2-044-26_ODOT_Cascadia__Proposal_10012025.pdf

Prepared For :

Jack Marchbanks

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

S P E C I F I C A T I O N P R O P O S A L Data Code Weight Front Weight RearDescription

Price Level

PRL-30K CASCADIA PRL-30K (EFF:MY27 ORDERS)

Data Version

DRL-007 SPECPRO21 DATA RELEASE VER 007

Vehicle Configuration

001-235 8,955 6,969CASCADIA 126 INCH DAY CAB

004-227 2027 MODEL YEAR SPECIFIED

002-002 SET BACK AXLE - TRACTOR

003-001 LH PRIMARY STEERING LOCATION

General Service

AA1-001 TRACTOR/TRAILER CONFIGURATION

AA6-002 DOMICILED, USA 50 STATES (EPA CLEAN IDLE LABEL

OR NO CLEAN IDLE REQUIRED)

99D-027 EPA CLEAN IDLE LABEL - (INCLUDES 6X4 INCH LABEL

ON LOWER FORWARD OF DRIVER DOOR)

A85-005 LINEHAUL/LONG HAUL SERVICE

A84-1GF GENERAL FREIGHT BUSINESS SEGMENT

AA4-001 GENERAL FREIGHT COMMODITY

AA5-002 TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS

SPENT ON PAVED ROADS

AB1-008 MAXIMUM 8% EXPECTED GRADE

AB5-001 SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST

SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE

995-1AD FREIGHTLINER LEVEL I WARRANTY

A66-99D EXPECTED FRONT AXLE(S) LOAD 14600.0 lbs

A68-99D EXPECTED REAR DRIVE AXLE(S) LOAD 40000.0 lbs

A63-99D EXPECTED GROSS VEHICLE WEIGHT CAPACITY 54600.0

lbs

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

07:57 AM

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

A70-99D EXPECTED GROSS COMBINATION WEIGHT 80000.0 lbs

Truck Service

AF3-2CR TRACTOR ONLY WITH NO BODY UPFIT

Tractor Service

AA2-001 VAN TRAILER

AH6-001 SINGLE (1) TRAILER

Engine

101-3FH -280 -10DETROIT DD13 GEN 5 12.8L 450 HP @ 1625 RPM, 1900

GOV RPM, 1650 LB-FT @ 975 RPM

Electronic Parameters

79A-065 65 MPH ROAD SPEED LIMIT

79B-006 CRUISE CONTROL SPEED LIMIT SAME AS ROAD SPEED

LIMIT, WITH AUTO RESUME AFTER SHIFT

79D-050 1650 RPM LIMIT FOR LOW GEARS, 1650 RPM LIMIT FOR

MIDDLE GEARS, 1650 RPM LIMIT FOR HIGH GEARS

79F-013 FLEET MANAGEMENT - DAILY ENGINE USAGE ENABLED

79G-006 5 MINUTES IDLE SHUTDOWN WITH CLUTCH AND

SERVICE BRAKE OVERRIDE

79K-009 PTO MODE ENGINE RPM LIMIT - 1200 RPM

79P-032 PTO RPM CONTROL WITH STEERING WHEEL SWITCHES

79S-013 PTO MODE CANCEL VEHICLE SPEED - 2 MPH

79T-001 PTO MODE RPM INCREMENT - 25 RPM

79U-002 PTO GOVERNOR RAMP RATE - 50 RPM PER SECOND

79W-011 THREE CLUSTER MENU PTO SPEEDS

79X-005 PTO SPEED 1 SETTING - 900 RPM

79Y-002 PTO SPEED 2 SETTING - 1000 RPM

79Z-024 PTO SPEED 3 SETTING - 1150 RPM

80C-012 ENGINE BRAKE WITH GLOBAL CRUISE CONTROL

ENABLED

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

80G-010 PTO MINIMUM RPM - 625

80L-001 ENABLE AUTO ENGINE RPM ELEVATE FOR EXTENDED

IDLE

80S-001 PTO 1, DASH SWITCH, STATIONARY OPERATION

80W-001 MAINTENANCE SYSTEM WITH NO POP-UPS AND NO

MENU IN CLUSTER

Engine Equipment

