1-Crafco-Techcrete-Safety-Data-Sheet.pdf

SAFETY DATA SHEET

1. Identification

Crafco Techcrete ProductsProduct identifier

None.Other means of identification

Pavement PatchingRecommended use

None known.Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

Crafco, Inc.Manufacturer:

6165 West Detroit St.Address:

Chandler, AZ 85226 USA

Crafco Materials EngineeringContact Name:

602-276-0406Telephone:

sales@crafco.comE-mail:

800-424-9300 (North America)CHEMTREC:

+ 1-703-527-3887 (International)

2. Hazard(s) identification

Not classified.Physical hazards

Not classified.Health hazards

Not classified.Environmental hazards

Not classified.OSHA defined hazards

*Hazards not stated here are "Not classified", "Not applicable" or "Classification not possible".

Label elements

None.Hazard symbol

Signal word Not applicable.

Hazard statement Not applicable.

Precautionary statement

Prevention Not applicable.

Response Not applicable.

Storage Not applicable.

Disposal Not applicable.

Hazard(s) not otherwise classified (HNOC)

None known.

Supplemental information None.

3. Composition/information on ingredients

Mixtures

CAS number %Chemical name Common name and synonyms

68476-25-5FELDSPAR 20 - 40

471-34-1CALCIUM CARBONATE 5 - 15

64742-16-1PETROLEUM HYDROCARBON RESIN 5 - 15

14808-60-7QUARTZ 5 - 15

64742-52-5DISTILLATES (PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC

< 5

65997-15-1PORTLAND CEMENT < 2

1 / 7

Material name: Crafco Techcrete Products

5001 Version #: 04 Revision date: 05-08-2020 Issue date: 12-11-2014

SDS US

4. First-aid measures

If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing.

Oxygen or artificial respiration if needed. Induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. Get medical attention, if needed.

Inhalation

Remove contaminated clothing. Wash off with soap and plenty of water. Get medical attention if irritation develops and persists. Wash clothing separately before reuse.

Skin contact

Immediately flush eyes with plenty of water for at least 15 minutes. If a contact lens is present, DO NOT delay irrigation or attempt to remove the lens. Continue rinsing. Get medical attention if irritation develops and persists.

Eye contact

Rinse mouth thoroughly. Do not induce vomiting without advice from poison control center. If vomiting occurs, keep head low so that stomach content doesn't get into the lungs. Induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. Call a POISON CENTER or doctor/physician if you feel unwell.

Ingestion

Not available.Most important symptoms/effects, acute and delayed

Symptoms may be delayed.Indication of immediate medical attention and special treatment needed

If you feel unwell, seek medical advice (show the label where possible). Wash contaminated clothing before re-use.

General information

5. Fire-fighting measures

Water spray, foam, dry powder or carbon dioxide.Suitable extinguishing media

Straight Streams of WaterUnsuitable extinguishing media

Irritating and toxic gases or fumes may be released during a fire.Specific hazards arising from the chemical

Wear full protective clothing, including helmet, self-contained positive pressure or pressure demand breathing apparatus, protective clothing and face mask.

Special protective equipment and precautions for firefighters

Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA.

Fire fighting equipment/instructions

6. Accidental release measures

Avoid inhalation of vapor, fumes, dust and/or mist from the spilled material.Personal precautions, protective equipment and emergency procedures

Never return spills in original containers for re-use. Collect in marked containers and deliver to approved depot.

Methods and materials for containment and cleaning up

Do not contaminate water.Environmental precautions

7. Handling and storage

Do not get this material in contact with eyes. Do not get this material in contact with skin. Do not get this material on clothing. Do not use in areas without adequate ventilation. Avoid prolonged exposure. Wash thoroughly after handling.

Precautions for safe handling

Store in a well-ventilated place. Keep container tightly closed. Store in a closed container away from incompatible materials. Never allow product to get in contact with water during storage. Keep away from food, drink and animal feedingstuffs. Keep out of the reach of children. Use care in handling/storage.

Conditions for safe storage, including any incompatibilities

8. Exposure controls/personal protection

Occupational exposure limits

US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) FormValueComponents Type

PEL 5 mg/m3 Respirable fraction.CALCIUM CARBONATE (CAS 471-34-1)

15 mg/m3 Total dust.

2 / 7

Material name: Crafco Techcrete Products

US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) FormValueComponents Type

PEL 5 mg/m3 Mist.DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

PEL 5 mg/m3 Respirable fraction.PORTLAND CEMENT (CAS 65997-15-1)

15 mg/m3 Total dust.

