2-023A-26_ODOT_ITEM_2_WSTR_47X_L9.pdf

Prepared for:

OHIO DOT

1620 W BROAD ST

COLUMBUS, OH 43223

Phone: 614-721-2972

Prepared by:

Greg Simonic

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

Parma, OH 44130 Phone: 216-267-4800

Application Version 12.0.303 Data Version PRL-29X.047

023A-26 ODOT ITEM 2 WSTR 47X L9

07/16/2025 7:48 AM

A proposal for

Prepared by

VALLEY FREIGHTLINER, INC.

Jul 16, 2025

Western Star 47X

Components shown may not reflect all spec'd options and are not to scale

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

S P E C I F I C A T I O N P R O P O S A L

Description

Price Level

WST 47X/49X PRL-29X (EFF:MY26 ORDERS)

Data Version

SPECPRO21 DATA RELEASE VER 047

Vehicle Configuration

WESTERN STAR 47X

2026 MODEL YEAR SPECIFIED

SET FORWARD AXLE - TRUCK

TRAILER TOWING PROVISION AT END OF

FRAME WITH SAE J560

LH PRIMARY STEERING LOCATION

General Service

TRUCK/TRAILER CONFIGURATION

DOMICILED, USA (EXCLUDING CALIFORNIA AND

CARB OPT-IN STATES)

EXPECTED FRONT AXLE(S) LOAD : 20000.0 lbs

EXPECTED REAR DRIVE AXLE(S) LOAD :

