Attach_04_Asbestos_Rpt.pdf

Nellis Air Force Base Asbestos and Lead Based Paint Inspection Report

Work Order Scope of Work:

Replace carpet throughout the building.

Building Number: 201

Inspection Date: 8/23/2016

Nellis Work Order: 28221

Macrotec Job Number: 16634

The information contained in this report pertains only to the specific area defined in the above scope of work. This summarized report is for reference purposes, only. A detailed generic report is on file with Nellis Air Force Base Civil Engineering. Only proper personnel should interpret this report to determine whether the information herein can be utilized for current and future renovation activities within the building

Macrotec Consulting, LLC. performed an inspection for Asbestos Containing Building Materials and Lead Based Paint. The intent of this inspection was to identify materials containing asbestos and lead, within the subject site, that may be impacted during planned renovation activities.

Introduction:

Report Limitations:

Dustin R. McAllister

Nevada-OSHA Certified Asbestos Abatement Consultant

License # IPM0961

US EPA Lead Risk Assessor

Certificate # NV-R-16781-2

9724 Mild Weather Ct., Las Vegas, NV 89148 Phone: (702) 338-8213 Fax: (702) 629-5677

Appendix A - Asbestos Assessment

Macrotec Job #16634 - Bldg. 201

The following table lists each of the materials suspected to contain asbestos at the subject site. For each material the sample number, location and laboratory result are listed. If the material was found to contain asbestos, the friablity and NESHAP classification is identified.

1 12X12 VCT - Beige - Below Carpet This material is located below the carpet in room 6.

No Asbestos Detected

None Detected1st Floor - Old - Room 6 - SW cornerAB1

2 VCT Floor Mastic - Black This material is located below the floor tile in Room 6 and below the carpet in Rooms 1-5, 43, 29-32, 64 and auditorium 22.

Non-Friable, Category I

2% Chrysotile1st Floor - Old - Room 6 - SW cornerAB2

3 Carpet Mastic - Black/Yellow This material is located below the floor tile in Room 6 and below the carpet in Rooms 1-5, 43, 29-32, 64 and auditorium 22.

Non-Friable, Category I

2% Chrysotile1st Floor - Old - Room 22 - NW cornerAB3

4 Base Cove Mastic - White This material is located behind the base cove in the one story old section of the building.

No Asbestos Detected

None Detected1st Floor - Old - Room 22 - NW cornerAB4

5 Carpet Mastic - Yellow This material is located below the carpet in Room 24.

No Asbestos Detected

None Detected1st Floor - Old - Room 24 - W sideAB5

6 Carpet Mastic - Yellow This material is located below the carpet in Rooms 29, 30, 31 and 32.

No Asbestos Detected

None Detected1st Floor - Old - Room 29 - CenterAB6

7 12X12 VCT - Beige - Below Carpet This material is located below the carpet in Rooms 29, 30, 31 and 32.

No Asbestos Detected

None Detected1st Floor - Old - Room 29 - CenterAB7

Asbestos Survey

WO #28221 - Bldg. 201

Macrotec Job #16634

Appendix A macro Highlight 2% Chrysotile macro Highlight 2% Chrysotile

Appendix A

8 VCT Floor Mastic - Yellow This material is located below the floor tile in Rooms 29, 30, 31 and 32.

No Asbestos Detected

None Detected1st Floor - Old - Room 29 - CenterAB8

9 Carpet Mastic - Yellow This material is located below the carpet in Room 43.

No Asbestos Detected

None Detected1st Floor - Old - Room 43 - NW cornerAB9

10 Floor Fill - White This material is located below the carpet in Room 43.

No Asbestos Detected

None Detected1st Floor - Old - Room 43 - NW cornerAB10

11 Carpet Mastic - Black This material is located below the floor tile in Room 6 and below the carpet in Rooms 1-5, 43, 29-32, 64 and auditorium 22.

