Aquaphalt_SDS.pdf

RoadStone Production, LLC 1230 River Road, Charlottesville, VA 22901, Tel: 866-784-5031 www.aquaphalt.com

Aquaphalt Safety Data Sheet

SECTION 1: PRODUCT AND COMPANY INFORMATION

GHS product identifier: Cold Asphalt Mix Trade Name: Aquaphalt Premium 0/4.0, 0/6.0, 0/9.0, 0/12.0 Recommended use: Reactively curing, cold applied asphalt mix, free of solvents Emergency phone number

EMERGENCY CONTACT 24 hours:

CHEMTREC 1-800-424-9300

INFORMATION CONTACT: 866-784-5031

Manufacturer

RoadStone Production LLC 1230 River Road

Charlottesville, VA 22901

Revision Issue Date: March, 2020 Supersedes Date: January, 2015

SECTION 2: HAZARDS IDENTIFICATION

Signal Word: Warning

Physical Hazards: Not Classified

Health Hazards: The product is classified as not acute toxic, not sub-acute respectively chronically toxic, and classified as not irritating or sensitizing. Causes mild/moderate eye irritation (tears, blurred vision and redness), prolonged exposure may cause moderate skin irritation. May cause drying/defatting of the skin. Not likely to be toxic if ingested, but may cause irritation of the mouth, throat and stomach. See Section 11 for more information

Pictogram: Not Applicable Precautionary Statements:

Environmental Hazards: Not Classified

R O A D S T O N E

PRODUCTION LLC

Version March 2020 Page 2 of 5 Safety Data Sheet AQUAPHALT 0/4.0, 0/6.0, 0/9.0, 0/12.0, AQUAPHALT SAFETY DATA SHEET, Rev. Date: Mar 2020Page 2 of 5

Chemical family: _Bitumen Asphalt without Solvent_

This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP.

While this material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200), this MSDS contains valuable information critical to the safe handling and proper use of the product. This MSDS should be retained and available for employees and other users of this product.

Potential Environmental Effects: See Section 12 for more information

SECTION 3: COMPOSITION, INFORMATION ON INGREDIENTS

Component CAS # % by Wt.

Mineral aggregates _not applicable_ 92 - 94 Binder _not applicable_ 8 - 6

HAZARDS DISCLOSURE: This product contains no known hazardous materials as defined by the OSHA

Hazard Communication Standard 29 CFR 1910.1200.

SECTION 4: FIRST AID MEASURES

Eye contact: Rinse opened eye for several minutes under running water; consult a physician.

Skin contact: Remove contaminated clothing and wash before reuse. Wash skin with soap and water. Get medical attention if irritation develops.

Inhalation: Not relevant.

Ingestion: Do NOT induce vomiting. Do NOT administer anything by mouth to unconscious person. Offer water to drink. Get medical attention.

Note to Physicians: Not relevant.

SECTION 5: FIRE FIGHTING MEASURES

Suitable Extinguishing Media: Foam, powder, water spray Unsuitable Extinguishing Media: Water stream Products of Combustion: Not applicable Specific firefighting methods: No specific methods required Specific protective devices: Self-contained breathing apparatus Specific hazards: No specific hazards known

Protection of Firefighters: Firefighters should wear self-contained breathing apparatus and full fire-fighting turnout gear.

SECTION 6: ACCIDENTAL RELEASE MEASURES

Personal precautionary measures: No special measures required.

Environmental precautionary measures: Observe usual precautions.

Methods for cleaning up: Collect mechanically.

Other Information: Spills of this material do not need to be reported to the National

Response Center.

SECTION 7: HANDLING AND STORAGE

Handling

Keep away from heat, sparks and flame - do not smoke - Do not get in eyes. Do not breathe vapor. Avoid prolonged contact with skin.

Version March 2020 Page 3 of 5 Safety Data Sheet AQUAPHALT 0/4.0, 0/6.0, 0/9.0, 0/12.0, AQUAPHALT SAFETY DATA SHEET, Rev. Date: Mar 2020Page 3 of 5

Storage

Requirements on storage rooms and containers: Store in weather / sun protected area! Keep container well closed, material cures by exposure to air. Product residue may remain in empty containers. Observe all label precautions until container is cleaned, reconditioned or destroyed.

Information about storage in a common storage facility: Not relevant Further information about storage conditions: Store in weather / sun protected area Storage class according to VCI: Not relevant.

Appropriate application(s): For patching up asphalt and concrete

SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION

Exposure Guidelines Component 1: Not established.

Component 2: Not established.

Engineering measures: No special requirement.

Components with critical values that require inspection at the place of work: The product does not contain any relevant quantities of material with critical values, which have to be monitored at a work place.

Eye/face protection: Not required

Skin protection: Wear suitable work gloves.

Respiratory protection: Not required

General Hygiene Considerations: Wash thoroughly after handling. Have eye-wash facilities immediately available. Do not eat, drink and smoke while working.

SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES

Appearance: black, solid Odor: characteristic Odor threshold: Not available Physical state: mineral – binder - mix pH - value: not relevant Freezing point: not relevant Boiling point: not relevant Flash point: not relevant Flammability: not relevant Upper Flammability Limit: not relevant Lower Flammability Limit: not relevant Vapor pressure at 20 °C/68 °F [mmHg]: not relevant Vapor Density at 25° C [g/ cm3]: 2-2.5 Solubility in water at 20°C/68 °F: not relevant Solubility in fat at 20 °C°C/68 °F: not relevant Auto-ignition Temperature: Not available.

Dynamic viscosity at 20° C°C/68 °F [mPas]: not relevant Percent Volatile, wt. %: _0_ Volatile Organic Compound (VOC) content, wt. %: _0_ Fire promoting properties [°C]: product is not oxidizing Danger of explosion [°C]: product is not explosive

Version March 2020 Page 4 of 5 Safety Data Sheet AQUAPHALT 0/4.0, 0/6.0, 0/9.0, 0/12.0, AQUAPHALT SAFETY DATA SHEET, Rev. Date: Mar 2020Page 4 of 5

SECTION 10: STABILITY AND REACTIVITY

Stability: Stable.

Conditions to avoid: Keep away from heat, sparks and flames.

Incompatible Materials: not relevant Possibility of Hazardous Reactions: Will not occur.

Hazardous Decomposition Products: Not relevant

SECTION 11: TOXICOLOGICAL INFORMATION

No adverse effects are expected if this product is handled in accordance with this Safety Data Sheet and the product label. Symptoms or effects that arise when the product is mishandled or overexposure occurs are:

ACUTE EFFECTS:

The product is classified as not acute toxic.

CHRONIC EFFECTS: *

The product is classified as not sub-acute respectively chronically toxic.

Corrosive or irritant effect or sensitization:

The product is classified as not irritating or sensitizing.

Likely Routes of Exposure: Eye contact, skin contact.

Eye: Causes mild/moderate irritation (tears, blurred vision and redness).

Skin: Prolonged exposure may cause moderate skin irritation. May cause drying/defatting of the skin.

Ingestion: Not likely to be toxic but may cause irritation of the mouth, throat and stomach.

Inhalation: Not relevant

Medical Conditions Aggravated By Exposure:

May cause more significant skin irritation in people with pre-existing skin conditions.

SECTION 12: ECOLOGICAL INFORMATION

Mobility in Environment: Not relevant.

Persistence/ Degradability: Not relevant.

Bioaccumulation/ Accumulation: Not relevant.

Further negative effects: There are no negative effects known.

SECTION 13: DISPOSAL CONSIDERATIONS

Disposal: Dispose of in accordance with federal, state and local regulations. * Packaging: Packaging can be reused or recycled after cleaning. Note local restrictions. *

SECTION 14: TRANSPORT INFORMATION

UN number Not applicable UN Proper shipping name Not applicable Transport Hazard class(es) Not applicable Packing group, if applicable Not applicable Marine pollutant (Y/N) Not available Special precautions: Not available

Version March 2020 Page 5 of 5 Safety Data Sheet AQUAPHALT 0/4.0, 0/6.0, 0/9.0, 0/12.0, AQUAPHALT SAFETY DATA SHEET, Rev. Date: Mar 2020Page 5 of 5

US DOT (ground) Proper Shipping Description: This product is not regulated for shipping by US DOT.

Canadian TDG (ground) Proper Shipping Description: See US DOT

ICAO (air) Proper Shipping Description: See US DOT

IMDG (water)

Proper Shipping Description: See US DOT

ADR/ RID

Proper Shipping Description: See US DOT

ADN/ ADNR

Proper Shipping Description: See US DOT

SECTION 15: REGULATORY INFORMATION

OSHA PROCESS SAFETY (29CFR1910.119): Not regulated.

Inventory Status United States (TSCA): All ingredients are on the inventory or exempt from listing.

SECTION 16: OTHER INFORMATION

NFPA 704: National Fire Protection Association Health – 0 Fire –0 Reactivity –1 0 = minimal hazard, 1 = slight hazard, 2 = moderate hazard, 3 = severe hazard, 4 = extreme hazard

The above SDS complies with OSHA hazard communication standard 29 CFR 1910.1200(g), as revised in 2012.

To the best of our belief, information and knowledge, we believe the information contained in this MSDS to be accurate and reliable as of the date of this Material Safety Data Sheet. The above information is based on information received from raw material suppliers and other sources and references the products as currently formulated. We make no expressed or implied warranty regarding the accuracy or reliability of the data or results obtained from the use of the product and assume no responsibility or liability for personal injury or property damage incurred by the use of these materials due to the fact that the conditions of handling, use, and storage of these materials are beyond our control. Any and all materials should be used with caution and may present unknown hazards. The information and recommendations in this material safety data sheet are offered for the users' consideration and examination. It is each user’s responsibility to determine if the information and data contained herein is suitable and to comply with all applicable international, federal, state, and local laws and regulations.

Modifications compared to a prior version are marked with the star symbol * on the right margin.

Prepared by Reactive Asphalt Distribution LLC (revised by OHK Environmental Consulting, LLC, March 2020)