1-Biorestor_Asphalt_Rejuvenator_Emulsifiable_Concentrate_SDS_March2024_v2__1_.pdf

BioBased Spray Systems, LLC 2506 Fair Rd

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 1 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

SECTION 1. IDENTIFICATION

Product identifier used on the label

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Other means of identification Not available.:

Asphalt rejuvenator Professional use only See manufacturers specifications

Recommended use of the chemical and restrictions on use

Chemical family : Terpene/oleo polymer blend

Name, address, and telephone number of the supplier:

Name, address, and telephone number of the manufacturer:

BioBased Spray Systems, LLC Refer to supplier

2506 Fair Rd Sidney, OH, USA 45365-7523

(937) 498 9803 (8 a.m. - 5 p.m. EST) www.Biorestor.com

:Supplier's Telephone #

24 Hr. Emergency Tel # : Chemtrec: 1-800-424-9300 (Within Continental U.S.); 703-527-3887.

SECTION 2. HAZARDS IDENTIFICATION

Classification of the chemical

Clear,colorless to pale yellow liquid.

This material is classified as hazardous under U.S. OSHA regulations (29CFR 1910.1200) (Hazcom 2012) and Canadian WHMIS regulations (Hazardous Products Regulations) (WHMIS 2015).

Classification

Skin Irritation - Category 2 Skin sensitization - Category 1A Serious eye damage/eye irritation - Category 2A

Label elements

Hazard pictogram(s)

Signal Word

Warning!

Hazard statement(s)

Causes skin irritation.

May cause an allergic skin reaction.

Causes serious eye irritation.

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 2 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

Precautionary statement(s)

Avoid breathing fumes, mists or vapors.

Wash hands and face thoroughly after handling.

Contaminated work clothing must not be allowed out of the workplace.

Wear protective gloves/eye protection/face protection.

IF ON SKIN: Wash with plenty of soap and water.

Take off contaminated clothing and wash before re-use.

If skin irritation or rash occurs: Get medical advice/attention.

IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.

Continue rinsing.

If eye irritation persists: get medical advice/attention.

Dispose of in accordance with local regulations.

Other hazards

Other hazards which do not result in classification: Burning produces obnoxious and toxic fumes. Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea.

Environmental precautions: Avoid release to the environment. See ECOLOGICAL INFORMATION, Section 12.

SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS

Mixture

CAS # Chemical name Concentration (% by weight) Common name and synonyms

138-86-3Dipentene 10.0 - 30.0Not available.

ProprietarySurfactant ProprietaryProprietary

The exact concentrations of the above listed chemicals are being withheld as a trade secret.

SECTION 4. FIRST-AID MEASURES

Description of first aid measures

IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. Rinse mouth.Do NOT induce vomiting.Never give anything by mouth to an unconscious person. If vomiting occurs spontaneously, keep victim's head lowered (forward) to reduce the risk of aspiration.

:Ingestion

If inhaled: Remove person to fresh air and keep comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell.

:Inhalation

IF ON SKIN: Wash with plenty of soap and water. Take off contaminated clothing and wash before re-use. If skin irritation or rash occurs: Get medical advice/attention.

Skin contact :

IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: get medical advice/attention.

Eye contact :

Most important symptoms and effects, both acute and delayed

Causes skin irritation. Symptoms may include redness, blistering, pain and swelling.

Causes serious eye irritation. Symptoms may include tearing, redness and discomfort.

May cause an allergic skin reaction (e.g. swelling, rash and eczema).

Indication of any immediate medical attention and special treatment needed

Treat symptomatically.:

SECTION 5. FIRE-FIGHTING MEASURES

Extinguishing media

Suitable extinguishing media

Dry chemical, foam, carbon dioxide and water fog.

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 3 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

Unsuitable extinguishing media

Do not use a solid water stream as it may scatter and spread fire.

Closed containers may build up pressure when exposed to heat and flame.:

Special hazards arising from the substance or mixture / Conditions of flammability

Flammability classification (OSHA 29 CFR 1910.106)

: Not flammable.