46000.0 lbs

EXPECTED GROSS VEHICLE WEIGHT CAPACITY

: 66000.0 lbs

Engine

CUM L9 370 HP @ 2100 RPM; 2100 GOV RPM,

1250 LB-FT @ 1200 RPM

Electronic Parameters

68 MPH ROAD SPEED LIMIT

30 MINUTE IDLE SHUTDOWN - TIMER RESET

WITH CLUTCH AND SERVICE BRAKE

Engine Equipment

EPA 2010/GHG 2024 CONFIGURATION

STANDARD OIL PAN

ENGINE MOUNTED OIL CHECK AND FILL

SIDE OF HOOD AIR INTAKE WITH ENGINE

MOUNTED AIR CLEANER, WITH

INSIDE/OUTSIDE AIR AND SNOW DOOR

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

DR 12V 200 AMP 28-SI QUADRAMOUNT PAD

ALTERNATOR WITH REMOTE BATTERY VOLT

SENSE

(2) DTNA GENUINE, FLOODED STARTING, MIN

2000CCA, 370RC, THREADED STUD BATTERIES

BATTERY BOX WITH ALUMINUM COVER

MOUNTED SHORT SIDE TO RAIL

SINGLE BATTERY BOX FRAME MOUNTED LH

SIDE BACK OF CAB

WIRE GROUND RETURN FOR BATTERY CABLES

WITH ADDITIONAL FRAME GROUND RETURN

UNPOLISHED ALUMINUM WST BATTERY BOX

COVER

PROGRESSIVE LOW VOLTAGE DISCONNECT AT

12.3 VOLTS FOR DESIGNATED CIRCUITS

CUMMINS TURBOCHARGED 18.7 CFM AIR

COMPRESSOR WITH INTERNAL SAFETY VALVE

ELECTRONIC ENGINE INTEGRAL SHUTDOWN

PROTECTION SYSTEM

C-BRAKE BY JACOBS WITH LOW/OFF/HIGH

BRAKING DASH SWITCH

RH OUTBOARD UNDER STEP MOUNTED

HORIZONTAL AFTERTREATMENT SYSTEM

ASSEMBLY WITH RH B-PILLAR MOUNTED

VERTICAL TAILPIPE

ENGINE AFTERTREATMENT DEVICE,

AUTOMATIC OVER THE ROAD ACTIVE

REGENERATION AND VIRTUAL REGENERATION

REQUEST SWITCH IN CLUSTER AND DASH

MOUNTED INHIBIT SWITCH

11 FOOT 06 INCH (138 INCH+0/-5.9 INCH)

EXHAUST SYSTEM HEIGHT

RH CURVED VERTICAL TAILPIPE B-PILLAR

MOUNTED ROUTED FROM STEP

8 GALLON DIESEL EXHAUST FLUID TANK

UNPOLISHED ALUMINUM WST DIESEL

EXHAUST FLUID TANK COVER

LH HEAVY DUTY STANDARD DIESEL EXHAUST

FLUID TANK LOCATION

STANDARD DIESEL EXHAUST FLUID TANK CAP

STAINLESS STEEL AFTERTREATMENT

DEVICE/MUFFLER/TAILPIPE SHIELD

ELECTRONICALLY CONTROLLED VARIABLE

SPEED VISCOUS FAN DRIVE

AUTOMATIC FAN CONTROL WITHOUT DASH

SWITCH, NON ENGINE MOUNTED

DETROIT FUEL/WATER SEPARATOR WITH

WATER IN FUEL SENSOR AND 12 VOLT

PREHEATER

CUMMINS SPIN ON FUEL FILTER

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

FULL FLOW OIL FILTER

1400 SQUARE INCH VOCATIONAL RADIATOR

WITH PROTECTION PACKAGE

ANTIFREEZE TO -34F, OAT (NITRITE AND

SILICATE FREE) EXTENDED LIFE COOLANT

GATES BLUE STRIPE COOLANT HOSES OR

EQUIVALENT

STANDARD CHARGE AIR COOLER PLUMBING

RADIATOR DRAIN VALVE

LOWER RADIATOR GUARD

1350 ADAPTER FLANGE FOR FRONT PTO

PROVISION

PHILLIPS-TEMRO 1000 WATT/115 VOLT BLOCK

HEATER

BLACK PLASTIC ENGINE HEATER RECEPTACLE

MOUNTED UNDER LH DOOR

ELECTRIC GRID AIR INTAKE WARMER

DELCO 12V 39MT HD/OCP STARTER WITH

THERMAL PROTECTION AND INTEGRATED

MAGNETIC SWITCH

Transmission

ALLISON 3000 RDS AUTOMATIC TRANSMISSION

WITH PTO PROVISION

Transmission Equipment

NEUTRAL AT STOP ENABLED

HEAVY DUTY ELECTRONIC TRANSMISSION

SHIFT CONTROL, COLUMN MOUNTED

Front Axle and Equipment

DETROIT DA-F-20.0-5 20,000# FL1 71.0 KPI/3.74

DROP SINGLE FRONT AXLE

CONMET PRESET PLUS PREMIUM ALUMINUM

FRONT HUBS

BENDIX ADB22X AIR DISC FRONT BRAKES

NON-ASBESTOS FRONT BRAKE LINING

BENDIX FRONT DISC SPLINED BRAKE ROTORS

FRONT BRAKE DUST SHIELDS

FRONT OIL SEALS

VENTED FRONT HUB CAPS WITH WINDOW,

