Crafco-Roadsaver-Polyflex-Safety-Data-Sheet.pdf

SAFETY DATA SHEET

1. Identification

Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

Product identifier

None.Other means of identification

Pavement Crack and Joint Sealing and PreservationRecommended use

None known.Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

Crafco, Inc.Manufacturer:

6165 West Detroit St.Address:

Chandler, AZ 85226 USA

Crafco Materials EngineeringContact Name:

602-276-0406Telephone:

sales@crafco.comE-mail:

800-424-9300 (North America)CHEMTREC:

+ 1-703-527-3887 (International)

2. Hazard(s) identification

Not classified.Physical hazards

Not classified.Health hazards

Not classified.Environmental hazards

Not classified.OSHA defined hazards

*Hazards not stated here are "Not classified", "Not applicable" or "Classification not possible".

Label elements

None.Hazard symbol

Signal word Not applicable.

Hazard statement Not applicable.

Precautionary statement

Prevention Not applicable.

Response Not applicable.

Storage Not applicable.

Disposal Not applicable.

Hazard(s) not otherwise classified (HNOC)

None known.

Supplemental information None.

3. Composition/information on ingredients

Mixtures

CAS number %Chemical name Common name and synonyms

8052-42-4ASPHALT 20 - 100

49.39Other components below reportable levels

64742-52-5DISTILLATES (PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC

0 - 40

4. First-aid measures

If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing.

Get medical attention, if needed. Call a physician if symptoms develop or persist.

Inhalation

1 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

4988 Version #: 03 Revision date: 05-15-2020 Issue date: 06-24-2019

SDS US

In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Thoroughly wash (or discard) clothing and shoes before reuse.

Skin contact

Immediately flush eyes with plenty of water for at least 15 minutes. If a contact lens is present, DO NOT delay irrigation or attempt to remove the lens. Get medical attention if irritation develops and persists.

Eye contact

Rinse mouth. Do not induce vomiting. Do not use mouth-to-mouth method if victim ingested the substance. Call a POISON CENTER or doctor/physician if you feel unwell.

Ingestion

Not available.Most important symptoms/effects, acute and delayed

In case of ingestion, the decision of whether or not to induce vomiting should be made by the attending physician. Certain pre-existing conditions may make workers particularly susceptible to the effects of this chemical: asthma, allergies, impaired pulmonary function.

Indication of immediate medical attention and special treatment needed

If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Discard any shoes or clothing items that cannot be decontaminated.

General information

5. Fire-fighting measures

Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2). Addition of water or foam to the fire may cause frothing.

Suitable extinguishing media

Do not use a solid water stream as it may scatter and spread fire.Unsuitable extinguishing media

Fire may produce irritating, corrosive and/or toxic gases. Development of hazardous combustion gases or vapours possible in the event of a fire. The following may develop: Acrolein.

Specific hazards arising from the chemical

Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. Firefighters should wear full protective clothing including self contained breathing apparatus. Structural firefighters protective clothing will only provide limited protection.

Special protective equipment and precautions for firefighters

In case of fire and/or explosion do not breathe fumes. Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA. ALWAYS stay away from tanks engulfed in flame. Fight fire from maximum distance or use unmanned hose holders or monitor nozzles. In the event of fire, cool tanks with water spray. By fire, toxic gases may be formed (COx, NOx). Keep run-off water out of sewers and water sources. Dike for water control.

Fire fighting equipment/instructions

In the event of fire and/or explosion do not breathe fumes. In the event of fire, cool tanks with water spray. Use water spray to cool unopened containers.

Specific methods

6. Accidental release measures

Keep unnecessary personnel away. Wear appropriate protective equipment and clothing during clean-up. Ventilate closed spaces before entering them. Do not touch or walk through spilled material.

Personal precautions, protective equipment and emergency procedures

ELIMINATE all ignition sources (no smoking, flares, sparks or flames in immediate area). Dike far ahead of spill for later disposal. Following product recovery, flush area with water.

Never return spills in original containers for re-use.

Methods and materials for containment and cleaning up

Prevent further leakage or spillage if safe to do so. Runoff or release to sewer, waterway or ground is forbidden.

Environmental precautions

7. Handling and storage

The product is non-combustible. If heated, irritating vapors may be formed. Do not use in areas without adequate ventilation. Wash hands thoroughly after handling. Wash hands after handling.

Observe good industrial hygiene practices.