Non-Friable, Category I

3 % Chrysotile1st Floor - Old - Room 64 - S sideAB11

12 Carpet Mastic - Green This material is located below the carpet in Main Auditorium in the two story new section.

No Asbestos Detected

None Detected1st Floor - New - Main Auditorium - SW cornerAB12

13 Carpet Mastic - Yellow This material is located below the carpet in Rooms 105, 106, and 107.

No Asbestos Detected

None Detected1st Floor - New - Room 107 - NE cornerAB13

14 12X12 Floor Tile - Beige - Below Carpet This material is located below the carpet in Rooms 105, 106, and 107.

No Asbestos Detected

None Detected1st Floor - New - Room 107 - NE cornerAB14

15 Floor Tile Mastic - Yellow This material is located below the floor tile in Rooms 105, 106, and 107.

No Asbestos Detected

None Detected1st Floor - New - Room 107 - NE cornerAB15

Asbestos Survey

WO #28221 - Bldg. 201

Macrotec Job #16634

Appendix A macro

3 % Chrysotile

24 Floor Fill - White This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 214 - Adj. doorAB24

25 Carpet Mastic - Yellow This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 222 - NW cornerAB25

26 Base Cove Mastic - White This material is located behind the base cove in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 222 - NW cornerAB26

Asbestos Survey

WO #28221 - Bldg. 201

Macrotec Job #16634

16 Carpet - This material is located below the carpet in Room 133.

No Asbestos Detected

None Detected1st Floor - New - Room 133 - SE cornerAB16

17 Carpet Mastic - Yellow This material is located below the carpet in Room 133.

No Asbestos Detected

None Detected1st Floor - New - Room 133 - SE cornerAB17

18 Carpet Mastic - Yellow This material is located below the carpet in Rooms 135 and 136.

No Asbestos Detected

None Detected1st Floor - New - Room 136 - SW cornerAB18

19 Carpet Mastic - Green This material is located below the carpet in the hallways of the two story new section.

No Asbestos Detected

None Detected1st Floor - New - NW Hallway - Adj. StairsAB19

20 Carpet Mastic - Yellow This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 202 - Adj. doorAB20

21 Floor Fill - Below Carpet - Black This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 202 - Adj. doorAB21

22 Carpet Mastic - Yellow This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 210 - Adj. doorAB22

23 Carpet Mastic - Yellow This material is located below the carpet in the second floor rooms of the two story new section.

No Asbestos Detected

None Detected2nd Floor - New - Room 214 - Adj. doorAB23

Asbestos Survey

WO #28221 - Bldg. 201

Appendix B - Lead Assessment

Macrotec conducted analysis of the painted surfaces and/or bulk materials that may be impacted during the defined scope of work, using an XRF analyzer. No lead was detected during the inspection of the suspect materials. Appendix D lists the painted surfaces that were analyzed during this inspection along with its location and analysis result. Note: If suspect materials are found during renovation activities outside what was identified in this report, stop work immediately until further testing can be completed.

Lead Paint Survey

WO #28221 - Bldg. 201

Asbestos and Lead Based Paint Inspection

Nellis AFB—Building 201-One Story Old Section

Macrotec Project # 16634

Appendix C

Sample Location Diagram

AB1

The floor tile in the area above was tested for lead based paint with a XRF Analyz-

er. See results page for materials & locations.

AB2

AB3

AB4

AB5

AB6

AB7

AB8

AB9

AB10

AB11

Areas where asbestos containing black mastic was found.

Areas where no carpet exists and was not tested because it was not part of this projects scope of work.

Areas where asbestos containing black mastic does not appear to be present.

macro Highlight

AB2

macro Highlight

AB3

macro

AB11

Asbestos and Lead Based Paint Inspection

Nellis AFB—Building 201-Two Story New Section

Macrotec Project # 16634

Appendix C

Sample Location Diagram

AB21

AB20

AB14

AB15

AB16

AB17

AB18

AB19

AB13

AB12

1st Floor

2nd Floor

AB22

AB23

AB24

AB25

AB26

The floor tile in the area above was tested for lead based paint with a XRF Analyz-

er. See results page for materials & locations.

Macrotec Consulting

TRIANGLE ENVIRONMENTAL SERVICE CENTER, INC.

