2-Item_2_Chassis_Specs_International_HV507_SFA_6x4.pdf

Prepared For: Presented By:

State of Ohio - Dept. of Transportation Doug Burke 1620 W Broad St.

Columbus, OH 43223-1202 (614)644 - 7870 Reference ID: Item 2 Base

RUSH TRUCK CENTERS

Ron Huckery

11775 HIGHWAY DRIVE

CINCINNATI OH 45241 -

(513)372-8800

Thank you for the opportunity to provide you with the following quotation on a new International truck. I am sure the following detailed specification will meet your operational requirements, and I look forward to serving your ODOT fleet needs.

Model Profile

2026 HV507 SFA (HV507)

AXLE CONFIG: 6X4

MISSION: Requested GVWR: 66000. Calc. GVWR: 66000. Calc. GCWR: 80000

Calc. Geared Speed: 71.4 MPH DIMENSION: Wheelbase: 217.00, CA: 142.00, Axle to Frame: 96.00 ENGINE, DIESEL: {Cummins L9 370} EPA 2024, 370HP @ 2100 RPM, 1250 lb-ft Torque @ 1200 RPM, 2100 RPM

Governed Speed, 370 Peak HP (Max) TRANSMISSION, AUTOMATIC: {Allison 3000 RDS} 6th Generation Controls, Close Ratio, 6-Speed with Double Overdrive, with

PTO Provision, Less Retarder, Includes Oil Level Sensor, with 80,000-lb GVW and GCW Max, On/Off Highway

CLUTCH: Omit Item (Clutch & Control) AXLE, FRONT NON-DRIVING: {Meritor MFS-20-133A} Wide Track, I-Beam Type, 20,000-lb Capacity AXLE, REAR, TANDEM: {Meritor RT-46-160} Single Reduction, 46,000-lb Capacity, 200 Wheel Ends Gear Ratio: 5.63 CAB: Conventional, Day Cab TIRE, FRONT: (2) 315/80R22.5 Load Range L XZU-S2 (MICHELIN), 488 rev/mile, 65 MPH, All-Position TIRE, REAR: (8) 12R22.5 Load Range H G622 RSD (GOODYEAR), 482 rev/mile, 75 MPH, Drive SUSPENSION, REAR, TANDEM: {Hendrickson RT-463} Walking Beam, 46,000-lb Capacity, 54" Axle Spacing, Multileaf Springs, with Bronze Center Bushings PAINT: Cab schematic 100WK

Location 1: 9219, Winter White (Std) Chassis schematic N/A

July 15, 2025

1 Proposal: 25757-01

Code Description HV50700 Base Chassis, Model HV507 SFA with 217.00 Wheelbase, 142.00 CA, and 96.00 Axle to Frame.

1AND AXLE CONFIGURATION 6x4

1CAJ FRAME RAILS Heat Treated Alloy Steel (120,000 PSI Yield); 10.866" x 3.622" x 0.437" (276.0mm x 92.0mm x 11.1mm); 456.0" (11582mm) Maximum OAL

1LLK BUMPER, FRONT Omit Item

1LPN SPECIAL FRAME PIERCING Additional Holes for State of Ohio, Gledhill Snow Plow Hitch

1MEJ FRAME DIMPLE Dimple on Left and Right Top Flange of Frame Rail to Reference Rear Axle Centerline

1WBC CROSSMEMBER, SUSPENSION (1) 7-Piece Steel in lieu of (1) Double Dogbone, Forward

1WGB WHEELBASE RANGE 177" (450cm) Through and Including 226" (575cm)

1WMA CROSSMEMBER, INTERMEDIATE (1) 5-Piece in lieu of Each Single Dogbone with 4x2 & 4x4 Chassis; Each Double Dogbone with 6x4, 6x6 & 8x6 Tridem Chassis

2ARY AXLE, FRONT NON-DRIVING {Meritor MFS-20-133A} Wide Track, I-Beam Type, 20,000-lb Capacity

3708 SHOCK ABSORBERS, FRONT

3ACS SUSPENSION, FRONT, SPRING Multileaf, Shackle Type, 20,000-lb Capacity, Less Shock Absorbers