Carbon monoxide, carbon dioxide, reactive hydrocarbons, aldehydes and other irritant gases, which may include toxic constituents.

Hazardous combustion products

Special protective equipment and precautions for firefighters Protective equipment for fire-fighters

: Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA.

Firefighters should wear proper protective equipment and self-contained breathing apparatus with full face piece operated in positive pressure mode.

Special fire-fighting procedures

Move containers from fire area if safe to do so. Cool closed containers exposed to fire with water spray.Prevent runoff from fire control or dilution from entering sewers, drains, drinking water supply or any natural waterway. Dike for water control.

Evacuate personnel to safe areas. Keep all other personnel upwind and away from the spill/release. All persons dealing with clean-up should wear the appropriate protective equipment including self-contained breathing apparatus. Restrict access to area until completion of clean-up. Refer to protective measures listed in sections 7 and 8.

Personal precautions, protective equipment and emergency procedures

SECTION 6. ACCIDENTAL RELEASE MEASURES

Ensure spilled product does not enter drains, sewers, waterways, or confined spaces.

If necessary, dike well ahead of the spill to prevent runoff into drains, sewers, or any natural waterway or drinking supply.

Environmental precautions :

Ventilate the area. Remove all sources of ignition. Prevent further leakage or spillage if safe to do so. Use only non-sparking tools. Bond and ground transfer containers and equipment to avoid static accumulation. For spilled liquids: absorb spill with inert, non-combustible material such as sand, then place into suitable containers. Do not use combustible absorbents, such as sawdust. Pick up and transfer to properly labeled containers. Contaminated absorbent material may pose the same hazards as the spilled product. Contact the proper local authorities.

Methods and material for containment and cleaning up

Special spill response procedures

: If a spill/release in excess of the EPA reportable quantity is made into the environment, immediately notify the National Response Center in the United States (phone:

1-800-424-8802).

Use only outdoors or in a well-ventilated area. Keep away from flames and hot surfaces. - No smoking. Wear protective gloves/clothing and eye/face protection.

Avoid breathing fumes, mists or vapors. Do not eat, drink or smoke when using this product. Do not ingest. Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. Avoid contact with incompatible materials.

Precautions for safe handling

SECTION 7. HANDLING AND STORAGE

:Conditions for safe storage Store in a well ventilated place. Keep cool. Keep container tightly closed. Store locked

up. Store away from incompatibles and out of direct sunlight.Storage area should be clearly identified, clear of obstruction and accessible only to trained and authorized personnel. Inspect periodically for damage or leaks. No smoking in the area.

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 4 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

:Incompatible materials Strong oxidizing agents; Acids

SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Exposure Limits:

Chemical Name

STELPELSTELTWA

ACGIH TLV OSHA PEL

Dipentene N/AvN/AvN/AvN/Av

Surfactant N/AvN/AvN/AvN/Av

Exposure controls

Ventilation and engineering measures

: Use only outdoors or in a well-ventilated area. Apply technical measures to comply with the occupational exposure limits. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. Use non-sparking equipment. In case of insufficient ventilation wear suitable respiratory equipment.

Respiratory protection : If engineering controls and work practices are not effective in controlling exposure to this material, then wear suitable approved respiratory protection. If the TLV is exceeded, a NIOSH/MSHA-approved respirator is advised. Respirators should be selected based on the form and concentration of contaminants in air, and in accordance with OSHA (29 CFR 1910.134) or CSA Z94.4-02.

Wear protective gloves. Where extensive exposure to product is possible, use resistant coveralls, apron and boots to prevent contact. The suitability for a specific workplace should be discussed with the producers of the protective gloves.

:Skin protection

Wear eye/face protection. Wear safety glasses with side shields ( or goggles).:Eye / face protection

Other protective equipment : Ensure that eyewash stations and safety showers are close to the workstation location.