13509 East Boundary Road, Suite B, Midlothian, VA 23112

804-739-1751 • fax: 804-739-1753

BULK ASBESTOS SAMPLE ANALYSIS SUMMARY

9724 Mild Weather Ct.

Las Vegas, NV 89148

16634

WO #28221 - Bldg. 201

160824E

08/24/2016

08/24/2016

08/24/2016

F. JiangJOB SITE:

TESC LOGIN #:

DATE OF RECEIPT:

DATE OF ANALYSIS:

DATE OF REPORT:

ANALYST:

TESC

SAMPLE #

CLIENT SAMPLE ID

& GROSS DESCRIPTION

ESTIMATED

% ASBESTOS

NON ASBESTOS

% FIBERS

NON FIBROUS

% MATERIALS

CLIENT:

CLIENT JOB:

100%AB1 / Beige vinyl NAD1

98%AB2 / Black adhesive 2% Chrysotile2

98%AB3 / Black, yellow adhesive 2% Chrysotile3

100%AB4 / White adhesive NAD4

100%AB5 / Yellow adhesive NAD5

100%AB6 / Yellow adhesive NAD6

100%AB7 / Beige vinyl NAD7

100%AB8 / Yellow adhesive NAD8

100%AB9 / Yellow adhesive NAD9

100%AB10 / White powder NAD10

August 24, 2016 Page 1 of 3

Samples are analyzed in accordance with “Interim Method for the Determination of Asbestos in Bulk Insulation Samples”, EPA 600/M4-82-020, Dec. 1982 and "Method for the Determination of Asbestos in Bulk Building Materials", EPA 600/R-93/116, July 1993. None Detected: not detected at/or below the detected limit of method (Reporting limit: 1% Asbestos). Glass fiber is analyzed for quality control blank. TESC recommends by point count or Transmission

Electron Microscopy (TEM), for materials regulated by the EPA NESHAP (National Emission Standards for Hazardous Air Pollutants) and found to contain less than ten percent (<10%) asbestos by Polarized Light Microscopy (PLM). Both services are available for an additional fee. This report shall not be reproduced, except in full written approval of Triangle Environmental Service Center, Inc. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. This test report relates only to the item(s) tested.

NVLAP Lab Code: 200794-0 LEGEND NAD=No Asbestos Detected, Lino.=Linoleum, JC=Joint Compound] [

Reviewed By Authorized Signatory:

Feng Jiang, MS Senior Geologist, Laboratory Director

Yuedong Fang, Senior Geologist

13509 East Boundary Road, Suite B, Midlothian, VA 23112

16634

WO #28221 - Bldg. 201

160824E

08/24/2016

08/24/2016

08/24/2016

DATE OF REPORT:

ANALYST:

TESC

SAMPLE #

CLIENT SAMPLE ID

& GROSS DESCRIPTION

ESTIMATED

% ASBESTOS

NON ASBESTOS

% FIBERS

NON FIBROUS

% MATERIALS

97%AB11 / Black adhesive 3% Chrysotile11

100%AB12 / Green adhesive NAD12

100%AB13 / Yellow adhesive NAD13

100%AB14 / Beige vinyl NAD14

100%AB15 / Yellow adhesive NAD15

98% Synthetic 2%AB16 / White, black fibers NAD16

100%AB17 / Yellow adhesive NAD17

100%AB18 / Yellow adhesive NAD18

100%AB19 / Green adhesive NAD19

100%AB20 / Yellow adhesive NAD20

August 24, 2016 Page 2 of 3

Samples are analyzed in accordance with “Interim Method for the Determination of Asbestos in Bulk Insulation Samples”, EPA 600/M4-82-020, Dec. 1982 and "Method for the Determination of Asbestos in Bulk Building Materials", EPA 600/R-93/116, July 1993. None Detected: not detected at/or below the detected limit of method (Reporting limit: 1% Asbestos). Glass fiber is analyzed for quality control blank. TESC recommends by point count or Transmission

Electron Microscopy (TEM), for materials regulated by the EPA NESHAP (National Emission Standards for Hazardous Air Pollutants) and found to contain less than ten percent (<10%) asbestos by Polarized Light Microscopy (PLM). Both services are available for an additional fee. This report shall not be reproduced, except in full written approval of Triangle Environmental Service Center, Inc. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. This test report relates only to the item(s) tested.