4091 BRAKE SYSTEM, AIR Dual System for Straight Truck Applications

4619 TRAILER CONNECTIONS Four-Wheel, with Hand Control Valve and Tractor Protection Valve, for Straight Truck

4677 TRAILER HOSES Glad Hands for Four-Wheel Connections, Temporarily Mounted with Bulkhead Connectors on End of Frame, Includes Additional Hosing and Dummy Glad Hands

4722 DRAIN VALVE {Bendix DV-2} Automatic, with Heater, for Air Tank

4AZJ AIR BRAKE ABS {Bendix AntiLock Brake System} 4-Channel (4 Sensor/4 Modulator) Full Vehicle Wheel Control System, with Automatic Traction Control

4EBS AIR DRYER {Bendix AD-9} with Heater

4GBM BRAKE, PARKING Manual Push-Pull Pneumatic Parking Brake

4SPA AIR COMPRESSOR {Cummins} 18.7 CFM

4VGN AIR TANK Painted Aluminum, with Straight Thread O-Ring Ports

4VJJ AIR TANK LOCATION (3) : One Mounted Inside Right Rail, Back of Cab, Two Mounted Between Rails, Back of Cab

4VKC AIR DRYER LOCATION Mounted Inside Left Rail, Back of Cab

4WJM DUST SHIELDS, FRONT BRAKE Pad and Rotor, with Air Disc Brakes

4WJN DUST SHIELDS, REAR BRAKE Pad and Rotor, with Air Disc Brakes

4XCJ BRAKES, FRONT {Bendix Spicer ADB22X} Air Disc Type, Extended Service, Size 22.5", 23,000-lb Capacity

4XCK BRAKES, REAR {Bendix Spicer ADB22X} Air Disc Type, Extended Service, Size 22.5", 26,000-lb Capacity per Axle

4XDX BRAKE CHAMBERS, FRONT AXLE 20 SqIn, for Air Disc Brakes

4XEA BRAKE CHAMBERS, REAR AXLE 18/24 SqIn Spring Brake, Double Diaphragm, for Air Disc Brakes

4XEE PARK BRAKE CHAMBERS,ADDITIONAL (2) Spring Brake Type

5708 STEERING COLUMN Tilting

Vehicle Specifications July 15, 2025

2026 HV507 SFA (HV507)

2 Proposal: 25757-01

5CAW STEERING WHEEL 4-Spoke; 18" Dia., Black

5PTB STEERING GEAR (2) {Sheppard M100/M80} Dual Power

6DGT DRIVELINE SYSTEM {Dana Spicer} SPL170 Main Driveline with SPL170 Interaxle Shaft, for 6x4

7BEV AFTERTREATMENT COVER Steel, Black

7BLW EXHAUST SYSTEM Horizontal Aftertreatment System, Frame Mounted Right Side Under Cab, for Single Vertical Tail Pipe, Frame Mounted Right Side Back of Cab

7SDP ENGINE COMPRESSION BRAKE {Jacobs} for Cummins ISL/L9 Engines; with Selector Switch and On/Off Switch

7WAZ TAIL PIPE (1) Turnback Type

7WDM EXHAUST HEIGHT 10'

7WDN MUFFLER/TAIL PIPE GUARD (1) Aluminum

8000 ELECTRICAL SYSTEM 12-Volt, Standard Equipment

8GXE ALTERNATOR {Leece-Neville AVI160P2012} Brush Type, 12 Volt, 190 Amp Capacity, Pad Mount, with Remote Sense

8HAB BODY BUILDER WIRING Back of Day Cab at Left Frame or Under Sleeper, Extended or Crew Cab at Left Frame; Includes Sealed Connectors for Tail/Amber Turn/Marker/ Backup/Accessory Power/Ground and Sealed Connector for Stop/Turn

8HAH ELECTRIC TRAILER BRAKE/LIGHTS Accommodation Package to Rear of Frame; for Combined Trailer Stop, Tail, Turn, Marker Light Circuits; Includes Electric Trailer Brake Accommodation Package with Cab Connections for Mounting Customer Installed Electric Brake Unit, Less Trailer Socket