PEL 0.05 mg/m3 Respirable dust.QUARTZ (CAS 14808-60-7)

US. OSHA Table Z-3 (29 CFR 1910.1000) FormValueComponents Type

TWA 50 mppcfPORTLAND CEMENT (CAS 65997-15-1)

TWA 0.1 mg/m3 Respirable.QUARTZ (CAS 14808-60-7)

2.4 mppcf Respirable.

US. ACGIH Threshold Limit Values FormValueComponents Type

TWA 5 mg/m3 Inhalable fraction.DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

TWA 1 mg/m3 Respirable fraction.PORTLAND CEMENT (CAS 65997-15-1)

TWA 0.025 mg/m3 Respirable fraction.QUARTZ (CAS 14808-60-7)

US. NIOSH: Pocket Guide to Chemical Hazards FormValueComponents Type

TWA 5 mg/m3 Respirable.CALCIUM CARBONATE (CAS 471-34-1)

10 mg/m3 Total

Ceiling 1800 mg/m3DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

STEL 10 mg/m3 Mist.

TWA 350 mg/m3

TWA 5 mg/m3 Respirable.PORTLAND CEMENT (CAS 65997-15-1)

10 mg/m3 Total

TWA 0.05 mg/m3 Respirable dust.QUARTZ (CAS 14808-60-7)

No biological exposure limits noted for the ingredient(s).Biological limit values

Provide adequate ventilation, including appropriate local extraction, to ensure that the defined occupational exposure limit is not exceeded.

Appropriate engineering controls

Individual protection measures, such as personal protective equipment

Wear safety glasses; chemical goggles (if splashing is possible).Eye/face protection

Skin protection

Chemical resistant gloves are recommended. If contact with forearms is likely wear gauntlet style gloves.

Hand protection

Do not get this material in contact with skin. Chemical resistant gloves.Other

3 / 7

Material name: Crafco Techcrete Products

When workers are facing concentrations above the exposure limit they must use appropriate certified respirators.

Respiratory protection

Not available.Thermal hazards

Do not get in eyes. When using, do not eat, drink or smoke. Avoid contact with eyes. Avoid contact with skin. Wash hands before breaks and immediately after handling the product. Keep away from food and drink. Handle in accordance with good industrial hygiene and safety practice.

General hygiene considerations

9. Physical and chemical properties

Granular.Appearance

Solid.Physical state

Solid.Form

Grey.Color

Not significant.Odor

Odor threshold Not available.

pH Not available.

Melting point/freezing point 225 °F (107.22 °C)

Initial boiling point and boiling range

Not determined

Flash point > 445.0 °F (> 229.4 °C)

Evaporation rate Not available.

Not available.Flammability (solid, gas)

Upper/lower flammability or explosive limits

Flammability limit - lower

Not available.

Flammability limit -upper (%)

Not available.

Explosive limit - lower

Not available.

Explosive limit - upper

Not available.

Vapor pressure < 1 mm Hg

Vapor density Not available.

Relative density Not available.

Solubility(ies)

Solubility (water) Insoluble

Partition coefficient (n-octanol/water)

Not available.

Auto-ignition temperature Not determined

Decomposition temperature Not available.

Viscosity Not available.

Other information

Specific gravity 1.7 - 2

10. Stability and reactivity

Not ReactiveReactivity

Stable under normal temperature conditions.Chemical stability

Not available.Possibility of hazardous reactions

Thermal decomposition or combustion may liberate carbon oxides and other toxic gases or vapors.Conditions to avoid

Oxidizing materials.Incompatible materials

Irritants. Toxic gas.Hazardous decomposition products

4 / 7

Material name: Crafco Techcrete Products

11. Toxicological information

Information on likely routes of exposure

Inhalation May cause irritation to the respiratory system.

Skin contact Causes mild skin irritation.

Eye contact May be irritating to eyes.

Ingestion May cause discomfort if swallowed.

Symptoms related to the physical, chemical and toxicological characteristics

Not available.

Information on toxicological effects

Acute toxicity Not classified.

Test ResultsComponents Species

CALCIUM CARBONATE (CAS 471-34-1)

Oral

Acute

* Estimates for product may be based on additional component data not shown.

LD50 Rat 6450 mg/kg

Not classified.Skin corrosion/irritation

Not classified.Serious eye damage/eye irritation

Respiratory or skin sensitization

Respiratory sensitization Not available.

Irritating to skin.Skin sensitization

No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic.

Germ cell mutagenicity

Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. This product contains crystalline silica. Silica is a known carcinogen; however in this encapsulated form the normal routes of exposure are unavailable.

