Booster_Pumps_Combo.doc

Combined Synopsis/Solicitation

(IAW FAR 12.603)

Solicitation Number: FA8126-19-Q-9072 Booster Pumps

This is a combined synopsis/solicitation for commercial items prepared in accordance with the format in Subpart 12.6, as supplemented with additional information included in this notice. This announcement constitutes the only solicitation; quotes are being requested and a written solicitation will not be issued.

This soliciation is being issued as a request for quotation (RFQ) IAW FAR Part 13.

This solicitation document and incorporated provisions and clauses are those in effect through the Federal Acquisition Circular (FAC) 2019-01, Defense Federal Acquisition Regulation Supplement Change Notice (DPN) 20190215, and Air Force Acquisition Circular (AFAC) 2018-0525.

The Air Force Sustainment Center (AFSC/PZIMB) at Tinker Air Force Base Oklahoma, intends to award one firm fixed price contract for the acquisition of material listed below.

(100% Small Business set-aside)

NAICS Code: 333914 Size Standard: 750 Contract Line Items (CLINs):

Note: All CLINs are Firm Fixed Price (FFP)

Contractor is required to provide commercial product literature for all items quoted

Model Number: HVL4D3-10SV11GJ4F60-6GD with RS485 BMS

Model Number: HVL3D2-5SV18GH4F60-4GD with RS485 BMS

Part Number: WTA-449

Description of Items:

CLIN 0001

Two (2) Xylem Goulds Pump Aquaforce e-HV Series Booster Pump or equivalent

(a) Model Number: HVL4D3-10SV11GJ4F60-6GD with RS485 BMS or equivalent

(b) Quantity: Two (2)

(c) The booster pump must meet the following requirements:

· Four vertically assembled multistage centrifugal pumps in parallel with pump split 25/25/25/25, (Lead + Lag 1 + Lag 2 + Lag 3)

· Stainless steel: pump body, impeller, diffuser, casing, and shaft; Stainless steel pedestal and base mounted

· Voltage 460/3/60, 3500rpm,

· Working liquid temperature 32F-180F

· Each single pump with Hydrovar VFD

· Electric disconnect panel with pump circuit breakers

· Discharge transducers (1ea/VFD)

· Low Water Pressure Switch, Isolation Butterfly Valves, Wafer Check Valve

· Pressure gauge for suction and discharge manifolds

· Duty Point Flow rate 220 GPM @ 465 ft Head

· Max. Operating Pressure 270 psi

· Single Pump 10HP

· Single Pump Total Impeller Stages =11, 2 Pole

· Prem-TEFC Pump Motor Enclosure

· Built-in protection for motor and inverter over temperature

· Overall Assembly Dimension 60”L x 40”D x 60”H

· RS-485 Communication, Bacnet, RTU, ASCII for Full Integration Into Building Management System (Communication Protocol)

· VFD Schematic Diagram and Installation & Operation Manual

CLIN 0002

One (1) Xylem Goulds Pump Aquaforce e-HV Series Booster Pump or equivalent

(a) Model Number: HVL3D2-5SV18GH4F60-4GD with RS485 BMS or equivalent

(b) Quantity: One (1)

(c) The booster pump must meet the following requirements:

· Three vertically assembled multistage centrifugal pumps in parallel with pump split 33/33/33, (Lead + Lag 1 + Lag 2)

· Stainless steel: pump body, impeller, diffuser, casing, and shaft; Stainless steel pedestal and base mounted

· Dia. 2” Header Stainless Steel Suction and Discharge Manifolds w/ Victaulic end

· Voltage 460/3/60, 3500rpm

· Working Liquid Temperature 32F-180F

· Each Single Pump with Hydrovar VFD

· Electric Disconnect Panel with Pump Circuit Breakers

· Discharge Transducers (1ea/VFD)

· Low Water Pressure Switch

· Isolation Ball Valves

· Silent Check Valve

· Pressure gauge for suction and discharge manifolds

· Duty Point Flow rate 95 GPM @ 460 ft Head

· Max. Operating Pressure 270 psi

· Single Pump 7.5HP

· Single Pump Total Impeller Stages =18, 2 Pole

· Prem-TEFC Pump Motor Enclosure

· Built-in protection for motor and inverter over temperature

· Overall Assembly Dimension 44”L x 40”D x 60”H

· RS-485 Communication, Bacnet, RTU, ASCII for Full Integration Into Building Management System (Communication Protocol)

· VFD Schematic Diagram and Installation & Operation Manual

CLIN 0003

One (1) Xylem Bell & Gossett ASME Bladder Expansion Tank or equivalent

(a) Part Number: WTA-449

(b) Quantity: One (1)

(c) The expansion tank must meet the following requirements:

· ASME Code Vertical Bladder Expansion Tank with ASME data plate

· Factory Pre-Charged

· Operating temperature up to 300F

· Heavy duty diaphragm

· Tank Material of construction - Carbon Steel

· Charging Valve

· Working Pressure 300 psi rating

· Tank volume 132 gallon

· Tank Acceptance factor 0.65

· Tank Size: Max. 85” Height, Max. 24" Diameter

· Dia. 2" System Connection

· Exterior Finish Gray Powder Paint Delivery Information:

30 Days ARO FOB Destination to Tinker AFB, OK 73145; Shipping must be included in price.

NET 30

Terms and Conditions Please note full text of the Federal Acquisition Regulation (FAR) can be accessed on the internet at: http://www.farsite.hill.af.mil, http://farsite.hill.af.mil/vfdfara.htm, http://farsite.hill.af.mil/vmaffara.htm FAR 52.212-1. Instructions to Offerors – Instructions to Offerors -- Commercial, applies to this acquisition.

