Lap Products Hydropac Pouch Machine and Maintenance
Added: Apr 06, 2016 2:44 pm INTRODUCTIONTHIS IS A PRE-SOLICITATION NON-COMPETITIVE (NOTICE OF INTENT) SYNOPSIS TO AWARD A PURCHASE ORDER WITHOUT PROVIDING FOR FULL AND OPEN COMPETITION (INCLUDING BRAND-NAME).The National Heart, Lung, and Blood Institute (NHLBI), Office of Acquisitions (OA) on behalf of The National Institute of Dental and Craniofacial Reseach (NIDCR) intends to negotiate and award a Purchase Order without providing for full and open competition (Including brand-name) to Lab Products for maintenance services for the NIDCR owned Hydropac® AWS 2500 and to procure one Lab Products Hydropac® AWS 2500 Pouch Machine with the associated maintenance plan.NORTH AMERICAN INDUSTRY CLASSIFICATION SYSTEM (NAICS) CODEThe intended procurement is classified under NAICS code 811219, Other Electronic and Precision Equipment Repair and Maintenance, with a Size Standard of $20.5M.REGULATORY AUTHORITYThe resultant Purchase Order will include all applicable provisions and clauses in effect tough the Federal Acquisition Circular (FAC) 05-87 effective 07 MAR 2016.This acquisition is conducted under the procedures as prescribed in FAR subpart 13-Simplified Acquisition Procedures at an amount not exceeding the simplified acquisition teshold ($150,000).STATUTORY AUTHORITYThis acquisition is conducted under the authority of the Federal Acquisition Regulation (FAR) Part 13-Simplified Acquisition Procedures, Subpart 13.106-1 (b) (1), Soliciting from a single source and is not expected to exceed the simplified acquisition teshold. Contracts awarded using FAR Part 13-Simplified Acquisition Procedures are exempt from the requirements of FAR Part 6-Competition Requirements. FAR Subpart 6.302-1-Only one responsible source and no other supplies or services will satisfy agency requirements 41 U.S.C. 253(c)(1), provides the authority to sole source.DESCRIPTION OF REQUIREMENTBackground The National Institute of Health (NIH) is the nation's leading medical research agency and the primary Federal agency conducting, supporting and making medical discoveries that improve people's health and save lives. The mission of the National Institute of Dental and Craniofacial Research (NIDCR) is to improve dental, oral, and craniofacial health tough research, research training, and the dissemination of health information. The function of the Veterinary Resources Core (VRC) is to provide husbandry, veterinary care, research technical support, assistance in the writing of Animal Study Protocols, and education and assistance regarding interpretations of animal use regulations, and health and safety policies. The VRC owns a Hydropac® AWS 2500 machine and requires a maintenance service plan to ensure its continued operation.Purpose and ObjectivesThe purpose of this acquisition is to procure a maintenance service plan for the NIDCR owned Hydropac® AWS 2500. The maintenance plan will ensure the machine will continue to provide highly filtered water to the VRC rodent population.Period of PerformanceBase Year: May 4th, 2016 - May 3rd, 2017Option Year 1: May 4th, 2017 - May 3rd, 2018Option Year 2: May 4th, 2018 - May 3rd, 2019Option Year 3: May 4th, 2019 - May 3rd, 2020Option Year 4: May 4th, 2020 - May 3rd, 2021Performance LocationNational Institutes of Health, NIDCR9000 Rockville Pike Building 30Bethesda, MD 20892Project DescriptionContractor Tasks/Deliverables:1) Contractor shall deliver one (1) Lab Products Hydropac® AWS 2500 pouch machine with the associated maintenance plan to NIH/NIDCR.2) Contractor shall perform not less than 4 preventative maintenance inspection(s) during the contract period. Service shall be performed by factory trained Field Service representatives. Service shall consist of a thorough cleaning, calibration, adjusting, inspection, lubrication and testing of all equipment in accordance with the manufacturer's latest established service procedures. All equipment shall be operationally tested tough at least one (1) complete operating cycle at the end of the preventive maintenance inspection to assure optimum and efficient performance.3) Upon each regularly scheduled visit the contractor shall visually inspect, test, and make any needed adjustments to:a. SAFETY GUARDS: includingi. Door, Latches & Hingesii. Rear Guardsiii. Light Curtainiv. Heater Guardsb. HEATER BAR: includingi. Clean Knifeii. Clean Horizontal Heater Bariii. Heater Bar Secure & Alignediv. Mandrel Tape & Siliconev. Heater