2-FTL_108_PLUS_ODOT_023A-26_ITEM_3_L9.pdf

Prepared for:

JACK MARCHBANKS PH. D.

OHIO DOT

1620 W BROAD ST

COLUMBUS, OH 43223

Phone: 614-721-2972

Prepared by:

Greg Simonic

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd Parma, OH 44130

Phone: 216-267-4800

Application Version 12.0.303 Data Version PRL-29D.047

FTL 108 PLUS ODOT 023A-26 ITEM 3

L9

07/15/2025 5:32 PM

A proposal for

OHIO DOT

Prepared by

CLEVELAND FREIGHTLINER, INC.

Jul 15, 2025

Freightliner 108SD Plus

Components shown may not reflect all spec'd options and are not to scale

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

S P E C I F I C A T I O N P R O P O S A L

Description

Vehicle Configuration

108SD PLUS CONVENTIONAL CHASSIS

2026 MODEL YEAR SPECIFIED

SET BACK AXLE - TRUCK

TRAILER TOWING PROVISION AT END OF

FRAME WITH SAE J560

LH PRIMARY STEERING LOCATION

General Service

TRUCK/TRAILER CONFIGURATION

DOMICILED, USA (EXCLUDING CALIFORNIA AND

CARB OPT-IN STATES)

EXPECTED FRONT AXLE(S) LOAD : 20000.0 lbs

EXPECTED REAR DRIVE AXLE(S) LOAD :

