1-118-25_VALLEY_M2106_B6.7_Base_Spec.pdf

Prepared for:

OHIO DOT

1620 W BROAD ST

COLUMBUS, OH 43223

Phone: 614-721-2972

Prepared by:

Greg Simonic

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Parma, OH 44130 Phone: 216-267-4800

Application Version 12.0.303 Data Version PRL-29M.044 118-25 M2106 B6.7 Base Spec

06/08/2025 10:41 AM

A proposal for

Prepared by

CLEVELAND FREIGHTLINER, INC.

Jun 08, 2025

Freightliner M2 106 Plus

Components shown may not reflect all spec'd options and are not to scale

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

S P E C I F I C A T I O N P R O P O S A L

Data Code

Description

Weight Front

Weight Rear

Vehicle Configuration

001-172 M2 106 PLUS CONVENTIONAL CHASSIS 5,709 3,450

004-226 2026 MODEL YEAR SPECIFIED

002-004 SET BACK AXLE - TRUCK

019-004 STRAIGHT TRUCK PROVISION, NON-TOWING

(SEE OPTIONS)

003-001 LH PRIMARY STEERING LOCATION

General Service

AA1-002 TRUCK CONFIGURATION

AA6-002 DOMICILED, USA (EXCLUDING CALIFORNIA AND

CARB OPT-IN STATES)

99D-027 EPA CLEAN IDLE LABEL FOR INITIAL

REGISTRATION IN EPA OR ACT STATES -

(INCLUDES 6X4 INCH LABEL ON LOWER

FORWARD OF DRIVER DOOR)

AF2-998 NONE

A85-011 CONSTRUCTION SERVICE

A84-1GM GOVERNMENT BUSINESS SEGMENT

AA4-010 DIRT/SAND/ROCK COMMODITY

AA5-002 TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN

TRANSIT, IS SPENT ON PAVED ROADS

AB1-008 MAXIMUM 8% EXPECTED GRADE

AB5-001 SMOOTH CONCRETE OR ASPHALT PAVEMENT -

MOST SEVERE IN-TRANSIT (BETWEEN SITES)

ROAD SURFACE

995-091 MEDIUM TRUCK WARRANTY

A66-99D EXPECTED FRONT AXLE(S) LOAD : 8000.0 lbs

A68-99D EXPECTED REAR DRIVE AXLE(S) LOAD :