99C-024 EPA 2010/GHG 2024 CONFIGURATION

13E-001 STANDARD OIL PAN

105-001 ENGINE MOUNTED OIL CHECK AND FILL

014-1CT DUAL SIDE OF HOOD AIR INTAKE WITH ENGINE

MOUNTED AIR CLEANER

124-1D7 DR 12V 160 AMP 28-SI QUADRAMOUNT PAD

ALTERNATOR WITH REMOTE BATTERY VOLT SENSE

292-214 (4) DTNA GENUINE, FLOODED STARTING AND CYCLING,

MIN 2800CCA, 760RC, THREADED STUD BATTERIES

290-1D3 STEEL BATTERY BOX WITH ENCLOSED TRAY

282-001 SINGLE BATTERY BOX FRAME MOUNTED LH SIDE

UNDER CAB

291-017 WIRE GROUND RETURN FOR BATTERY CABLES WITH

ADDITIONAL FRAME GROUND RETURN

289-013 POLISHED DIAMOND PLATE BATTERY BOX COVER

293-998 NO BATTERY SHUTOFF SWITCH

306-015 PROGRESSIVE LOW VOLTAGE DISCONNECT AT 12.3

VOLTS FOR DESIGNATED CIRCUITS

180-1AP DETROIT HEAVY DUTY AUTOMATED MANUAL

TRANSMISSION CLUTCH

107-046 BW MODEL FE-921 19.0 CFM SINGLE CYLINDER AIR

COMPRESSOR WITH SAFETY VALVE

108-002 STANDARD MECHANICAL AIR COMPRESSOR

GOVERNOR

131-013 AIR COMPRESSOR DISCHARGE LINE

152-041 ELECTRONIC ENGINE INTEGRAL SHUTDOWN

PROTECTION SYSTEM

128-002 JACOBS COMPRESSION BRAKE

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

016-1C3 RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL

AFTERTREATMENT SYSTEM ASSEMBLY WITH RH

HORIZONTAL TAILPIPE

28F-014 ENGINE AFTERTREATMENT DEVICE, AUTOMATIC OVER

THE ROAD REGENERATION AND VIRTUAL

REGENERATION REQUEST SWITCH IN CLUSTER

239-001 STANDARD EXHAUST SYSTEM LENGTH

237-052 RH STANDARD HORIZONTAL TAILPIPE

23U-002 13 GALLON DIESEL EXHAUST FLUID TANK

30N-003 100 PERCENT DIESEL EXHAUST FLUID FILL

23Z-001 15 5POLISHED ALUMINUM DIAMOND PLATE DIESEL

EXHAUST FLUID TANK COVER

43X-001 LH HEAVY DUTY STANDARD DIESEL EXHAUST FLUID

TANK LOCATION

43Y-001 STANDARD DIESEL EXHAUST FLUID TANK CAP

242-998 NO MUFFLER/TAILPIPE SHIELD

273-058 AIR POWERED ON/OFF ENGINE FAN CLUTCH

276-001 AUTOMATIC FAN CONTROL WITHOUT DASH SWITCH,

NON ENGINE MOUNTED

110-068 DDC SUPPLIED ENGINE MOUNTED FUEL FILTER/FUEL

WATER SEPARATOR WITH WATER-IN-FUEL INDICATOR

118-001 FULL FLOW OIL FILTER

120-998 -10NO COOLANT FILTER

266-1C1 1400 SQUARE INCH FUEL ECONOMY RADIATOR

103-039 ANTIFREEZE TO -34F, OAT (NITRITE AND SILICATE

FREE) EXTENDED LIFE COOLANT

171-007 GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT

172-001 CONSTANT TENSION HOSE CLAMPS FOR COOLANT

HOSES

261-001 STANDARD CHARGE AIR COOLER PLUMBING

269-001 STANDARD RADIATOR MOUNTING

270-020 HDEP VARIABLE SPEED COOLANT PUMP WITH

COOLANT FILL/EVACUATION QUICK CONNECT ON

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

RADIATOR

168-002 LOWER RADIATOR GUARD

134-001 ALUMINUM FLYWHEEL HOUSING

155-076 -45DELCO 12V MOD 3.175-39MT+ STARTER WITH ENGINE

ECU SOFTWARE PROTECTION AND INTEGRATED

MAGNETIC SWITCH

Transmission

342-2AV DT12-1650-OH ON-HIGHWAY 12-SPEED OVERDRIVE

