPONENTS SUPPLIED BY ENGINE

MANUFACTURER

GENERAL ACCESSORIES • TACHOMETER ASSEMBLY – MECHANICAL

• HARDWARE, MOUNTING - COMPLETE

NAVIGATION SYSTEM ASSEMBLY, GPS

• HEAD - NAVIGATION SYSTEM, GPS

• MONITOR - CONTROL, DASH MOUNTED, GPS

• AIR PUMP ASSEMBLY - ON BOARD

150915 – Truck Coverage 4 Page 10

• WIRING - NAVIGATION SYSTEM, GPS

ELECTRICAL ACCESSORIES • RADIO

• SPEAKER ASSEMBLY – RADIO

• WIRING HARNESS – RADIO

• SPEAKER ASSEMBLY - RADIO

• INVERTER, POWER - AC TO DC; DC TO AC

• TELEVISION – ASSEMBLY

• REFRIGERATOR – ASSEMBLY

• RADAR DETECTOR ASSEMBLY

• ASSEMBLY - COMPLETE, CELL PHONE

HORNS & MOUNTINGS & REVERSE

SIGNAL ALARMS

• HORN ASSEMBLY – AIR

• HARDWARE, MOUNTING - HORN ASSEMBLY

• WIRING, HORN - STEERING COLUMN

• HORN ASSEMBLY – CITY

• COMPRESSOR - AIR HORN

• HORN – ELECTRIC

• ALARM - REVERSE SIGNAL

• HARDWARE, MOUNTING - REVERSE SIGNAL

ALARM

• SIREN ASSEMBLY

POWER TAKE-OFF • PTO ASSEMBLY – COMPLETE

• WIRING HARNESS - CONTROL, PTO

• LEVER - CONTROL, PTO

• BELT - HYDRAULIC PUMP DRIVE, PTO

• BELT - AUXILIARY DRIVE, PTO

• FILTER - BREATHER, PTO

*DTNA DOES NOT COVER COMPONENTS SUPPLIED BY THIRD PARTY AND COVERED BY MANUFACTURERS SUCH AS EATON, ALLISON, OR DT12 CLUTCH.

**THIS LIST IS INTENDED AS AN OVERVIEW ONLY AND SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE. ALL CLAIMS SUBJECT TO CLAIM CODE

RESTRICTIONS. IF YOU NEED CLARIFICATION, PLEASE CONTACT ASPHELP@DAIMLER.COM

mailto:asphelp@daimler.com