8MSG BATTERY SYSTEM {Fleetrite} Maintenance-Free, (3) 12-Volt 1980CCA Total, Top Threaded Stud

8RMZ SPEAKERS (2) 6.5" Dual Cone Mounted in Both Doors, (2) 5.25" Dual Cone Mounted in Both B-Pillars

8RPP ANTENNA Shark Fin, Roof Mounted

8RPS RADIO AM/FM/WB/Clock/Bluetooth/USB Input/Auxiliary Input

8THJ AUXILIARY HARNESS 3.0' for Auxiliary Front Head Lights and Turn Signals for Front Plow Applications

8TKK TRAILER AUXILIARY FEED CIRCUIT for Electric Trailer Brake Accommodation/Air Trailer ABS; with 30 Amp Fuse and Relay, Controlled by Ignition Switch

8VAY HORN, ELECTRIC Disc Style

8VUL BATTERY BOX Steel, with Plastic Cover, 18" Wide, 2-4 Battery Capacity, Mounted Left Side Back of Cab

8WCK POWER SOURCE, TERMINAL TYPE 2-Post

8WPH CLEARANCE/MARKER LIGHTS (5) {Truck Lite} Amber LED Lights, Flush Mounted on Cab or Sunshade

8WWJ INDICATOR, LOW COOLANT LEVEL with Audible Alarm

8WXG STARTING MOTOR {Mitsubishi Electric Automotive America 105P} 12-Volt, with Soft-Start

8XAH CIRCUIT BREAKERS Manual-Reset (Main Panel) SAE Type III with Trip Indicators, Replaces All Fuses

8XGT TURN SIGNALS, FRONT Includes LED Side Turn Lights Mounted on Fender

8XHN HORN, AIR Single Trumpet, Black, with Lanyard Pull Cord

8XNY HEADLIGHTS Halogen

8XPC ACCESSORY WIRING, SPECIAL for Body Builder Feeds & Road Speed Wire Coiled Behind Driver Seat for Customer Use, Includes 15 & 5 Amp Ignition, (2) 20 Amp Battery, (2) Ground and Road Speed

Vehicle Specifications July 15, 2025

3 Proposal: 25757-01

9585 FENDER EXTENSIONS Rubber

9AAB LOGOS EXTERIOR Model Badges

9AAE LOGOS EXTERIOR, ENGINE Badges

9HAN INSULATION, UNDER HOOD for Sound Abatement

9HAT GRILLE Stationary, Painted Grille & Headlight Bezels 8752 Charcoal Metallic

9HBN INSULATION, SPLASH PANELS for Sound Abatement

9WAC BUG SCREEN Mounted Behind Grille

9WBC FRONT END Tilting, Fiberglass, with Three Piece Construction, for WorkStar/HV

10060 PAINT SCHEMATIC, PT-1 Single Color, Design 100

10761 PAINT TYPE Base Coat/Clear Coat, 1-2 Tone

10AGB COMMUNICATIONS MODULE Telematics Device with Over the Air Programming; Includes Five Year Data Plan and International 360

10BAE LABEL, DEF "DEF ONLY"

10SLV PROMOTIONAL PACKAGE Government Silver Package

10UAV VEHICLE REGISTRATION IDENTITY ID for Non-CARB Omnibus and/or Non-ACT Adopting State or Exempt Vehicle. Not for use on vehicles registering in CA/MA /OR/NJ/NY/WA. Contains non-mitigated legacy engine & cannot be registered in CA unless exempt. You may be held liable under state law for failure to properly register vehicle.