CENTER AND SIDE PLUGS - OIL

FRONT AIR DISC BRAKE INTERNAL ADJUSTERS

DUAL POWER STEERING GEARS, BENDIX 16-

20K

4 QUART POWER STEERING RESERVOIR

OIL/AIR POWER STEERING COOLER

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

CURRENT AVAILABLE SYNTHETIC 75W-90

FRONT AXLE LUBE

Front Suspension

20,000# FLAT LEAF FRONT SUSPENSION

THREADED SPRING PINS AND BUSHINGS -

FRONT SUSPENSION

FRONT SHOCK ABSORBERS

Rear Axle and Equipment

MERITOR RT-46-160 46,000# R-SERIES TANDEM

REAR AXLE

CONMET PRESET PLUS PREMIUM IRON REAR

HUBS

5.38 REAR AXLE RATIO

IRON REAR AXLE CARRIER WITH STANDARD

AXLE HOUSING

MXL 17T MERITOR EXTENDED LUBE MAIN

DRIVELINE WITH HALF ROUND YOKES

MXL 17T MERITOR EXTENDED LUBE INTERAXLE

DRIVELINE WITH HALF ROUND YOKES

(1) INTERAXLE LOCK VALVE FOR TANDEM

DRIVE AXLES

INDICATOR LIGHT FOR EACH INTERAXLE

LOCKOUT SWITCH

BENDIX ADB22X AIR DISC REAR BRAKES

NON-ASBESTOS REAR BRAKE LINING

STANDARD BRAKE CHAMBER LOCATION

REAR DISC BRAKE ROTORS

REAR BRAKE DUST SHIELDS

REAR OIL SEALS

AIR DISC LONGSTROKE 1-DRIVE AXLE SPRING

PARKING CHAMBERS

REAR AIR DISC BRAKE INTERNAL ADJUSTERS

CURRENT AVAILABLE SYNTHETIC 75W-90 REAR

AXLE LUBE

STANDARD REAR AXLE BREATHER(S)

Rear Suspension

HENDRICKSON RT463 @46,000# REAR

SUSPENSION

12.0 INCH NOMINAL RIDE HEIGHT (520MM

GLOBAL REFERENCE HEIGHT)

STANDARD AXLE SEATS IN AXLE CLAMP

GROUP

52 INCH AXLE SPACING

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

STEEL BEAMS AND BRONZE CENTER

BUSHINGS WITH BAR PIN ADJUSTABLE END

CONNECTIONS

FORE/AFT CONTROL RODS

NO REAR SHOCK ABSORBERS

Pusher / Tag Equipment

NO PUSHER/TAG BRAKE DUST SHIELDS

Brake System

WABCO 4S/4M ABS WITH TRACTION CONTROL

WITH ATC SHUT OFF SWITCH

REINFORCED NYLON, FABRIC BRAID AND WIRE

BRAID CHASSIS AIR LINES

RELAY VALVE WITH 5-8 PSI CRACK PRESSURE,

NO REAR PROPORTIONING VALVE

WABCO SYSTEM SAVER HP WITH INTEGRAL

AIR GOVERNOR AND HEATER

WABCO OIL COALESCING FILTER FOR AIR

DRYER

AIR DRYER FRAME MOUNTED

ALUMINUM AIR BRAKE RESERVOIRS MOUNTED

INSIDE RAILS

BW DV-2 AUTO DRAIN VALVE WITH HEATER TO

WET TANK; DRAIN VALVE CABLES ON ALL

OTHER TANKS

Trailer Connections

AIR CONNECTIONS TO END OF FRAME WITH

GLAD HANDS FOR TRUCK AND DUST COVERS

PRIMARY CONNECTOR/RECEPTACLE WIRED

FOR COMBINATION STOP/TURN, CENTER PIN

POWERED THROUGH IGNITION WITH STOP

SIGNAL PREWIRE PACKAGE

SAE J560 7-WAY PRIMARY TRAILER CABLE

RECEPTACLE TEMPORARY TIED & COILED IN

CHASSIS END OF FRAME WITH 4' ADDITIONAL;

NO BRACKETS

Wheelbase & Frame

5690MM (224 INCH) WHEELBASE, SFA ONLY

13.0MM X 87.0MM X 311.0MM STEEL FRAME

(0.51X3.43X12.24 INCH) 120 KSI

2450MM (96 INCH) REAR FRAME OVERHANG

Chassis Equipment

UNPOLISHED ALUMINUM WST EQUIPMENT

COVERS

OMIT FRONT BUMPER, CUSTOMER INSTALLED

SPECIAL BUMPER, DOES NOT COMPLY WITH

FMCSR 393.203

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

NO FRONT TOW HOOKS

NO LICENSE PLATE MOUNTING

CLASS 10.9 THREADED METRIC FASTENERS

EXTERIOR HARNESSES WRAPPED IN

ABRASION TAPE

Fuel Tanks

70 GALLON/264 LITER ALUMINUM FUEL TANK -

LH

25 INCH DIAMETER FUEL TANK(S)

PLAIN ALUMINUM/PAINTED STEEL

FUEL/HYDRAULIC TANK(S) WITH POLISHED

STAINLESS STEEL BANDS

FUEL TANK(S) FORWARD

PLAIN STEP FINISH

CHROME FUEL TANK CAP(S)