Precautions for safe handling

Prevent electrostatic charge build-up by using common bonding and grounding techniques. Store in a well-ventilated place. Keep the container tightly closed and dry. Store in a closed container away from incompatible materials. Keep out of the reach of children.

Conditions for safe storage, including any incompatibilities

2 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

8. Exposure controls/personal protection

Occupational exposure limits

US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) FormValueComponents Type

PEL 5 mg/m3 Mist.DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

US. ACGIH Threshold Limit Values FormValueComponents Type

TWA 0.5 mg/m3 Inhalable fume.ASPHALT (CAS 8052-42-4)

TWA 5 mg/m3 Inhalable fraction.DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

US. NIOSH: Pocket Guide to Chemical Hazards FormValueComponents Type

Ceiling 5 mg/m3 Fume.ASPHALT (CAS 8052-42-4)

Ceiling 1800 mg/m3DISTILLATES

(PETROLEUM),

HYDROTREATED HEAVY

NAPHTHENIC (CAS

64742-52-5)

STEL 10 mg/m3 Mist.

TWA 350 mg/m3

No biological exposure limits noted for the ingredient(s).Biological limit values

Provide adequate ventilation, including appropriate local extraction, to ensure that the defined occupational exposure limit is not exceeded.

Appropriate engineering controls

Individual protection measures, such as personal protective equipment

Wear safety glasses; chemical goggles (if splashing is possible). Wear chemical goggles; face shield (if handling molten material).

Eye/face protection

Skin protection

Chemical resistant gloves are recommended. If contact with forearms is likely wear gauntlet style gloves.

Hand protection

Wear suitable protective clothing and eye/face protection. Use of an impervious apron is recommended.

Other

If airborne concentrations are above the applicable exposure limits, use NIOSH approved respiratory protection.

Respiratory protection

During product use, there is a risk of thermal burns.Thermal hazards

When using do not smoke. Avoid contact with eyes. Avoid contact with skin. Keep away from food and drink. Handle in accordance with good industrial hygiene and safety practice.

General hygiene considerations

9. Physical and chemical properties

Solid.Appearance

Solid.Physical state

Solid.Form

Black. Dark brownColor

Product is a black, semi-solid with a burnt tar odor.Odor

Odor threshold Not available.

pH Not available.

Melting point/freezing point 150 - 250 °F (65.56 - 121.11 °C) ASTM D36 Softening Point

3 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

Initial boiling point and boiling range

> 800 °F (> 426.67 °C)

Flash point > 400.0 °F (> 204.4 °C)

Evaporation rate Not available.

Not available.Flammability (solid, gas)

Upper/lower flammability or explosive limits

Flammability limit - lower

Not available.

Flammability limit -upper (%)

Not available.

Explosive limit - lower

Not available.

Explosive limit - upper

Not available.

Vapor pressure Not available.

Vapor density Not available.

Relative density Not available.

Solubility(ies)

Solubility (water) Not available.

Partition coefficient (n-octanol/water)

Not available.

Auto-ignition temperature > 700 °F (> 371.11 °C)

Decomposition temperature Not available.

Viscosity Not available.

Other information

Density Not Available

Percent volatile 0 %

Specific gravity 1 - 1.9

10. Stability and reactivity

Not ReactiveReactivity

Material is stable under normal conditions.Chemical stability

Hazardous polymerization does not occur.Possibility of hazardous reactions

Strong oxidizing agents.Conditions to avoid

Incompatible with oxidizing agents.Incompatible materials

Upon decomposition, product emits acrid dense smoke with carbon dioxide, carbon monoxide, trace oxides of nitrogen and sulfur, and water.

Hazardous decomposition products

11. Toxicological information

Information on likely routes of exposure

Inhalation May be harmful if inhaled. However, this product does not currently meet the criteria for classification.

Skin contact Frequent or prolonged contact may defat and dry the skin, leading to discomfort and dermatitis.

Eye contact May be irritating to eyes.

Ingestion May cause gastrointestinal discomfort if swallowed. Do not induce vomiting. Vomiting may increase risk of product aspiration.

Symptoms related to the physical, chemical and toxicological characteristics

Not available.

Information on toxicological effects

Acute toxicity Not classified.

Not classified. May cause defatting of the skin, but is neither an irritant nor a sensitizer.Skin corrosion/irritation

4 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

Not classified.Serious eye damage/eye irritation

Respiratory or skin sensitization

Respiratory sensitization Not classified.