26000.0 lbs

EXPECTED GROSS VEHICLE WEIGHT CAPACITY

: 46000.0 lbs

Engine

CUM L9 370 HP @ 2100 RPM; 2100 GOV RPM,

1250 LB-FT @ 1200 RPM

Electronic Parameters

65 MPH ROAD SPEED LIMIT

30 MINUTES IDLE SHUTDOWN WITHOUT

CLUTCH AND SERVICE BRAKE OVERRIDE

Engine Equipment

EPA 2010/GHG 2024 CONFIGURATION

STANDARD OIL PAN

ENGINE MOUNTED OIL CHECK AND FILL

SIDE OF HOOD AIR INTAKE WITH FIREWALL

MOUNTED DONALDSON AIR CLEANER WITH

SAFETY ELEMENT AND INSIDE/OUTSIDE AIR

WITH SNOW DOOR

DR 12V 200 AMP 28-SI QUADRAMOUNT PAD

ALTERNATOR WITH REMOTE BATTERY VOLT

SENSE

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

(2) DTNA GENUINE, FLOODED STARTING, MIN

2000CCA, 370RC, THREADED STUD BATTERIES

BATTERY BOX FRAME MOUNTED

STANDARD BATTERY JUMPERS

SINGLE BATTERY BOX FRAME MOUNTED LH

SIDE UNDER CAB

WIRE GROUND RETURN FOR BATTERY CABLES

WITH ADDITIONAL FRAME GROUND RETURN

NON-POLISHED BATTERY BOX COVER

PROGRESSIVE LOW VOLTAGE DISCONNECT AT

12.3 VOLTS FOR DESIGNATED CIRCUITS

CUMMINS TURBOCHARGED 18.7 CFM AIR

COMPRESSOR WITH INTERNAL SAFETY VALVE

ELECTRONIC ENGINE INTEGRAL SHUTDOWN

PROTECTION SYSTEM

C-BRAKE BY JACOBS WITH LOW/OFF/HIGH

BRAKING DASH SWITCH

RH OUTBOARD UNDER STEP MOUNTED

HORIZONTAL AFTERTREATMENT SYSTEM

ASSEMBLY WITH RH B-PILLAR MOUNTED

VERTICAL TAILPIPE

ENGINE AFTERTREATMENT DEVICE,

AUTOMATIC OVER THE ROAD REGENERATION

AND VIRTUAL REGENERATION REQUEST

SWITCH IN CLUSTER

11 FOOT 06 INCH (138 INCH+0/-5.9 INCH)

EXHAUST SYSTEM HEIGHT

RH CURVED VERTICAL TAILPIPE B-PILLAR

MOUNTED ROUTED FROM STEP

6 GALLON DIESEL EXHAUST FLUID TANK

100 PERCENT DIESEL EXHAUST FLUID FILL

STANDARD DIESEL EXHAUST FLUID PUMP

MOUNTING

LH MEDIUM DUTY STANDARD DIESEL EXHAUST

FLUID TANK LOCATION

STANDARD DIESEL EXHAUST FLUID TANK CAP

ALUMINUM AFTERTREATMENT

DEVICE/MUFFLER/TAILPIPE SHIELD(S)

AIR POWERED ON/OFF ENGINE FAN CLUTCH

AUTOMATIC FAN CONTROL WITHOUT DASH

SWITCH, NON ENGINE MOUNTED

CUMMINS SPIN ON FUEL FILTER

COMBINATION FULL FLOW/BYPASS OIL FILTER

1115 SQUARE INCH ALUMINUM RADIATOR

ANTIFREEZE TO -34F, OAT (NITRITE AND

SILICATE FREE) EXTENDED LIFE COOLANT

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

GATES BLUE STRIPE COOLANT HOSES OR

EQUIVALENT

CONSTANT TENSION HOSE CLAMPS FOR

COOLANT HOSES

RADIATOR DRAIN VALVE

1350 ADAPTER FLANGE FOR FRONT PTO

PROVISION

PHILLIPS-TEMRO 1000 WATT/115 VOLT BLOCK

HEATER

BLACK PLASTIC ENGINE HEATER RECEPTACLE

MOUNTED UNDER LH DOOR

ELECTRIC GRID AIR INTAKE WARMER

DELCO 12V 38MT HD STARTER WITH

INTEGRATED MAGNETIC SWITCH

Transmission

ALLISON 3000 RDS AUTOMATIC TRANSMISSION

WITH PTO PROVISION

Transmission Equipment

NEUTRAL AT STOP ENABLED

HEAVY DUTY ELECTRONIC TRANSMISSION

SHIFT CONTROL, COLUMN MOUNTED

Front Axle and Equipment

DETROIT DA-F-20.0-5 20,000# FL1 71.0 KPI/3.74

DROP SINGLE FRONT AXLE

BENDIX ADB22X AIR DISC FRONT BRAKES

NON-ASBESTOS FRONT BRAKE LINING

FRONT DISC BRAKE ROTORS

FRONT OIL SEALS

VENTED FRONT HUB CAPS WITH WINDOW,

CENTER AND SIDE PLUGS - OIL

STANDARD SPINDLE NUTS FOR ALL AXLES

FRONT AIR DISC BRAKE INTERNAL ADJUSTERS

STANDARD KING PIN BUSHINGS

TRW THP-60 POWER STEERING WITH RCH45

AUXILIARY GEAR

POWER STEERING PUMP

4 QUART POWER STEERING RESERVOIR

OIL/AIR POWER STEERING COOLER

CURRENT AVAILABLE SYNTHETIC 75W-90

FRONT AXLE LUBE

Front Suspension

20,000# FLAT LEAF FRONT SUSPENSION

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

GRAPHITE BRONZE BUSHINGS WITH SEALS -

FRONT SUSPENSION

FRONT SHOCK ABSORBERS

Rear Axle and Equipment

MERITOR RS-26-185 26,000# T-SERIES SINGLE

REAR AXLE

5.38 REAR AXLE RATIO

IRON REAR AXLE CARRIER WITH STANDARD

AXLE HOUSING

MXL 17T MERITOR EXTENDED LUBE MAIN

DRIVELINE WITH HALF ROUND YOKES

BENDIX ADB22X AIR DISC REAR BRAKES

NON-ASBESTOS REAR BRAKE LINING

BRAKE CAMS AND CHAMBERS ON REAR SIDE

OF DRIVE AXLE(S)