10WBS KEYS - ALL ALIKE, ADDITIONAL 2 Keys

10WKN KEYS - ALL ALIKE, ID I-1624 Compatible with Z-250

11001 CLUTCH Omit Item (Clutch & Control)

12703 ANTI-FREEZE Red, Extended Life Coolant; To -40 Degrees F/ -40 Degrees C, Freeze Protection

12849 BLOCK HEATER, ENGINE 120V/1000W, for Cummins ISB/B6.7/ISL/L9 Engines

12851 PTO EFFECTS, ENGINE FRONT Less PTO Unit, Includes Adapter Plate on Engine Front Mounted

12EZA ENGINE, DIESEL {Cummins L9 370} EPA 2024, 370HP @ 2100 RPM, 1250 lb-ft Torque @ 1200 RPM, 2100 RPM Governed Speed, 370 Peak HP (Max)

12THT FAN DRIVE {Horton Drivemaster} Two-Speed Type, Direct Drive, with Residual Torque Device for Disengaged Fan Speed

12UWZ RADIATOR Aluminum, Cross Flow, Front to Back System, 1228 SqIn, with 1167 SqIn Charge Air Cooler, Includes In-Tank Oil Cooler

12VAG AIR CLEANER Single Element, with Integral Snow Valve and In-Cab Control

12VKC EMISSION, CALENDAR YEAR {Cummins L9} EPA, OBD and GHG Certified for Calendar Year 2025

12VXT THROTTLE, HAND CONTROL Engine Speed Control; Electronic, Stationary, Variable Speed; Mounted on Steering Wheel

12VYP ENGINE CONTROL, REMOTE MOUNTED No Provision for Remote Mounted Engine Control

12WCG HOSE CLAMPS, RADIATOR HOSES {R.G. Ray Mini Flex Seal} Coil Spring/"T"-Bolt Constant Torque Type, for Radiator Hoses over 1" I.D.

12WVG EPA IDLE COMPLIANCE Low NOx Idle Engine, Complies with EPA Clean Air Regulations; Includes "Certified Clean Idle" Decal on Hood

Vehicle Specifications July 15, 2025

4 Proposal: 25757-01

12WZE CARB IDLE COMPLIANCE Does Not Comply with California Clean Air Idle Regulations

12XCS CARB EMISSION WARR COMPLIANCE Does Not Comply with CARB Emission Warranty

13BCS TRANSMISSION, AUTOMATIC {Allison 3000 RDS} 6th Generation Controls, Close Ratio, 6-Speed with Double Overdrive, with PTO Provision, Less Retarder, Includes Oil Level Sensor, with 80,000-lb GVW and GCW Max, On/Off Highway

13WET TRANSMISSION SHIFT CONTROL Column Mounted Stalk Shifter, Not for Use with Allison 1000 & 2000 Series Transmission

13WGK TRANSMISSION COOLER HOSES Stainless Steel

13WLP TRANSMISSION OIL Synthetic; 29 thru 42 Pints

13WUC ALLISON SPARE INPUT/OUTPUT for Rugged Duty Series (RDS) and Regional Haul Series (RHS), General Purpose Trucks, Construction, Package Number 223

13WVV NEUTRAL AT STOP Allison Transmission Shifts to Neutral When Service Brake is Depressed and Vehicle is at Stop; Remains in Neutral Until Service Brake is Released

13WYH TRANSMISSION TCM LOCATION Located Inside Cab

13WYU SHIFT CONTROL PARAMETERS {Allison} 3000 or 4000 Series Transmissions, Performance Programming

13XAN PTO LOCATION Customer Does Not Intend to Install PTO

14GRD AXLE, REAR, TANDEM {Meritor RT-46-160} Single Reduction, 46,000-lb Capacity, 200 Wheel Ends . Gear Ratio: 5.63

14UHK SUSPENSION, REAR, TANDEM {Hendrickson RT-463} Walking Beam, 46,000-lb Capacity, 54" Axle Spacing, Multileaf Springs, with Bronze Center Bushings

14WZY AXLE SHAFT MODIFICATION Axle Shaft Flanges Modified for 0.625" Diameter Drive Studs with Solid Type Cone-Locks

15924 FUEL TANK STRAPS Bright Finish Stainless Steel

15LNS FUEL/WATER SEPARATOR {Racor 400 Series} 12 VDC Electric Heater, Includes Pre-Heater, with Primer Pump, Includes Water-in-Fuel Sensor, Mounted on Engine