AUTOMATED MANUAL TRANSMISSION

Transmission Equipment

343-2BH DT12 ECONOMY PACKAGE: ECONOMY ONLY, NO ICU

CONTROL MENUS, NO KICKDOWN

84D-007 12 FORWARD GEARS SELECTABLE DT12 MANUAL

MODE

85G-000 MAXIMUM OUTPUT SPEED FOR PTO ENGAGEMENT 25

RPM

85J-004 REVERSE GEAR RANGE LIMITED TO 2ND GEAR

85P-002 DT12 REAR PTO HIGH SPEED RATIO

347-002 ALUMINUM CLUTCH HOUSING

362-825 25CUSTOMER INSTALLED DT12 REAR MOUNTED PTO FOR

CUSTOMER INSTALLED HYDRAULIC PUMP

363-004 PTO MOUNTING, REAR OF MAIN TRANSMISSION

DETROIT & EATON FULLER

341-017 MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION FILL

AND DRAIN, AXLE(S) FILL AND DRAIN

345-078 HEAVY DUTY ELECTRONIC TRANSMISSION SHIFT

CONTROL, COLUMN MOUNTED

370-002 15AIR TO OIL TRANSMISSION COOLER

368-998 -2NO EXTERNAL TRANSMISSION OIL FILTER

35T-003 SYNTHETIC TRANSMISSION LUBE

Front Axle and Equipment

400-1A8 10DETROIT DA-F-14.7-3 14,700# FF1 71.5 KPI/3.74 DROP

SINGLE FRONT AXLE

402-109 MERITOR EX+LS AXIAL AIR DISC FRONT BRAKES

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

403-043 2011/2013-FMVSS 121 RSD FRONT BRAKE LINING

419-004 FRONT DISC BRAKE ROTORS

409-006 FRONT OIL SEALS

408-001 VENTED FRONT HUB CAPS WITH WINDOW, CENTER

AND SIDE PLUGS - OIL

416-022 STANDARD SPINDLE NUTS FOR ALL AXLES

405-030 FRONT AIR DISC BRAKE INTERNAL ADJUSTERS

536-012 40TRW TAS-85 POWER STEERING

539-003 POWER STEERING PUMP

534-015 2 QUART SEE THROUGH POWER STEERING

RESERVOIR

40T-002 CURRENT AVAILABLE SYNTHETIC 75W-90 FRONT AXLE

LUBE

Front Suspension

620-010 10514,600# TAPERLEAF FRONT SUSPENSION

619-005 MAINTENANCE FREE RUBBER BUSHINGS - FRONT

SUSPENSION

410-001 FRONT SHOCK ABSORBERS

Rear Axle and Equipment

420-324 DETROIT DA-RT-40.0-4T HH 40,000# R-SERIES TANDEM

REAR AXLE WITH AXLE LUBRICATION MANAGEMENT

(ALM 2.0)

421-308 3.08 REAR AXLE RATIO

424-001 IRON REAR AXLE CARRIER WITH STANDARD AXLE

HOUSING

386-067 RPL25SD MERITOR MAIN DRIVELINE

388-039 RPL20 MERITOR INTERAXLE DRIVELINE

878-019 (1) INTERAXLE LOCK VALVE FOR TANDEM OR TRIDEM

DRIVE AXLES

87A-012 INDICATOR LIGHT FOR EACH INTERAXLE LOCKOUT

SWITCH WITH IAD FEEDBACK

423-109 MERITOR EX+LS AXIAL AIR DISC REAR BRAKES

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

97E-002 DEALER/CUSTOMER ALLOWS DTNA TO CHOOSE

BRAKES/BRAND TO MAINTAIN BUILD SCHEDULE

433-043 2011/2013-FMVSS 121 RSD REAR BRAKE LININGS

434-003 STANDARD BRAKE CHAMBER LOCATION

451-005 REAR DISC BRAKE ROTORS

440-006 REAR OIL SEALS

426-1AH AIR DISC LONGSTROKE 1-DRIVE AXLE SPRING

PARKING CHAMBERS

428-030 REAR AIR DISC BRAKE INTERNAL ADJUSTERS

41T-002 CURRENT AVAILABLE SYNTHETIC 75W-90 REAR AXLE

LUBE

42T-001 STANDARD REAR AXLE BREATHER(S)

Rear Suspension

622-218 70AIRLINER 40,000# EXTRA DUTY REAR SUSPENSION

621-118 7.9 INCH NOMINAL RIDE HEIGHT (415MM GLOBAL

REFERENCE HEIGHT)