REAR DISC BRAKE ROTORS

REAR OIL SEALS

AIR DISC LONGSTROKE 1-DRIVE AXLE SPRING

PARKING CHAMBERS

REAR AIR DISC BRAKE INTERNAL ADJUSTERS

CURRENT AVAILABLE SYNTHETIC 75W-90 REAR

AXLE LUBE

STANDARD REAR AXLE BREATHER(S)

Rear Suspension

30,000# FLAT LEAF SPRING REAR SUSPENSION

WITH HELPER AND RADIUS ROD

SPRING SUSPENSION - 1.50" AXLE SPACER

STANDARD AXLE SEATS IN AXLE CLAMP

GROUP

FORE/AFT CONTROL RODS

Pusher / Tag Equipment

NO PUSHER/TAG BRAKE DUST SHIELDS

Brake System

WABCO 4S/4M ABS WITH TRACTION CONTROL

REINFORCED NYLON, FABRIC BRAID AND WIRE

BRAID CHASSIS AIR LINES

FIBER BRAID PARKING BRAKE HOSE

STANDARD BRAKE SYSTEM VALVES

STANDARD AIR SYSTEM PRESSURE

PROTECTION SYSTEM

STD U.S. FRONT BRAKE VALVE

RELAY VALVE WITH 5-8 PSI CRACK PRESSURE,

NO REAR PROPORTIONING VALVE

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

WABCO SYSTEM SAVER HP WITH INTEGRAL

AIR GOVERNOR AND HEATER

AIR DRYER MOUNTED INBOARD ON LH RAIL

ALUMINUM AIR BRAKE RESERVOIRS MOUNTED

INSIDE RAILS

BW DV-2 AUTO DRAIN VALVE WITH HEATER TO

WET TANK; DRAIN VALVE CABLES ON ALL

OTHER TANKS

Trailer Connections

AIR CONNECTIONS TO END OF FRAME WITH

GLAD HANDS FOR TRUCK AND DUST COVERS

PRIMARY CONNECTOR/RECEPTACLE WIRED

FOR COMBINATION STOP/TURN, CENTER PIN

POWERED THROUGH IGNITION WITH STOP

SIGNAL PREWIRE PACKAGE

SAE J560 7-WAY PRIMARY TRAILER CABLE

RECEPTACLE TEMPORARY TIED & COILED IN

CHASSIS END OF FRAME WITH 4' ADDITIONAL;

NO BRACKETS

Wheelbase & Frame

4250MM (167 INCH) WHEELBASE

7/16X3-9/16X11-1/8 INCH STEEL FRAME

(11.11MMX282.6MM/0.437X11.13 INCH) 120KSI

1775MM (70 INCH) REAR FRAME OVERHANG

Chassis Equipment

OMIT FRONT BUMPER, CUSTOMER INSTALLED

SPECIAL BUMPER, DOES NOT COMPLY WITH

FMCSR 393.203

NO MUDFLAP BRACKETS

NO REAR MUDFLAPS

GRADE 8 THREADED HEX HEADED FRAME

FASTENERS

EXTERIOR HARNESSES WRAPPED IN

ABRASION TAPE

Fifth Wheel

NO FIFTH WHEEL

Fuel Tanks

70 GALLON/264 LITER ALUMINUM FUEL TANK -

LH

25 INCH DIAMETER FUEL TANK(S)

PLAIN ALUMINUM/PAINTED STEEL

FUEL/HYDRAULIC TANK(S) WITH POLISHED

STAINLESS STEEL BANDS

FUEL TANK(S) FORWARD

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

PLAIN STEP FINISH

CHROME FUEL TANK CAP(S)