15SWE FUEL TANK Top Draw, Non-Polished Aluminum, 26" Dia, 70 US Gal (265L), Mounted Left Side, Under Cab

15WDG DEF TANK 7 US Gal (26L) Capacity, Frame Mounted Outside Left Rail, Under Cab

16030 CAB Conventional, Day Cab

16564 HEATER SHUT-OFF VALVES (1) Ball Valve Type, Supply Line

16ATC AUTOMATIC CLIMATE CONTROL Automatically Maintains Cabin Comfort Based on Selected Temperature

16BAM AIR CONDITIONER with Integral Heater and Defroster

16GED GAUGE CLUSTER Base Level; English with English Electronic Speedometer

16HCS GAUGE, TEMPERATURE, AMBIENT Sensor Wiring with Display Unit Mounted in Cluster

16HGH GAUGE, OIL TEMP, AUTO TRANS for Allison Transmission

16HHE GAUGE, AIR CLEANER RESTRICTION {Filter-Minder} Mounted in Instrument Panel

16HKT IP CLUSTER DISPLAY On Board Diagnostics Display of Fault Codes in Gauge Cluster

16KDB SEAT, PASSENGER {National 2000 195} Air Suspension, High Back with Integral Headrest, Vinyl, Isolator, 8" Adjuster, 1 Chamber Lumbar, 2 Position Front Cushion Adjust, 6-23 Degree Back Angle Adjust

16KZW SEAT, DRIVER {National 2000 195} Air Suspension, High Back with Integral Headrest, Vinyl, Isolator, 8" Adjuster, 1 Chamber Lumbar, 2 Position Front Cushion Adjust, 6-23 Degree Angle Back Adjust

Vehicle Specifications July 15, 2025

5 Proposal: 25757-01

16SGH GRAB HANDLE, EXTERIOR (2) Chrome, for Cab Entry, (1) Towel Bar Type, with Anti-Slip Rubber Inserts

Mounted Left Side at B-Pillar, (1) Towel Bar Type Mounted Right Side on Vertical Exhaust

16SJW MIRROR, CONVEX, HOOD MOUNTED {Lang Mekra} (2) Right and Left Sides, Black, Heated, 7.5" Sq.

16SNP MIRRORS (2) C-Loop, Power Adjust, Heated, Black Heads and Arms, 7.5" x 14" Flat Glass, Includes 7.5" x 7" Convex Mirrors, for 102" Load Width

16VKB CAB INTERIOR TRIM Classic, for Day Cab

16VLV MONITOR, TIRE PRESSURE Omit

16VSL WINDSHIELD Heated, Single Piece

16WBY ARM REST, RIGHT, DRIVER SEAT

16WBZ ARM REST, LEFT, PASSENGER SEAT

16WEE CAB SOUND INSULATION Includes Dash Insulator and Engine Cover Insulator

16WHJ HOSE CLAMPS, HEATER HOSE {Breeze} Belleville Washer Type

16WJU WINDOW, POWER (2) and Power Door Locks, Left and Right Doors, Includes Express Down Feature

16WLS FRESH AIR FILTER Attached to Air Intake Cover on Cowl Tray in Front of Windshield Under Hood

16WSK CAB REAR SUSPENSION Air Bag Type

16XCW CAB, INTERIOR TRIM, CLOSEOUT Under IP, Driver Side

16XDS TELEMATICS BRACKET with Universal Mount, 1" Ball Mount Size, for Customer Supplied Telematics Device, Mounted in Auxiliary Gauge Location in Flat Panel, Includes (1) APO, (1) USB-A Port, (1) USB-C Port

16XJN INSTRUMENT PANEL Flat Panel

16XTK ACCESS, CAB Bright Aluminum, Driver & Passenger Sides, Two Steps per Door, for use with Day Cab or Extended Cab

16XWJ WINDSHIELD WIPER BLADES Winter Type

16XWY WINDSHIELD WASHER RESERVOIR Mounted Under Cab with Remote Fill Mounted Behind Cab Drivers Side