IARC Monographs. Overall Evaluation of Carcinogenicity

DISTILLATES (PETROLEUM), HYDROTREATED HEAVY

NAPHTHENIC (CAS 64742-52-5)

3 Not classifiable as to carcinogenicity to humans.

QUARTZ (CAS 14808-60-7) 1 Carcinogenic to humans.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

QUARTZ (CAS 14808-60-7) Cancer

US. National Toxicology Program (NTP) Report on Carcinogens

QUARTZ (CAS 14808-60-7) Known To Be Human Carcinogen.

Contains no ingredient listed as toxic to reproductionReproductive toxicity

Specific target organ toxicity

- single exposure

Not available.

Specific target organ toxicity

- repeated exposure

Not available.

Aspiration hazard Not available.

Chronic effects Crystalline silica, as respirable dust particles, has caused pulmonary fibrosis in laboratory animals and humans.

12. Ecological information

Not expected to be harmful to aquatic organisms.Ecotoxicity

5 / 7

Material name: Crafco Techcrete Products

Components Test ResultsSpecies

* Estimates for product may be based on additional component data not shown.

CALCIUM CARBONATE (CAS 471-34-1)

Aquatic

LC50Fish > 56000 mg/l, 96 hoursWestern mosquitofish (Gambusia affinis)

Not available.Persistence and degradability

Not available.Bioaccumulative potential

Not available.Mobility in soil

Other adverse effects Not available.

13. Disposal considerations

Dispose of contents/container in accordance with local/regional/national/international regulations.

When this product as supplied is to be discarded as waste, it does not meet the definition of a RCRA waste under 40 CFR 261.

Disposal instructions

Not applicable.Hazardous waste code

Dispose of in accordance with local regulations.Waste from residues / unused products

Offer rinsed packaging material to local recycling facilities.Contaminated packaging

14. Transport information

DOT

Not regulated as dangerous goods.

IATA

Not regulated as dangerous goods.

IMDG

Not regulated as dangerous goods.

Not available.Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code

15. Regulatory information

CERCLA/SARA Hazardous Substances - Not applicable.US federal regulations

TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)

Not regulated.

CERCLA Hazardous Substance List (40 CFR 302.4)

Not listed.

SARA 304 Emergency release notification

Not regulated.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

QUARTZ (CAS 14808-60-7) Cancer lung effects immune system effects kidney effects

SARA 302 Extremely hazardous substance

Superfund Amendments and Reauthorization Act of 1986 (SARA)

Not listed.

NoSARA 311/312 Hazardous chemical

SARA 313 (TRI reporting)

Not regulated.

Other federal regulations

Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List

Not regulated.

6 / 7

Material name: Crafco Techcrete Products

Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)

Not regulated.

Not regulated.Safe Drinking Water Act

(SDWA)

WARNING: This product contains a chemical known to the State of California to cause cancer.US state regulations

California Proposition 65

US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3, subd. (a))

QUARTZ (CAS 14808-60-7)

International Inventories

Country(s) or region Inventory name On inventory (yes/no)*

YesAustralia Australian Inventory of Chemical Substances (AICS)

YesCanada Domestic Substances List (DSL)

NoCanada Non-Domestic Substances List (NDSL)

YesChina Inventory of Existing Chemical Substances in China (IECSC)

YesEurope European Inventory of Existing Commercial Chemical Substances

(EINECS)

NoEurope European List of Notified Chemical Substances (ELINCS)

YesJapan Inventory of Existing and New Chemical Substances (ENCS)

NoKorea Existing Chemicals List (ECL)

NoNew Zealand New Zealand Inventory

NoPhilippines Philippine Inventory of Chemicals and Chemical Substances

(PICCS)

NoTaiwan Taiwan Chemical Substance Inventory (TCSI)

YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory

*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s).

16. Other information, including date of preparation or last revision

12-11-2014Issue date

05-08-2020Revision date

Version # 04

HMIS® is a registered trade and service mark of the NPCA.Further information

Health: 1 Flammability: 0 Instability: 0

NFPA ratings

ACGIH

EPA: AQUIRE database NLM: Hazardous Substances Data Base US. IARC Monographs on Occupational Exposures to Chemical Agents IARC Monographs. Overall Evaluation of Carcinogenicity National Toxicology Program (NTP) Report on Carcinogens ACGIH Documentation of the Threshold Limit Values and Biological Exposure Indices

References

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.

Disclaimer

Physical & Chemical Properties: Multiple Properties GHS: Classification

Revision information

7 / 7

Material name: Crafco Techcrete Products