431-005 RESTRAINED AXLE SEATS IN AXLE CLAMP GROUP

624-016 51 INCH AXLE SPACING

888-047 MANUAL DUMP VALVE FOR AIR SUSPENSION WITHOUT

GAUGE

87D-007 INDICATOR LIGHT AND BUZZER FOR EACH REAR

SUSPENSION CONTROL SWITCH

910-001 SINGLE AIR REAR SUSPENSION LEVELING VALVE

623-002 TRANSVERSE CONTROL RODS

439-005 20REAR SHOCK ABSORBERS - TWO AXLES (TANDEM) (AIR

RIDE SUSPENSION)

Pusher / Tag Equipment

429-998 NO PUSHER/TAG BRAKE DUST SHIELDS

Brake System

490-115 WABCO 6S/4M ABS WITH HILL START AID AND

TRACTION CONTROL WITH ATC SHUT OFF SWITCH

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

871-001 REINFORCED NYLON, FABRIC BRAID AND WIRE BRAID

CHASSIS AIR LINES

904-001 FIBER BRAID PARKING BRAKE HOSE

412-001 STANDARD BRAKE SYSTEM VALVES

413-002 STD U.S. FRONT BRAKE VALVE

432-003 RELAY VALVE WITH 5-8 PSI CRACK PRESSURE, NO

REAR PROPORTIONING VALVE

480-088 WABCO SYSTEM SAVER HP WITH INTEGRAL AIR

GOVERNOR AND HEATER

483-004 WABCO OIL COALESCING FILTER FOR AIR DRYER

479-015 AIR DRYER FRAME MOUNTED

460-001 STEEL AIR BRAKE RESERVOIRS

46A-998 -10 -15NO AUXILIARY AIR TANK

2TD-001 (1) 620 CUBIC INCH ALUMINUM TRANSMISSION AIR

TANK, INLET CHECK VALVE

477-004 PULL CABLES ON ALL AIR RESERVOIR(S)

Trailer Connections

481-003 1012 FOOT STRAIGHT TRAILER AIR HOSE

476-002 36 INCH STAINLESS STEEL SLIDE BAR WITH SPRING

TYPE AIR HOSE HANGER

484-032 COMBINATION DUMMY GLAD HANDS AND LIGHT PLUG

HOLDER MOUNTED LH BACK OF CAB WITH GROUND

ACCESS

297-027 SAE J560 7-WAY PRIMARY TRAILER CABLE

RECEPTACLE MOUNTED LOWER LH BACK OF CAB

296-010 PRIMARY CONNECTOR/RECEPTACLE WIRED FOR

SEPARATE STOP/TURN, ABS CENTER PIN POWERED

THROUGH IGNITION

310-002 12 FOOT DETACHABLE STRAIGHT PRIMARY TRAILER

ELECTRICAL CABLE WITH SAE J560 CONNECTOR

Wheelbase & Frame

545-487 4875MM (192 INCH) WHEELBASE

546-1C2 150 508.0MM X 88.0MM X 281.0MM STEEL FRAME

(0.31X3.46X11.06 INCH) 120 KSI

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

552-024 1350MM (53 INCH) REAR FRAME OVERHANG

55W-005 FRAME OVERHANG RANGE: 51 INCH TO 60 INCH

AC8-99D CALC'D BACK OF CAB TO REAR SUSP C/L (CA) 116.93 in

AE8-99D CALCULATED EFFECTIVE BACK OF CAB TO REAR

SUSPENSION C/L (CA) 111.34 in

AE4-99D CALC'D FRAME LENGTH - OVERALL 278.14 in

FSS-0LH CALCULATED FRAME SPACE LH SIDE 1.29 in

FSS-0RH CALCULATED FRAME SPACE RH SIDE 59.56 in

AM6-99D CALC'D SPACE AVAILABLE FOR DECKPLATE 46.65 in

560-008 UNDER OR OVERSLUNG CROSSMEMBER

553-002 FLANGED TAPERED END OF FRAME

550-001 FRONT CLOSING CROSSMEMBER

559-003 LIGHTWEIGHT HEAVY DUTY ALUMINUM ENGINE

CROSSMEMBER

562-001 STANDARD MIDSHIP #1 CROSSMEMBER(S)