Bar Linesvi. Vertical Tapevii. Horizontal Front Tapeviii. Horizontal Rear Tapeix. Clean Vertical Heater Barc. FILM FEED: includingi. Brake Assemblyii. Roller 1-9iii. Film Roll Shaftiv. Film Alignment Wheel Assemblyv. Forming Headvi. Fill Tube Counter Stopvii. Film Advance Assemblyd. PNEUMATICS: includingi. Hose Connectionsii. Cylindersiii. Valve Island (PSI)iv. Safety Valvev. Moisture Filtervi. Hose Connectionsvii. Moisture Trapviii. Condensation Drain Valvese. GENERAL: includingi. Cooling Fansii. Solenoid Connectionsiii. Castersiv. Pouch Diverterv. Cabinet Conditionf. PLUMBING: includingi. Water Supply Hoseii. Water Supplyiii. Large / 13 Oz. Volume ___iv. Small / 8 Oz. Volume ___4) During the PM visit the contractor shall replace the following parts, as required:a. 584030 SILICONE SEAL STRIP.250X.483 Extruded SLC x 8.813 2b. 770606 Gasket Strip 1/4" x 1/2" SIL 70 DUR x 36" Long Piece * 3FT.c. 770926 5.0MILX2"Pres Sens Adh Teflon Tape x 18 Yard Roll * 3FT.d. 95670308 P/L HP Replacement Filter 1e. 641060 AIR COMPRESSOR INTAKE MUFFLER 2f. 730887 Hdwe Bronze Flange Bushing 2g. 730888 Hdwe Bronze Bushing 1h. 730889 Hdwe Bronze Bushing 1i. A610028 Tust Washer Side Seal Arm 15) The contractor shall not be responsible for any repairs necessitated by abuse, neglect, vandalism, Acts of God, fire or water. These repairs shall be the subject of a separate purchase order and shall not be performed under this contract.Contractor Requirements1) Personnel shall be factory trained and have experience in the servicing aforementioned instrument. All primary service personnel shall have at least one backup Field Service representative with at least the same level of expertise on the equipment covered by this contract.2) Equipment diagnosis shall be provided within two (2) hours and on site repair within two (2) days.CONTRACTING WITHOUT PROVIDING FOR FULL OR OPEN COMPETITION (INCLUDING BRAND-NAME) DETERMINATIONOnly one source is available: The determination by the Government to make a single-sole source is based upon the market research conducted as prescribed in FAR Part 10-Market Research, specifically the results of the market research concluded that Lab Products is the sole provider of maintenance for the AWS 2500 Pouch Machine. Lab Products is the Original Equipment Manufacturer (OEM) of the federally trademarked Hydropac AWS 2500. As the OEM, Lab Products provides unique characteristics client choice contractors cannot provide, most notably the ability to provide technicians specifically trained on the required equipment, OEM repair parts without a maximum dollar teshold, and on-site maintenance calls within 48 hours. Due to these unique characteristics, Lab Products is the only responsible source for the AWS 2500 maintenance.CLOSING STATEMENTThis synopsis is not a request for competitive proposals. However, interested parties may identify their interest and capability to respond to this notice. Responses to this notice shall contain sufficient information to establish the interested parties' bona-fide capabilities for fulfilling the requirement and include: unit price, list price, shipping and handling costs, the delivery period after contract award, the prompt payment discount terms, the F.O.B. Point (Destination or Origin), the Dun & Bradstreet Number (DUNS), the Taxpayer Identification Number (TIN), and the certification of business size. All offerors must have an active registration in the System for Award Management (SAM) www.sam.gov."A determination by the Government not to compete this proposed contract based upon responses to this notice is solely within the discretion of the Government. The information received will normally be considered solely for the purposes of determining whether to proceed on a non-competitive basis or to conduct a competitive procurement.All responses must be received by April 18th, 2016 9:00 AM EST and must reference number NHLBI-CSB-DE-2016-112-RSF. Responses may be submitted electronically to Rashida Ferebee, ferebeers@nhlbi.nih.gov, or by U.S. mail to the National Heart, Lung, and Blood Institute, Office of Acquisitions, COAC Services Branch,6701 Rockledge Drive, Suite 6142, Bethesda, MD 20892-7902, Attention: Rashida Ferebee. Fax responses will not be accepted."All responsible sources may submit a capability statement, proposal, or quotation, which shall be considered by the agency." NHLBI-CSB-DE-2016-112-RSF Department of Health and Human Services National Institutes of Health
4/6/16, 2:44 PM