EQUIFLO INBOARD FUEL SYSTEM

HIGH TEMPERATURE REINFORCED NYLON

FUEL LINE

Tires

315/80R22.5 20 PLY RADIAL FRONT TIRES

12R22.5 16 PLY RADIAL REAR TIRES

Wheels

22.5X9.00 10-HUB PILOT 3.12 INSET 10-HD

ALUMINUM FRONT WHEELS

22.5X9.00 10-HUB PILOT 5.99 INSET ALUMINUM

REAR WHEELS

FRONT WHEEL MOUNTING NUTS

REAR WHEEL MOUNTING NUTS

Cab Exterior

111.6 INCH BBC CONVENTIONAL ALUMINUM

CAB

STAINLESS STEEL CAB ACCENT MOLDING

FRONT FENDERS

BOLT-ON MOLDED FLEXIBLE FENDER

EXTENSIONS

INTERIOR GRAB HANDLES WITH ADDED

LOWER LH AND RH A PILLAR GRAB HANDLES

AND LH AND RH EXTERIOR NON-SLIP GRAB

HANDLES

BRIGHT HOOD MOUNTED AIR INTAKE GRILLE,

BLACK SCREEN

X-SERIES STEEL REINFORCED ALUMINUM CAB

X-SERIES VOCATIONAL HOOD

HOOD OPENING ASSIST WITH LOCKING STRUT

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

WESTERN STAR NAMEPLATES

SINGLE AIR HORN UNDER LH DECK

SINGLE ELECTRIC HORN

REAR LICENSE PLATE MOUNT END OF FRAME

DUAL STAGE INTELLIGENT LED HEADLIGHTS

WITH HEATED LENS SYSTEM

ROOF MOUNTED LED MARKER LIGHTS

WIRING AND SWITCH FOR CUSTOMER

FURNISHED SNOW PLOW LAMPS WITH SINGLE

CONNECTION AT LH FORWARD

DAYTIME RUNNING LIGHTS

INTEGRAL LED STOP/TAIL/BACKUP LIGHTS

LED SIDE TURN SIGNAL

C-BAR MIRROR SYSTEM WITH DUAL HEATED

MIRRORS WITH INTEGRAL HEATED CONVEX,

DUAL REMOTE, STAINLESS STEEL BACK

COVER, AND BLACK C-BAR

102 INCH EQUIPMENT WIDTH

LH AND RH CONVEX MIRRORS INTEGRAL WITH

PRIMARY MIRRORS

NO AUXILIARY MIRROR

RH AND LH HEATED BLACK HOOD/FENDER

MOUNTED SIDE VIEW MIRRORS WITH BRIGHT

FINISH MOUNTING ARM

STANDARD SIDE/REAR REFLECTORS

UNPOLISHED ALUMINUM WST

AFTERTREATMENT SYSTEM COVER

NO SLEEPER VENT

SINGLE SOLAR TINTED REAR WINDOW, (1) 31

INCH X 20 INCH

1-PIECE ROPED-IN SOLAR GREEN GLASS

WINDSHIELD

8 LITER (2 GAL) WINDSHIELD WASHER

RESERVOIR, CAB MOUNTED, WITH FLUID

LEVEL INDICATOR

Cab Interior

X-SERIES BASE INTERIOR TRIM LEVEL

PACKAGE

CHARCOAL BLACK VINYL BASE LEVEL

INTERIOR

CARBON WITH BASE BLACK ACCENT

BLACK MATS

(2) DASH MOUNTED POWER OUTLETS AND

COIN TRAY

FORWARD ROOF MOUNTED CONSOLE

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

LH AND RH DOOR STORAGE POCKETS

INTEGRATED INTO MOLDED DOOR PANELS

(2) COAT HOOKS ON BACKWALL OF CAB

NO UPPER BUNK

DIGITAL ALARM CLOCK IN DRIVER DISPLAY