Other equipment may be required depending on workplace standards.

General hygiene considerations

: Avoid breathing fumes, mists or vapors. Avoid contact with skin, eyes and clothing. Do not eat, drink, smoke or use cosmetics while working with this product. Upon completion of work, wash hands before eating, drinking, smoking or use of toilet facilities. Remove and wash contaminated clothing before re-use.Handle in accordance with good industrial hygiene and safety practice.

Clear colorless to pale yellow liquid.:Appearance

SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES

:Odour Characteristic odor.

Odour threshold : N/Av

:pH N/Av

7.2°C:Melting Point/Freezing point

Initial boiling point and boiling range

Flash point

Flashpoint (Method)

: 100°C

: 119°C

: Tag closed cup

<1:Evaporation rate (BuAe = 1)

Flammability (solid, gas) : N/Ap

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 5 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

Lower flammable limit (% by vol.)

: N/Av

N/Av:

Upper flammable limit (% by vol.)

None.:Oxidizing properties

Explosive properties : Not explosive

: N/AvVapour pressure

: N/AvVapour density

: 7.1-7.3 lbs/gal

Relative density / Specific gravity

Solubility in water N/Av:

Other solubility(ies) : N/Av

Partition coefficient: n-octanol/water or Coefficient of water/oil distribution

N/Av:

N/Av:Auto-ignition temperature

Decomposition temperature : N/Av N/AvViscosity :

>10%Volatiles (% by weight) :

Volatile organic Compounds (VOC's)

N/Av Absolute pressure of container

: N/Ap

Flame projection length : N/Ap

None reported by the manufacturer.:

Other physical/chemical comments

Not normally reactive.

SECTION 10. STABILITY AND REACTIVITY

:Reactivity

Stable under normal conditions.:Chemical stability

Possibility of hazardous reactions : No dangerous reaction known under conditions of normal use.

: Avoid heat and open flame. Keep away from direct sunlight. Ensure adequate ventilation, especially in confined areas. Avoid contact with incompatible materials.

Conditions to avoid

Incompatible materials : Strong oxidizing agents, Acids

Carbon oxides

Hazardous decomposition products

:Routes of entry inhalation

Information on likely routes of exposure:

SECTION 11. TOXICOLOGICAL INFORMATION

YES

:Routes of entry skin & eye YES

:Routes of entry Ingestion YES

Routes of exposure skin absorption

NO

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 6 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

Sign and symptoms Inhalation

Mild respiratory irritant

Potential Health Effects:

Signs and symptoms of short-term (acute) exposure

Sign and symptoms ingestion

Ingestion may irritate digestive tract and cause nausea, vomiting and diarrhea.

:Sign and symptoms skin Causes skin irritation. Symptoms may include redness, blistering, pain and swelling.

:Sign and symptoms eyes Causes serious eye irritation. Symptoms may include tearing, redness and discomfort.

None known or reported by the manufacturer.:

Potential Chronic Health Effects

Mutagenicity : Not expected to be mutagenic in humans.

Carcinogenicity : Not classifiable as a human carcinogen.

Reproductive effects & Teratogenicity

: Not expected to cause reproductive effects.

Sensitization to material : Not expected to be a skin sensitizer.

Not expected to be a respiratory sensitizer.

Specific target organ effects : According to the classification criteria of U.S. OSHA regulations (29CFR 1910.1200) (Hazcom 2012) and Canadian WHMIS regulations (Hazardous Products Regulations) (WHMIS 2015), this product is not expected to cause target organ toxicity through single or repeated exposures.

Medical conditions aggravated by overexposure

: Pre-existing skin, eye, respiratory and central nervous system disorders.

Synergistic materials : None reported by the manufacturer.

There is no available data for the product itself, only for the ingredients. See below for individual ingredient acute toxicity data.

The calculated ATE values for this mixture are:

ATE oral = >5000mg/kg ATE dermal = >5000mg/kg ATE inhalation (vapours) =>50 mg/L See below for individual ingredient acute toxicity data.

