Attach___2,_MX_Checklist.pdf

Preventive Maintenance

Customer: Date: Click here to enter a date.

Contact Name: Tower Location Address:

Phone Number:

Email Address:

Serial Numbers Camera Model Camera Serial #

Tower Serial #: Camera 1:

Customer Serial #: Camera 2:

Generator Serial #: Camera 3:

Generator Model: Camera 4:

Generator Hours: Camera 5:

I. Electrical Compartment and Solar Panel

Pump and Motor Additional Comments

1. Is hydraulic fluid at correct level? Choose an item.

2. Is pump free of leaks and loose connections? Choose an item.

3. Is wiring on motor in good condition and working correctly? Choose an item.

4. Is hydraulic fill cap in good condition? Choose an item.

5. Is pump eliminator switch working properly? Choose an item.

6. Is generator wiring harness in good condition without cracks or cuts? Choose an item.

Solar Charging System Additional Comments

7. Generator start battery voltage. (Remove and clean terminals) Is battery in good order?

Pre Gen Set Start Post Gen Set Start Choose an item.

8. a. Is solar panel clean?

b. Is solar panel free from damage?

Choose an item.

Choose an item.

9. Is solar panel charger working correctly? Choose an item.

10. Are wires running to panel and start battery secure? Choose an item.

Electrical Compartment Additional Comments

11. Is Up / Down switch working properly? Choose an item.

12. Is interior light okay? Choose an item.

13. Are battery cables secure and routed properly? Check for damage. Choose an item.

14. Are 12V DC circuit breakers in good condition? Choose an item.

15. Is GFI outlet working as it should? Choose an item.

16. Is Onan switch working as it should? Choose an item.

17. Are all wires free of damage? Choose an item.

18. Are paddle or twist handle door latches in good order? Choose an item.

Weep Lines Additional Comments

19. Are weep lines strapped to the cylinders with zip ties? Choose an item.

20. Are weep lines free of cracks and in a non-weathered state? Choose an item.

21. Are weep lines connected to fittings at cylinder and pump? Choose an item.

High Pressure Lines Additional Comments

22. Are fittings at cylinders and pump free of leaks? Choose an item.

23. Is hose condition in a non-weathered state and free of leaks? Choose an item.

Cylinders Additional Comments

24. Have piston shafts been cleaned in up position? Choose an item.

25. Check External seals for leaks by raising and lowering tower twice. Are external seals in good working order?

Choose an item.

26. Check for internal leaks by removing weep lines at pump and raise, then lower tower. Are internal seals in good working order?

Choose an item.

Grease Fittings (indicate if point has been greased) *Number of fittings may vary by model

Left Side Additional Comments

27. Two points on officer’s compartment at arm connection. Choose an item.

28. Four points at upper cylinder. Choose an item.

29. Three points at base of cylinder. Choose an item.

30. One point at upper arm pivot. Choose an item.

31. One point at lower arm pivot. Choose an item.

32. Three points at left side front outrigger. Choose an item.

33. Three points at left side rear outrigger. Choose an item.

34. One point at tongue jack. Choose an item.

Right Side Additional Comments

35. Two points on officer’s compartment at arm connection. Choose an item.

36. Four points at upper cylinder. Choose an item.

37. Three points at base of cylinder. Choose an item.

38. One point at upper arm pivot. Choose an item.

39. One point at lower arm pivot. Choose an item.

40. Three points at right side front outrigger. Choose an item.

41. Three points at right side rear outrigger. Choose an item.

Pins Additional Comments

42. Inspect top cylinder pins. Okay? Choose an item.

43. Inspect bottom cylinder pins. Okay? Choose an item.

44. Inspect upper arm pins. Okay? Choose an item.

45. Inspect lower arm pins. Okay? Choose an item.

46. Inspect officer’s compartment pins. Okay? Choose an item.

Officer’s Compartment Additional Comments

47. Does tower pass E-Down Function Test? Choose an item.

48. Test remote start from officer’s compartment and start switch on generator. Are both operating correctly?

Choose an item.

49. Is interior light okay? Choose an item.

50. Is battery gauge okay? Choose an item.

51. Is door relay switch / safety switch in good working order? Choose an item.

52. Is joystick working properly? Choose an item.

53. Is 12 volt outlet in good working order? Choose an item.

54. Is flasher relay working correctly? Choose an item.

55. Is descent alarm in good working order? Choose an item.

56. Is strobe light operating correctly? Choose an item.

57. Is wind speed meter working properly? Choose an item.

58. Is GFI outlet working as it should? Choose an item.

59. Is air conditioner functioning okay? Choose an item.

60. Is toe heater functioning okay? Choose an item.

61. Are all cameras operating as they should? Choose an item.

62. Is DVR working correctly? Choose an item.

63. Is monitor functioning as it should? Choose an item.

64. Is PTZ (Pan / Tilt) for camera working correctly? Choose an item.

65. Is convertor system running as it should? (12V Output) Choose an item.

66. Is public address system and all speakers working correctly? Choose an item.

67. Are spotlights performing as they should? Choose an item.

68. Are all floodlights working? Choose an item.

69. Is fuel gauge light on? Choose an item.

70. Are exterior door handles on officer’s compartment operational? Choose an item.

71. Are interior door handles on officer’s compartment operational? Choose an item.

72. Are latches in officer’s compartment working smoothly? Choose an item.

73. Is door safety cable in good working order? Choose an item.

74. Examine windows (cracks, tint, locks). Okay? Choose an item.

75. Is fire extinguisher fully charged and in the green? Choose an item.

Generator Additional Comments

76. Is Generator Charging System working correctly?

Gen Set Voltage

Choose an item.