STANDARD HEATER PLUMBING

RADIATOR MOUNTED AIR CONDITIONER

CONDENSER

STANDARD INSULATION

STANDARD LED CAB LIGHTING

NO SECURITY DEVICE

ALL UNIT (S) KEYED ALIKE WITH CUSTOMER

SPECIFIED KEY NUMBER FT1041

KEY QUANTITY OF 2

LH AND RH ELECTRIC DOOR LOCKS WITH

AUTO UNLOCK FEATURE WHEN DOOR IS SET

FROM OPEN TO CLOSED POSITION

BLACK DOOR HANDLES

NO MATTRESS

BASIC 2.0 HIGH BACK AIR SUSPENSION DRIVER

SEAT WITH 1 CHAMBER AIR LUMBAR,

INTEGRATED CUSHION EXTENSION AND TILT

BASIC 2.0 HIGH BACK AIR SUSPENSION

PASSENGER SEAT WITH 1 CHAMBER AIR

LUMBAR, INTEGRATED CUSHION EXTENSION

AND TILT

INBOARD DRIVER AND PASSENGER SEAT

ARMRESTS

BLACK VINYL DRIVER SEAT COVER WITH NO

LOGO

BLACK VINYL PASSENGER SEAT COVER WITH

NO LOGO

3 POINT ADJUSTABLE D-RING RETRACTOR

DRIVER AND FIXED D-RING RETRACTOR

PASSENGER SEAT BELTS

ADJUSTABLE TILT AND TELESCOPING

STEERING COLUMN

4-SPOKE 18 INCH (450MM) BLACK STEERING

WHEEL WITH SWITCHES

DRIVER AND PASSENGER INTERIOR SUN

VISORS

Instruments & Controls

STANDARD FOOT PEDAL SYSTEM

ELECTRONIC ACCELERATOR CONTROL

BLACK GAUGE BEZELS

STANDARD CENTER INSTRUMENT PANEL

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

DUAL NEEDLE PRIMARY AND SECONDARY AIR

PRESSURE GAUGE

DASH MOUNTED AIR RESTRICTION INDICATOR

WITH GRADUATIONS

ELECTRONIC CRUISE CONTROL WITH

CONTROLS ON STEERING WHEEL SPOKES

KEY OPERATED IGNITION SWITCH AND

INTEGRAL START POSITION; 4 POSITION

OFF/RUN/START/ACCESSORY

AUXILIARY POWER DISTRIBUTION MODULE

FOR TEM USE, AUXILIARY EVAULT MOUNTED,

FUSE PROTECTED

PREMIUM INSTRUMENT CLUSTER WITH 5.0

INCH TFT COLOR DISPLAY

DIGITAL PANEL LAMP DIMMER SWITCH IN

DRIVER DISPLAY

HEAVY DUTY ONBOARD DIAGNOSTICS

INTERFACE CONNECTOR WITH DUST CAP

LOCATED BELOW LH DASH

2 INCH ELECTRIC FUEL GAUGE

ENGINE REMOTE INTERFACE WITH ONE OR

MORE SET SPEEDS

ELECTRICAL ENGINE COOLANT TEMPERATURE

GAUGE

NO ENGINE OIL TEMPERATURE GAUGE

ELECTRIC ENGINE OIL PRESSURE GAUGE

2 INCH TRANSMISSION OIL TEMPERATURE

GAUGE

ELECTRONIC OUTSIDE TEMPERATURE

SENSOR DISPLAY IN DRIVER MESSAGE

CENTER

ENGINE AND TRIP HOUR METERS INTEGRAL

WITHIN DRIVER DISPLAY

PTO CONTROLS FOR ENHANCED VEHICLE

ELECTRIC/ELECTRONIC ARCHITECTURE

NO OBSTACLE DETECTION SYSTEM

NO SIDE OBJECT DETECTION SYSTEM

NO DR ASSIST SYSTEM