17500.0 lbs

A63-99D EXPECTED GROSS VEHICLE WEIGHT CAPACITY

: 25500.0 lbs

AA3-005 FLATBED/PLATFORM/STAKE BODY

Engine

101-21R CUM B6.7 220 HP @ 2400 RPM, 2600 GOV, 600

LB-FT @ 1600 RPM

Engine Equipment

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

99C-024 EPA 2010/GHG 2024 CONFIGURATION

13E-001 STANDARD OIL PAN

105-001 ENGINE MOUNTED OIL CHECK AND FILL

014-099 SIDE OF HOOD AIR INTAKE WITH FIREWALL

MOUNTED DONALDSON AIR CLEANER

124-1D7 DR 12V 160 AMP 28-SI QUADRAMOUNT PAD

ALTERNATOR WITH REMOTE BATTERY VOLT

SENSE

292-235 (2) DTNA GENUINE, FLOODED STARTING, MIN

2000CCA, 370RC, THREADED STUD BATTERIES

290-017 BATTERY BOX FRAME MOUNTED

281-001 STANDARD BATTERY JUMPERS

282-001 SINGLE BATTERY BOX FRAME MOUNTED LH

SIDE UNDER CAB

291-017 WIRE GROUND RETURN FOR BATTERY CABLES

WITH ADDITIONAL FRAME GROUND RETURN

289-001 NON-POLISHED BATTERY BOX COVER

306-015 PROGRESSIVE LOW VOLTAGE DISCONNECT AT

12.3 VOLTS FOR DESIGNATED CIRCUITS

107-032 CUMMINS TURBOCHARGED 18.7 CFM AIR

COMPRESSOR WITH INTERNAL SAFETY VALVE

108-002 STANDARD MECHANICAL AIR COMPRESSOR

GOVERNOR

131-013 AIR COMPRESSOR DISCHARGE LINE

152-041 ELECTRONIC ENGINE INTEGRAL SHUTDOWN

PROTECTION SYSTEM

128-076 CUMMINS ENGINE INTEGRAL BRAKE WITH

VARIABLE GEOMETRY TURBO ON/OFF

016-106 RH INBOARD FRAME MOUNTED HORIZONTAL

AFTERTREATMENT SYSTEM ASSEMBLY WITH

LH HORIZONTAL TAILPIPE EXITING FORWARD

OF REAR TIRES

-30 -30

28F-014 ENGINE AFTERTREATMENT DEVICE,

AUTOMATIC OVER THE ROAD REGENERATION

AND VIRTUAL REGENERATION REQUEST

SWITCH IN CLUSTER

239-001 STANDARD EXHAUST SYSTEM LENGTH

237-027 LH HORIZONTAL TAILPIPE, EXIT FORWARD OF

REAR TIRES

20 20

23U-001 6 GALLON DIESEL EXHAUST FLUID TANK

30N-003 100 PERCENT DIESEL EXHAUST FLUID FILL

43X-002 LH MEDIUM DUTY STANDARD DIESEL EXHAUST

FLUID TANK LOCATION

23Y-001 STANDARD DIESEL EXHAUST FLUID PUMP

MOUNTING

43Y-001 STANDARD DIESEL EXHAUST FLUID TANK CAP

242-998 NO MUFFLER/TAILPIPE SHIELD -10

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

273-058 AIR POWERED ON/OFF ENGINE FAN CLUTCH

276-001 AUTOMATIC FAN CONTROL WITHOUT DASH

SWITCH, NON ENGINE MOUNTED

110-003 CUMMINS SPIN ON FUEL FILTER

118-001 FULL FLOW OIL FILTER

120-998 NO COOLANT FILTER -10

266-100 700 SQUARE INCH ALUMINUM RADIATOR

103-039 ANTIFREEZE TO -34F, OAT (NITRITE AND

SILICATE FREE) EXTENDED LIFE COOLANT

171-007 GATES BLUE STRIPE COOLANT HOSES OR

EQUIVALENT

172-001 CONSTANT TENSION HOSE CLAMPS FOR

COOLANT HOSES

270-016 RADIATOR DRAIN VALVE

168-002 LOWER RADIATOR GUARD

134-001 ALUMINUM FLYWHEEL HOUSING

132-004 ELECTRIC GRID AIR INTAKE WARMER

155-057 DELCO 12V 29MT STARTER WITH INTEGRATED

MAGNETIC SWITCH

Transmission

342-1MM ALLISON 2200 RDS AUTOMATIC TRANSMISSION

WITH PARK PAWL WITH PTO PROVISION

Transmission Equipment

345-074 DASH MOUNTED T-HANDLE CABLE SHIFT

CONTROL WITH PARK POSITION FOR INTERNAL

PARK PAWL

Front Axle and Equipment

400-1A5 DETROIT DA-F-10.0-3 10,000# FF1 71.5 KPI/3.74

DROP SINGLE FRONT AXLE

402-075 AIR DISC FRONT BRAKES 30

403-002 NON-ASBESTOS FRONT BRAKE LINING

419-004 FRONT DISC BRAKE ROTORS