572-001 STANDARD REARMOST CROSSMEMBER

565-002 30HEAVY DUTY SUSPENSION CROSSMEMBER

Chassis Equipment

674-001 LH BACK OF CAB ACCESS

592-053 14 INCH (350MM) DECK PLATE FLUSH MOUNTED

BETWEEN RAILS

556-079 SOLID DARK GRAY AERODYNAMIC BUMPER

574-007 BUMPER MOUNTING FOR (3) LICENSE PLATES

585-042 BETTS B-25 PAINTED MUDFLAP BRACKETS

590-001 BLACK MUDFLAPS

586-015 FRONT ANTI-SPRAY CAB MOUNTED MUDFLAPS

551-002 HUCK-SPIN ROUND COLLAR CHASSIS FASTENERS

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

44Z-002 EXTERIOR HARNESSES WRAPPED IN ABRASION TAPE

489-998 NO TIRE PRESSURE CONTROL/SENSOR

Fifth Wheel

578-1W7 FONTAINE 6000 SERIES 6NWB 12.0 INCH AIR SLIDE

FIFTH WHEEL

577-305 FIFTH WHEEL 305MM (12.0 INCHES) AHEAD OF

SUSPENSION CENTERLINE

582-013 171MM (6.75 INCH) FIFTH WHEEL HEIGHT

570-001 STEEL OUTBOARD ANGLE - FIFTH WHEEL MOUNTING

890-001 DASH MOUNTED CONTROL AND PLUMBING FOR FIFTH

WHEEL

579-003 SIDE LEFT FIFTH WHEEL RELEASE

Fuel Tanks

206-998 -85 -30NO RH FUEL TANK

204-156 10100 GALLON/378 LITER ALUMINUM FUEL TANK - LH

218-006 25 INCH DIAMETER FUEL TANK(S)

215-005 PLAIN ALUMINUM/PAINTED STEEL FUEL/HYDRAULIC

TANK(S) WITH PAINTED BANDS

212-008 FUEL TANK(S) AFT

664-001 PLAIN STEP FINISH

205-001 FUEL TANK CAP(S)