DETROIT FUEL/WATER SEPARATOR WITH

WATER IN FUEL SENSOR AND 12 VOLT

PREHEATER

EQUIFLO INBOARD FUEL SYSTEM

HIGH TEMPERATURE REINFORCED NYLON

FUEL LINE

Tires

315/80R22.5 20 PLY RADIAL FRONT TIRES

12R22.5 16 PLY RADIAL REAR TIRES

Hubs

CONMET PRESET PLUS PREMIUM IRON FRONT

HUBS

CONMET PRESET PLUS PREMIUM IRON REAR

HUBS

Wheels

22.5X9.00 10-HUB PILOT 5.99 INSET ALUMINUM

FRONT WHEELS

22.5X9.00 10-HUB PILOT 5.99 INSET ALUMINUM

REAR WHEELS

FRONT WHEEL MOUNTING NUTS

REAR WHEEL MOUNTING NUTS

Cab Exterior

108 INCH BBC FLAT ROOF ALUMINUM

CONVENTIONAL CAB

AIR CAB MOUNTING

NONREMOVABLE BUGSCREEN MOUNTED

BEHIND GRILLE

SHORT FENDER WITH MUDFLAP

BOLT-ON MOLDED FLEXIBLE FENDER

EXTENSIONS

LH AND RH EXTERIOR GRAB HANDLES WITH

SINGLE RUBBER INSERT

STATIONARY BLACK GRILLE

BLACK HOOD MOUNTED AIR INTAKE GRILLE

FIBERGLASS HOOD

FREIGHTLINER NAME PLATES

TUNNEL/FIREWALL LINER

SINGLE 14 INCH ROUND HADLEY AIR HORN

UNDER LH DECK

SINGLE ELECTRIC HORN

REAR LICENSE PLATE MOUNT END OF FRAME

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

HALOGEN COMPOSITE HEADLAMPS WITH

BLACK BEZELS

LED AERODYNAMIC MARKER LIGHTS

WIRING AND SWITCH FOR CUSTOMER

FURNISHED SNOW PLOW LAMPS WITH SINGLE

CONNECTION AT LH FORWARD

NO DAYTIME RUNNING LIGHTS

INTEGRAL STOP/TAIL/BACKUP LIGHTS

STANDARD FRONT TURN SIGNAL LAMPS

DUAL WEST COAST BRIGHT FINISH HEATED

MIRRORS WITH LH AND RH REMOTE

DOOR MOUNTED MIRRORS

102 INCH EQUIPMENT WIDTH

LH AND RH 8 INCH BRIGHT FINISH CONVEX

MIRRORS MOUNTED UNDER PRIMARY

MIRRORS

RH AND LH 8 INCH HEATED STAINLESS STEEL

FENDER MOUNTED CONVEX MIRRORS WITH

TRIPOD BRACKETS

STANDARD SIDE/REAR REFLECTORS

RH AFTERTREATMENT SYSTEM CAB ACCESS

WITH POLISHED DIAMOND PLATE COVER

63X14 INCH TINTED REAR WINDOW

TINTED DOOR GLASS LH AND RH WITH TINTED

NON-OPERATING WING WINDOWS

RH AND LH ELECTRIC POWERED WINDOWS

1-PIECE BONDED HEATED WIPER PARK SOLAR

GREEN GLASS WINDSHIELD

8 LITER (2 GAL) WINDSHIELD WASHER

RESERVOIR, CAB MOUNTED, WITHOUT FLUID

LEVEL INDICATOR

Cab Interior

RUGGED TRIM PACKAGE

GRAY & CARBON VINYL INTERIOR "RUGGED"

CARBON WITH PREMIUM GUNMETAL ACCENT

(RUGGED)