NVLAP Lab Code: 200794-0 LEGEND NAD=No Asbestos Detected, Lino.=Linoleum, JC=Joint Compound] [

Reviewed By Authorized Signatory:

13509 East Boundary Road, Suite B, Midlothian, VA 23112

16634

WO #28221 - Bldg. 201

160824E

08/24/2016

08/24/2016

08/24/2016

DATE OF REPORT:

ANALYST:

TESC

SAMPLE #

CLIENT SAMPLE ID

& GROSS DESCRIPTION

ESTIMATED

% ASBESTOS

NON ASBESTOS

% FIBERS

NON FIBROUS

% MATERIALS

100%AB21 / Yellow adhesive NAD21

100%AB22 / Yellow adhesive NAD22

100%AB23 / Yellow adhesive NAD23

100%AB24 / White powder NAD24

100%AB25 / Yellow adhesive NAD25

100%AB62 / White adhesive NAD26

Total Samples/Layers Analyzed: 26

August 24, 2016 Page 3 of 3

Samples are analyzed in accordance with “Interim Method for the Determination of Asbestos in Bulk Insulation Samples”, EPA 600/M4-82-020, Dec. 1982 and "Method for the Determination of Asbestos in Bulk Building Materials", EPA 600/R-93/116, July 1993. None Detected: not detected at/or below the detected limit of method (Reporting limit: 1% Asbestos). Glass fiber is analyzed for quality control blank. TESC recommends by point count or Transmission

Electron Microscopy (TEM), for materials regulated by the EPA NESHAP (National Emission Standards for Hazardous Air Pollutants) and found to contain less than ten percent (<10%) asbestos by Polarized Light Microscopy (PLM). Both services are available for an additional fee. This report shall not be reproduced, except in full written approval of Triangle Environmental Service Center, Inc. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. This test report relates only to the item(s) tested.

NVLAP Lab Code: 200794-0 LEGEND NAD=No Asbestos Detected, Lino.=Linoleum, JC=Joint Compound] [

Reviewed By Authorized Signatory:

client Name Nellis Bulk Sampling Chain of Custody Form

Project Name Bldg' 2Ol Project Location UO #25227 - Etdq. 2O7 rechnician Dustin R lflcfrllister

Project Number

Collection Date

WO Number

76631 a/23/2076 28227

Turn Around Time

Method of Analysis

Matrix Bulk

Rush 3F- ^Laboratory I E>C

Stop at 1st Positive?: y / N Composite Wall Substrate?: y / N

PLM

Sample # H # | Count

Sample Description (Material Type : Color / Description)

Sample Location _ (General : Room : Specific)t lasr lTst Floor - Old - Room 6 - SUI corner t_tlst Floor - Old - Room 6 - Sl,t) corner

|st Floor - Old - Room 22 - NtA) corner

7st Floor - Old - Room 22 - Ntl corner

,tt Fl"* - Old - Room 24 - Lrl side

6 laee Carpet //lqstic - Yellow |st Floor - Old - Room 29 - Center 7 lasz 72X72 VCT - Beige - Below Carpet lst Floor - Old - Room 29 - Centera lasa VC'T Floor lllastic - Yellow

Carpet /l4astic - Yellow

|st Floor - Old - Room 29 - Cenbere lass 7st Floor - Old - Room 43 - Nll corner rc lnsrc Floor Fill - Uhite 1st Floor - Old - Room 43 - NUJ corner 7l

Carpet /l/lqstic - Black lst Floor - Old - Room 64 - S side Carpet //lastic - Green |st Floor - New - //tain Auditorium - Sl,t) cornerrc lasrc Carpet ilasbic - Yellow lst Floor - New - Room 7O7 - NE corner