216-020 EQUIFLO INBOARD FUEL SYSTEM

202-016 HIGH TEMPERATURE REINFORCED NYLON FUEL LINE

221-998 -10NO FUEL COOLER

Tires

093-994 50MICHELIN XZE 12R22.5 16 PLY RADIAL FRONT TIRES

094-2DE 160MICHELIN X MULTI ENERGY D 11R22.5 14 PLY RADIAL

REAR TIRES

Hubs

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

418-058 CONMET PRESET PLUS PREMIUM ALUMINUM FRONT

HUBS

450-058 CONMET PRESET PLUS PREMIUM ALUMINUM REAR

HUBS

Wheels

502-1HB -62ALCOA 88167X 22.5X8.25 10-HUB 5.81 INSET ALUMINUM

DISC FRONT WHEELS

505-1HB -248ALCOA 88167X 22.5X8.25 10-HUB PILOT ALUMINUM DISC

REAR WHEELS

50U-020 16FLOW BELOW MOLD IN COLOR GRANITE GRAY

AERODYNAMIC REAR AXLE WHEEL COVERS WITH

LOCK, SHIP LOOSE

50W-998 NO RIM/WHEEL TIRE PRESSURE SENSOR

496-011 FRONT WHEEL MOUNTING NUTS

497-011 REAR WHEEL MOUNTING NUTS

Cab Exterior

829-111 126 INCH BBC ALUMINUM CONVENTIONAL CAB

653-004 RH CAB DOOR(S) WITH 70 DEGREE DOOR STOP

651-004 LH CAB DOOR(S) WITH 70 DEGREE DOOR STOP

784-998 NO AIR SHIELD OR BRACKETS

783-998 NO SIDE EXTENDERS

782-998 NO FRAME SIDE FAIRINGS

779-998 NO FORWARD CHASSIS FAIRING SUPPORT

770-998 NO AERODYNAMIC SKIRT FOR CHASSIS FAIRINGS

650-008 AIR CAB MOUNTING

648-002 NONREMOVABLE BUGSCREEN MOUNTED BEHIND

GRILLE

695-998 -15NO SLEEPER DOOR

678-053 INTERIOR LH AND RH A PILLAR GRAB HANDLES

646-045 MOLD-IN COLOR GRILLE

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

65X-004 BLACK HOOD MOUNTED AIR INTAKE GRILLE

644-001 AERODYNAMIC HOOD

67U-002 HOOD OPENING ASSIST

652-026 CASCADIA NAMEPLATE

727-1AH SINGLE 14 INCH ROUND POLISHED AIR HORN ROOF

MOUNTED

726-001 SINGLE ELECTRIC HORN

575-001 REAR LICENSE PLATE MOUNT END OF FRAME

312-075 LED LOW BEAM AND HIGH BEAM HEADLIGHTS

302-072 ROOF MOUNTED LED MARKER LIGHTS

311-001 DAYTIME RUNNING LIGHTS

294-071 TRUCK-LITE SERIES 60 LED STOP/TAIL WITH SEPARATE

BACKUP LIGHTS

300-043 LED SIDE TURN SIGNAL

318-1F6 -3(1) FLUSH LED UTILITY LIGHT MOUNTED LH BACK OF

CAB/SLEEPER

744-1E4 DUAL BLACK HEATED AERODYNAMIC MIRRORS WITH

INTEGRAL CONVEX AND LH AND RH REMOTE

797-001 DOOR MOUNTED MIRRORS

74A-001 RH DOWN VIEW MIRROR

729-001 STANDARD SIDE/REAR REFLECTORS

73A-002 REAR REFLECTIVE DEVICE

677-055 RH AFTERTREATMENT SYSTEM CAB ACCESS WITH

POLISHED DIAMOND PLATE COVER

275-061 PARK BRAKE REMINDER WARNING SYSTEM

776-998 -10NO SLEEPER VENT

768-059 (2) 28X22 INCH SOLAR TINTED REAR WINDOWS

661-016 SOLAR TINTED DOOR GLASS LH AND RH WITH TINTED

FORWARD SIDE GLASS

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

654-011 4RH AND LH ELECTRIC POWERED WINDOWS

663-019 1-PIECE ROPED-IN SOLAR GREEN GLASS WINDSHIELD

659-007 8 LITER (2 GAL) WINDSHIELD WASHER RESERVOIR, CAB

MOUNTED, WITHOUT FLUID LEVEL INDICATOR

Cab Interior

707-114 MIDNIGHT BASE LEVEL INTERIOR

70K-024 MIDNIGHT WITH ONYX HARD TRIM

706-034 STANDARD LH DOOR TRIM

708-034 STANDARD RH DOOR TRIM

772-001 BLACK MATS

785-021 (2) DASH MOUNTED POWER OUTLETS, LIGHTER AND

ASH TRAY

691-001 FORWARD ROOF MOUNTED CONSOLE

693-019 LH AND RH DOOR STORAGE POCKETS INTEGRATED

INTO MOLDED DOOR PANELS

741-015 (2) COAT HOOKS ON BACKWALL OF CAB

745-998 -50 -50NO UPPER BUNK

738-021 DIGITAL ALARM CLOCK IN DRIVER DISPLAY

680-036 WING DASH WITH E-VAULT

700-014 HEATER, DEFROSTER AND AIR CONDITIONER WITH

CONSTANT OUTLET TEMPERATURE CONTROL

701-002 HVAC DUCTING WITH MAIN FRESH AIR FILTER

703-005 MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH

170-015 STANDARD HEATER PLUMBING

130-041 VALEO HEAVY DUTY A/C REFRIGERANT COMPRESSOR

698-001 RADIATOR MOUNTED AIR CONDITIONER CONDENSER

702-002 BINARY CONTROL, R-134A

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

739-033 STANDARD INSULATION

285-013 SOLID-STATE CIRCUIT PROTECTION AND FUSES

280-007 12V NEGATIVE GROUND ELECTRICAL SYSTEM

324-1B3 STANDARD LED CAB LIGHTING