MOLDED DOOR PANEL

MOLDED PLASTIC DOOR PANEL

BLACK MATS WITH SINGLE INSULATION

(1) 12V DASH MOUNTED POWER OUTLET

FORWARD ROOF MOUNTED CONSOLE

LH AND RH DOOR STORAGE POCKETS

INTEGRATED INTO MOLDED DOOR PANELS

DIGITAL ALARM CLOCK IN DRIVER DISPLAY

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

(2) CUP HOLDERS LH AND RH DASH

M2/SD DASH

HEATER, DEFROSTER AND AIR CONDITIONER

STANDARD HVAC DUCTING WITH SNOW

SHIELD FOR FRESH AIR INTAKE

MAIN HVAC CONTROLS WITH RECIRCULATION

SWITCH

STANDARD HEATER PLUMBING

VALEO HEAVY DUTY A/C REFRIGERANT

COMPRESSOR

BINARY CONTROL, R-134A

STANDARD INSULATION

SOLID-STATE CIRCUIT PROTECTION AND

FUSES

12V NEGATIVE GROUND ELECTRICAL SYSTEM

STANDARD LED CAB LIGHTING

NO SECURITY DEVICE

ALL UNIT(S) KEYED ALIKE WITH CUSTOMER

SPECIFIED KEY NUMBER FT1010

KEY QUANTITY OF 4

LH AND RH ELECTRIC DOOR LOCKS

NO MATTRESS

BASIC ISRINGHAUSEN HIGH BACK AIR

SUSPENSION DRIVERS SEAT WTIH

MECHANICAL LUMBAR AND INTEGRATED

CUSHION EXTENSION

BASIC ISRINGHAUSEN HIGH BACK AIR

SUSPENSION PASSENGER SEAT WTIH

MECHANICAL LUMBAR AND INTEGRATED

CUSHION EXTENSION

INBOARD DRIVER AND PASSENGER SEAT

ARMRESTS

LH AND RH INTEGRAL DOOR PANEL ARMRESTS

BLACK VINYL DRIVER SEAT COVER

BLACK VINYL PASSENGER SEAT COVER

BLACK SEAT BELTS

ADJUSTABLE TILT AND TELESCOPING

STEERING COLUMN

4-SPOKE 18 INCH (450MM) BLACK STEERING

WHEEL WITH SWITCHES

DRIVER AND PASSENGER INTERIOR SUN

VISORS

Instruments & Controls

ELECTRONIC ACCELERATOR CONTROL

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

NO INSTRUMENT PANEL-DRIVER

CONFIGURABLE LOWER PANEL WITH

INTEGRATED UPPER STORAGE

ENGINE REMOTE INTERFACE WITHOUT

INTERLOCKS

BRIGHT ARGENT FINISH GAUGE BEZELS

LOW AIR PRESSURE INDICATOR LIGHT AND

AUDIBLE ALARM

DUAL NEEDLE PRIMARY AND SECONDARY AIR

PRESSURE GAUGE

DASH MOUNTED AIR RESTRICTION INDICATOR

WITH GRADUATIONS

ELECTRONIC CRUISE CONTROL WITH

CONTROLS ON STEERING WHEEL SPOKES

KEY OPERATED IGNITION SWITCH AND

INTEGRAL START POSITION; 4 POSITION

OFF/RUN/START/ACCESSORY

PREMIUM INSTRUMENT CLUSTER WITH 5.0

INCH TFT COLOR DISPLAY

DIGITAL PANEL LAMP DIMMER SWITCH IN

DRIVER DISPLAY

HEAVY DUTY ONBOARD DIAGNOSTICS

INTERFACE CONNECTOR LOCATED BELOW LH

DASH

2 INCH ELECTRIC FUEL GAUGE

ENGINE REMOTE INTERFACE WITH ONE OR

MORE SET SPEEDS

QUICKFIT POWERTRAIN INTERFACE

CONNECTOR LOCATED BETWEEN SEATS WITH

BLUNTCUTS

12 EXTRA PROGRAMMABLE

SWITCHES/INDICATORS

QUICKFIT PROGRAMMABLE INTERFACE

CONNECTOR(S) BETWEEN SEATS WITH

BLUNTCUTS

ELECTRICAL ENGINE COOLANT TEMPERATURE

GAUGE

ELECTRIC ENGINE OIL PRESSURE GAUGE

2 INCH TRANSMISSION OIL TEMPERATURE