Toxicological data :

LD50LC50(4hr) inh, ratChemical name (Rabbit, dermal)(Oral, rat)

Dipentene N/Av 5300 mg/kg N/Av

Surfactant Not available. 1378mg/kg >2000mg/kg

Other important toxicological hazards : None known or reported by the manufacturer.

SECTION 12. ECOLOGICAL INFORMATION

Ecotoxicity Not expected to be harmful to aquatic organisms. See the following tables for individual ingredient ecotoxicity data.

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 7 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

Ecotoxicity data:

NOEC / 21 dayLC50 / 96h M Factor

Toxicity to Fish CAS #Ingredients

Dipentene 80 mg/L138-86-3 N/Av None.

Surfactant 8.5mg/LProprietary Not available. Not available.

CAS #Ingredients Toxicity to Daphnia

EC50 / 48h NOEC / 21 day M Factor

138-86-3 None. N/Av17 mg/LDipentene

Proprietary Not available.Not available.5.3mg/LSurfactant

CAS #Ingredients Toxicity to Algae

EC50 / 96h or 72h NOEC / 96h or 72h M Factor

138-86-3Dipentene N/Av N/Av None.

ProprietarySurfactant Not available. Not available. Not available.

No data is available on the product itself.

Persistence and degradability

Bioaccumulation potential : No data is available on the product itself. See the following data for ingredient information.

Components Partition coefficient n-octanol/water (log Kow) Bioconcentration factor (BCF)

:Mobility in soil No data is available on the product itself.

The ecological characteristics of this product have not been fully investigated.

Other Adverse Environmental effects

SECTION 13. DISPOSAL CONSIDERATIONS

Handle in accordance with good industrial hygiene and safety practice. Refer to protective measures listed in sections 7 and 8.

:Handling for Disposal

Dispose in accordance with all applicable federal, state, provincial and local regulations.

:Methods of Disposal

:RCRA If this product, as supplied, becomes a waste in the United States, it may meet the criteria of a hazardous waste as defined under RCRA, Title 40 CFR 261. It is the responsibility of the waste generator to determine the proper waste identification and disposal method.

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 8 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

SECTION 14. TRANSPORT INFORMATION

Regulatory Information UN Number UN proper shipping name

Packing Group

Label Transport hazard class(es)

Not regulated. not regulated49CFR/DOT None. none

Additional information

None.49CFR/DOT

Not regulated. not regulatedTDG None none

Additional information

This product meets the criteria for an environmentally hazardous material according to the IMDG Code.TDG

Not regulated. not regulatedIMDG None. none

Additional information

None.IMDG

Not regulated. not regulatedICAO/IATA None. none

Additional information

None.ICAO/IATA

: Keep away from flames and hot surfaces. - No smoking.Special precautions for user

Environmental hazards : This product does not meet the criteria for an environmentally hazardous mixture, according to the IMDG Code. See ECOLOGICAL INFORMATION, Section 12.

Not available.:

Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code

Components listed below are present on the following U.S. Federal chemical lists:

US Federal Information:

SECTION 15 - REGULATORY INFORMATION

Ingredients CAS #

TSCA

Inventory

CERCLA

Reportable

Quantity(RQ) (40

CFR 117.302):

SARA TITLE III:

Sec. 302, Extremely Hazardous

Substance, 40

CFR 355:

SARA TITLE III: Sec. 313, 40 CFR 372, Specific Toxic Chemical

Toxic Chemical de minimus

Concentration

Dipentene 138-86-3 N/Ap N/Av N/ApYes No

Surfactant Proprietary None. None. N/ApYes No

SARA TITLE III: Sec. 311 and 312, SDS Requirements, 40 CFR 370 Hazard Classes: Flammable; Skin sensitization;

Skin irritation ; Eye irritation;

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 9 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

The following chemicals are specifically listed by individual States:

US State Right to Know Laws:

Ingredients CAS # California Proposition 65

Listed Type of Toxicity

State "Right to Know" Lists

CA RIMA PAMN NJ

138-86-3Dipentene No No No No Yes No NoN/Ap

ProprietarySurfactant No No No No No No NoN/Ap

California Proposition 65: Methanol

Canadian Environmental Protection Act (CEPA) information: All ingredients listed appear on the Domestic Substances List (DSL).