16XXC COWL TRAY LID

27DUS WHEELS, FRONT {Accuride 41730} DISC; 22.5x9.00 Rims, Extra Polish Aluminum, 10-Stud, 285.75mm BC, Hub-Piloted, Flanged Nut, with Steel Hubs

28DUS WHEELS, REAR {Accuride 41730} DUAL DISC; 22.5x9.00 Rims, Extra Polish Aluminum, 10-Stud, 285.75mm BC, Hub-Piloted, Flanged Nut, with Steel Hubs

29WAP WHEEL GUARDS, FRONT {Accuride} for Metric Hub Piloted Wheels with Flanged Mounting Nuts Mounted Between Hub and Wheel

60AAH BDY INTG, REMOTE POWER MODULE (2) Mounted Inside Cab Behind Driver Seat, Up to 6 Outputs & 6 Inputs Each, Max 20 amp per Channel, Max 80 amp Total; Includes 2 Switch Packs with Latched Switches

7382158102 (8) TIRE, REAR 12R22.5 Load Range H G622 RSD (GOODYEAR), 482 rev/mile, 75 MPH, Drive

7682543212 (2) TIRE, FRONT 315/80R22.5 Load Range L XZU-S2 (MICHELIN), 488 rev/mile, 65 MPH, All-Position

Cab schematic 100WK

Location 1: 9219, Winter White (Std)

Chassis schematic N/A

Vehicle Specifications July 15, 2025

6 Proposal: 25757-01

Services Section:

40128 WARRANTY Standard for HV507/HV509, HV50B, HV607/HV609 Models, Effective with Vehicles Built July 1, 2017 or Later, CTS-2025A

40YAP SRV CONTRACT, EXT VEH COVERAGE To 60-Month/100,000 Miles (160,000 km), Excludes Extended Warranty for Engine and Transmission

40YYX SRV CONT, EXT CUMMINS ENGINE To 60-Month/100,000 Miles (160,000 km), Extended Cummins L9 Engine Coverage, Protection Plan 1

Vehicle Specifications July 15, 2025

7 Proposal: 25757-01

GVWR Component Rating(s)

Ratings Primary Adjusted By

GAWR* GVWR**

ATA Class Feature Rating

(lbf) ATA Class Feature Rating

(lbf) (lbf) (lbf)

Front Component Ratings AXLE, FRONT NON-

DRIVING

0002ARY 20000

BRAKES, FRONT 0004XCJ 23000

SUSPENSION,

FRONT, SPRING

0003ACS 20000

WHEELS, FRONT 0027DUS 20000 TIRE, FRONT 0768254 20000

Front GAWR 20000 Rear Component Ratings BRAKES, REAR 0004XCK 52000

BRAKE SYSTEM,

AIR

0004091 46000 BRAKES, REAR 0004XCK 52000

SUSPENSION,

REAR, TANDEM

0014UHK 46000

WHEELS, REAR 0028DUS 72720 TIRE, REAR 0738215 54240

AXLE, REAR,

TANDEM

0014GRD 46000

Rear GAWR 46000 Overall Vehicle Limitations TRANSMISSION, AUTOMATIC

0013BCS 80000

GVWR Based on Axle Ratings***

66000

Calculated GVWR 66000

GCWR Component Rating(s)

Ratings Primary Adjusted By

GCWR****

ATA Class Feature Rating

(lbf) ATA Class Feature Rating

(lbf) (lbf)

GCWR Component Rating AXLE, REAR, TANDEM

0014GRD 160000

TRANSMISSION,

AUTOMATIC

0013BCS 80000

ENGINE, DIESEL 0012EZA 80000

Calculated GCWR 80000

* GAWR (Gross Axle Weight Rating) is the rating capacity of an axle system which include wheels, tires, axles, brakes, springs, and suspensions.

** GVWR (Gross Vehicle Weight Rating) is the maximum amount that a loaded vehicle can weight.

*** GVWR Based on Axle Ratings = Front GAWR + Rear GAWR. Overall vehicle weight limitations are not taken into account.

**** GCWR (Gross Combined Weight Rating) is the maximum weight of a tractor and trailer.

Ratings July 15, 2025

8 Proposal: 25757-01