NO VEHICLE STABILITY ADVISOR OR CONTROL

NO LANE DEPARTURE WARNING SYSTEM

1 QUIKFIT PROGRAMABLE MODULE (QPMXMC)

W/ (8) 20AMP FUSED RELAYS

TMC RP1226 ACCESSORY CONNECTOR

LOCATED BEHIND PASSENGER SIDE

REMOVEABLE DASH PANEL

AM/FM/WB WORLD TUNER RADIO WITH

BLUETOOTH, USB AND AUXILIARY INPUTS,

J1939

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

DASH MOUNTED RADIO

STANDARD SPEAKER SYSTEM

NO AM/FM RADIO ANTENNA

POWER AND GROUND STUDS ON TOP OF DASH

TOP OF DASH MOUNT CB RADIO PROVISION

WITH PLATE AND STRAPS

SINGLE REMOTE SPEAKER WITH LEAD FOR 2-

WAY RADIO

SINGLE FIBERGLASS LH MIRROR MOUNTED CB

ANTENNA WITH BRACKET AND LEAD

HEADLINER MULTI-BAND ANTENNA:

AM/FM/WEATHERBAND, WIFI/BLUETOOTH,

GNSS/GPS

NO DIGITAL SATELLITE AUDIO RECEIVER

ANTENNA

ELECTRONIC MPH SPEEDOMETER WITH

SECONDARY KPH SCALE, WITHOUT

ODOMETER

ELECTRONIC 2500 RPM TACHOMETER

DETROIT CONNECT PLATFORM HARDWARE

5 YEARS DAIMLER CONNECTIVITY BASE

PACKAGE (FEATURES VARY BY MODEL)

POWERED BY DETROIT CONNECT ON

CUMMINS ENGINES

IGNITION SWITCH CONTROLLED ENGINE STOP

NO PRE TRIP SYSTEM TEST

STANDARD TRACTOR PROTECTION VALVE

TRAILER HAND CONTROL BRAKE VALVE

DIGITAL TURBO AIR PRESSURE IN DRIVER

DISPLAY

DIGITAL VOLTAGE DISPLAY INTEGRAL WITH

DRIVER DISPLAY

ROTARY HEADLAMP SWITCH, MARKER

LIGHTS/HEADLIGHTS SWITCH WITH PULL OUT

FOR OPTIONAL FOG/ROAD LAMPS

TWO VALVE PARKING BRAKE SYSTEM WITH

WARNING INDICATOR

SELF CANCELING TURN SIGNAL SWITCH WITH

DIMMER, HEADLAMP FLASH,

WASH/WIPE/INTERMITTENT

PROGRAMMABLE SWITCHES/INDICATORS

LOCATED IN AUXILIARY PANEL

QUICKFIT POWERTRAIN INTERFACE

CONNECTOR LOCATED BETWEEN SEATS WITH

BLUNTCUTS

12 EXTRA PROGRAMMABLE

SWITCHES/INDICATORS

1620 W BROAD ST

VALLEY FREIGHTLINER, INC.

10901 Brookpark Rd

QUICKFIT PROGRAMMABLE INTERFACE

CONNECTOR(S) BETWEEN SEATS WITH

BLUNTCUTS

Design

PAINT: ONE SOLID COLOR

Color

CAB COLOR A: L0006EY WHITE ELITE EY

BLACK, HIGH SOLIDS POLYURETHANE CHASSIS

PAINT

Certification / Compliance

U.S. FMVSS CERTIFICATION, EXCEPT SALES

CABS AND GLIDER KITS

(***) All cost increases for major components (Engines, Transmissions, Axles, Front and Rear Tires) and government mandated requirements, tariffs, and raw material surcharges will be passed through and added to factory invoices.