Canadian Information:

Components listed below are present on the following International Inventory list:

International Information:

CAS #Ingredients European EINECs

Australia

AICS

Philippines

PICCS

Japan ENCS Korea

KECI/KECL

China

IECSC

NewZealand

IOC

Dipentene 138-86-3 205-341-0 Present Present (7)-988; (3)-2245;

(3)-2226

HSR001142KE-24396 Present

Surfactant Proprietary Present Present Present Present PresentPresent Present

ACGIH: American Conference of Governmental Industrial Hygienists AICS: Australian Inventory of Chemical Substances CAS: Chemical Abstract Services CERCLA: Comprehensive Environmental Response, Compensation, and Liability Act of 1980 CSA: Canadian Standards Association DOT: Department of Transportation EC50: Effective Concentration 50% ENCS: Existing and New Chemical Substances EPA: Environmental Protection Agency IARC: International Agency for Research on Cancer IMDG: International Maritime Dangerous Goods KECI: Korean Existing Chemicals Inventory KECL: Korean Existing Chemicals List LC: Lethal Concentration /LD: Lethal Dose N/Ap: Not Applicable / N/Av: Not Available NIOSH: National Institute of Occupational Safety and Health NTP: National Toxicology Program NOEC: No observable effect concentration NTP: National Toxicology Program OECD: Organisation for Economic Co-operation and Development OSHA: Occupational Safety and Health Administration PEL: Permissible exposure limit PICCS: Philippine Inventory of Chemicals and Chemical Substances SARA: Superfund Amendments and Reauthorization Act

:Legend

SECTION 16. OTHER INFORMATION

Sidney, OH, USA, 45365-7523 Telephone: (937) 498 9803

BIORESTOR®

Asphalt Rejuvenator Emulsifiable Concentrate

Page 10 of 10SDS Preparation Date (mm/dd/yyyy): 03/25/2024

SAFETY DATA SHEET

STEL: Short Term Exposure Limit TDG: Canadian Transportation of Dangerous Goods Act & Regulations TLV: Threshold Limit Values TPQ: Threshold Planning Quantity TSCA: Toxic Substance Control Act TWA: Time Weighted Average

1. ACGIH, Threshold Limit Values for Chemical Substances and Physical Agents & Biological Exposure Indices

2. ECHA - European Chemical Agency

3. Canadian Centre for Occupational Health and Safety, CCInfoWeb databases

4. Safety Data Sheets from manufacturer.

5. US EPA Title III List of Lists

6. California Proposition 65 List

7. OECD - The Global Portal to Information on Chemical Substances - eChemPortal

References :

Preparation Date (mm/dd/yyyy)

: 03/25/2024 Other special considerations for handling

: Provide adequate information, instruction and training for operators.

Prepared by:

ICC The Compliance Center Inc.

Telephone: (888) 442-9628 (U.S.): (888) 977-4834 (Canada) http://www.thecompliancecenter.com

Prepared for:

BioBased Spray Systems, LLC 2506 Fair Rd Sidney, OH 45365-7523

(937) 498 9803

DISCLAIMER

The information in the Safety Data Sheet is offered for your consideration and guidance when exposed to this product BioBased Spray Systems, LLC, Inc expressly disclaim all expressed or implied warranties and assume no responsibilities for the accuracy or completeness of the data contained herein. The data in this SDS does not apply to use with any other product or in any other process.This Safety Data Sheet may not be changed, or altered in any way without the expressed knowledge and permission of BioBased Spray Systems, LLC

END OF DOCUMENT

http://www.thecompliancecenter.com