/4 | ast+ l2xl2 Floor Tile - Beige - Below Carpet 7st Floor - New - Room 7O7 - NE corner rc lnsrc Floor Tile //lastic - Yellow |st Floor - New - Room /O7 - NE corner t6 lasto Carpet |st Floor - New - Room 133 - SE corner

7a

Carpet ll4asbic - Yellow |st Floor - New - Room 735 - SE corner Carpet /l4astie - Yeltow 7st Floor - New - Room 736 - Stt) corner rc lnsrc Carpet lllastic - Green |st Floor - New - Nlil Hallway - Adj. gtairs zo lnszo Carpet /llastic - Yellow Znd Floor - New - Room 2O2 - Adj. door

Relinquished By:

"t",,ffi{/t Received By:

Relinquished By: Date: Received By: Date:

lo. t5 PtYr-

Macrotec Phone: (702)949-62

Fax. (702) 629-5677

_6tt Project lrlame 6ldg' 2Ol Project r-ocation W #?9?2| - Btdq. 2O7 client Name Nellis Bulk Sampling Chain of Custody Form

Technician _Dusti'n, R, //lcfrltlister fF- ^Laboratcrv I E>C

Stop at 1st por;itive?: \/ i N Composite Wall Substrate?: y / N

Project Number

Collection Date

WO Number

76631:

8'/23/2076

2!8227

Turn Around Time

Method of Anatysis

Matrix Bulk

Rush

Ptm

Sample # H # lCourrt

Sample Description (t\/aterial Type : Color / Description,l

--Floor Fill - Below Carpet - Btack

Cc,rpet //la::tic - yellon, Carpet //lastic - yeltow, Floor Fill - ldhite I Carpeb //lastic - Yellow 1 le Location )pecific)

-r_ om 2021. - Adj. door om 2/O - frdj. door

2nd Floor - New - Room 27q - Adj. do,cr

2nd Floor - New - Room 2/4 - Adj. dottr

2nd Floor - New - Room 222 _ NUJ corner

2nd Floor - New - Roo,m 222 - Nlt) corner

I nB 2t7 zz I ns z'z

2s I aszs

24 InB24 zs

I ns zs zo I flB 2r5 Base Cove /,trlastic - l,lhite

- Date:

i:

Received By: { { ,., \*- Date: r

Relinquished By:

Relinquished By: Date: Received By: F\a+^.

UdLC.

'..i. 1. j 11,i.

XRF Data Table

Time Component Substrate Color Condition Building Floor Room Results Depth PbC PbC Error PbL PbL Error PbK PbK Error

8/25/16 15:12 Floor VCT Beige Intact 201 1 107 Negative 6.93 < LOD 0.23 < LOD 0.23 < LOD 2.71

8/25/16 15:12 Floor VCT Beige Intact 201 1 107 Negative 3.25 < LOD 0.06 < LOD 0.06 < LOD 1.46

8/25/16 15:13 Floor VCT Beige Intact 201 1 6 Negative 1.51 < LOD 0.05 < LOD 0.05 < LOD 2.73

8/25/16 15:15 Floor VCT Beige Intact 201 1 29 Negative 5.27 < LOD 0.75 < LOD 0.06 < LOD 0.75

8/25/16 15:22 Floor VCT Beige Intact 201 1 Hall Negative 1.29 < LOD 0.03 < LOD 0.03 < LOD 2.32

8/25/16 15:22 Floor VCT Beige Intact 201 1 Hall Negative 6.72 < LOD 0.2 < LOD 0.2 < LOD 2.25

8/25/16 15:23 Floor VCT Beige Intact 201 2 Hall Negative 10 < LOD 0.43 < LOD 0.43 < LOD 3.25

8/25/16 15:23 Floor VCT Beige Intact 201 2 Hall Negative 1 < LOD 0.03 < LOD 0.03 < LOD 3.48

8/25/16 15:24 Floor VCT Beige Intact 201 2 Hall Negative 1.69 < LOD 0.06 < LOD 0.06 < LOD 3.54

Nellis Air Force Base Bldg. 201 Macrotec Job #16634 1