GAUGE

ELECTRONIC OUTSIDE TEMPERATURE

SENSOR DISPLAY IN DRIVER MESSAGE

CENTER

ENGINE AND TRIP HOUR METERS INTEGRAL

WITHIN DRIVER DISPLAY

PTO CONTROLS FOR ENHANCED VEHICLE

ELECTRIC/ELECTRONIC ARCHITECTURE

NO OBSTACLE DETECTION SYSTEM

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

NO DR ASSIST SYSTEM

NO VEHICLE STABILITY ADVISOR OR CONTROL

NO LANE DEPARTURE WARNING SYSTEM

NO OVERHEAD INSTRUMENT PANEL

1 QUIKFIT PROGRAMABLE MODULE (QPMXMC)

W/ (8) 20AMP FUSED RELAYS

TOP OF DASH RAM MOUNT WITHOUT POWER

OR GROUND, FOR CUSTOMER FURNISHED

DEVICE

AM/FM/WB WORLD TUNER RADIO WITH

BLUETOOTH, USB AND AUXILIARY INPUTS,

J1939

DASH MOUNTED RADIO

(2) RADIO SPEAKERS IN CAB

AM/FM ANTENNA MOUNTED ON FORWARD LH

ROOF

POWER AND GROUND STUDS TOP OF DASH

PLUS POWER AND GROUND WIRING

PROVISION IN OVERHEAD CONSOLE

ROOF/OVERHEAD CONSOLE AND TOP OF DASH

WITH PLATE AND STRAPS PROVISIONS FOR CB

RADIO

NO MULTIBAND ANTENNA

NO DIGITAL SATELLITE AUDIO RECEIVER

ANTENNA

ELECTRONIC MPH SPEEDOMETER WITH

SECONDARY KPH SCALE, WITHOUT

ODOMETER

STANDARD VEHICLE SPEED SENSOR

ELECTRONIC 3000 RPM TACHOMETER

DETROIT CONNECT PLATFORM HARDWARE

3 YEARS DAIMLER CONNECTIVITY BASE

PACKAGE ON (FEATURES VARY BY MODEL)

POWERED BY DETROIT CONNECT ON

CUMMINS ENGINES

TMC RP1226 ACCESSORY CONNECTOR

LOCATED BEHIND PASSENGER SIDE

REMOVEABLE DASH PANEL

IGNITION SWITCH CONTROLLED ENGINE STOP

12 SWITCH SLOTS, DRIVER OVERHEAD

CONSOLE

(1) OVERHEAD MOUNTED LANYARD CONTROL

FOR DRIVER AIR HORN

STANDARD TRACTOR PROTECTION VALVE

TRAILER HAND CONTROL BRAKE VALVE

DIGITAL VOLTAGE DISPLAY INTEGRAL WITH

DRIVER DISPLAY

OHIO DOT

1620 W BROAD ST

CLEVELAND FREIGHTLINER,

INC.

10901 Brookpark Rd

SINGLE ELECTRIC WINDSHIELD WIPER MOTOR

WITH DELAY AND ARCTIC TYPE BLADES

ROTARY HEADLAMP SWITCH, MARKER

LIGHTS/HEADLIGHTS SWITCH WITH PULL OUT

FOR OPTIONAL FOG/ROAD LAMPS

TWO VALVE PARKING BRAKE SYSTEM WITH

WARNING INDICATOR

SELF CANCELING TURN SIGNAL SWITCH WITH

DIMMER, HEADLAMP FLASH,

WASH/WIPE/INTERMITTENT

INTEGRAL ELECTRONIC TURN SIGNAL

FLASHER WITH 40 AMP (20 AMP PER SIDE)

TRAILER LAMP CAPACITY

NO WRG/SW-OPTL #2,CHAS,AIR

Design

PAINT: ONE SOLID COLOR

Color

CAB COLOR A: L0006EY WHITE ELITE EY

BLACK, HIGH SOLIDS POLYURETHANE CHASSIS

PAINT

STANDARD E COAT/UNDERCOATING

Certification / Compliance

U.S. FMVSS CERTIFICATION, EXCEPT SALES

CABS AND GLIDER KITS

(***) All cost increases for major components (Engines, Transmissions, Axles, Front and Rear Tires) and government mandated requirements, tariffs, and raw material surcharges will be passed through and added to factory invoices.