FAR 52.212-2 Evaluation Commercial items, Evaluation -- Commercial Items, (a) The Government will award a contract resulting from this solicitation to the responsible offeror whose offer conforming to the solicitation will be most advantageous to the Government, price and other factors considered. The following factors shall be used to evaluate offers:

PRICE

* All quotes will be evaluated only by price and adherence to the solicitation. The lowest priced quote will be evaluated for adherence on an acceptable/unacceptable basis. If the lowest priced quote is found to be in compliance with the solicitation, then no further evaluations will be conducted and award will be made. If the lowest priced quote is not in adherence to the solicitation, the next lowest priced quote will be evaluated, and so on until a technically acceptable quote is found.

52.212-3 -- Offeror Representations and Certifications -- Commercial Items.

The offeror shall complete only paragraphs (b) of this provision if the Offeror has completed the annual representations and certification electronically via the System for Award Management (SAM) Web site located at http://www.sam.gov/portal (Only complete and return if there are changes to current SAM Registration. If 52.212-3 is not returned the contractor is affirming that the current SAM registration is current, accurate, and complete). If the Offeror has not completed the annual representations and certifications electronically, the Offeror shall complete only paragraphs (c) through (u) of this provision.

52.212-4, Contract Terms and Conditions -- Commercial Items, applies to this acquisition.

52.212-5, Contract Terms and Conditions Required to Implement Statues or Executive Orders—Commercial Items, applies to this acquisition.

The following clauses/provisions within 52.212-5 are included but not limited to:

52.204-10, Reporting Executive Compensation and First-Tier Subcontract

52.209-6, Protecting the Government's Interest When Subcontracting with Contractors Debarred, Suspended, or Proposed for Debarment 52.219-6, Notice of Total Small Business Set-Aside

52.219-13, Notice of Set-Aside of Orders

52.219-28, Post Award Small Business Program Representation

52.222-3, Convict Labor

52.222-19, Child Labor—Cooperation with Authorities and Remedies 52.222-21, Prohibition of Segregated Facilities 52.222-26, Equal Opportunity

52.222-36, Equal Opportunity for Workers with Disabilities

52.222-40, Notification of Employee Rights Under the National Labor Relations

52.222-50, Combating Trafficking in Persons

52.223-11, Ozone-Depleting Substances and High Global Warming Potential Hydrofluorocarbons

52.223-18, Encouraging Contractor Policies to Ban Text Messaging While

52.225-1, Buy American—Supplies 52.225-3, Buy American Free Trade Agreements—Israeli Trade Act

52.225-13, Restrictions on Certain Foreign Purchases The following DFARS clauses/provisions are included but not limited to:

252.203-7000, Requirements Relating to Compensation of Former DoD Officials

252.203-7005, Representation Relating to Compensation of Former DoD Officials 252.204-7011, Alternative Line Item Structure 252.204-7012, Safeguarding Covered Defense Information and Cyber Incident Reporting 252.204-7015, Notice of Authorized Disclosure of Information for Litigation Support 252.223-7008, Prohibition of Hexavalent Chromium 252.232-7003, Electronic Submission of Payment Requests and Receiving Reports

252.232-7006, Wide Area Workflow Payment Instructions Standard Commercial warranties apply.

Contact Information Quotations are due by: 3 July 2019, by 2:00pm Central Standard Time (CST). Contact the following individual for information regarding this solicitation:

Ms. Jaqueline Hughes, Contract Specialist, (405) 739-3962 jaqueline.hughes@us.af.mil Mr. James Farris, Contracting Officer, (405) 736-4112 james.farris.1@us.af.mil

RESPONSE PAGE

RETURN THIS PAGE WITH THE COMPLETED INFORMATION AND AUTHORIZED SIGNATURE. OFFEROR MAY PROVIDE COMPANY QUOTATION SHEET IN CONJUNCTION WITH THIS RESPONSE PAGE

1. OFFEROR INFORMATION

BUSINESS NAME:

CAGE CODE and DUNS:

BUSINESS WEB ADDRESS:

CONTACT PERSON:

E-MAIL:

2. Supplies/Services and Prices/Costs

Contractor is required to provide commercial product literature for all items quoted below CLIN 0001 Unit/EA Price: $____________ 2 ea Total Price for CLIN 0001: $____________

CLIN 0002 Unit/EA Price: $____________ 1 ea Total Price for CLIN 0002: $____________

CLIN 0003 Unit/EA Price: $____________ 1 ea Total Price for CLIN 0003: $____________

Total Proposed Price for all CLINs: $__________

DISCOUNT TERMS:

NET 30 or _______% IN _______ DAYS

DAYS REQUIRED FOR DELIVERY:

3. Certification of Response

Contractor is Required to sign this document and return 1 copy to issuing office. Contractor agrees to furnish and deliver all items set forth or otherwise identified above and on any additional sheets subject to the terms and conditions specified herein. Contractor is required to provide commercial product literature for all items quoted above