409-006 FRONT OIL SEALS

408-001 VENTED FRONT HUB CAPS WITH WINDOW,

CENTER AND SIDE PLUGS - OIL

416-022 STANDARD SPINDLE NUTS FOR ALL AXLES

405-030 FRONT AIR DISC BRAKE INTERNAL ADJUSTERS

536-050 TRW THP-60 POWER STEERING

539-003 POWER STEERING PUMP

534-015 2 QUART SEE THROUGH POWER STEERING

RESERVOIR

40T-001 MINERAL SAE 80/90 FRONT AXLE LUBE

Front Suspension

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

620-032 8,000# TAPERLEAF FRONT SUSPENSION -30

619-005 MAINTENANCE FREE RUBBER BUSHINGS -

FRONT SUSPENSION

410-001 FRONT SHOCK ABSORBERS

Rear Axle and Equipment

420-1C6 DETROIT DA-RS-17.5-2 17,500# R-SERIES

SINGLE REAR AXLE

-170

421-478 4.78 REAR AXLE RATIO

424-001 IRON REAR AXLE CARRIER WITH STANDARD

AXLE HOUSING

386-073 MXL 17T MERITOR EXTENDED LUBE MAIN

DRIVELINE WITH HALF ROUND YOKES

423-075 AIR DISC REAR BRAKES -30

433-002 NON-ASBESTOS REAR BRAKE LINING

434-012 BRAKE CAMS AND CHAMBERS ON REAR SIDE

OF DRIVE AXLE(S)

451-005 REAR DISC BRAKE ROTORS

440-006 REAR OIL SEALS

426-1AH AIR DISC LONGSTROKE 1-DRIVE AXLE SPRING

PARKING CHAMBERS

428-030 REAR AIR DISC BRAKE INTERNAL ADJUSTERS

41T-002 CURRENT AVAILABLE SYNTHETIC 75W-90 REAR

AXLE LUBE

Rear Suspension

622-1ME 18,000# 52 INCH VARIABLE RATE MULTI-LEAF

SPRING REAR SUSPENSION WITH LEAF

SPRING HELPER

431-001 STANDARD AXLE SEATS IN AXLE CLAMP

GROUP

Brake System

018-002 AIR BRAKE PACKAGE

490-100 WABCO 4S/4M ABS

871-001 REINFORCED NYLON, FABRIC BRAID AND WIRE

BRAID CHASSIS AIR LINES

904-001 FIBER BRAID PARKING BRAKE HOSE

412-001 STANDARD BRAKE SYSTEM VALVES

46D-002 STANDARD AIR SYSTEM PRESSURE

PROTECTION SYSTEM

413-002 STD U.S. FRONT BRAKE VALVE

432-003 RELAY VALVE WITH 5-8 PSI CRACK PRESSURE,

NO REAR PROPORTIONING VALVE

480-088 WABCO SYSTEM SAVER HP WITH INTEGRAL

AIR GOVERNOR AND HEATER

479-015 AIR DRYER FRAME MOUNTED

460-001 STEEL AIR BRAKE RESERVOIRS

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

477-003 BW DV-2 AUTO DRAIN VALVE WITHOUT HEATER

- WET TANK

Trailer Connections

481-998 NO TRAILER AIR HOSE

476-998 NO AIR HOSE HANGER

310-998 NO TRAILER ELECTRICAL CABLE (SEE

OPTIONS)

Wheelbase & Frame

545-500 5000MM (197 INCH) WHEELBASE

546-094 9/32X3-7/16X10-1/16 INCH STEEL FRAME

(7.14MMX255.6/0.281X10.06 INCH) 80KSI

40 -10

552-037 1775MM (70 INCH) REAR FRAME OVERHANG

553-001 SQUARE END OF FRAME

550-001 FRONT CLOSING CROSSMEMBER

559-001 STANDARD WEIGHT ENGINE CROSSMEMBER

561-001 STANDARD CROSSMEMBER BACK OF

TRANSMISSION

562-001 STANDARD MIDSHIP #1 CROSSMEMBER(S)

572-001 STANDARD REARMOST CROSSMEMBER

565-001 STANDARD SUSPENSION CROSSMEMBER

Chassis Equipment

556-1AN THREE-PIECE 14 INCH STEEL CENTER BUMPER

WITH FLEXIBLE PLASTIC ENDS

574-011 SINGLE LICENSE PLATE BUMPER MOUNTING

ON LH SIDE

585-998 NO MUDFLAP BRACKETS

590-998 NO REAR MUDFLAPS

586-024 FENDER AND FRONT OF HOOD MOUNTED

FRONT MUDFLAPS

551-007 GRADE 8 THREADED HEX HEADED FRAME

FASTENERS

44Z-002 EXTERIOR HARNESSES WRAPPED IN

ABRASION TAPE

Fuel Tanks

204-215 50 GALLON/189 LITER SHORT RECTANGULAR

ALUMINUM FUEL TANK - LH

218-005 RECTANGULAR FUEL TANK(S)