787-004 REMOTE KEYLESS ENTRY AND 2 TRANSMITTERS

657-001 DOOR LOCKS AND IGNITION SWITCH KEYED THE SAME

78G-002 KEY QUANTITY OF 2

655-028 LH AND RH ELECTRIC DOOR LOCKS WITH AUTO

UNLOCK FEATURE WHEN DOOR IS SET FROM OPEN TO

CLOSED POSITION

64C-003 BLACK DOOR HANDLES

740-998 -20 -15NO MATTRESS

284-998 NO POWER SUPPLY SLEEPER/CAB

710-998 NO CAB PRIVACY CURTAIN

756-1J5 BASIC 2.0 HIGH BACK AIR SUSPENSION DRIVER SEAT

WITH 1 CHAMBER AIR LUMBAR, INTEGRATED CUSHION

EXTENSION AND TILT

760-1J4 BASIC 2.0 HIGH BACK NON SUSPENSION PASSENGER

SEAT

758-036 VINYL WITH VINYL INSERT DRIVER SEAT

761-036 VINYL WITH VINYL INSERT PASSENGER SEAT

763-1AD 3 POINT ADJUSTABLE D-RING RETRACTOR DRIVER AND

FIXED D-RING RETRACTOR PASSENGER SEAT BELTS

WITH DRIVER SEAT BELT STATUS INDICATOR LIGHT

AND AUDIBLE ALARM

532-002 20ADJUSTABLE TILT AND TELESCOPING STEERING

COLUMN

540-044 4-SPOKE 18 INCH (450MM) BLACK STEERING WHEEL

WITH SWITCHES

765-002 DRIVER AND PASSENGER INTERIOR SUN VISORS

Instruments & Controls

106-004 ELECTRONIC ACCELERATOR CONTROL WITH KICK

DOWN FEATURE

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

734-018 STANDARD CENTER INSTRUMENT PANEL

870-001 BLACK GAUGE BEZELS

486-001 LOW AIR PRESSURE INDICATOR LIGHT AND AUDIBLE

ALARM

840-001 DUAL NEEDLE PRIMARY AND SECONDARY AIR

PRESSURE GAUGE

198-025 INTAKE MOUNTED AIR RESTRICTION INDICATOR

WITHOUT GRADUATIONS

149-045 ELECTRONIC CRUISE CONTROL WITH INTELLIGENT

POWERTRAIN MANAGEMENT AND CONTROLS ON

STEERING WHEEL SPOKES

156-007 KEY OPERATED IGNITION SWITCH AND INTEGRAL

START POSITION; 4 POSITION

OFF/RUN/START/ACCESSORY

811-044 PREMIUM INSTRUMENT CLUSTER WITH 5.0 INCH TFT

COLOR DISPLAY

81B-003 DIGITAL PANEL LAMP DIMMER SWITCH IN DRIVER

DISPLAY

160-038 HEAVY DUTY ONBOARD DIAGNOSTICS INTERFACE

CONNECTOR LOCATED BELOW LH DASH

844-001 2 INCH ELECTRIC FUEL GAUGE

845-011 FUEL FILTER RESTRICTION INDICATOR

148-085 EMISSIONS LIMITED IDLE ADJUST

856-001 ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE

854-008 DIGITAL ENGINE OIL TEMPERATURE IN DRIVER

DISPLAY

867-004 ELECTRONIC OUTSIDE TEMPERATURE SENSOR

DISPLAY IN DRIVER MESSAGE CENTER

830-017 ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN

DRIVER DISPLAY

372-123 PTO CONTROLS FOR ENHANCED VEHICLE

ELECTRIC/ELECTRONIC ARCHITECTURE

736-140 DETROIT ASSURANCE, ACTIVE BRAKE ASSIST 5, WITH

ADAPTIVE CRUISE CONTROL TO 0 MPH AND FIXED

HEADWAY

73K-002 10DETROIT SIDE GUARD ASSIST

72J-001 SIDE GUARD ASSIST AND TRAFFIC SIGN DISPLAY

VIRTUAL OFF SWITCHES

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

49B-004 ELECTRONIC STABILITY CONTROL

14L-001 DETROIT SERVICE BRAKE HOLD FUNCTION

73B-031 10DETROIT LANE DEPARTURE WARNING SYSTEM WITH 15

MINUTE OFF TIMEOUT DASH SWITCH

73U-001 TRAFFIC SIGN DISPLAY

852-002 ELECTRIC ENGINE OIL PRESSURE GAUGE

746-143 7" B-PANEL INTERACTIVE TOUCHSCREEN DISPLAY

RADIO W/ USB-C, APPLE CARPLAY, ANDROID AUTO,

BLUETOOTH/AM/FM/SXM/WB, WITH MICROPHONE

747-001 DASH MOUNTED RADIO

750-041 STANDARD SPEAKER SYSTEM

753-998 NO AM/FM RADIO ANTENNA

748-006 POWER AND GROUND WIRING PROVISION OVERHEAD

749-001 ROOF/OVERHEAD CONSOLE CB RADIO PROVISION

752-044 SINGLE LH CB ANTENNA

75W-002 SHARKFIN MULTI-BAND ANTENNA, RIGHT HAND BIAS

ROOF MOUNTING LOCATION: AM/FM/WEATHERBAND,

WIFI/BLUETOOTH, SDAR/SIRIUSXM, GNSS/GPS

78C-003 INTEROPERABLE SDAR ANTENNA

810-027 ELECTRONIC MPH SPEEDOMETER WITH SECONDARY

KPH SCALE, WITHOUT ODOMETER

817-001 STANDARD VEHICLE SPEED SENSOR

812-032 ELECTRONIC 2500 RPM TACHOMETER

813-1C8 DETROIT CONNECT PLATFORM HARDWARE

8D1-215 5 YEARS DETROIT CONNECT BASE

PACKAGE(FEATURES VARY BY MODEL) DETROIT

CONNECT PLATFORM

8D3-165 5 YEARS DETROIT CONNECT SAFETY PLUS FOR

DETROIT ASSURANCE FOR GEN 4, PLUS SERIES AND X-

SERIES BEGINNING IN MY2027

6TS-012 (3) TMC RP 1226 ACCESSORY CONNECTORS: (2)