77. Is coolant at full mark? Choose an item.

78. Check coolant anti-freeze protection every 500 hrs. Is coolant protection still good?

Choose an item.

79. Flush Coolant / Replace pressure cap every 1000 hrs. or annually. Is coolant and pressure cap okay?

Choose an item.

80. Replace spark plug (Gasoline Models Only) every 1000 hrs. or annually. Is spark plug okay?

Choose an item.

81. Check oil before starting generator and run test for 15 minutes. Does Generator run as it should?

Choose an item.

82. a) Change engine oil every 150 hrs. and replace oil filter. Has engine oil been changed this visit?

Choose an item.

b) Fill reservoir in oilmate system as needed and change oil filter ever 500 hrs. Has reservoir been filled and / or filter changed this visit?

Choose an item.

83. Check air filter (change if needed). Has air filter been changed this visit? Choose an item.

84. Replace fuel filter every 500 hrs. Has fuel filter been changed this visit? Choose an item.

85. Is breaker on generator operating properly? Choose an item.

86. Is tail pipe secure? Choose an item.

87. Clean spark arrestor every 150 hrs. Has spark arrestor been cleaned? Choose an item.

88. Inspect engine V-belt. (Must be replaced by a qualified mechanic authorized by Onan every 1000 hrs.) Does V-belt appear okay?

Choose an item.

89. Inspect crankcase breather. (Must be replaced by a qualified mechanic authorized by Onan every 1000 hrs.) On 7.5 diesel only. Does CC Breather appear okay?

Choose an item.

90. Inspect coolant hoses and thermostat. (Must be replaced by a qualified mechanic authorized by Onan ever 1000 hrs.)

Choose an item.

Other Components Additional Comments

91. Is fuel tank free of leaks? Choose an item.

92. Are fuel sending unit wires secure? Choose an item.

93. Are fuel lines secure? Choose an item.

94. Is condition of fuel cap okay? Choose an item.

Outriggers Additional Comments

95. Inspect outrigger plate bolts. Okay? Choose an item.

96. Inspect outrigger jacks and bolts connecting them to the outrigger. Okay? Choose an item.

97. Check outrigger reflective tape. Okay? Choose an item.

Tongue Additional Comments

98. Inspect split-ball coupler. Okay? Choose an item.

99. Inspect safety chains. Okay? Choose an item.

100. Inspect tongue jack. Okay? Choose an item.

101. Are breakaway brake switch, cable and ‘S’ hook intact? Choose an item.

102. Is UHMW on outrigger plates free from damage? Choose an item.

103. Check bubble levels. Are they free of cracks or breaks? Choose an item.

Paint Additional Comments

104. Check for any defects in paint or primer. Okay? Choose an item.

105. Is tower free of rust that would affect operation of tower? Choose an item.

106. Is under coating on officer’s compartment okay? Choose an item.

Miscellaneous Additional Comments

107. Are bumpers on bottom of officer’s compartment in good working order? Choose an item.

108. Is tire air pressure okay? (see stickers inside technical comp. for inflation info) Choose an item.

109. Inspect condition of spare tire. Okay? Choose an item.

110. Inspect wheel hubs. Okay? Choose an item.

111. Are warning labels still visible? Choose an item.

112. Is operation manual present? Choose an item.

DC Units Only Additional Comments

113. Is generator compartment door handle working correctly? Choose an item.

At Ground

Level Fully Raised

114. Remove and clean terminals. Voltage on battery #1. Is battery fully charged?

Choose an item.

115. Remove and clean terminals. Voltage on battery #2. Is battery fully charged?

Choose an item.

116. Is battery gauge okay in electrical compartment? Choose an item.

117. Is battery charger functioning? Choose an item.

118. Is weather stripping on the electrical compartment in good condition? Choose an item.

119. Is battery gauge okay in officer’s compartment? Choose an item.

120. Check outrigger pins – Are they secure and in good working order? Choose an item.

121. Is officer’s compartment level? Choose an item.

122. Check gator guard on fuel cell and floor of trailer. Okay? Choose an item.

123. Is anti-skid tape still in good shape? Choose an item.

Click here to enter a date.

Inspection Performed By Certified FLIR Technician Date

ADDITIONAL COMMENTS

Line Item # Description Part # Qty Used

ADDITIONAL AND / OR ALTERED EQUIPMENT FOUND ON TOWER