215-005 PLAIN ALUMINUM/PAINTED STEEL

FUEL/HYDRAULIC TANK(S) WITH PAINTED

BANDS

212-007 FUEL TANK(S) FORWARD

664-001 PLAIN STEP FINISH

205-001 FUEL TANK CAP(S)

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

122-1J1 DETROIT FUEL/WATER SEPARATOR WITH

WATER IN FUEL SENSOR, HAND PRIMER AND

12 VOLT PREHEATER"

-5

216-020 EQUIFLO INBOARD FUEL SYSTEM

202-016 HIGH TEMPERATURE REINFORCED NYLON

FUEL LINE

Tires

093-16M 11R22.5 14 PLY RADIAL FRONT TIRES 70

094-12P 11R22.5 14 PLY RADIAL REAR TIRES 92

Hubs

418-060 CONMET PRESET PLUS PREMIUM IRON FRONT

HUBS

450-060 CONMET PRESET PLUS PREMIUM IRON REAR

HUBS

Wheels

502-735 22.5X8.25 10-HUB PILOT 5.79 INSET ALUMINUM

DISC FRONT WHEELS

-64

505-736 22.5X8.25 10-HUB PILOT ALUMINUM DISC REAR

WHEELS

-128

Cab Exterior

829-071 106 INCH BBC FLAT ROOF ALUMINUM

CONVENTIONAL CAB

650-009 RUBBER CAB MOUNTS

678-018 LH AND RH EXTERIOR GRAB HANDLES WITH

SINGLE RUBBER INSERT

646-045 MOLD-IN COLOR GRILLE

65X-011 MOLD-IN COLOR HOOD MOUNTED AIR INTAKE

GRILLE

644-004 FIBERGLASS HOOD

690-998 NO NOISE SHIELD-ENG COMPARTMENT

727-1AF SINGLE 14 INCH ROUND HADLEY AIR HORN

UNDER LH DECK

726-001 SINGLE ELECTRIC HORN

575-001 REAR LICENSE PLATE MOUNT END OF FRAME

312-043 INTEGRAL HEADLIGHT/MARKER ASSEMBLY

302-047 LED AERODYNAMIC MARKER LIGHTS

311-001 DAYTIME RUNNING LIGHTS

294-001 INTEGRAL STOP/TAIL/BACKUP LIGHTS

300-015 STANDARD FRONT TURN SIGNAL LAMPS

744-1BK DUAL WEST COAST MOLDED-IN COLOR

HEATED MIRRORS WITH LH AND RH REMOTE

797-001 DOOR MOUNTED MIRRORS

796-001 102 INCH EQUIPMENT WIDTH

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

743-1AP LH AND RH 8 INCH MOLDED-IN COLOR CONVEX

MIRRORS M0UNTED UNDER PRIMARY

MIRRORS

729-001 STANDARD SIDE/REAR REFLECTORS

677-016 DUAL LEVEL CAB ENTRY STEPS ON BOTH

SIDES

768-043 63X14 INCH TINTED REAR WINDOW

661-003 TINTED DOOR GLASS LH AND RH WITH TINTED

NON-OPERATING WING WINDOWS

654-011 RH AND LH ELECTRIC POWERED WINDOWS

663-013 1-PIECE SOLAR GREEN GLASS WINDSHELD

659-019 2 GALLON WINDSHIELD WASHER RESERVOIR

WITHOUT FLUID LEVEL INDICATOR, FRAME

MOUNTED

Cab Interior

785-025 (1) 12V DASH MOUNTED POWER OUTLET

691-001 FORWARD ROOF MOUNTED CONSOLE

693-019 LH AND RH DOOR STORAGE POCKETS

INTEGRATED INTO MOLDED DOOR PANELS

738-021 DIGITAL ALARM CLOCK IN DRIVER DISPLAY

742-007 (2) CUP HOLDERS LH AND RH DASH