LOCATED BEHIND PASSENGER SIDE REMOVABLE DASH

PANEL, AND (1) LOCATED CENTER OF OVERHEAD

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Data Code Weight Front Weight RearDescription

CONSOLE

162-002 IGNITION SWITCH CONTROLLED ENGINE STOP

81Y-005 PRE-TRIP INSPECTION FEATURE FOR EXTERIOR LAMPS

ONLY

264-033 STEERING WHEEL MOUNTED ELECTRIC HORN

CONTROL

482-001 STANDARD TRACTOR PROTECTION VALVE

883-001 TRAILER HAND CONTROL BRAKE VALVE

836-015 DIGITAL VOLTAGE DISPLAY INTEGRAL WITH DRIVER

DISPLAY

660-008 SINGLE ELECTRIC WINDSHIELD WIPER MOTOR WITH

DELAY

304-056 AUTOMATIC WIPERS/HEADLAMPS, INTELLIGENT HIGH-

BEAM

882-021 TWO VALVE PARKING BRAKE SYSTEM WITH DASH

VALVE CONTROL AUTONEUTRAL AND WARNING

INDICATOR

299-028 MANUAL TURN SIGNAL SWITCH WITH DIMMER,

HEADLAMP FLASH, WASH/WIPE/INTERMITTENT

298-046 INTEGRAL ELECTRONIC TURN SIGNAL FLASHER WITH

40 AMP (20 AMP PER SIDE) TRAILER LAMP CAPACITY

Design

065-000 PAINT: ONE SOLID COLOR

Color

980-5F6 CAB COLOR A: L0006EY WHITE ELITE EY

986-020 BLACK, HIGH SOLIDS POLYURETHANE CHASSIS PAINT

Certification / Compliance

996-001 U.S. FMVSS CERTIFICATION, EXCEPT SALES CABS AND

GLIDER KITS

Secondary Factory Options

998-998 DEALER ACCEPTS RESPONSIBILITY FOR IN-SERVICE

PDI INSPECTION

999-061 MUST MEET REQUIREMENTS IN PTO INSTALLATION

GUIDELINE DOCUMENT ON DDCSN.COM, SPECIFICALLY

MAX BENDING MOMENT & MIN ENGINE SPEED DURING

PTO OPERATION

T O T A L V E H I C L E S U M M A R Y

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025

OHIO DOT

1980 W BROAD ST FL 1

COLUMBUS, OH 43223

UNITED STATES

Phone :6144667170

2700 NE PLAIN CITY - GEORGESVILLE RD

Prepared by:

Jonah Schneider

WEST JEFFERSON, OH 43162

Phone :6148510002

FYDA FREIGHTLINER COLUMBUS,INC

Weight Summary

Weight Rear

Total Weight

Weight Front

Factory Weight+ 15779 lbs6952 lbs8827 lbs

Total Weight+ 8827 lbs 6952 lbs 15779 lbs

Other Factory Charges

RD1-215 5 YEARS DETROIT CONNECT BASE PACKAGE(FEATURES VARY BY

MODEL) DETROIT CONNECT PLATFORM

RD3-165 5 YEARS DETROIT CONNECT SAFETY PLUS FOR DETROIT ASSURANCE

FOR GEN 4, PLUS SERIES, AND X-SERIES BEGINNING IN MY2027

PAT-024 STEEL, ALUMINUM, AND CHINA TARIFF IMPACT FEE OHWY

R27-001 MY27 ESCALATOR

P73-2FT STANDARD DESTINATION CHARGE

(**) Prices shown do not include taxes, fees, etc… "Net Equipment Selling Price" is located on the Quotation Details Proposal Report.

(***) All cost increases for major components (Engines, Transmissions, Axles, Front and Rear Tires) and government mandated requirements, tariffs, and raw material surcharges will be passed through and added to factory invoices.

(+) Weights Shown are estimates only.

If weight is critical, contact Customer Application Engineering.

044-26 ODOT Cascadia

Application Version 12.0.404

Data Version PRL-30K.007

10/01/2025