Not classified.Skin sensitization

Non-mutagenic based on Modified Ames Assay.Germ cell mutagenicity

Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.

IARC Monographs. Overall Evaluation of Carcinogenicity

Not listed.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

Not regulated.

US. National Toxicology Program (NTP) Report on Carcinogens

Not listed.

Contains no ingredient listed as toxic to reproductionReproductive toxicity

Specific target organ toxicity

- single exposure

Not classified.

Specific target organ toxicity

- repeated exposure

Not classified.

Aspiration hazard Not classified.

Chronic effects Prolonged or repeated contact may cause drying, cracking, or irritation of the skin.

12. Ecological information

This product has no known eco-toxicological effects. Not expected to be harmful to aquatic organisms.

Ecotoxicity

Not available.Persistence and degradability

Not available.Bioaccumulative potential

Not available.Mobility in soil

Other adverse effects Not available.

13. Disposal considerations

Dispose of contents/container in accordance with local/regional/national/international regulations.

When this product as supplied is to be discarded as waste, it does not meet the definition of a RCRA waste under 40 CFR 261.

Disposal instructions

Not applicable.Hazardous waste code

Dispose of in accordance with local regulations.Waste from residues / unused products

Offer rinsed packaging material to local recycling facilities.Contaminated packaging

14. Transport information

DOT

Not regulated as dangerous goods.

IATA

Not regulated as dangerous goods.

IMDG

Not regulated as dangerous goods.

Not available.Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code

Not regulated as dangerous goods.General information

If the product is shipped at temperatures below 212°F (100°C), it is not regulated for transport by ground, air or vessel. If shipped above 212 deg F: "UN3257, Elevated Temperature Liquid, n.o.s.

(Asphalt mixture), 9, PG III"

Further information

15. Regulatory information

All components are on the U.S. EPA TSCA Inventory List.US federal regulations

5 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)

Not regulated.

CERCLA Hazardous Substance List (40 CFR 302.4)

Not listed.

SARA 304 Emergency release notification

Not regulated.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

Not regulated.

SARA 302 Extremely hazardous substance

Superfund Amendments and Reauthorization Act of 1986 (SARA)

Not listed.

NoSARA 311/312 Hazardous chemical

SARA 313 (TRI reporting)

Not regulated.

Other federal regulations

Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List

Not regulated.

Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)

Not regulated.

Not regulated.Safe Drinking Water Act

(SDWA)

WARNING: This product contains a chemical known to the State of California to cause cancer.US state regulations

International Inventories

Country(s) or region Inventory name On inventory (yes/no)*

YesAustralia Australian Inventory of Chemical Substances (AICS)

YesCanada Domestic Substances List (DSL)

NoCanada Non-Domestic Substances List (NDSL)

YesChina Inventory of Existing Chemical Substances in China (IECSC)

YesEurope European Inventory of Existing Commercial Chemical Substances

(EINECS)

NoEurope European List of Notified Chemical Substances (ELINCS)

YesJapan Inventory of Existing and New Chemical Substances (ENCS)

YesKorea Existing Chemicals List (ECL)

YesNew Zealand New Zealand Inventory

YesPhilippines Philippine Inventory of Chemicals and Chemical Substances

(PICCS)

YesTaiwan Taiwan Chemical Substance Inventory (TCSI)

YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory

*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s).

16. Other information, including date of preparation or last revision

06-24-2019Issue date

05-15-2020Revision date

Version # 03

HMIS® is a registered trade and service mark of the NPCA.Further information

Health: 0 Flammability: 1 Instability: 0

NFPA ratings

6 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder

ACGIH

EPA: AQUIRE database US. IARC Monographs on Occupational Exposures to Chemical Agents HSDB® - Hazardous Substances Data Bank IARC Monographs. Overall Evaluation of Carcinogenicity National Toxicology Program (NTP) Report on Carcinogens ACGIH Documentation of the Threshold Limit Values and Biological Exposure Indices

References

The information in the sheet was written based on the best knowledge and experience currently available. The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.

Disclaimer

Physical & Chemical Properties: Multiple PropertiesRevision information

7 / 7

Material name: Roadsaver, Polyflex, Parking Lot, Asphalt Rubber, Asphalt Cement, DF, Superflex, Matrix Binder, Loop Detector, Joint Adhesive, Polyfiber, Fiber Asphalt, Marker Adhesive, Quikstix, Asphalt Adhesive, PCF 100, High Slope, QWIKSEAL, QWIKDOT, Joint Binder