680-029 M2/SD DASH

700-002 HEATER, DEFROSTER AND AIR CONDITIONER

701-001 STANDARD HVAC DUCTING

703-005 MAIN HVAC CONTROLS WITH RECIRCULATION

SWITCH

170-015 STANDARD HEATER PLUMBING

130-041 VALEO HEAVY DUTY A/C REFRIGERANT

COMPRESSOR

702-002 BINARY CONTROL, R-134A

739-033 STANDARD INSULATION

285-013 SOLID-STATE CIRCUIT PROTECTION AND

FUSES

280-007 12V NEGATIVE GROUND ELECTRICAL SYSTEM

324-1B3 STANDARD LED CAB LIGHTING

787-998 NO SECURITY DEVICE

657-1AW ALL UNIT(S) KEYED ALIKE WITH CUSTOMER

SPECIFIED KEY NUMBER FT1010

78G-002 KEY QUANTITY OF 2

655-005 LH AND RH ELECTRIC DOOR LOCKS

740-998 NO MATTRESS -20 -15

756-338 BASIC ISRINGHAUSEN HIGH BACK AIR

SUSPENSION DRIVERS SEAT WTIH

MECHANICAL LUMBAR AND INTEGRATED

CUSHION EXTENSION

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

760-338 BASIC ISRINGHAUSEN HIGH BACK AIR

SUSPENSION PASSENGER SEAT WTIH

MECHANICAL LUMBAR AND INTEGRATED

CUSHION EXTENSION

25 10

759-002 INBOARD DRIVER AND PASSENGER SEAT

ARMRESTS

711-004 LH AND RH INTEGRAL DOOR PANEL ARMRESTS

758-1AK BLACK VINYL DRIVER SEAT COVER

761-1AK BLACK VINYL PASSENGER SEAT COVER

763-101 BLACK SEAT BELTS

532-002 ADJUSTABLE TILT AND TELESCOPING

STEERING COLUMN

540-044 4-SPOKE 18 INCH (450MM) BLACK STEERING

WHEEL WITH SWITCHES

765-002 DRIVER AND PASSENGER INTERIOR SUN

VISORS

Instruments & Controls

106-002 ELECTRONIC ACCELERATOR CONTROL

732-998 NO INSTRUMENT PANEL-DRIVER

734-022 FULLY CONFIGURABLE CENTER INSTRUMENT

PANELS

870-001 BLACK GAUGE BEZELS

486-001 LOW AIR PRESSURE INDICATOR LIGHT AND

AUDIBLE ALARM

840-001 DUAL NEEDLE PRIMARY AND SECONDARY AIR

PRESSURE GAUGE

198-025 INTAKE MOUNTED AIR RESTRICTION

INDICATOR WITHOUT GRADUATIONS

149-015 ELECTRONIC CRUISE CONTROL WITH

CONTROLS ON STEERING WHEEL SPOKES

156-007 KEY OPERATED IGNITION SWITCH AND

INTEGRAL START POSITION; 4 POSITION

OFF/RUN/START/ACCESSORY

811-044 PREMIUM INSTRUMENT CLUSTER WITH 5.0

INCH TFT COLOR DISPLAY

81B-003 DIGITAL PANEL LAMP DIMMER SWITCH IN

DRIVER DISPLAY

844-001 2 INCH ELECTRIC FUEL GAUGE

856-001 ELECTRICAL ENGINE COOLANT TEMPERATURE

GAUGE

864-001 2 INCH TRANSMISSION OIL TEMPERATURE

GAUGE

867-004 ELECTRONIC OUTSIDE TEMPERATURE

SENSOR DISPLAY IN DRIVER MESSAGE

CENTER

830-017 ENGINE AND TRIP HOUR METERS INTEGRAL

WITHIN DRIVER DISPLAY

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

736-998 NO OBSTACLE DETECTION SYSTEM

72J-998 NO DR ASSIST SYSTEM

49B-998 NO VEHICLE STABILITY ADVISOR OR CONTROL

73B-998 NO LANE DEPARTURE WARNING SYSTEM

852-002 ELECTRIC ENGINE OIL PRESSURE GAUGE

679-998 NO OVERHEAD INSTRUMENT PANEL

746-143 7" B-PANEL INTERACTIVE TOUCHSCREEN

DISPLAY RADIO W/ USB-C, APPLE CARPLAY,

ANDROID AUTO, BLUETOOTH/AM/FM/SXM/WB,

WITH MICROPHONE

747-001 DASH MOUNTED RADIO

750-002 (2) RADIO SPEAKERS IN CAB

753-001 AM/FM ANTENNA MOUNTED ON FORWARD LH

ROOF

748-002 POWER AND GROUND STUDS ON TOP OF DASH

749-006 TOP OF DASH MOUNT CB RADIO PROVISION

WITH PLATE AND STRAPS

75W-998 NO MULTIBAND ANTENNA

78C-004 INTEROPERABLE SDAR ANTENNA, SHIP LOOSE

74D-006 STANDARD RADIO WIRING WITH STEERING

WHEEL CONTROLS

810-027 ELECTRONIC MPH SPEEDOMETER WITH

SECONDARY KPH SCALE, WITHOUT

ODOMETER

817-001 STANDARD VEHICLE SPEED SENSOR

812-001 ELECTRONIC 3000 RPM TACHOMETER

813-1C8 DETROIT CONNECT PLATFORM HARDWARE

6TS-005 TMC RP1226 ACCESSORY CONNECTOR

LOCATED BEHIND PASSENGER SIDE

REMOVEABLE DASH PANEL

162-002 IGNITION SWITCH CONTROLLED ENGINE STOP

264-030 (1) OVERHEAD MOUNTED LANYARD CONTROL

FOR DRIVER AIR HORN

883-998 NO TRAILER HAND CONTROL BRAKE VALVE

836-015 DIGITAL VOLTAGE DISPLAY INTEGRAL WITH

DRIVER DISPLAY

660-001 SINGLE ELECTRIC WINDSHIELD WIPER MOTOR

WITH DELAY AND ARCTIC TYPE BLADES

304-030 ROTARY HEADLAMP SWITCH, MARKER

LIGHTS/HEADLIGHTS SWITCH WITH PULL OUT

FOR OPTIONAL FOG/ROAD LAMPS

882-009 ONE VALVE PARKING BRAKE SYSTEM WITH

WARNING INDICATOR

299-020 SELF CANCELING TURN SIGNAL SWITCH WITH

DIMMER, HEADLAMP FLASH,

WASH/WIPE/INTERMITTENT

1620 W BROAD ST

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark Rd

Front

Weight Rear

298-046 INTEGRAL ELECTRONIC TURN SIGNAL

FLASHER WITH 40 AMP (20 AMP PER SIDE)

TRAILER LAMP CAPACITY

87T-998 NO WRG/SW-OPTL #2,CHAS,AIR

Design

065-000 PAINT: ONE SOLID COLOR

Color

980-5F6 CAB COLOR A: L0006EY WHITE ELITE EY

986-020 BLACK, HIGH SOLIDS POLYURETHANE CHASSIS

PAINT

964-6Z7 BUMPER PAINT: FP24812 ARGENT SILVER

DUPONT FLEX

Certification / Compliance

996-001 U.S. FMVSS CERTIFICATION, EXCEPT SALES

CABS AND GLIDER KITS

Extended Warranty

WAI-45C CUM 2017 B6.7: HD1 MD DTY 5 YEARS / 100,000 MILES / 161,000 KM

EXTENDED WARRANTY. FEX APPLIES

WBB-344 TC4: MD MODERATE 5 YEARS/100,000 MILES / 161,000 KM

EXTENDED TRUCK COVERAGE. FEX APPLIES